Culligan Aqua-Cleer CC Basic Filter, Aqua-Cleer CC Basic RO, Aqua-Cleer CC Basic LC-100 RO, Aqua-Cleer CC Basic AC50 RO Installation & Operation Manual
Installation, Operation
& Service Instructions
with Parts List
®
CULLIGAN
Aqua-Cleer® CC Basic™
Cat. No. 01021819
Rev. O 12/31/08
DCO # 010916
Bottle-less Cooler
©2008 Culligan International Com pa ny
Printed in USA
Attention Culligan Customer:
Your local independently operated Culligan dealer employs trained service and maintenance personnel who are experienced
in the installation, function and repair of Culligan equipment. This publication is written specifically for these individuals and is
intended for their use.
We encourage Culligan users to learn about Culligan products, but we believe that product knowledge is best obtained by consulting with your Culligan dealer. Untrained individuals who use this manual assume the risk of any resulting property damage
or personal injury.
Culligan POU Coolers are combined with selected Culligan water treatment components to create a system specifically tailored to match the customer application.
Prior to servicing equipment, disconnect power supply to prevent electrical WARNING!
shock.
This system is not intended for use where water is microbiologically unsafe or with water of un-NOTE
known quality.
If incorrectly installed, operated or maintained, this product can cause severe WARNING!
injury. Those who install, operate, or maintain this product should be trained in
its proper use, warned of its dangers, and should read the entire manual before
attempting to install, operate, or maintain this product.
Products manufactured and marketed by Culligan International Company (Culligan) and its affiliates are protected by patents
issued or pending in the United States and other countries. Culligan reserves the right to change the specifications referred to
in this literature at any time, without prior notice. Culligan, Aqua-Cleer, Culligan Man and www.culligan.com are trademarks of
Culligan International Company or its affiliates.
Culligan International Company
9399 West Higgins Road, Suite 1100
Rosemont, Illinois 60018
To Order Culligan Parts call: 1-800-428-2828
www.culliganindustrial.com
www.culligancommercial.com
This device complies with part 15 of the FCC rules subject to the two follow-WARNING!
ing conditions: 1) This device may not cause harmful interference, and 2) This
device must accept all intereference received including interference that may
cause undesired operation.
This equipment complies with Part 15 of the FCC rules. Any changes or modifications not expressly approved by the manufacturer could void the user’s authority to operate the equipment. Changes or modifications not expressly approved by the party
responsible for compliance could void the user’s authority to operate the equipment.
Installation, Operation
& Service Instructions
Culligan® Aqua-Cleer®
CC Basic™
with Parts List
Bottle-less Cooler
Models from 2008
Contents
Key Pre-Delivery Activities ................................................ii
Introduction ....................................................................... 1
Safety Information ............................................................3
CC Basic™ Inspection and Setup .................................... 4
Installing the CC Basic™ .................................................. 8
Sanitizing the CC Basic™ ..............................................10
Descaling the CC Basic™ .............................................. 11
Troubleshooting .............................................................. 13
Technical Specifications ................................................. 14
Warranty .......................................................................... 15
CC Basic™ Parts List ..................................................... 16
Appendix Overview......................................................... 17
Appendix A .....................................................................18
Appendix B .....................................................................19
Appendix C ..................................................................... 22
Appendix D ..................................................................... 26
Appendix E .....................................................................29
Cat. No. 01021819
Contents i
Key Pre-Delivery Activities
The cooler and the water treatment equipment must be properly prepared before CAUTION!
the system is delivered to the customer.
Aqua-Cleer® CC Basic™ Filter Systems
Aqua-Cleer® CC Basic™ Filter—see Appendix A, Figure 5, on page 18.
Uses: sediment filter and carbon block filter in two (2) E-Z Change heads.•
Aqua-Cleer® CC Basic™ Reverse Osmosis Systems
Aqua-Cleer® CC Basic™ RO—see Appendix B, Figure 8 on page 19.
Uses: carbon block and RO 50 cartridges in two (2) E-Z Change heads with storage tank and inline post carbon •
filler.
®
For detailed instructions about • Aqua-Cleer
Service Manual, Cat. No. 01020219.
®
Aqua-Cleer
Aqua-Cleer
CC Basic™ LC-100 RO—see Appendix C, Figure 13 on page 22.
Uses: Preferred Series 250 Filter and LC-100 RO with storage tank and inline post carbon filter.•
For detailed instructions about Aqua-Cleer LC components please refer to the complete Installation, Operation and •
Service Manual, Cat. No. 01882074.
®
CC Basic™ AC50 RO—see Appendix D, Figure 17 on page 26.
Uses: AC50 inline post carbon filter and storage tank.•
For detailed instructions about AC 50 components please refer to the complete Installation, Operation and Service •
Manual, Cat. No. 01018587.
components please refer to the complete Installation, Operation and
Aqua-Cleer® CC Basic™ POU Cooler
Inspection and Setup Procedures—see Appendix E on page 29.
ii Culligan® Aqua-Cleer® CC Basic™
ii Cat. No. 01021819
Pre-Delivery Activity: Prepare and Flush Water Treatment Components
All RO Membranes will require a 24-hour flush to drain. All flushing of mem-CAUTION!
branes and filters must be done with chlorine-free, filtered, softened water.
Activity Aqua-Cleer®
Flush the filters to drain for at least five (5)
minutes with filtered soft water
Verify that system includes Automatic
Shut-Off Valve (01021587)
Verify that system includes Check Valve
(01021588)
Verify system includes Air Gap (44403001
or equivalent) for system drain
Flush the RO cartridge to a drain with filtered softened water for 24 hours prior to
installation
Flush the carbon block filter to drain for
at least five (5) minutes until there are no
more carbon fines observed.
Activate the Preferred Series 250 cartridge and thoroughly flush per the detailed
instructions
Flush the pre-carbon filter and sediment
filters to drain
Flush the carbon post filter to drain
Sanitize and flush the storage tank
CC Basic™
Filter
c
®
Aqua-Cleer
CC Basic™ RO
Aqua-Cleer
CC Basic™ LC-
100 RO
c c
c c
c c c
c c c
c
c
c c c
c c c
®
Aqua-Cleer
CC Basic™
AC50 RO
c
®
Pre-Delivery Activity: Prepare and Flush POU Cooler for Service
Activity Aqua-Cleer
Unpack the POU Cooler.
Inspect the POU Cooler for any shipping damage.
Flush and test the POU Cooler.
Cat. No. 01021819
®
CC Basic™ POU
Cooler
c
c
c
Key Pre-Delivery Activities iii
This page intentionally left blank.
iv Culligan® Aqua-Cleer® CC Basic™
iv Cat. No. 01021819
Introduction
The Culligan Aqua-Cleer® CC Basic™ system provides an economical solution to point-of-use water treatment systems in
the marketplace. Unlike a bottled water cooler, incoming tap water is treated as it is needed, so the water is always fresh
and great tasting. Best of all, there are no bottles to change and the supply is unlimited.
®
The Culligan Aqua-Cleer
nology depending on your needs and the incoming water supply.
The Culligan Aqua-Cleer
virtually any incoming water condition. You decide on the filtration package needed and then simply twist the filters selected into the EZ Aqua-Cleer filter heads behind the lower front panel.
The Culligan Aqua-Cleer
such as the AC-50 RO System and the LC-100 RO Membrane with Preferred Series Filter Systems.
This publication is based on information available when approved for printing. Continuing design refinements could cause
changes that may not be included in this publication.
CC Basic™ dispenses both hot and cold water using selected filters or reverse osmosis tech-
®
CC Basic™ is shipped with empty EZ change single heads that will enable configurations for
®
CC Basic™ has been designed to facilitate the use of other Culligan filtration and RO options
Cat. No. 01021819
Introduction 1
Safe Practices
Throughout this manual there are paragraphs set off by special headings.
Notice
Notice is used to emphasize installation, operation or maintenance information which is important, but does not present
any hazard. For example,
The nipple must extend no more than 1 inch above the cover plate.NOTICE
Caution
Caution is used when failure to follow directions could result in damage to equipment or property. For example,
Disassembly while under water pressure can result in flooding.CAUTION!
Warning
Warning is used to indicate a hazard which could cause injury or death if ignored. For example,
Electrical shock hazard! Unplug the unit before removing the timer mechanism or WARNING!
cover plates!
The CAUTION and WARNING paragraphs are not meant to cover all possible conditions and situations that may occur. It
must be understood that common sense, caution, and careful attention are conditions which cannot be built into the equipment. These MUST be supplied by the personnel installing, operating, or maintaining the system.
Be sure to check and follow the applicable plumbing codes and ordinances when installing this equipment. Local codes
may prohibit the discharge of sanitizing or descaling solutions to drain.
Use protective clothing and proper face or eye protection equipment when handling chemicals or power tools.
The Culligan Aqua-CleerNOTE
safe or of unknown quality without adequate disinfection either before or after the system.
®
CC Basic™ is not intended for use with water that is microbiologically un-
Check with your public works department for applicable local plumbing and sanitation codes. Follow NOTE
local codes if they differ from the standards used in this manual. To ensure proper and efficient operation of the Culligan Aqua-Cleer® CC Basic™ to your full satisfaction, carefully follow the instructions in
this manual.
2 Culligan® Aqua-Cleer® CC Basic™
2 Cat. No. 01021819
Loading...