Custom Autosound USA-66 User Manual
Owner's Manual
MANUAL TUNED AM/FM RECEIVER,
CD CHANGER CONTROLLER
CUSTOM MADE FOR
"Classic Mustangs!"
◆ CHANGER CONTROLLER ◆ RCA PRE-AMP OUTPUTS
◆ AUXILIARY IN ◆ POWER ON/OFF & VOLUME
◆ AUTO- ANTENNA DRIVE LEAD ◆ FRONT/ REAR FADER
◆ HIGH POWER 200 WATTS (50 x 4) ◆ LEFT/RIGHT BALANCE
USA-66
A CUSTOM MADE REPLICA
OF THE 1966 Mustang AM-FM OPTION
(WITH ADDED FEATURES!)
LIMITED WARRANTY
If your product does not work properly because of a defect in material or work-
manship, Custom Autosound Mfg.,Inc. (the Company) will for the length of the
period indicated on the chart below, which starts with the date of original pur-
chase (“Limited Warranty period”), at its option either (a) repair your product with
new or refurbished parts, or (b) replace it with a new or refurbished product. The
decision to repair or replace will be made by the company.
During the “Labor” Limited Warranty period there will be no charge for labor.
During the “Parts” Limited Warranty period, there will be no charge for parts. This
Limited Warranty is extended only to the original purchaser and only covers
product purchased as new. A purchase receipt or other proof of the original pur-
chase date is required for Limited Warranty service.
To obtain repairs or replacement within the terms of this warranty, the product
should be delivered, transportation prepaid, to the Company at the address
shown below.
This warranty does not extend to the elimination of car static or motor noise cor-
rection antenna problems, costs incurred for removal or reinstallation of product,
or damage of tapes, speakers accessories or car electrical systems.
This warranty does not apply to any product or part thereof which has been
damaged through alteration, mishandling, misuse neglect, or accident.
ANY IMPLIED WARRANTY IS LIMITED TO THE DURATION OF THIS WRIT-
TEN WARRANTY. UNDER NO CIRCUMSTANCES SHALL THE COMPANY BE
LIABLE FOR ANY LOSS OR DAMAGE, DIRECT OR CONSEQUENTIAL, ARIS-
ING OUT OF THE USE OR INABILITY TO USE THIS PRODUCT: No person or
representative is authorized to assume for the Company any liability other than
expressed herein in connection with the sale of this product.
Some states do not allow limitations on how long an implied warranty last or the
exclusion or limitation of incidental or consequential damage to the above limita-
tions or exclusion may not apply to you.
This warranty gives you specific legal rights and you may also have other rights
which vary from state to state.
1030 W. Williamson Ave. Fullerton CA. 92833
800-888-8637 714-773-1423 FAX 714-773-1523
Product or Part Name PART S LABOR
All In-dash car radios, radio/tape
player combinations.
Two (2) Years One (1) Year
Table of Contents
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
General Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Radio Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Low Level Output Connection . . . . . . . . . . . . . . . . . . . .4
Wiring Diagram. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Controls and Display . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Receiver Basic Operation . . . . . . . . . . . . . . . . . . . . . . .7
CDC Changer Operation . . . . . . . . . . . . . . . . . . . . . . . .7
Aux Input Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Noise Suppression . . . . . . . . . . . . . . . . . . . . . . . . . . .8-9
Trouble Shooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
1
Radio Specifications
FM Section
Tuner Type . . . . . . . . . . . . . . . . . . . . . . . . .PLL
Frequency Range . . . . . . . . . . .87.5-1 08 MHz
Image Rejection . . . . . . . . . . . . . . . . . . . .50dB
Quieting Sensitivity . . . . . . . . . . . . . . . . . .4uV
T.H.D . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1%
IF Rejection . . . . . . . . . . . . . . . . . . . . . . .60dB
AM Section
Frequency Range . . . . . . . . . . . .530-1710KHz
S/N Ratio . . . . . . . . . . . . . . . . . . . . . . . . .50dB
Selectivity . . . . . . . . . . . . . . . . . . . . . . . . . 25dB
A
udio Section
Output Channel . . . . . . . . . . . . . . . . . . .50 X 4
Output Impedance . . . . . . . .4ohm per speaker
Response . . . . . . . . . . . . . . . . . . .30Hz-I 8KHz
General
Power Supply . . . . . .12VDC Negative Ground
Speaker impedance . . . . . . . . . . . . . .4-8 ohm
Stand-By Current . . . . . . . . . . . . . . . . . .0.02A
Chassis .... 180mm(7
7
/
8”)(w) X 70 (2 -
1
/
4")mm
. X 150 (5
5
/8")mm(D)
IF Frequency . . . . . . . . . . . . .10.7MHZ
Sensitivity . . . . . . . . . . . . . . . . . . .2.6V
S/N Ratio . . . . . . . . . . . . . . . . . .60dB
Capture Ratio . . . . . . . . . . . . . . .1.5dB
Separation . . . . . . . . . . . . . . . . .35dB
IF Frequency . . . . . . . . . . . . .450KHz
Sensitivity . . . . . . . . . . . . . . . . . .2OuV
System Power . . . . . . . . . . .200 Watts
THD . . . . . . . . . . . . . . . . . . . . . . .0.5%
Problem Cause Solution
NO Lights, NO Sound
Power Lead:Red Wire not con-
nected or Power not getting to
radio
Check fuse in filter box.Check
all connections on this wire
and verify that radio is getting
12V on this wire.
Lights but No Sound
Power Lead:Orange Wire not
Connected or power not getting
to radio
Check fuse in filter box.Check
all connections on this wire
and verify that radio is getting
12V on this wire
Lights Displayed but No
Sound
Problem with a speaker or
speaker wire
Verify all speakers used are
4ohm or greater. Verify that
none of the speakers are
going to ground.
Verify that none of the speak-
er wires are shorting to them-
selves or ground.
Sound only heard on one
side
Noise with Radio
Reception
Speaker wires disconnected
Balance control set to one side
Antenna not fully extended
Car underneath Fluorescent
lights
Check all connections
Adjust balance control to cen-
ter position
Extend antenna to full length.
Back vehicle out of garage
and test again
Loading...