Page 1
Pass-Thru
Holding Cabinet
FL-2254LC
5925 Heisley Road • Mentor, OH 44060-1833
LITTLE CAESARS HOT-N-READY
OPERATING and MAINTENANCE INSTRUCTIONS
Model: H138NPS-CLC Pass-Thru Hot Cabinet Series
ELECTRICAL SPECIFICATIONS:
Model No. Volts Watts Amps Hertz Phase NEMA
H138NPS-CLC Series 120 1920 16 60 1 5-20P
H138NPS-CLC 240 Series 240 2000 8.3 60 1 6-15P
Rev. 7 (7/07) Page 1 of 4
H138NPS-CLC Series
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
Page 2
Pass-Thru
Holding Cabinet
FL-2254LC
Rev. 7 (7/07) Page 2 of 4
OPERATING and MAINTENANCE INSTRUCTIONS
Model: H138NPS-CLC Pass-Thru Hot Cabinet Series
HOW TO INSTALL UNIT:
Place cabinet on level fl oor.
1.
Plug cord into proper wall outlet.
2.
Yellow Light
5925 Heisley Road • Mentor, OH 44060-1833
LITTLE CAESARS HOT-N-READY
Power Switch
Thermostat
Thermometer
HOW TO START UNIT:
Push POWER switch to ON. The yellow light will
1.
turn on.
Turn thermostat knob to desired setting.
2.
Preheat cabinet for 30-45 minutes.
3.
Put food into cabinet and close door.
4.
Typical temperature settings:
No. 5-1/2 setting = approx. 160°F/71°C
No. 8 setting = approx. 185°F/85°C
NOTE: Proper food holding temperature is
140°F/60°C or higher.
TO TURN OFF UNIT:
Push the POWER switch to OFF.
The yellow light will go out.
WARNING
RISK OF FIRE OR ELECTRIC SHOCK
DO NOT OPEN
WARNING: TO REDUCE THE RISK OF FIRE OR ELECTRIC SHOCK,
DO NOT REMOVE COVER (OR BACK)
NO USER-SERVICEABLE PARTS INSIDE
REPAIR SHOULD BE DONE BY AUTHORIZED SERVICE
PERSONNEL ONLY
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
Page 3
Pass-Thru
Holding Cabinet
FL-2254LC
5925 Heisley Road • Mentor, OH 44060-1833
LITTLE CAESARS HOT-N-READY
OPERATING and MAINTENANCE INSTRUCTIONS
Model: H138NPS-CLC Pass-Thru Hot Cabinet Series
Cleaning Notes:
Wipe up spills as soon as possible.
WARNING
BEFORE Cleaning the Cabinet:
Allow cabinet to cool.
1.
Do NOT use abrasives or harsh chemicals.
2.
HOW TO CLEAN UNIT:
SOIL CLEANER METHOD
Mild detergent* and hot water, or mild
DIRT
FINGERPRINTS,
GREASE and OIL
WATER SPOTS Mild abrasive cleaner.
abrasive cleaner.
Steam (no strong alkaline additive).
Chemical oven cleaner.
Mild abrasive cleaner; oily or waxy
cleaner.
*Mild detergents include soaps and non-abrasive cleaners.
1.
Clean cabinet regularly to avoid heavy dirt build-up.
2.
Make a test spot with cleaner.
3.
Follow manufacturer’s directions on cleaner.
4.
Do not mix cleaners.
5.
Avoid drips and splashes.
6.
1. Use soft, damp cloth.
2. Rinse with hot water
3. Wipe dry.
1. Rinse after steam cleaning.
2. Wipe dry.
Follow oven cleaner manufacturer’s
directions
Apply with a soft, clean cloth.
1. Apply with damp cloth.
2. Rinse and dry.
Rev. 7 (7/07) Page 3 of 4
TROUBLE-SHOOTING CHART:
FAILURE: POSSIBLE CAUSE:
1a. Circuit breaker/fuse to wall outlet is blown
1. Yellow light on switch does NOT light.
2. Unit does not heat.
3. Unit gets too hot or won’t shut off.
4. Blower does not work or makes noise. 4a. Defective blower
If cause is none of the above, refer to our list of Authorized Service Centers, FL-1400
1b. Cord is unplugged from wall outlet.
1c. Switch is “OFF.”
2a. Thermostat set too low or is “OFF.”
2b. Switch is “OFF.”
3a. Defective electrical parts. UNPLUG UNIT
FROM WALL OUTLET :
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
Page 4
Pass-Thru
Holding Cabinet
FL-2254LC
Rev. 7 (7/07) Page 4 of 4
5925 Heisley Road • Mentor, OH 44060-1833
LITTLE CAESARS HOT-N-READY
OPERATING and MAINTENANCE INSTRUCTIONS
Model: H138NPS-CLC Pass-Thru Hot Cabinet Series
HOT UNIT REPLACEMENT PARTS: CABINET REPLACEMENT PARTS:
DESCRIPTION 120 VOLT 240 VOLT DESCRIPTION CMP NO.
Power Unit 0675-048LC 0675-057LC Door, Full 1221-540
Heater, Air 0811-074 0811-074-1 Door , Full, Window 1221-550
High Limit 0848-060 0848-060 Door, Half, Window 1221-535-01
Thermometer 5238-030 5238-030 Door, Half 1221-534
Thermostat, Air 0848-008-ACK 0848-008-ACK Door Gasket, Full 0861-246
Power Cord 0810-065-12-K 0810-039-07-K Door Gasket, Half 0861-245
Power Switch 0808-116 0808-116 Door Hinge (Full Door) 0519-089
Power Light 0766-094 0766-095 Door Hinge (Half Door) 0519-087-K
Vent Fan 0769-165 0769-174 Door Latch 1006-120-01
Blower 0769-180-K 0769-182-K Caster 0569-306
Caster with Brake 0569-306-B
Angle Slide Set 0621-281-K
Post, Angle Slide 0696-228
Blower Guard 1170-211
6-15P PLUG
240V, 15A
NOTES:
120V. UNITS - ATTACH WIRE #15 TO
TERMINAL #9 OF TEMP. CONT. BOARD.
208/240V. UNITS - ATTACH WIRE #15 TO
TERMINAL #10 OF TEMP. CONT. BOARD.
WIRE NUT UNUSED LEAD.
= PROTECTIVE SLEEVE
BM = BLOWER MOTOR
FAN = VENT FAN
A = AMBER (YELLOW) LIGHT
W
G
G
5-20P
120V; 20A
WIRING DIAGRAM
Full-Height Pass-Thru Units
TEMPERATURE CONTROL BOARD
POWER
SWITCH
10 9 8
15
2
1
54
16 4 520
t°
SENSOR
TERMINAL BLOCK
16
15
G
4
2
1
67
HEATER AIR
HIGH LIMIT
56
3
HIGH LIMIT
21
A
8
BM
FAN
FANBM
7
2324
34
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
Loading...