Charbroil 4611118 Owner's Manual
Tabletop Propane Gas Grill
Model 461111803
For Outdoor Use Only
Please read Safety and Precaution statements, Grill
Maintenance, Leak Testing Your Grill, and Lighting your grill
before using grill for first time.
To the installer:
reference.
To the consumer:
use.
Leave instructions with consumer for future
Please keep these instructions for future
WARNING
FOR YOUR SAFETY
1. Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
2. An LP cylinder not connected for use shall not
be stored in the vicinity of this or any other
appliance.
FOR YOUR SAFETY
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, immediately call your gas
supplier or your fire department.
Call Grill Service Center for Help and Parts
• If you need help or warranty parts call , U.S.,
1-800-387-6057
or , CAN., or send a FAX to 1-706-576-6355.
Business hours:
• To order non-warranty replacement parts or to buy
accessories ( ) call 1-800-993-2677 or send a
FAX to 1-706-565-2121.
• Please know your date of purchase prior to calling.
Safety Symbols
The symbols and boxes shown below explain what each
heading means. Read and follow all of the messages found
throughout the manual.
Open 24 hours – Seven days a week.
cleaners, paint
1-800-241-7548
CAUTION
CAUTION: Indicates a potentially hazardous situation which,
if not avoided, may result in minor or moderate injury.
WARNING
WARNING: Be alert to the possibility of serious bodily injury
if the instructions are not followed. Be sure to read and
carefully follow all of the messages.
FAILURE TO FOLLOW THESE INSTRUCTIONS
COULD RESULT IN FIRE OR EXPLOSION WHICH
COULD CAUSE PROPERTY DAMAGE, PERSONAL
INJURY OR DEATH.
WARNING
• Grill is for outdoor use only. Grill should be operated in a
well-ventilated space. Never operate in an enclosed
space, garage or building. Your grill is not intended to be
installed in or on recreational vehicles and/or boats.
• Do not install or use grill
within 36” (10 ft.
recommended) of
combustible materials from
back and sides of grill. Grill
shall not be located under
overhead surfaces
carport, garage, porch, patio)
• Never attempt to attach this grill to the self-contained LP
gas system of a camper trailer or motor home.
• It is the responsibility of the assembler/owner to
assemble, install and maintain gas grill. Do not let
children operate or play near your grill. Failure to follow
these instructions could result in serious personal injury
and/or property damage.
• Remove lid before lighting grill. When grill is not in use,
turn off control knob on regulator.
• Carefully follow instructions in this manual for proper
assembly and leak testing of your grill. Do not use grill
until leak checked. If leak is detected at any time, it must
be stopped and corrected before using grill further.
• Appliance area should be kept clear and free from
combustible materials, gasoline, bottled gas in any form
and other flammable vapors and liquids. Do not obstruct
flow of combustion and ventilation air.
• Ensure proper bottle position prior to lighting your grill.
Bottle should be vertical.
• Never try to light grill with lid closed! Buildup of gases is
very dangerous and could cause an explosion.
(closed
that can catch fire.
Some parts may contain sharp edges – especially as
noted in manual! Wear protectives gloves if necessary.
Thermos Gas Tabletop / G102-001-0801T / 09-04-02
CAUTION
WARNING
Do not
• leave your grill unattended while in operation.
Do not
• use while under the influence of drugs or alcohol.
Do not
• store any spare LP (propane) cylinder, full or
empty, under or near your grill.
• Appliance is intended for commercial use or rental.
Installation Safety Precautions
• Installation must conform with local codes or, in the absence
of local codes, with the National Fuel Gas Code, ANSI
Z223.1, Storage and handling of Liquefied Petroleum Gases,
ANSI/NFPA 58 or CSA B149.1, Natural Gas and Propane
Installation Code.
• Visually check burner flames (see
illustration).
• Only cylinders marked “propane”
must be used. The cylinder must be
disconnected when the appliance is
not in use.
• The pressure regulator supplied with the appliance must be
used. Replacement pressure regulators must be those
specified by the manufacturer.
• Cylinder supply system must be arranged for vapor
withdrawal.
• The LP gas supply cylinder to be used must be constructed
and marked in accordance with the specifications for LP gas
cylinders of the U.S. Department of Transportation (DOT)
CFR 49, or the National Standard of Canada, CAN/CSAB339, Cylinders, Spheres and Tubes for the Transportation of
Dangerous Goods.
Propane Gas Cylinders
• Your grill is designed to operate with one 16.4 oz. disposable
cylinder (Dot 39 Cylinder) that is 7-3/8” high (not included).
Do not attempt to refill any 16.4 oz. disposable fuel
cylinders.
• The cylinder must be installed, transported and stored in an
upright position and should not be dropped or handled
roughly.
• When the appliance is to be stored indoors, the propane gas
cylinder must be disconnected from the appliance.
• When the propane gas cylinder is not disconnected from the
appliance, the appliance and cylinder must be stored
outdoors in a well-ventilated space.
• The cylinder should never be transported or stored where
temperature can reach 125°F (51°C).
• Cylinders must be stored outdoors out of the reach of
children and must not be stored in a building, garage, or any
other enclosed area.
not
WARNING
Natural Hazards — Insects and Spiders
A clogged tube can lead to a
fire beneath the appliance.
During shipment or storage, it
is possible that small insects
and spiders could find their
way into the venturi tubes and
make nests or webs. This could block the flow of gas
through the venturi tube causing a smoky yellowish flame,
or prevent a burner from lighting. It could even cause the
gas to burn outside the venturi tube, which could seriously
damage your grill. If this occurs, turn off the gas flow and
wait for the grill to cool. When the grill has cooled, remove
the burner and clean out the venturi tube with a brush or
pipe cleaner. Replace the burner and be sure that the
venturi tube is seated over the orifice located on the gas
valves. Cleaning of the venturi tube should be conducted
periodically, especially at the start of the season.
Damage resulting from blocked venturi tube is not
Note:
covered under warranty.
One Year Limited Warranty
THERMOS
product shall be free from defects in workmanship and materials
under normal and reasonable use and correct assembly (if
assembled by consumer-purchaser) for a period of one (1) year from
date of original consumer purchase.
THERMOS
found to be defective during the warranty period. may
require you to return the part(s) claimed to be defective, for its
inspection, freight or postage prepaid.
If you wish to obtain performance of any obligation under this
limited warranty, you should write to:
THERMOS
suggest you keep your invoice.
In the State of California only, if refinishing or replacement of the
product is not commercially practicable, the retailer selling this
product or will refund the purchase price paid for the
product, less the amount directly attributable to use by the original
consumer-purchaser prior to discovery of the nonconformity. In
addition, in the State of California only, you may take the product to
the retail establishment from which it was purchased or to any retail
establishment selling this product in order to obtain performance
under this warranty.
This warranty does not include the cost of any inconvenience or
property damage due to failure of the product and does not cover
damage due to misuse, abuse, accident, damage arising out of
transportation of the product, or damage incurred through
commercial use of the product. This express warranty is the sole
warranty given by the manufacturer and is in lieu of all other
warranties, express or implied, including implied warranty of
merchantability or fitness for a particular purpose. Neither
THERMOS
has any authority to make any warranties or to promise remedies in
addition to or inconsistent with those stated above.
maximum liability, in any event, shall not exceed the purchase price
of the product paid by the original consumer-purchaser. Some states
do not allow the exclusion or limitation of incidental or consequential
damages. So the above limitations or exclusions may not apply to
you. This warranty gives you specific legal rights and you may also
have other rights which vary from state to state.
warrants to the original consumer-purchaser that this
will, at its option, refinish or replace any product or part
THERMOS
THERMOS
Consumer Warranty / P.O. Box 1240
Columbus, GA 31902-1240
may require reasonable proof of purchase and we
THERMOS
dealers nor the retail establishment selling this product
THERMOS
Parts List
Item no. Quantity Description Part no.
1 1 Handle G102-0001-9031
2 1 Lid G102-0002-0031
3 2 Hinge Bracket G102-0003-0031
4 1 Cooking Grate G102-0004-9081
5 1 Heat Distribution Plate G102-0005-0000
6 1 Burner G102-0100-0000
7 1 Heat Resistant Shield G102-0010-0000
8 1 Bottom G102-0006-0031
9 2 Ear Handle G102-0007-9031
Item no. Quantity Description Part no.
10 1 Regulator/Valve Set G102-0200-9000
11 2 Leg G102-0008-9081
12 6 Spacer G102-0009-9000
13 3 1/4” x 3/8” Screw 20120-13010-031
14 8 3/16” Hexagon Nut 30224-13000-031
15 4 3/16” x 3/4” Screw 20124-10018-031
16 4 3/16” x 3/8” Screw 20124-10010-031
17 2 15/64” Plain Washer 40100-13000-031
Loading...