CV-EHS Economy Hand Sink
Wash Stand with Wheels
General Overview
The CV-EHS Economy Hand Sink is easily
transportable with a built-in handle
and rubber treaded wheels. Designed for
use where convenient hand washing is
ces, classrooms, construction sites, festivals, food
service locations, etc., to be used indoors
or out. The compact design allows it to be
used most anywhere. Ideal where space is
limited. Shipped fully assembled.
cations
Height 62 in 157.5 cm
Width 18 in 45.5 cm
Depth 22 in 55.9 cm
Fresh Water Capacity 17 gal 64.4 L
Gray Water Capacity 19 gal 72 L
Pump Capacity
(per stroke)
Soap Dispenser
Capacity
Number of Single
Dispenses
Paper Towel
Capacity
Weight Empty 47 lb 21.3 kg
Weight Full 189 lb 85.7 kg
oz 59.14 ml
oz 887 ml
1088 1088
1 Roll or 500 Single Fold
User Manual
All materials, including resin, pigments and
additives used to make the plastic components as well as the plumbing components
that come in contact with the fresh water
are U.S. FDA food grade compliant.
CV-EHS Economy Hand Sink
June 2012
Page 1 of 4
Crown Verity Inc
37 Adams Blvd.
Brantford, Ontario
N3S 7V8
1-888.505.7240
www.crownverity.com
Parts Drawing - Exploded View
PC- 000339
Elbow 3/8" Tube x 3/8" Npt
PC-000581G - Sink Tap
(2) PC-000107 - Rivet
(2) PC-000106 - Washer
PSE2-0001
Sink Tank
PC-000415
Rubber UniSeal
PC-000551 - 1/2" Drain Plug
PC-000346 - 1/2” O-Ring
CT38-003
3/8" Tubing x 3" Long
PC-000600 - Baby Foot Pump
(4) PC-000102 - Rivet Small Flange
(4) PC-000106 - Washer
PC-000554 - 1" Fill Plug
PC-000345 - 1” O-Ring
PC-000325 - Straight
1" Npt x 3/4" Barb
PC-000351 - #10
Hose Clamp
CH075-037 - 3/4"
Drain Hose 37" Long
CT38-046 - Tubing
3/8" O.D. x 46" Long
PSE2-0002
Cover Plate
(4) PC-000158 - Screws
PS02-0003 - Foot Pump Plate
(2) PC-000147 - Screw
Important Decals
NOT FOR COOKING OR DRINKING, required by law in certain areas of the U.S. Other geographi-
cal areas require that the materials used to manufacture the sinks comply with the U.S. Federal
and 178.3297 (colorants for polymers). The materials also comply with the U.S. Public Health Service Drinking Water Standards, 42 CFR part 72 and U.S. Environmental Protection Agency Interim
Primary Drinking Water Regulations 40 CFR part 141.
HANDS FREE SINK, instruction for user to use foot pump to operate the sink.
UNIT MUST BE DRAINED BEFORE TRANSPORTING, reminds service operator to fully drain both
the fresh water and waste water tanks before transporting.
CV-EHS Economy Hand Sink
June - 2012
Page 2 of 4
n polymers)
Crown Verity Inc
37 Adams Blvd.
Brantford, Ontario
N3S 7V8
1-888.505.7240
www.crownverity.com
LS04-0001 Soap
Dispenser
(3) PC-000105 - Rivet
(3) PC-000106 - Washer
PC-000417
3/4” Uni-Seal
(Replaces the 1/2”
and elbow in
previous models)
PSE2-1000
Euro Wash Stand
Complete
(2) PC-000158 - Screw
Parts Drawing - Exploded View
TD04-1000 - Paper Towel
Dispenser
(4) PC-000105 Rivet
(4) PC-000106 Washer
PC-000213 - Wheel,
Rubber Tread
PC-000550 3” Gray Plug
PC-000377
- 3/4” Garden Hose Cap
PC-000313
- Rubber Hose Washer
PC-000376
- Fitting 1” x 3/4” MGHT
PC-000352
- Hose Clamp
CH100-0435
1”I.D. x 43.5” Long
PC-000352 - Hose Clamp
PC-100316 - Elbow
1” Barb x 1” Barb
PC-000417 - 3/4” Uni-Seal
PSW1-0001P
- Wash Stand W/Wheels Tank
PSW1-0021 - Axle
Filling with Fresh Water
ll plug located at the top, right hand side of the wash basin. Insert a
ll with a few gallons of fresh water to per-
form a system check. Depress the pump a few times to “prime” it (the pump has a built-in
check valve that will hold a prime between uses). lling to the top
(which is the 17 gallon water level capacity). nished.
Emptying Fresh Water
Drain the fresh water by unscrewing the 1/2” plug located at the bottom of the sink, to
nished.
Emptying Gray Water
Wheel the sink to a proper and approved drain location. Pull the hose out from the rib
on the back of the holding tank, remove the hose cap and empty the gray water. Re-
nished.
Paper Towel Dispenser
The dispenser is designed to accept single or multi fold, as well as roll towels. The
recommended towels are the single fold or the Baywest Ecosoft
#46200 - roll towel. NOTE: When using other towels, be sure the width does not exceed
9-1/2”.
CV-EHS Economy Hand Sink
June - 2012
Page 3 of 4
Crown Verity Inc
37 Adams Blvd.
Brantford, Ontario
N3S 7V8
1-888.505.7240
www.crownverity.com
Soap Dispenser
ll the soap dispenser, open it by placing your hands on both sides of the dispenser
uid ounces (or desired
amount) of liquid soap and snap the lid back on. To remove the dispenser for transporting the unit, remove the lid, and locate the tab on the middle of the mounting plate at
. Snap the
lid back onto the dispenser. IMPORTANT: at or transport your GrandStand
before either removing or completely draining the soap dispenser to avoid accidental
spillage of liquid soap as a slip/drop hazard may occur.
Winterizing
• Drain all water from the tanks.
• Depress the foot pump to clear lines.
• Flush tank with a solution of chlorine and water.
CLEANING AND MAINTENANCE
Use a mild soap to clean all surfaces and component parts.
Minor scratches and abrasions can be lightly sanded or scrubbed with a mild abrasive
cleaner (such as “Soft Scrub”) that contains calcium carbonate, hypochlorate bleach and
detergents. Be sure to follow the cleaning product directions since these ingredients
may cause hazardous gases when mixed with other chemicals. Rinse the cleaned area
with a conventional wax.
Some light scratches may also be hidden by using an industrial hot air gun.
To keep the water fresh add a “Fresh Sink Tablet” (chlorinated tablet)(our part number
lled with water.
THANK YOU FOR PURCHASING CROWN VERITY INC. PRODUCTS!
Look for us on the Web @ www.crownverity.com
CV-EHS Economy Hand Sink
June - 2012
Page 4 of 4
Crown Verity Inc
37 Adams Blvd.
Brantford, Ontario
N3S 7V8
1-888.505.7240
www.crownverity.com
Loading...