Page 1
5925 Heisley Road • Mentor, OH 44060-1833
877/CRES COR (273-7267) • 440/350-1100
Fax: 440/350-7267 • www.crescor.com
OPERATING and MAINTENANCE INSTRUCTIONS
Model H138NPS1813CLA and H138NPS1832CLA
Pass-thru Hot Cabinet Series
ELECTRICAL SPECIFICATIONS:
MODEL No. Volts Watts Amps Hertz Phase NEMA
H138NPS1813CLA 120 2000 16.6 60 1 5-30P
H138NPS1832CLA 120 2000 16.6 60 1 5-30P
Pass-thru
Holding Cabinet
Rev. 3 (9/04) Page 1 of 5
FL-2254LA
H138NPS1813CLA H138NPS1832CLA
Page 2
5925 Heisley Road • Mentor, OH 44060-1833
877/CRES COR (273-7267) • 440/350-1100
Fax: 440/350-7267 • www.crescor.com
OPERATING and MAINTENANCE INSTRUCTIONS
Model H138NPS1813CLA and H138NPS1832CLA
Pass-thru Hot Cabinet Series
HOW TO INSTALL UNIT:
1. Place cabinet on level floor.
2. Plug cord into proper wall outlet.
Pass-thru
Holding Cabinet
Rev. 3 (9/04) Page 2 of 5
FL-2254LA
HOW TO START UNIT:
1. Turn POWER switch to ON.
The yellow light will turn on.
2. Turn thermostat to #10.
3. Preheat cabinet for 30 minutes.
4. Put food into cabinet.
5. Turn thermostat to #8 ½ and close door.
No. 8 setting = approx. 185°F (85°C)
No. 6 setting = approx. 160°F (71°C)
No. 4 setting = approx. 130°F (54°C)
NOTE: Proper food holding temperature is
140°F/60°C or higher.
TO TURN OFF UNIT:
Turn the POWER switch to OFF.
The yellow light will go out.
Page 3
5925 Heisley Road • Mentor, OH 44060-1833
877/CRES COR (273-7267) • 440/350-1100
Fax: 440/350-7267 • www.crescor.com
Pass-thru
Holding Cabinet
Rev. 3 (9/04) Page 3 of 5
OPERATING and MAINTENANCE INSTRUCTIONS
Model H138NPS1813CLA and H138NPS1832CLA
Pass-thru Hot Cabinet Series
BEFORE CLEANING THE CABINET:
1. Allow cabinet to cool.
2. Do NOT use abrasives or harsh chemicals.
HOW TO CLEAN UNIT:
SOIL CLEANER METHOD
Mild detergent* and hot
water, or mild abrasive
cleaner.
Steam (no strong alkaline
additive).
Chemical oven cleaner.
and OIL
WATER SPOTS Mild abrasive cleaner.
*Mild detergents include soaps and non-abrasive cleaners.
TROUBLE SHOOTING CHART:
FAILURE:
1. Yellow light on switch does NOT light.
2. Unit does not heat.
3. Unit gets too hot or won't shut off.
4. Blower does not work or makes noise.
If cause is none of the above, refer to our list of Authorized Service Centers, FL-1400.
Mild abrasive cleaner; oily
or waxy cleaner.
1a. Circuit breaker/fuse to wall outlet is blown
1b. Cord is unplugged from wall outlet.
1c. Switch is "OFF."
2a. Thermostat set too low or is "OFF."
2b. Switch is "OFF."
3a. Defective electrical parts. UNPLUG UNIT
Cleaning Notes:
1. Wipe up spills as soon as possible.
2. Clean cabinet regularly to avoid heavy dirt
build-up.
3. Make a test spot with cleaner.
4. Follow manufacturer’s directions on cleaner.
5. Do not mix cleaners.
6. Avoid drips and splashes.
1. Use soft, damp cloth.
2. Rinse with hot water
3. Wipe dry. DIRT
1. Rinse after steam cleaning.
2. Wipe dry.
Follow oven cleaner
manufacturer’s directions FINGERPRINTS, GREASE
Apply with a soft, clean cloth.
1. Apply with damp cloth.
2. Rinse and dry.
POSSIBLE CAUSE:
FROM WALL OUTLET:
4a. Defective blower
FL-2254LA
Page 4
5925 Heisley Road • Mentor, OH 44060-1833
877/CRES COR (273-7267) • 440/350-1100
Fax: 440/350-7267 • www.crescor.com
OPERATING and MAINTENANCE INSTRUCTIONS
Model H138NPS1813CLA and H138NPS1832CLA
Pass-thru Hot Cabinet Series
REPLACEMENT PARTS:
Power Unit 0675-007
Heater, Air 0811-074
High Limit 0848-060
Thermometer 5238-030
Thermostat, Air 0848-062-K
Power Cord 0810-158-K
Power Switch 0808-116
Pass-thru
Holding Cabinet
Rev. 3 (9/04) Page 4 of 5
FL-2254LA
Power Light 0766-094
Vent Fan 0769-165
Blower 0769-005
Door, Complete, Full 1221-540
Door, Complete, Half 1221-534
Door Gasket, Full 0861-246
Door Gasket, Half 0861-245
Door Hinge 0519-089
Caster 0569-290
Caster with Brake 0569-290 B
Rack Insert 1103-104
Door Latch 1006-120-01
Page 5
5925 Heisley Road • Mentor, OH 44060-1833
877/CRES COR (273-7267) • 440/350-1100
Fax: 440/350-7267 • www.crescor.com
OPERATING and MAINTENANCE INSTRUCTIONS
Model H138NPS1813CLA and H138NPS1832CLA
Pass-thru Hot Cabinet Series
Wiring Diagram
Full-Height Pass-thru Units
Pass-thru
Holding Cabinet
Rev. 3 (9/04) Page 5 of 5
FL-2254LA
Loading...