IMI CORNELIUS INC.
www.cornelius.com
Nordic
Model CCM1848***1 & 2148***1
Service Parts Manual
Publication Number: 631806064
Revision Date: November 14, 2008
Revision: B
Visit the IMI Cornelius web site at www.cornelius.com for all your Literature needs.
CCM1848***1 & CCM2148***1 Service Parts Manual Manual Number 631806064
SERVICE PARTS MANUAL
22 INCH WIDE ICE SERIES CUBERS
MODEL-ICE0320, ICE0520
Includes 50Hz. Units
ICE-O-Matic
11100 East 45th Ave
Denver, Colorado 80239
Part Number 9081297-01 PD04/02 Rev1/05
CCM Series Service Parts Table of Contents
This parts list contains the service parts available for the following icemakers.
CCM1848***1 Water and Remote
CCM2148***1 Water and Remote
Check the model number on the data plate and refer to the correct listing for the specific component.
Check carefully that the correct part is identified and ordered.
Table of Contents Page 1
Exterior Panels Page 2
Water Cooled Page 4
Remote Page 6
Control Box Page 8
Harvest Assist Page 10
Water Pump/Float Page 12
Remote Condenser Page 14
E-Mail: tech.service@Cornelius.com
Website: www.cornelius.com
Telephone Number
800-238-3600 All Departments
The CCM Series Service manual is available separately Part Number 631806061
Note: Model Number Suffix Indicates Machine Voltage As Follows:
1=115/60/1
2=208-230/60/1
3=208-230/60/3
5=230/50/1
Engineering Revision Level =1
Page 1
CCM1848***1 & CCM2148***1 Exterior Panels
Page 2
CCM1848***1 & CCM2148***1 Exterior Panels
r
Item
No. CCM1848 2 CCM1848 3 CCM2148 2 CCM2148 3 Description
1 620204773 620204773 620204773 620204773 Front Panel
2 620204774 620204774 620204774 620204774 Front Panel Screws
3 620204859 620204859 620204859 620204859 Right Hand Side Panel-Water Cooled and Remote Only
4 620204772 620204772 620204772 620204772 Top Panel
5 620204444 620204444 620204444 620204444 Top Panel Screws
6 620204858 620204858 620204858 620204858 Left Hand Side Panel-Water Cooled and Remote Only
7 620204442 620204442 620204442 620204442 Side Panel Screw
8 620204868 620204868 620204868 620204868 Rear Panel
9 620204441 620204441 620204441 620204441 Rear Cover Panel Screws
10 620204864 620204864 620204864 620204864 Junction Box Cover
11 620204441 620204441 620204441 620204441 Junction Box Cover Screws
12 620204866 620204866 620204866 620204866 Ice Deflector
13 620204893 620204893 620204893 620204893 Control Box Top Cover
14 620204863 620204863 620204863 620204863 Control Box Side Cove
Model Number
Page 3
CCM1848***1 & CCM2148***1 Water Cooled
Page 4
CCM1848***1 & CCM2148***1 Water Cooled
f
Item
No. CCM1848 2 CCM1848 3 CCM2148 2 CCM2148 3 Description
1 620204690 620204691 620204878 620204879 Compressor
2 620204602 620204602 620204602 620204602 Filter Drier
3 620204880 620204880 620204880 620204880 Expansion Valve
4 620204612 620204612 620204612 620204612 Hot Gas Valve Body
5 620204614 620204614 620204614 620204614 Hot Gas Valve Coil
6 620204480 620204480 620204480 620204480 High Temperature Safety Control
7 620204597 620204597 620204597 620204597 Water Condenser
8 620204816 620204816 620204816 620204816 Evaporator Splash Curtain
9 620204866 620204866 620204866 620204866 Ice Deflector
10 620204499 620204499 620204499 620204499 Washer Tube
11 620204873 620204873 620204873 620204873
11 620204874 620204874 620204874 620204874
12 620204874 620204874 620204874 620204874
12 620204875 620204875 620204875 620204875
13 620204495 620204495 620204495 620204495 Evaporator Left Side Mounting Panel
14 620204494 620204494 620204494 620204494 Evaporator Right Side Mounting Panel
15 620204486 620204486 620204486 620204486 Water return
16 620204709 620204709 620204709 620204709 Spillway
17 620204534 620204534 620204534 620204534 Valve Core
18 620204535 620204535 620204535 620204535 Valve Cap
19 620204552 620204552 620204552 620204552
20 620204552 620204552 620204552 620204552
21 620204464 620204464 620204464 620204464 Water Regulating Valve
22 620204867 620204867 620204867 620204867 Rear Brace
23 620204474 620204474 620204474 620204474 High Pressure Control
24 620204529 620204529 620204529 620204529 Condenser Drain Fitting
Model Number
Evaporator Right Side Full Cube
Evaporator Right Side Half Cube
Evapoartor Left Side Full Cube
Evapoartor Left Side Hal
Bin Switch Right Side (Cut Arm)
Bin Switch Left Side (Cut Arm)
Cube
Page 5
CCM1848***1 & CCM2148***1 Remote
Page 6
CCM1848***1 & CCM2148***1 Remote
f
Item
No. CCM1848 2 CCM1848 3 CCM2148 2 CCM2148 3 Description
1 620204690 620204691 620204878 620204879 Compressor
2 620204602 620204602 620204602 620204602 Filter Drier
3 620204880 620204880 620204880 620204880 Expansion Valve
4 620204612 620204612 620204612 620204612 Hot Gas Valve Body
5 620204614 620204614 620204614 620204614 Hot Gas Valve Coil
6 620204480 620204480 620204480 620204480 High Temperature Safety Control
7 620204609 620204609 620204609 620204609 Receiver
8 620204493 620204493 620204493 620204493 Evaporator Splash Curtain
9 620204866 620204866 620204866 620204866 Ice Deflector
10 620204499 620204499 620204499 620204499 Washer Tube
11 620204873 620204873 620204873 620204873
11 620204874 620204874 620204874 620204874
12 620204874 620204874 620204874 620204874
12 620204875 620204875 620204875 620204875
13 620204495 620204495 620204495 620204495 Evaporator Left Side Mounting Panel
14 620204494 620204494 620204494 620204494 Evaporator Right Side Mounting Panel
15 620204486 620204486 620204486 620204486 Water return
16 620204709 620204709 620204709 620204709 Spillway
17 620204534 620204534 620204534 620204534 Valve Core
18 620204535 620204535 620204535 620204535 Valve Cap
19 620204552 620204552 620204552 620204552
20 620204552 620204552 620204552 620204552
21 620204855 620204855 620204855 620204855 Remote Shut-Off Valve (Large)
620204856 620204856 620204856 620204856 Remote Shut-Off Valve (Small)
22 620204867 620204867 620204867 620204867 Rear Brace
23 620204474 620204474 620204474 620204474 High Pressure Control
24 620204475 620204475 620204475 620204475 Pump Down Control
25 620204612 620204612 620204612 620204612 Liquid Line Solenoid
26 620204891 620204891 620204891 620204891 Accumulator Assembly
620204527 620204527 620204527 620204527 1/2 Inch Coupling (Not Shown)
620204526 620204526 620204526 620204526 3/8 Inch Coupling (Not Shown)
620204623 620204623 620204623 620204623 Check Valve (Not Shown)
Model Number
Evaporator Right Side Full Cube
Evaporator Right Side Half Cube
Evapoartor Left Side Full Cube
Evapoartor Left Side Hal
Bin Switch Right Side (Cut Arm)
Bin Switch Left Side (Cut Arm)
Cube
Page 7
CCM1848***1 & CCM2148***1 Control Box
Page 8
CCM1848***1 & CCM2148***1 Control Box
A
A
A
A
y
Item
No. CCM1848 2 CCM1848 3 CCM2148 2 CCM2148 3 Description
1 620204545 620204782 620204545 620204782 Contactor
2 620204548 620204548 620204548 620204548 Relay Base
3 620204551 620204551 620204551 620204551 Relay
4 620204553 620204553 620204553 620204553 Purge Switch
5 620204557 620204557 620204557 620204557 ICE-OFF-WASH Switch
6 620204556 620204556 620204556 620204556 Timer
7 620204556 620204556 620204556 620204556 Timer (6 Minute-Remote only)
8 620204476 620204476 620204476 620204476 Low Pressure Control (Timer Initiate)
9 620204652 N/A 620204652 N/A Start Capacitor
10 620204674 N/A 620204671 N/A Run Capacitor
11 620204676 N/
CCM1848 2 CCM1848 3 CCM2148 2 CCM2148 3
620204690 620204691 620204878 620204879 Compressor Kit
620204652 N/A 620204652 N/A Start Capacitor
620204674 N/A 620204671 N/A Run Capacitor
620204676 N/
Model Number
620204677 N/
620204677 N/
Compressor Relay
Rela
Page 9
CCM1848***1 & CCM2148***1 Harvest Assist
Page 10
CCM1848***1 & CCM2148***1 Harvest Assist
Item
No. CCM1848 2 CCM1848 3 CCM2148 2 CCM2148 3 Description
1 620204366 620204366 620204366 620204366 Bracket, Probe Motor
2 620204631 620204631 620204631 620204631 Gear Motor
3 620204569 620204569 620204569 620204569
620204571 620204571 620204571 620204571
4 620204483 620204483 620204483 620204483 Snap Bushing
5 620204481 620204481 620204481 620204481 Snap Bushing
6 620204439 620204439 620204439 620204439 #6-32 x 1/2 Fillister Head Screw
7 620204484 620204484 620204484 620204484 Connecting Rod
8 620204424 620204424 620204424 620204424 Probe, Single Length
9 620204427 620204427 620204427 620204427 Plain Flat Washer
10 620204451 620204451 620204451 620204451 Shoulder Screw
11 620204516 620204516 620204516 620204516 Spacer, Cam Switch
12 620204556 620204556 620204556 620204556 Cam Switch
13 620204407 620204407 620204407 620204407 Insulator, Switch
14 620204434 620204434 620204434 620204434 Pan Head Machine Screw
15 620204452 620204452 620204452 620204452 Speed Nut Plate
14 620204312 620204312 620204312 620204312
15 620204313 620204313 620204313 620204313
Model Number
Clutch Assembly 160 Degree Cam, Right Side
Clutch Assembly .312R Cam, Left Side
Complete Assembly-Primary-Right Side
Complete Assembly-Secondary-Left Side
Page 11
CCM1848***1 & CCM2148***1 Water Pump/Float
Page 12
CCM1848***1 & CCM2148***1 Water Pump/Float
Item
No. CCM1848 2 CCM1848 3 CCM2148 2 CCM2148 3 Description
1 620204865 620204865 620204865 620204865 Water Pump Bracket
2 620204639 620204639 620204639 620204639 Water Pump
3 620204565 620204565 620204565 620204565 Float
4 620204563 620204563 620204563 620204563 Float Deflector
5 620204467 620204467 620204467 620204467 Purge Valve
6 620204295 620204295 620204295 620204295 Water Distribution Tube Left
7 620204294 620204294 620204294 620204294 Water Distribution Tube Right
8 620204453 620204453 620204453 620204453 Thumb Screw
9 620204429 620204429 620204429 620204429 Washer
10 620204835 620204835 620204835 620204835 Elbow
11 620204832 620204832 620204832 620204832 Water Pump Tube (Water Pump/Purge Valve)
12 620204877 620204877 620204877 620204877 Water Pump Tube (Water Distribution Tube)
13 620204833 620204833 620204833 620204833 Water Trough
14 620204892 620204892 620204892 620204892 Water Inlet Tubing (34.00 inches long)
15 620204532 620204532 620204532 620204532 Sleeve
620204531 620204531 620204531 620204531 Barrel Fitting
16 620204443 620204443 620204443 620204443 Water Trough Screw
17 620204530 620204530 620204530 620204530 Drop Adapter
18 620204533 620204533 620204533 620204533 Water Inlet Fitting
19 620204813 620204813 620204813 620204813 Drain Fitting
20 620204420 620204420 620204420 620204420 Clamp
Model Number
Page 13
CCM1848***1 & CCM2148***1 Remote Condenser
Page 14
CCM1848***1 & CCM2148***1 Remote Condenser
r
CCM0830 CCM1448R1 CCM1848R1
CCM0530 CCM0630 CCM1030 CCM1530R1 CCM2148R1
Item RC05001 RC06002 RC08002 RC14002C RC21002C Description
1 620204581 620204581 620204581 620204581 620204843 Fan Guard
2 620204369 620204369 620204369 620204369 620204838 Top Panel
3 620204436 620204436 620204436 620204436 620204436 ¼-20 x 1/2 Screw
4 620204580 620204580 620204580 620204580 620204844 Fan Blade
5 620204647 620204646 620204646 620204646 620204846 Fan Motor
6 620204425 620204425 620204425 620204425 620204425 ¼-20 x ¾ Cap Screw
7 620204426 620204426 620204426 620204426 620204426 Flat Washer
8 620204448 620204448 620204448 620204448 620204448 Flanged Lock Nut
9 620204436 620204436 620204436 620204436 620204436 ¼-20 x 1/2 Screw
10 620204371 620204371 620204371 620204371 620204371 Rear Panel
11 620204373 620204373 620204373 620204373 620204840 Brace
12 620204374 620204374 620204374 620204374 620204374 Leg
13 620204375 620204375 620204375 620204375 620204841 Leg Brace
14 N/A N/A N/A N/A N/A T-Nut-Shipping Only
15 620204373 620204373 620204373 620204373 620204840 Brace
16 620204377 620204377 N/A N/A N/A Cover Panel
17 602204372 602204372 602204372 602204372 620204839 Center Panel
18 620204370 620204370 620204370 620204370 620204370 Front Panel
19 620204379 620204379 620204379 620204379 620204842 Motor Brace
20 620204378 620204378 620204378 620204378 620204378 Motor Brace Support
21 620204376 620204376 620204376 620204376 620204376 Junction Box Cover
22 620204625 620204625 620204625 620204625 620204625 Mixing Valve
23 620204600 620204600 620204600 620204837 620204845 Condenser
24 620204626 620204626 620204626 620204626 620204626 Filter
25 620204527 620204527 620204527 620204527 620204527 1/2 Coupling
26 620204526 620204526 620204526 620204526 620204526 3/8 Coupling
27 620204627 620204627 620204627 620204627 620204627 Filte
Page 15
Loading...