Page 1
Insulated
Hot Cabinet
FL-2251-J
5925 Heisley Road • Mentor, OH 44060-1833
Rev. 3 (3/07) Page 1 of 5
OPERATING and MAINTENANCE INSTRUCTIONS
Models: H137...CDJ & H13818...CDJ Series Hot Cabinets (Aluminum)
H137S...CDJ & H138S18...CDJ Series Hot Cabinets (Stainless)
ELECTRICAL SPECIFICATIONS:
Model No. Volts Watts Amps Hertz Phase NEMA
H137UA12CDJ1
H137SUA12CDJ1
H137UA9CDJ1
H137SUA9CDJ1
H1381834CDJ1
H138N1834CDJ1
H138S1834CDJ1
H137UA12CDJ2
H137SUA12CDJ2
H1381834CDJ2
H138S1834CDJ2
100 1400 14 50/60 1 5-15P
208 2000 9.6 50/60 1 6-16P
H137UA9CDJ2
H137SUA9CDJ2
H137SUA5CDJ1
H137SUA6CDJ1
H138S1816CDJ1
H137SUA5CDJ2
H137SUA6CDJ2
H138S1816CDJ2
208 1500 7.2 50/60 1 6-15P
100 1042 10.4 50/60 1 5-15P
208 1000 4.8 50/60 1 6-15P
NOTE: The above model numbers are basic models. They may be followed by letters: M
L, or ending with S.
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
Page 2
Insulated
Hot Cabinet
FL-2251-J
Rev. 3 (3/07) Page 2 of 5
5925 Heisley Road • Mentor, OH 44060-1833
OPERATING and MAINTENANCE INSTRUCTIONS
Models: H137...CDJ & H13818...CDJ Series Hot Cabinets (Aluminum)
H137S...CDJ & H138S18...CDJ Series Hot Cabinets (Stainless)
HOW TO INSTALL UNIT:
Place cabinet on level fl oor.
1.
Place cabinet in a well ventilated area.
2.
Plug cord end into proper wall outlet.
3.
INITIAL OPERATION:
NOTE: The optional digital thermometer display
fl ashes when temperature in center of cabinet
is below 60°C (140°F) or above 121°C
(250°F). Call the factory if you need different
settings.
(For fi rst-time operation only):
NOTE: A new oven needs to “burn of f” manufacturing
oils and excess adhesive before its fi rst use.
Do NOT load food into oven until this has
been done!
Turn the POWER switch on. The yellow light will
1.
turn on.
Turn thermostat to #10.
2.
Let unit operate for one hour.
3.
Turn unit off and let cool.
4.
Wipe inside clean with detergent and hot water.
5.
HOW TO START UNIT:
1.
Turn the POWER switch on. The yellow light will
turn on.
2.
Turn the thermostat to #6½.
3.
Preheat cabinet for one (1) hour.
4.
Put food into cabinet.
5.
Turn thermostat to desired setting and close door.
No. 8 setting = approx. 85°C / 185°F
No.6 setting = approx. 71°C / 160°F
No.4 setting = approx. 54°C / 130°F
Proper food holding temperature is 60°C / 140°F or higher.
TO TURN OFF UNIT:
Turn the POWER switch off. The yellow light will go out.
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
Page 3
Insulated
Hot Cabinet
FL-2251-J
5925 Heisley Road • Mentor, OH 44060-1833
Rev. 3 (3/07) Page 3 of 5
OPERATING and MAINTENANCE INSTRUCTIONS
Models: H137...CDJ & H13818...CDJ Series Hot Cabinets (Aluminum)
H137S...CDJ & H138S18...CDJ Series Hot Cabinets (Stainless)
BEFORE CLEANING CABINET:
Allow the cabinet to cool.
1.
Do NOT use abrasives or harsh chemicals.
2.
Is your cabinet aluminum or stainless steel
construction? Be sure your cleaner is suitable
for that material.
Note: Stainless Steel cabinets hae an “S” in
their model numbers.
Cleaning hints:
Wipe up spills as soon as possible.
1.
Clean cabinet regularly to avoid heavy dirt build-up.
2.
Make a test spot with cleaner.
3.
Follow manufacturer’s directions on cleaner.
4.
Do not mix cleaners.
5.
Avoid drips and splashes.
6.
HOW TO CLEAN THE UNIT:
Soil Cleaner Method
Mild Detergent* and hot water, or
mild abrasive cleaner.
Dirt
Steam (no strong alkaline additive)
Mild abrasive cleaner.
Oily or waxy cleaner.
Fingerprints, grease, oil
Chemical oven cleaner.
Water Spots Mild abrasive cleaner.
*Mild detergent includes soaps and non-abrasive cleaners.
1. Wipe with soft, damp cloth.
2. Rinse with hot water.
3. Wipe Dry.
1. Rinse after steam cleaning.
2. Wipe Dry
Apply with soft, clean cloth.
Follow oven cleaner manufacturer’s
instructions
1. Apply with soft, clean cloth.
2. Wipe with damp cloth.
TROUBLE-SHOOTING CHART:
FAILURE: POSSIBLE CAUSE:
1. Yellow light at switch does NOT light.
2. Unit does not heat.
1a. Circuit breaker/fuse to wall outlet is blown
1b. Cord is unplugged from wall outlet.
1c. Switch is “OFF.”
2a. Thermostat set too low or is “OFF.”
2b. Switch is “OFF.”
3. Unit gets too hot or won’t shut off. 3a. Defective electrical parts.
UNPLUG UNIT FROM WALL OUTLET
4. Blower does not work or makes noise. 4a. Defective blower
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
Page 4
Insulated
Hot Cabinet
FL-2251-J
Rev. 3 (3/07) Page 4 of 5
5925 Heisley Road • Mentor, OH 44060-1833
OPERATING and MAINTENANCE INSTRUCTIONS
Models: H137...CDJ & H13818...CDJ Series Hot Cabinets (Aluminum)
H137S...CDJ & H138S18...CDJ Series Hot Cabinets (Stainless)
REPLACEMENT PARTS:
PART DESCRIPTION 100V 208V
Blower Kit 0769-005-K 0769-006-K1
Heater Kit (1042/1000W) 0811-265 0811-074-02
(1333/1500W) 0811-268 0811-266
(2000W) 0811-269
Thermometer – digital, °C 5238-034-K1 5238-034-K1
Transformer (used with digital thermometer) 0769-159 0769-159
Thermostat 0848-062-K 0848-062-K
Power Cord 0810-029-06 0810-039-07
Power Switch 0808-116 0808-116
Power Light 0766-094 0766-095
Vent Fan 0769-165 0769-174
Terminal Block 0852-091 0852-091
CABINET REPLACEMENT PARTS:
DESCRIPTION
Caster, Swivel, with Brake 0569-306-B
Caster, Swivel 0569-306
Door Latch 1006-122-01-K
Door Strike 1006-122-02-K
Corner Bumper Kit 1056-002-K
REPLACEMENT PARTS:
PART DESCRIPTION
Door Hinge 0519-087
Door Gasket 0861-235
Door Assembly complete 1221-524
Power Unit complete 100V 0675-002-DC
Power Unit complete 208V 0675-005-DC
Push Handle, full ht. cabinets 1087-101
Interior Insert – H137 Series 0621-281
Rack Insert – H138 Series 1103-103
H137UA12CDJ
H1381834CDJ
H137SUA12CDJ
H137SUA6CDJ
H138S1834CDJ
H138S1816CDJ
0519-074 0519-087 0519-087 0519-074
0861-185 0861-263 0861-236 0861-182
1221-525 1221-554 1221-527 1221-526
0675-002-DC 0675-066-DC 0675-002-DC 0675-002-DC
0675-005-DC - 0675-005-DC 0675-005-DC
1087-101 1087-115-K 1087-101 1087-101
0621-281 - 0621-281 0621-281
1103-103 1103-107 - -
H138N834CDJ H137UA9CDJ H137SUA9CDJ
H137SUA5CDJ
0519-074
0861-250
1221-545
0675-002-DC
0675-005-DC
-
0621-281
-
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
Page 5
Insulated
Hot Cabinet
FL-2251-J
5925 Heisley Road • Mentor, OH 44060-1833
Rev. 3 (3/07) Page 5 of 5
OPERATING and MAINTENANCE INSTRUCTIONS
Models: H137...CDJ & H13818...CDJ Series Hot Cabinets (Aluminum)
H137S...CDJ & H138S18...CDJ Series Hot Cabinets (Stainless)
WIRING DIAGRAM
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
Loading...