Compaq Evo D510 SFF, Evo Deskpro D510 Supplementary Manual

Compaq Evo Deskpro D510 Small Form Factor Pentium Models

Illustrated Parts Map

Compaq, the Compaq logo, and Evo are trademarks of

Compaq Information Technologies Group, L.P.

Intel, Pentium, and Celeron are trademarks of Intel

Corporation in the United States and other countries.

All other product names mentioned herein may be

trademarks of their respective companies.

Compaq shall not be liable for technical or editorial errors

or omissions contained herein. The information in this document is provided “as is” without warranty of any kind and is subject to change without notice. The warranties for

Compaq products are set forth in the express limited

warranty statements accompanying such products. Nothing

herein should be construed as constituting an additional

warranty.

June 2002

Document Part Number 292401-001

Spare Part Number 302343-001

Standard and Optional Boards

1 System board

2 Memory module, 128 MB, DDR

* Memory module, 256 MB, DDR

* Memory module, 512 MB, DDR

3 Riser board

4 PCA, 10/100, IPSEC, NIC, Intel

*NIC,3COM

* Modem, PCI v92

Pentium Celeron Processor with alcohol pad and thermal grease

* 1.7 GHz / 128K cache, 400 FSB

* 1.8 GHz / 128K cache, 400 FSB

Pentium P4 Processor with alcohol pad and thermal grease

* 1.7 GHz / 256K cache, 400 FSB

* 1.8 GHz / 256K cache, 400 FSB

* 1.9 GHz / 256K cache, 400 FSB

* 2.0 GHz / 512K cache, 400 FSB

* 2.2 GHz / 512K cache, 400 FSB

* 2.4 GHz / 512K cache, 400 FSB

* 2.26 GHz / 512K cache, 533 FSB

* 2.4 GHz / 512K cache, 533 FSB

* 2.53 GHz / 512K cache, 533 FSB

Graphics Solutions

* nVIDIA P60-C04 graphics card, NV 11, 64 MB

memory, with LPX bracket

* nVIDIA P60-C04 graphics card, NV 11, 64 MB

memory, with ATX bracket

* Not shown

277977-001

285648-001

285649-001

285650-001

252298-001

215774-001

253951-001

239411-001

288691-001

288692-001

252919-001

255435-001

255436-001

273051-001

273052-001

283925-001

288688-001

288689-001

288690-001

289593-001

279777-001

System Unit

1 Computer cover Not spared

2 Front bezel assembly, complete

* Front bezel assembly, complete, EMEA only (Blue

Angel)

Expansion card cage Not spared

Power supply, PFC, dual voltage 274427-001

5 Chassis assembly with drive cage (reference only)

6 Front trim (below front bezel) 273034-001

* Front trim (below front bezel), CKK only 302605-001

Mass Storage Devices

20-GB, UATA, 100/7200 Quiet hard drive 180476-001

20-GB, UATA, 100/5400 Quiet hard drive 254451-001

20-GB, UATA, 100/4200, MultiBay 273407-001

* 40-GB UATA 100/ 7200 Quiet hard drive

* 40-GB UATA 100/5400 Quiet hard drive

80-GB, UATA 100/7200 hard drive 250185-001

Diskette drive, 3.5-inch, buttonless 278644-001

16/10/40X CD-RW/DVD-ROM drive, carbon 281749-001

40/10/40X CD-RW drive, carbon 286711-001

16/10/24X CD-RW drive, carbon 286691-001

* 48X CD-ROM drive, carbon

* 24X CD-ROM drive

* 16X DVD-ROM drive, carbon

* 8X DVD-RW MultiBay drive

DiskOnKey, 8-MB 249911-001

*Not shown

262011-001

288694-001

Not spared

202904-001

236921-001

232320-001

228746-001

278647-001

251292-001

Cables

Cable kit, includes:

2 CD-ROM audio cable, 12 in. (387527-002)

* CD data cable (108950-017) (not this product)

Other Cables

1 Diskette drive cable (168999-004)

3 Hard drive data cable (108950-035)

4 MultiBay drive data cable (277521-001)

* CD-ROM drive data cable (108950-039)

* Solenoid cable

*Not shown

Documentation and Packaging (not illustrated)

Service Reference Guide 259968-001

Quick Troubleshooting Guide 153837-001

Illustrated Parts Map 302343-001

Return kit

Keyboards (not illustrated)

PS2, Easy Access 271122-001

USB, Smart Card, Easy Access 271124-001

Arabic -171 Korean -KD8

Belgian -181 International -B31

Brazilian Portuguese -201 Latin American Spanish -161

BHCSY* -B41 Norwegian -091

Chinese -AA1 Polish -241

Czech -221 Portuguese -131

Danish -081 Russian -251

Dutch/Netherlands -331 Slovakian -231

Finnish -351 Spanish -071

French -051 Swedish -101

French Canadian -121 Swiss -111

German -041 Taiwanese -AB1

Greek -151 Thai -281

Hebrew -BB1 Turkish -141

Hungarian -211 United Kingdom -031

Italian -061 U.S. -001

Japanese -191

* Bosnia-Herzegovina, Croatia, Slovenia, and Yugoslavia

192263-001

289048-001

258209-001

302604-001

289049-001

265954-001

266280-001

Miscellaneous Parts

1 PCA, MultiBay

2 Front bezel assembly, complete

* Front bezel assembly, complete, EMEA only (Blue

Angel)

3 Speaker

4 Front trim (below front bezel)

* Front trim (below front bezel), CKK only 302605-001

5 Solenoid, 2-coil

Air baffles, include:

6 Air baffle, D-HS (250805-002)

7 Air baffle, D-HS-2 (250805-004)

Plastics kit, includes:

* Bezel blank (166775-002)

* Cable clip (172948-001) (not this product)

* Power switch spring (166837-002) (not this product)

* LED holder (112589-001) (not this product)

* Power switch holder (245154-001) (not this product)

Other Parts

* Heatsink with alcohol pad

* Chassis fan assembly

* Rubber foot (4 ea)

* Labtec Spin-22 speakers, Japan

* Mouse, carbon, 2-button with ratchet wheel

*Not shown

283985-001

262011-001

288694-001

249968-001

273034-001

201485-001

293324-001

257051-001

254286-001

289051-001

266051-001

223492-291

237241-001

System Board Connectors and Jumpers

CR1 Power LED (front of computer) P6 Speaker

CR2 HD LED (front of computer) P7 CD ROM audio

CR21 3.3V AUX LED (see sticker for location) P10 Diskette

CR28 +5V AUX (ON) / PSON LED (OFF)

DMM1 DIMM 1 P21 Secondary ATA

DMM2 DIMM 2 P27 MultiBay header

E15 Boot block P70 Chassis fan

E49 Password jumper P124 Hood lock

J30 Riser board connector SW6 Power button (front of computer)

J40 AGP socket* SW50 CMOS reset

J4002 CPU power XBT2 Battery

P1 Power supply XU1 Processor socket

* Note: AGP socket has a different front retainer latch that requires rotation before the card can be removed.

(see sticker for location)

P20 Primary ATA

Computer Diagnostic LEDs (on front of computer)

LED Color LED Activity State/Message

Power Green On (S0) Computer on

Power Green 1 blink every 2 seconds (S1) Normal Suspend Mode

Power Green 1 blink every 2 seconds (S3) Suspend to RAM

Power Clear Off (S4) Suspend to Disk (if applicable)

Power Clear Off (S5) Computer off

Power Red 2 blinks 1 second apart, fol-

Power Red On CPU not installed

Power Red 1 blink every 1 second ROM error

Power Red 1 blink every 2 seconds Power supply crow bar

Hard Drive Green Blinking Hard drive activity

Keyboard Diagnostic LEDs

LED Color LED Activity State/Message

Num Lock Green Flashing (Beeps - 1S, 2L) Memory error

Caps Lock Green Flashing (Beeps - 1L, 2S) No video

Scroll Lock Green Flashing (Beeps - 2L, 1S) System board failure, prior to video

Num, Caps, Scroll Lock

Num Lock Green On Boot block recovery failed - ROMPaq diskette

Caps Lock Green On Enter password.

Num, Caps, Scroll Lock

* Insert valid ROMPaq diskette in drive A. Turn power switch off, then on to reflash ROM. If ROM flash is successful, all three keyboard LEDs will light up, and you will hear a rising tone series of beeps. Remove diskette and turn power off, then on to restart the computer. For more information about flashing the ROM, refer to the Troubleshooting guide.

Clearing CMOS*

The computer's configuration (CMOS) may occasionally be corrupted. If it is, it is necessary to clear the CMOS memory using switch SW50.

To clear and reset the configuration, perform the following procedure:

1. Prepare the computer for disassembly.

2. Remove the access panel.

3. Press the SW50 button located on the system board and keep it depressed for 5 seconds.

4. Replace the access panel.

5. Turn the computer on and run F10 Computer Setup (setup utility) to reconfigure the system.

Green Flash On-Off 2 times (Beeps -

Green On (Rising Tone) ROM reflashed successfully

Green Blink On in sequence, one at a

CAUTION: The power cord must be disconnected from the power source before pushing the Clear CMOS Button (NOTE: All LEDs on the board should be OFF). Failure to do so may damage the system board

lowed by 2-second pause Repeat

1L, 3S)

time - N, C, SL

CPU thermal shutdown

Invalid system ROM detected. ROM forces reflash.

not present, is bad, or drive not ready.*

Keyboard locked in network mode

Riser Board Connectors and Jumpers

E9029 SCSI LED P9030 Aux CD audio

J9020 PCI Slot SW9001 Security hood switch

J9021 PCI Slot

System Hardware Interrupts

System Function IRQ System Function

IRQ

Timer Interrupt 8 Real-Time Clock

Keyboard 9 Available for PCI

Interrupt Controller Cascade 10 Available for PCI

Serial Port (COM B) 11 Available for PCI

Serial Port (COM A) 12 Mouse

Audio 13 Coprocessor

Diskette Drive 14 Primary ATA (IDE) controller

Parallel Port (LPT 1) 15 Secondary ATA (IDE) controller

System Board Diagnostic Lights

Main Power Switch Status 3.3 V_Aux LED 5 V_Aux/PSON LED

OFF

1. ON and OFF state of LEDs apply only to a good, working system board with AC power applied to the power supply.

2. Power LED on front of computer is OFF.

3. Power LED on front of computer is ON (Green).

4. 5V_Aux is ON.

5. PSON is active = power supply is turned ON.

OFF

Disabling or Clearing the Power-On and Setup Passwords*

1. Turn off the computer and any external devices, and disconnect the power cord from the power outlet.

2. Remove the access panel.

3. Locate the header and jumper labeled E49.

4. Remove the jumper from pins 1 and 2. Place the jumper over pin 2 only, in order to avoid losing it.

5. Replace the access panel.

6. Plug in the computer and turn on power. Allow the operating system to start. (Placing the jumper on pin 2 clears the current passwords and disables the password features.)

7. To re-enable the password features, repeat steps 1-3, then replace the jumper on pins 1 and 2.

8. Repeat steps 5-6, then establish new passwords.

Refer to the F10 Computer Setup (setup utility) instructions to establish new passwords.

Computer Setup (F10) Utility Features (not all features may be available)

System Information About Set Time and date

File

Storage

Security

Power

Advanced

Note: See Computer Setup (F10) Utility Guide on the Documentation Library CD.

Save to Diskette Restore From Diskette Set defaults and Exit Ignore Changes and Exit Save Changes and Exit

Device Configuration Options IDE DPS Self-Test Controller Order SCSI Narrow Termination Boot Order

Setup Password Power-On Password Password Options Smart Cover Smart Sensor DriveLock Master Boot Record Security Save Master Boot Record Restore Master Boot Record Device Security Network Service Boot System IDs

Energy Saver Timeouts Energy Saver Options

Power-On Options Onboard devices PCI Devices Bus Options Devise Options PCI VGA Configuration

Compaq Evo D510 SFF, Evo Deskpro D510 Supplementary Manual

Specifications and Main Features

Frequently Asked Questions

User Manual