Cres Cor H137WSRRC2020, HCWH2020 Installation Manual

5925 Heisley Road • Mentor, OH 44060-1833

OPERATING and MAINTENANCE INSTRUCTIONS

Models: H137WSRR-C Series Companion Holding Cabinet

FL-2330

Rev. 0 (2/07)

Models: H137WSRRC2020 SERIES for use with Convotherm C2020 Roll-In Rack (not included).

Cabinet model number:
Cabinet serial number:
Authorized Service Agency:
Ph: Fax:

Keep this manual for future reference.

FL-2330
Rev. 0 (2/07)

5925 Heisley Road • Mentor, OH 44060-1833

TABLE OF CONTENTS

SUBJECT PAGE

INSTALLATION INSTRUCTIONS..............................................................................................2

Illustration (Leg Adjustment), Figure 1...............................................................................2

Illustration (Drain Valve), Figure 2......................................................................................2

OPERATING INSTRUCTIONS………………...…………..……………...……..…….….........3

Illustration (Control Panel), Figure 3………….……..…………….....……………….......3

MAINTENANCE INSTRUCTIONS

How to Clean the Unit………………………………....………….....………………........4

Trouble Shooting Guide……………………………...…………....…………………........5

Replacement Parts (Cabinet)……………………………….……….......………….............6

Illustration (Cabinet Parts)...................................................................................................7

Replacement Parts (Power Unit)..........................................................................................8

Wiring Diagram.........................……...……………………......……….……….................9

How to Reverse the Door Opening.....................................................................................10

Companion

Holding Cabinet

FL-2330

5925 Heisley Road • Mentor, OH 44060-1833

Rev. 0 (2/07) Page 1 of 10

OPERATING and MAINTENANCE INSTRUCTIONS

Models: H137WSRR-C Series Companion Holding Cabinet

IDENTIFYING YOUR CABINET:

Look for this label on the back of your cabinet. This information is needed when calling for questions or service.

ELECTRICAL SPECIFICATIONS:

Model No. Volts Watts Amps Hertz Phase NEMA

HCWH2020

HCWH2020208

HCWH2020240

Note: The above model numbers are basic models. They may be followed by letters: L, M, 2M, D, or ending with S.

120 1920 16.0 60 1 5-20P

208 2000 10.0 60 1 6-15P

240 2000 8.6 60 1 6-15P

Companion

Holding Cabinet

FL-2330

Rev. 0 (2/07) Page 2 of 10

OPERATING and MAINTENANCE INSTRUCTIONS

Models: H137WSRR-C Series Companion Holding Cabinet

HOW TO INSTALL UNIT:

Remove all paper and packing material from inside of

1.
cabinet.
Remove protective paper and vinyl material from

2.
outside surfaces of cabinet.
Place the cabinet in a well-ventilated area.

3.
Place cabinet on level fl oor. (For cabinets with legs,

4.
adjust the legs of the cabinet to ensure proper fi t of rack
into cabinet. See Fig. 1)
Plug cord end into proper wall outlet.

5.
Fill water pan with 4 gallons (15 liters) of water.

6.

Make sure green drain valve is closed. See Figure 2.

Use of treated or

soft water may be
required for proper

operation and to maintain warranty.

5925 Heisley Road • Mentor, OH 44060-1833

Figure 1 Leg Adjustment

7. Push POWER switch to “ON.” Yellow POWER

LIGHT will come on.

8. Push the “SET” button on the TEMPERATURE

CONTROL. The TEMPERATURE DISPLAY will
show “SP1” (set point 1).

9. Press “SET” again and the current set point temperature

will be displayed.

10. Press the  ADJUST buttons to adjust to 200°F
(93°C).

11. Run the unit for one hour.

NOTE: DO NOT PUT FOOD IN CABINET!

This step is to burn off manufacturing oils and excess
adhesive.

Air is VERY HOT when door is opened.

Figure 2 Drain Valve

12. Let the cabinet cool and wipe inside clean with
detergent and hot water before fi rst use.