Charbroil 12601664 Owner's Manual
IMPORTANT: Fill out the product record information below.
Use only with GFI (Ground Fault Interrupter) protected circuit.
WARNING:
Do not use 16 or 18 gauge extension cords. Damage to
household wiring and/or fire could result.
DO NOT USE CHARCOAL. A charcoal fire will result and the
grill is not designed for charcoal. The fire will create an
unsafe condition and damage the grill.
INSTALLER/ASSEMBLER:
Leave this manual with consumer.
CONSUMER:
Keep this manual for future reference.
WARNING:
Failure to follow all manufacturer’s instructions could result in
serious personal injury and/or property damage.
CAUTION:
Some parts may contain sharp edges. Wear protective gloves
if necessary.
CAUTION:
Read and follow all safety statements, assembly instructions,
and use and care directions before attempting to assemble
and cook.
If you have questions or need assistance during assembly, please call
To insure your satisfaction and for follow-up service, register your appliance online at www.charbroil.com/register
© 2011 Char-Broil, LLC Printed in China • Columbus, GA 31902 • • Assembly Instructions © 2011
1-888-430-7870
42804643 • 06-21-11
TABLE OF CONTENTS
Product Record Information . . . . . . . . . . . . . . . . . 1
Important Safeguards. . . . . . . . . . . . . . . . . . . . . . 2
Safety Symbols . . . . . . . . . . . . . . . . . . . . . . . . . . 2
IMPORTANT SAFEGUARDS
When using electrical appliances, basic safety
precautions should always be followed including the
following:
General Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Use and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Food Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . 6
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Registration Card . . . . . . . . . . . . . . . . . . . . . . . . . 8
This instruction manual contains important
information necessary for the safe use of
the appliance.
Follow all warnings and instructions when
using the appliance.
Safety Symbols
The symbols and boxes shown below explain what
each heading means. Read and follow all of the
messages found throughout the manual.
DANGER
DANGER: Indicates an imminently hazardous situation
which, if not avoided, will result in death or serious injury.
WARNING
WARNING: Indicates an potentially hazardous situation
which, if not avoided, could result in death or serious
injury.
CAUTION
CAUTION: Indicates a potentially hazardous situation or
unsafe practice which, if not avoided, may result in minor
or moderate injury.
CAUTION
READ ALL INSTRUCTIONS
• Do not touch hot surfaces. Use handles or knobs.
• To protect against electrical shock, do not immerse cord,
plugs, controller or heating element in water or any other
liquid.
• Close supervision is necessary when any appliance is used
by or near children.
• Unplug from outlet when not in use and before cleaning. Allow
to cool before putting on or taking off parts.
• Do not operate any appliance with a damaged cord or plug or
after the appliance malfunctions or has been damaged in any
manner.
• The use of accessory attachments not recommended by the
appliance manufacturer may cause injuries.
• Do not let cord hang over edge of table or counter, or touch
hot surfaces.
• Do not place on or near a hot gas or electric burner, or in a
heated oven.
• Extreme caution must be used when moving an appliance
containing hot oil or other hot liquids.
• Do not use appliance for other than intended use.
• Use only with GFI (Ground Fault Interrupter) protected circuit.
• To prevent grill from being splashed or falling into water, do
not use grill within 10 feet of a pool, pond or other body of
water.
• Keep grill and electric controller dry and out of rain at all
times.
• When connecting controller to grill, plug electric controller into
grill first, make sure controller is set to OFF position, then plug
into outlet. When unplugging, turn controller to OFF position,
disconnect from outlet, then remove controller from grill.
• Unplug grill when not in use and before moving.
• Never remove grounding plug or use with an adapter to two
prongs.
• Keep electric plugs off ground and dry.
• Store controller indoors when not in use.
• Do not use water or other liquid spray to clean product without
first unplugging electric controller and removing heating
element.
• Fuel, such as charcoal briquettes, is not to be used with
appliance.
Use only on properly grounded outlet.
•
For residential use only. Do not use for commercial
cooking.
Page 2
SAVE THESE INSTRUCTIONS
General Safety
1. Do not touch hot surfaces with unprotected hands. Use
handles and knobs provided for operation.
2. Never leave grill unattended when ON.
3. Keep children away from grill both when hot and cold.
4. Use long barbeque utensils for cooking.
5. Allow grill to cool before moving, cleaning or storing.
6.
Keep grill 24" (2 feet) away from
walls and rails.
7.
For outdoor household use
only. Do not use indoors or
for commercial cooking.
8.
Do not use or store gasoline,
2
FT
FT
2
kerosene or other flammable
liquids within 20 feet of this
grill when in use.
9.
Store grill in weather protected area
or under grill cover when not in use and electric controller
indoors when not in use.
Use only accessory attachments recommended by
10.
manufacturer.
It is the responsibility of the assembler/owner to assemble,
11.
install and maintain grill.
Extension Cord Use and Safety
• For best grill performance use of extension cord is not
recommended.
If you must use an extension cord for your safety:
• Use only outdoor type with 3 prong grounding plug, rated for 15
amperes or more, approved by UL, marked with a W-A and a
tag stating “Suitable for Use with Outdoor Appliance”.
• Use the shortest length extension cord required. Do not connect
2 or more extension cords together. A 12 or 14 gauge extension
cord of 50 ft. or less is acceptable.
• Keep connections dry and off ground.
• Do not let cord hang over edge of table top or other items where
it can be pulled by children or tripped over.
Use and Care of Your Grill
Before first use of grill:
• Remove all packaging and sale labels from the grill. Do not
use sharp tools to remove stickers.
• Wash cooking grate with warm soapy water, rinse and dry
throughly.
Before each use of grill:
• Use grill only on a firm and level surface to prevent tipping
over.
• To prevent household circuit breakers from tripping, keep
electric controller dry and do not use other electrical products
on the same circuit.
• Check grease tray to make sure it is empty and is mounted
under the drain hole.
• For stick-free cooking, apply a thorough coating of vegetable
oil or vegetable oil based spray to the cooking grate.
Turn grill on:
• Ensure electrical controller is turned fully counterclockwise to
the off position.
• Plug power supply cord into a properly grounded, GFI
protected outlet. If extension cord must be used refer to
“Extension Cord Use and Safety” on page 3.
With controller fully seated in grill, turn knob clockwise.
Indicator light should come on.
Preheating the grill:
Keep lid closed.
•
Preheat for searing, 15-20 minutes with controller set to 5 HIGH.
( See illustration below)
•
When the controller light turns off, the maximum temperature
has been reached for the knob setting. This light will cycle
on and off during use.
Ground Fault Interrupter
•Since 1971 the National Electric Code (NEC) has required
Ground Fault Interrupter devices on all outdoor circuits.
•If your residence was built before 1971, check with a qualified
electrician to determine if a Ground Fault Interrupter protector
exists.
•Do not use this appliance if the circuit does not have GFI
protection.
•Do not plug this appliance into an indoor circuit.
WARNING
Use care when operating your grill. Be sure you read and
understand all the information and safeguards in this product
guide before operating this grill.
OFF
Position
HIGH
Position
Align settings on controller knob with
light/pointer on controller casing as shown
CAUTION
Do not use sharp or pointed tools to clean grill.
Do not use abrasive oven cleaners, steel wool or metal brushes
to clean porcelain grates or grill body. They will damage the
finish.
Replace damaged part(s) only with Char-Broil certified
replacement parts. Do not attempt to repair damaged parts.
Page 3
Loading...