Cleveland C9797-40 User Manual

Cleveland

™

P

roject ________________________________

Item __________________________________

Quantity _______________________________

F

CSI Section ____________________________

A

pproval _______________________________

D

ate __________________________________

1333 East 179 St.,

Cleveland, Ohio, U.S.A. 44110

Tel: [phone]

Fax: [phone]

Web Site: www.ClevelandRange.com

Email: [e-mail]

COMBI OVEN-STEAMER
Options & Accessories

MODEL:  C9797-K2PF

Kleensteam II

(for Combi's with a Generator, models OEB & OGB):

(with Prefilter, two Carbon-Block Cartridges & one Scale Stick Cartridge)

Cleveland Standard Features :

Kleensteam II

I

I

Recommended filter delivering high quality filtered water with scale

inhibition

I

I

System includes: one prefilter, two carbon-block cartridges and one
scale stick cartridge.

I

I

Dual cartridge design provides enhanced performance for low or high
flow capacity steamers

I

I

2 five micron carbon block filters improve performance, maximize
energy efficiency and increase the life of combi oven steamers

I

I

Reduces chlorine-induced corrosion

I

I

Long lasting SS-10 cartridge is more effective in higher
alkalinity/hardness/TDS/temperature installations.

I

I

Sophisticated Hydroblend compound prevents limescale formation in
high temperature steam applications

I

I

System is simple to install, operate and maintain

Prefilter:

I

I

Filters out larger dirt and rust particles

I

I

Extends the life of primary filter cartridges

I

I

Tightly spun EC210 sediment cartridge delivers 10 micron nominal
filtration

I

I

Durable slim bowl design makes cartridge change outs easy to handle

I

I

Clear housing allows for visually inspection of trapped particles and
makes determining when to change the cartridge easy

Prefilter

Kleensteam II

Short Form Specifications

Shall be Cleveland Model C9797-K2PF Kleensteam II with one prefilter, two
carbon-block cartridges and one scale stick cartridge, dual cartridge design
for Combi's with a Generator, models OEB & OGB, 2 five micron carbon block
filters and SS-10 cartridge for higher alkalinity / hardness / TDS / temperature
installations.

Options and Accessories

Ë Replacement Cartridges

SECT. IIB PAGE 12A

0810

2

0.50”

5

21mm

5.16”

131mm

25.50”

521mm

22.44”

570mm

O

utlet to

C

ombi

O

ven-Steamer

Inlet

3/4” FNPT

Kleensteam II

for Combi's with a Generator, models OEB & OGB):

(

(with Prefilter, two Carbon-Block Cartridges & one Scale Stick Cartridge)

Technical Data

Overall Dimensions:

Inlet Connection:

Outlet Connection:

Service Flow Rate:

Pressure Requirements:

Maximum Water Temperature at Inlet: 100°F (38°C)

Alkalinity Range: 2 to 12 grains per gallon

Electrical: No electrical connection required

Shipping Weight:

Operating Weight:

25.50”H x 20.50”W x 7.00”D

3/4” FNPT

3/4” FNPT

Maximum 3.5 gpm (13.2 Lpm) - twin cartridges

10 - 125 psi (0.7 – 8.6 bar), non-shock

34 lbs.

42 lbs.

Kleensteam IIPrefilter

The contaminants or other substances removed or reduced by this
drinking water system are not necessarily in your water. Do not
use with water that is microbiologically unsafe or of unknown
quality without adequate disinfection before or after the system.
Systems certified for cyst reduction may be used with disinfected
water that may contain filterable cysts.

NSF Certified under NSF/ANSI Standard 42 for materials

NOTES:

Cleveland Range reserves right of design improvement or modification, as warranted.
Many regional, state and local codes exist and it is the responsibility of the owner and installer to comply with the codes.
Cleveland Range equipment is built to comply with applicable standards for manufacturers.

SECT. IIB PAGE 13A

0810