Dacor MORS230, EORS230, EORD230, MORD227, EORS136 User Manual
...
Installation Instructions
Renaissance Wall Oven
Models:
EOR, MOR
Part No. 102579 Rev. G
All specifications are subject to change without notice. Dacor ® assumes no liability for changes to specifications.
© 2007 Dacor, all rights reserved.
Table of Contents
Before You Begin... ........................................................... 1
Important Safety Instructions .......................................... 1
Important Information About Safety Instructions .............. 1
Safety Symbols and Labels ............................................. 1
General Safety Precautions ............................................. 2
Customer Service Information ......................................... 3
If You Need Help... ........................................................... 3
Appliance Data Plate ....................................................... 3
Model Identification .......................................................... 3
Product Specifications ..................................................... 4
Power Supply Requirements ........................................... 4
Product Dimensions ......................................................... 4
Installation Specifications ................................................ 6
Installation Planning ......................................................... 6
Installation Instructions .................................................... 8
Verify the Package Contents ............................................ 8
Remove the oven door(s) ................................................ 8
Electrical Connection ....................................................... 9
Installing the Oven in the Cabinet .................................. 12
Installing the Exhaust Grill ............................................. 13
Reinstalling the Oven Doors .......................................... 13
Verifying Proper Operation ............................................. 14
Installation Checklist ...................................................... 15
Before You Begin...
Important:
Installer:• In the interest of safety and to minimize problems, read these installation instructions completely and care-
fully before you begin the installation process. Leave these installation instructions with the customer.
Customer:• Keep these installation instructions for future reference and the local electrical inspector’s use.
Important Safety Instructions
Important Information About
Safety Instructions
The • Important Safety Instructions and warnings in
these instructions are not meant to cover all possible
problems and conditions that can occur. Use common
sense and caution when installing, maintaining or operating this or any other appliance.
Always contact the Dacor Customer Service Team about •
problems and conditions that you don’t understand.
See Customer Service Information.
Safety Symbols and Labels
DANGER
Immediate hazards that WILL result in severe personal
injury or death.
WARNING
Hazards or unsafe practices that COULD result in severe
personal injury or death.
DANGER
IMPORTANT: Do not store or use combustible, flam-
mable, or explosive vapors and liquids (such as gasoline)
inside or in the vicinity of this or any other appliance. Also
keep items that could explode, such as aerosol cans,
away from the oven. Do not store flammable or explosive
materials in adjacent cabinets or areas.
WARNING
WARNING – NEVER use this appliance as a space
heater to heat or warm the room. Doing so may result in
carbon monoxide poisoning and overheating of the appliance.
WARNING
WARNING – NEVER cover any slots, holes or passages
in the oven bottom or cover an entire rack with materials
such as aluminum foil. Doing so blocks air flow through
the oven and may cause a fire hazard or carbon monoxide poisoning.
WARNING
CAUTION
Hazards or unsafe practices that COULD result in minor
personal injury or property damage.
READ AND SAVE
THESE INSTRUCTIONS
Do not install this appliance outdoors and/or near water,
for example, near a pool.
WARNING
When using the BROIL and CONVECTION BROIL settings, the oven door must be completely shut.
1
Important Safety Instructions
General Safety Precautions
To reduce the risk of fire, electric shock, serious injury or death when using your appliance, follow basic safety precautions, including the following:
WARNING
Read the accompanying use and care manual 1.
before operating this appliance.
Keep packaging materials away from children. 2.
Plastic sheets and bags can cause suffocation.
If you receive a damaged product, immediately con-3.
tact your dealer or builder. Do not install or use a
damaged appliance. Do not install or use the appliance if the conduit is damaged.
This oven must be properly installed and grounded 4.
by a qualified installer according to these installation instructions prior to use. The installer must
show the customer the location of the circuit breaker panel or fuse box so that they know where and
how to turn off electric power to the oven. Dacor
is not responsible for service required to correct a
faulty installation. The owner is responsible to make
sure this appliance is properly installed.
Do not use the door handle(s) to lift or move the 5.
oven.
A minimum of two people are required to safely 6.
install this appliance.
To avoid an electric shock hazard, do not install this 7.
appliance outside or near water. Do not install or
use this appliance if it has been exposed to water.
Do not install, repair or replace any part of the oven 8.
unless specifically recommended in the literature
accompanying it. A qualified service technician
should perform all other service.
Before performing any type of service or installa-9.
tion, make sure that the electric power to the oven
is turned off at the circuit breaker or fuse box.
Only use the oven for cooking tasks expected of a 10.
home appliance as outlined in the literature accompanying it. This oven is not intended for commercial
use.
Do not climb on any part of the appliance.11.
Do not leave children alone or unattended in the 12.
area around the oven. Do not allow children to play
with the controls, pull on the handle or touch other
parts of the oven.
Do not store items of interest to children above the 13.
oven. Children could be burned or injured while
climbing on the appliance.
Do not tamper with the controls. Do not adjust 14.
or alter any part of the oven unless specifically
instructed to do so in this manual.
WARNING
To prevent injury due to the unit from tipping for-15.
ward, secure the oven to the cabinet using the supplied mounting screws.
Keep flammable items, such as paper, cardboard, 16.
plastic and cloth away from hot surfaces. Do not put
such items in the oven. Do not allow pot holders to
touch hot surfaces.
Do not wear loose or hanging apparel while using 17.
the oven. Do not allow clothing to come into contact
with the interior of the oven and the surrounding
areas during and immediately after use.
Do not use the oven for storage.18.
Do not touch the interior surfaces of the oven during 19.
use. After use, make sure these surfaces have had
sufficient time to cool before touching them.
Do not touch the outside surfaces of the oven dur-20.
ing the self-clean cycle. They will be hot. Venting
from the oven may cause the trim to become hot.
For your safety, do not use the oven to cook without 21.
the convection filter installed. When the filter is not
installed, the spinning fan blades at the back of the
oven are exposed.
Non-stick coatings, when heated, can be harmful to 22.
birds. Remove birds to a separate, well-ventilated
room during cooking.
To prevent damage, remove the meat probe from 23.
the oven when it is not being used.
Do not line the oven with aluminum foil or other 24.
materials. These items can melt or burn up during
self-cleaning and cause permanent damage to the
oven.
Do not leave metal objects, such as aluminum foil, 25.
the meat probe, cookie sheets, etc. on the bottom
of the oven. Objects left on the bottom of the oven
could damage the bake element. In addition, the
objects themselves could be damaged.
Do not allow heating elements in the top and bot-26.
tom of the oven chamber to become covered up
by cookie sheets, aluminum foil, pots, pans, etc.
Covering the heating elements could cause them
to over-heat, damaging the oven. On some models
the heating elements are behind glass panels.
Always ensure that the light fixture lens covers are 27.
in place when using the oven. The lens covers protect the light bulbs from breakage caused by high
oven temperatures or mechanical shock.
2
Customer Service Information
If You Need Help...
If you have questions or problems with installation, con-•
tact your Dacor dealer or the Dacor Customer Service
Team. When you call, have the model and serial number of the appliance ready. The model and serial number are printed on the appliance data plate.
Dacor Customer Service Team
Phone: (800) 793-0093
E-mail: customerservice@Dacor.com
Web site: www.Dacor.com
Appliance Data Plate
The appliance data plate contains the model and serial •
number information and the electrical and gas supply
requirements.
It can be seen through the grill located below the control •
panel. Open the door to expose the grill. On double
ovens, the plate is located behind the top grill.
Model Identification
EORS227SCH
A BC D E
A MODEL:
EOR = Epicure Renaissance
MOR = Millennia Renaissance
B NUMBER OF CONVECTION OVENS:
S = Single
D = Double
C NUMBER OF OVENS:
1 = Single
2 = Double
D WIDTH:
27 = 27 Inch
30 = 30 Inch
36 = 36 Inch
E TRIM:
SCH = Stainless Steel with Chrome Trim
B = Black Handle, Black Trim
BK = Black Handle, Stainless Trim
S = Stainless Handle (Millennia Style)
View data plate
through grate
3
Product Specifications
Power Supply Requirements
It is the owner’s responsibility to ensure that a licensed •
electrician performs the installation of the electrical supply for this appliance. The electrical installation, including minimum supply wire size, must comply with the
National Electric Code ANSI/NFPA 70 (latest revision)
and local codes and ordinances.
A copy of this standard may be obtained from:
National Fire Protection Association
1 Batterymarch Park
Quincy, Massachusetts 02269-9101
The correct voltage, frequency and amperage must be •
supplied to the appliance from a dedicated, grounded,
single phase circuit that is protected by a properly sized
circuit breaker or time-delay fuse. If a time-delay fuse is
utilized, fuse both sides of the line (L1 and L2).
The required voltage, frequency and amperage ratings •
are listed on the appliance data plate (see page 3) and
in the table for reference.
Preheat times and cavity temperature recovery times will •
be increased slightly if operating the unit with less than
a 240 Vac circuit.
This appliance is provided with electrical wiring in a flex-•
ible metal conduit.
Model
Number
EORS127
MORS127
EORS130
MORS130
EORS136 5.3 kW (22 Amp.)
EORS227
MORS227
EORS230
MORS230
EORD227
MORD227
EORD230
MORD230
* The above specifications are for reference only. See the
appliance data plate (page 3) for exact specifications.
Dedicated Circuit
Requirements*
240 Vac 60 Hz,
30 Amp.
240 Vac 60 Hz,
40 Amp.
240 Vac 60 Hz,
50 Amp.
Total Connected
Load
5.0 kW (21 Amp.)
7.8 kW (33 Amp.)
10.0 kW (42 Amp.)
Product Dimensions
All tolerances: +1/16 (1.6 mm). -0, unless otherwise stated.
All Models
Model
Number
EORS127/
MORS127
EORS130/
MORS130
EORS136
EORX227/
MORX227
EORX230/
MORX230
X = Number of convection ovens, see page 3
* Width at light covers on sides
** To top of chassis notch behind control panel
Utility
Cutout
Width (F)
5”
(12.7 cm)
Overall
Width (A)
26 7/8”
(68.3 cm)
29 7/8”
(75.9 cm)
35 7/8”
(91.1 cm)
26 7/8”
(68.3 cm)
29 7/8”
(75.9 cm)
Utility
Cutout
Height (G)
5 ¼”
(13.3 cm)
Chassis
Width (B)*
25 3/8”
(64.5 cm)
28 3/8”
(72.1 cm)
34 3/8”
(87.3 cm)
25 3/8”
(64.5 cm)
28 3/8”
(72.1 cm)
Utility
Cutout
Depth (H)
6”
(15.2 cm)
Overall
Height (C)
28 7/16”
(72.2 cm)
28 5/8”
(72.7 cm)
49 15/16”
(127.0 cm)
Control
Panel
Depth (J)
1”
(2.54 cm)
Chassis
Height (D)**
27 1/2”
(69.9 cm)
27 5/8”
(70.2 cm)
49 1/16”
(124.6 cm)
Notch
Depth (K)
1 1/8”
(2.9 cm)
Control Panel
Overlay (E)
15/16”
(23.8 cm)
1” (2.5 cm)
7/8”
(2.2 cm)
Chassis
Depth (L)
24”
(61.0 cm)
Notch
Height (M)
1”
(2.5 cm)
4
Loading...