How it Works
Dacor
Loading...
ER36G
User Manual
20 pgs4.06 Mb1

Dacor ER36G User Manual

Installation Instructions
Epicure® 36-Inch Gas Range
For use with models ER36G and ER36GI
Part No. 106554 Rev. D
THIS APPLIANCE HAS BEEN TESTED IN ACCORDANCE WITH THE LATEST EDITION OF ANSI Z21.1 STANDARD FOR HOUSEHOLD GAS COOKING APPLIANCES.
Table of Contents
Important Information About Safety Instructions......................... 2
Gas and Electrical Locations ...................................................... 6
Verifying the Package Contents .................................................6
Parts List .....................................................................................6
Backguard Kit Installation ...........................................................7
Adjust the Range Height .............................................................8
Install the Anti-Tip Bracket ..........................................................9
Moving the Range to Final Location ......................................... 11
Re-Installing the Door ............................................................... 11
IMPORTANT:
Installer• : In the interest of safety and to minimize problems, read these installation instructions completely and
carefully before you begin the installation process. Leave these installation instructions with the customer.
Customer• : Keep these installation instructions for future reference and the local building inspector’s use.
Customer Service Information
If you have questions or problems with installation, contact your
®
Dacor
dealer or the Dacor Customer Service Team. For repairs to Dacor appliances under warranty call the Dacor Distinctive Service line. Whenever you call, have the model and serial number of the appliance ready. The model and serial number are on the model/ serial number label. It can be seen by opening the oven door and looking through the slot near the left hinge between the door and bottom of the oven chamber.
Dacor Customer Service Phone: (800) 793-0093 (U.S.A. and Canada) Monday — Friday 6:00
a.m. to 5:00 p.m. Pacific Time
Web site: www.Dacor.com
Dacor Distinctive Service (repairs under warranty only) Phone: (877) 337-3226 (U.S.A. and Canada) Monday — Friday 6:00
a.m. to 4:00 p.m. Pacific Time
View model/serial number label through slot near left hinge
Model Identification
Model Number
ER36GSCH/NG
ER36GSCH/LP
ER36GSCH/NG/H
ER36GSCH/LP/H
ER36GISCH/NG
ER36GISCH/LP
ER36GISCH/NG/H
ER36GISCH/LP/H
Side Panel
Type*
Full NG 6 Inch Below 4000 Ft.
Full LP 6 Inch Below 4000 Ft.
Full NG 6 Inch 4000 Ft. and over
Full LP 6 Inch 4000 Ft. and over
Partial NG 1 3/4 Inch Below 4000 Ft.
Partial LP 1 3/4 Inch Below 4000 Ft.
Partial NG 1 3/4 Inch 4000 Ft. and over
Partial LP 1 3/4 Inch 4000 Ft. and over
Gas Type
* See page 3 for more information. ** 4000 Ft. = 1219 M
All specifications subject to change without notice. Dacor assumes no liability for changes to specifications.
© 2008 Dacor, all rights reserved.
Standard
Backguard*
Operating
Altitude**
Important Safety Instructions
Important Information About Safety Instructions
The Important Safety Instructions and warnings in this Manual are not meant to cover all possible problems and conditions that can occur. Use common sense and caution when installing, maintaining or operating this appliance.
Always contact the Dacor Customer Service Team about problems or conditions you do not understand.
Safety Symbols and Labels
DANGER
Immediate hazards that WILL result in severe personal injury or death.
WARNING
Hazards or unsafe practices that COULD result in severe personal injury or death.
CAUTION
Hazards or unsafe practices that COULD result in minor personal injury or property damage.
DANGER
IMPORTANT: If you smell gas:
Do not use or light any appliance.• Do not touch any electrical switch or use any electrical •
devices, including the telephone, in your building. From a neighbors phone, immediately call the gas •
supplier. Follow the gas supplier’s instructions. If you cannot contact the gas supplier, call the fire •
department. Do not return to the building until instructed to do so •
by the gas supplier or fire department.
IMPORTANT: Do not store or use combustible, flammable or explosive vapors and liquids (such as gasoline) inside or in the vicinity of this or any other appliance. Also keep items that could explode, such as aerosol cans, away from the burners and the oven. Do not store flammable or explosive materials in adjacent cabinets or areas.
IMPORTANT: Junked or abandoned appliances are dangerous and can cause a child entrapment and suffocation hazard. When taking an appliance out of service, immediately follow the instructions below to help prevent accidents:
Take off the door.• Leave the racks in place so children cannot easily •
climb inside. Cut the prongs off the power cable plug and discard •
them. Cut the power cable off and discard it separately from •
the old appliance.
WARNING
WARNING – NEVER use this appliance as a space
heater to heat or warm the room. Doing so may result in carbon monoxide poisoning and overheating of the appliance.
WARNING
WARNING – Failure to install this appliance as specified
in these instructions may result in personal injury or death.
WARNING
WARNING – NEVER cover any slots, holes or passages
on the inside or outside of the range or cover an entire rack with materials such as aluminum foil. Doing so blocks air flow through the oven and may cause carbon monoxide poisoning. Aluminum foil linings may also trap heat, causing a fire hazard.
DANGER
TO REDUCE THE RISK OF INJURY TO PERSONS IN THE EVENT OF A RANGE TOP GREASE FIRE:
SMOTHER FLAMES with a close-fitting lid, cookie a. sheet or metal tray, then turn off the burner. BE CAREFUL TO PREVENT BURNS. If the flames do not go out immediately, EVACUATE AND CALL THE FIRE DEPARTMENT.
NEVER PICK UP A FLAMING PAN - you may be b. burned.
DO NOT USE WATER, including wet dish cloths or c. towels - a violent steam explosion may result.
Use a fire extinguisher ONLY if: d.
You have a Class ABC extinguisher, and you ◊ already know how to operate it.
The fire is small and contained in the area where it ◊ started.
The fire department is being called.◊ You can fight the fire with your back to an exit.◊
CALIFORNIA PROPOSITION 65 WARNING
The burning of gas cooking fuel generates some by-products that are on the list of substances which are known by the State of California to cause cancer or reproductive harm. California law requires businesses to warn customers of potential exposure to such substances. To minimize exposure to these substances, always operate this unit according to the use and care manual, ensuring you provide good ventilation when cooking with gas.
READ AND SAVE THESE
INSTRUCTIONS
1
Important Safety Instructions
General Safety Precautions
To reduce the risk of fire, explosion, electric shock, serious injury or death when installing or using this appliance, follow basic safety precautions, including the following:
WARNING
Read the accompanying use and care manual completely before operating this appliance.•
Keep packaging materials away from children. Plastic sheets and bags can cause suffocation.•
If you receive a damaged product, immediately contact your dealer or builder. Do not install or use a damaged • appliance.
This range must be properly installed by a qualified installer according to these installation instructions prior to use. • The installer should show the customer the location of the gas shut off valve and the fuse or junction box so that they know where and how to turn off the gas supply and electric power to the range.
Do not operate the range without the backguard in place. A fire may result.•
Do not install, repair or replace any part of the range unless specifically recommended in the literature • accompanying it. A qualified service technician should perform all other service.
Do not connect this range to the gas supply without the supplied gas pressure regulator installed.•
Before performing any type of service or installation, make sure that the gas supply to the range is turned off and • the power cord is disconnected.
Do not cover the IR broil burner in the top of the oven with cookie sheets, aluminum foil, pots, pans, etc. Covering it • could cause it to overheat resulting in a risk of fire and damage to the oven.
Only use the range for cooking tasks expected of a home appliance as outlined in the literature accompanying it. • This range is not intended for commercial use. This range is certified for indoor installation only.
DO NOT TOUCH THE SURFACES OF THE OVEN OR COOKTOP DURING OR IMMEDIATELY AFTER USE• .
Do not climb on any part of the appliance.•
Never leave this appliance unattended when in use.•
Do not leave children or pets alone or unattended in the area around the range. Do not allow children to play with • the controls, pull on the handle, or touch other parts of the range. Do not store items of interest to children on top of or above the range. Children could be burned or injured while climbing on the appliance.
Do not attempt to use this appliance in the event of a power failure.•
Do not tamper with the controls. Do not adjust or alter any part of the range unless specifically instructed to do so in • these instructions.
To prevent the unit from tipping forward and to provide a stable installation, this range must be secured in place with • the anti-tip device as specified in these instructions.
Clean the cooktop thoroughly before operating it for the first time.•
Keep flammable items, such as paper, cardboard, plastic and cloth away from the burners and other hot surfaces. • Do not place such items in the oven. Do not allow pot holders to touch hot surfaces or gas burners.
Do not wear loose or hanging apparel while using the range. Do not allow clothing to come into contact with the • interior of the oven or the cooktop and surrounding areas during and immediately after use.
To avoid a fire hazard, do not hang flammable or heat sensitive objects over the range.•
If the range is near a window, do not use long curtains as window treatment. The curtains could blow over the • cooktop and create a fire hazard.
Do not use the oven for storage. Do not use the cooktop as a counter for storage of utensils or other items.•
Make sure that all the cooktop parts are dry before lighting a burner.•
Turn the knobs to the • OFF position prior to removing them from the valve stems.
For your safety, do not use the oven to cook without the convection filter installed. When the filter is not installed, • the spinning fan blades at the back of the oven are exposed.
Always ensure that the light fixture lens cover is in place when using the oven. The lens cover protects the light bulb • from breakage caused by high oven temperatures or mechanical shock.
2
Important Safety Instructions
1 9/16” (40 mm)
2” (51 mm)
1
3” (76 mm)
Front of open door Front of handle
Front edge of bull nose Front panel Rear of front panel
7
26 3/4” (679 mm)
27 13/16” (706 mm)
29” (736 mm)
24 5/8” (625 mm)
ER36G:
Full stainless
steel side panels
ER36GI: Partial stainless steel side panel
Grates extend
1” above trim
Product width: 35 7/8” (911 mm)
35 3/4”
(908 mm)
to
37 7/8”
(962 mm)
46 7/8” (1191 mm)
1 1/4”
(32 mm)
15 1/4”
(387 mm)
A
B
C
D
19”
(482 mm)
9”
(229 mm)
(A) 1 3/4” (44 mm): Model AER36GLBG (low profile) 2 (B) 6” (152 mm): Model AER36GBG6
3, 5
(C) 9” (229 mm): Model AER36GBG9
4, 5
(D) 24” (610 mm): Model AER36GBG24
4, 5
WARNING
Do not operate the cooktop without the knobs and trim rings in place.•
Non-stick coatings, when heated, can be harmful to birds. Remove birds to a separate, well-ventilated room during • cooking.
IMPORTANT - This appliance is equipped with a three-prong grounding plug for your protection against possible electric shock hazards. Plug it only into a dedicated, grounded three­prong electrical outlet. It is the responsibility of the customer to make sure the proper type of outlet is installed. Do not under any circumstances:
Cut or remove the third (ground) prong from the power cord.•
Use an adapter plug.•
Use an extension cord.•
Use a power cord that is frayed or damaged.•
Connect to an electrical outlet with a ground fault interrupter (GFI).•
Installation Specifications
Product Dimensions
Trim thickness is 1/4” (6 mm) with optional self-rimming 1) kit installed (ER36GI only).
Standard on model ER36GI. Optional on model 2) ER36G.
Standard on model ER36G. Optional on model 3) ER36GI.
Optional on both models.4)
Overall Dimensions - Side View Available Backguards - Side View
All tolerances: ±1/16” (±1.6 mm), unless otherwise stated
NOTE: Neither model is compatible with raised vents.
Not for use with self rimming installations. ER36G is 5) not equipped for self-rimming installation.
ER36G is designed for freestanding installations. 6) ER36GI is designed for installation in a recessed cabinet or island.
This dimension is shortened to 24 inches when the 7) self-rimming kit is installed (ER36GI only).
3
Installation Specifications
15 7/8”
(403 mm)
to
18”
(457 mm)
3 3/4”
(95 mm)
WARNING
Observe all governing codes and ordinances during • planning and installation. Contact your local building department for further information.
To prevent an electric shock hazard, the power supply • must meet the specifications stated below. It is the owner’s responsibility to make sure that the electrical service meets electrical requirements and that the electrical outlet has been properly installed by a licensed electrician.
Electrical Power Supply Requirements
The range is supplied with a factory installed, 6 foot • long, power cord with a three-prong grounding plug. It is connected to the chassis at the rear of the range. It must be connected to a dedicated, grounded three­prong electrical outlet installed by a licensed electrician.
The electrical installation, including minimum supply • wire size and grounding, must be done in accordance with National Electric Code ANSI/NFPA 70* and local codes and ordinances. A copy of this standard may be obtained from:
National Fire Protection Association 1 Batterymarch Park Quincy, Massachusetts 02269-9101
The correct voltage, frequency and amperage must be • supplied to the electrical outlet according to the product data label located on the top of the kick plate under the door. Remove the door to view the data label (see page 9). See the Electrical Supply Requirements table below for reference.
Electrical Circuit
Required
120 Vac 60 Hz,
15 Amp.
Electrical Supply Requirements
IMPORTANT: The above information is for reference only.
If the information above differs from the information on the product data label on the appliance, use the information on the label.
Total Connected Load
120 Vac 60 Hz,
5.0 Amp.
Gas Supply Requirements
Be certain that the range being installed is correct for • the gas service being provided (natural gas or LP gas).
Check your local building codes for the proper method • of installation. In the absence of local codes, this appliance should be installed in accordance with the National Fuel Gas Code ANSI Z223.1/NFPA 54.
An external manual shut-off valve must be installed • between the gas inlet and the range for the purpose of turning on or shutting off gas to the appliance.
The cooktop comes from the factory with the regulator • installed. Use only the installed regulator. The inlet accommodates a 3/4” gas line. The range ships with a 1/2” to 3/4” adapter connected to the regulator.
Gas
Type
Natural 5” 6” 1/2 p.s.i.
LP 10” 11” 1/2 p.s.i.
* The gas supply pressure for testing the regulator setting shall be at least 1 inch water column (249Pa) above the specified manifold pressure.
IMPORTANT: The information above is for reference only. If the above data does not agree with the product data label, use the data on the product data label on top of the kick plate below the door (remove the door according to the instructions on page 9 to view it).
The gas connection is located on the back of the unit as shown below. Use a 1/2” male NPT to connect to the regulator.
Manifold
Pressure*
(WC)
Gas Supply Requirements
Min. Gas Supply
Pressure (WC)
Max. Input
Pressure
Gas connection
4
Power cord
Loading...
+ 14 hidden pages
Buy Points How it Works FAQ Contact Us Questions and Suggestions Privacy Policy Cookie Policy Terms of Use