Charbroil 12401734 Owner's Manual

GRILL NAME

GRILL2GO X200

MODEL NUMBERS

12401734 13401856

Product Guide

IMPORTANT: Fill out the product record information below.

Serial Number

Date Purchased

See rating label on unit for serial number.

FOR OUTDOOR USE ONLY

CAUTION:

Read and follow all safety statements, assembly instructions, and use and care directions before attempting to assemble and cook.

INSTALLER/ASSEMBLER:

Leave this manual with consumer.

CONSUMER:

Keep this manual for future reference.

If you have questions or need assistance during assembly, please call .

To insure your satisfaction and for follow-up service, register your appliance online at www.charbroil.com/register

WARNING:

Failure to follow all manufacturer’s instructions could result in serious personal injury and/or property damage.

CAUTION:

Some parts may contain sharp edges. Wear protective gloves if

necessary.

1-888-430-7870

42804972 • 02-08-13

TABLE OF CONTENTS

Product Record Information . . . . . . . . . . . . . . . . . 1

For Your Safety . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Safety Symbols . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Installation Safety Precautions. . . . . . . . . . . . . . . . 3

Use and Care . . . . . . . . . . . . . . . . . . . . . . . . . . 4-7

Food Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . 9

Parts list . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

Parts Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Troubleshooting. . . . . . . . . . . . . . . . . . . . . . . . 12-13

Registration Card . . . . . . . . . . . . . . . . . . . . . . . . 15

This instruction manual contains important

information necessary for the safe use of the appliance.

DANGER

1. Never operate this appliance unattended.

2. Never operate this appliance within 10ft (3m) of any structure, combustible material or other gas

cylinder.

3. Never operate this appliance within 25 ft (7.5 m) of any flammable liquid.

4. If a fire should occur, keep away from the

appliance and immediately call your fire

department. Do not attempt to extinguish an oil or grease fire with water.

Failure to follow these instructions could result in fire, explosion or burn hazard, which could cause property damage, personal injury or death.

DANGER

Read and follow all warnings and instructions before using the appliance.

Safety Symbols

The symbols and boxes shown below explain what each heading means. Read and follow all of the messages found throughout the manual.

DANGER

DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.

WARNING

WARNING: Indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.

CAUTION:

CAUTION: Indicates a potentially hazardous situation or unsafe practice which, if not avoided, may result in minor

or moderate injury.

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, keep away from the appliance and immediately call your gas supplier or your

fire department.

Failure to follow these instructions could result in fire or explosion, which could cause property damage, personal injury or death.

WARNING

Do not attempt to repair or alter the hose/valve/regulator for any “assumed” defect. Any modification to this assembly will void your warranty and create the risk of a gas leak and fire. Use only authorized replacement parts supplied by manufacturer.

CAUTION

For residential use only. Do not use for commercial

cooking.

Page 2

INSTALLATION SAFETY PRECAUTIONS

Installation Safety Precautions

• Use grill, as purchased, only with LP (propane) gas and the

regulator/valve assembly supplied.

CAUTION

• This appliance is not for use in or on recreational vehicles and/or boats.

• Grill installation must conform with local codes or, in the absence of local codes,with the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Storage and Handling of Liquefied Petroleum Gases, ANSI/NFPA 58; or Natural Gas and Propane Installation Code, CSA B149.1; Propane Storage and Handling, CSA B149.2.

• All electrical accessories (such as rotisserie) must be electrically grounded in accordance with local codes, or National Electrical Code, ANSI / NFPA 70. Keep any electrical cords and/or fuel supply hoses away from any hot surfaces.

• This grill is safety certified for use in the United States and/or Canada only. Do not modify for use in any other location. Modification will result in a safety hazard.

•

This appliance will be hot during and after use. Use insulated oven mitts or gloves for protection from hot surfaces or splatter from cooking liquids.

• For residential use only. Not intended for commercial use.

• Do not leave appliance unattended. Keep children and pets away from appliance at all times.

Call Grill Service Center for Help and Parts

• If you need assistance with your product or warranty parts call

1-888-430-7870

8:00 A.M. To 6:00 P.M. EST Monday - Friday.

• To order non-warranty replacement parts or accessories please visit us on the web at www.charbroil.com or call

1-888-430-7870

agents will be glad to assist you.

. Hours of Service Center Operation are

and one of our friendly and knowledgeable

• Do not leave appliance unattended. Keep children and pets away from appliance at all times.

WARNING

CALIFORNIA PROPOSITION 65

1. Combustible by-products produced when using this product contains chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm.

2. This product contains chemicals, including lead and lead compounds, known to the State of California to cause cancer, birth defects or other reproductive harm.

Wash your hands after handling this product.

Page 3

USE AND CARE

WARNING

For Safe Use of Your Grill and to Avoid Serious

Injury:

•

Do not let children operate or play near grill. Keep grill area clear and free from materials that burn (i.e.

•

gasoline, propane, or any other flammable liquid or gas).

•

Do not block holes in bottom or back of grill. Check burner flames regularly.

•

• Never use regulator from this grill with any other LP appliance.

• When cooking, the appliance must be on a level surface in an area clear of combustible material. Use grill only in well-ventilated space. For outdoor use only.

•

NEVER use in an enclosed space such as carport, garage, porch, covered patio, or under an overhead structure of any kind.

Do not use charcoal or ceramic briquets in a gas grill.

•

Unless briquets are supplied with your grill.)

(

• This appliance is not intended for and should never be used as a heater.

•

Do not cover grates with aluminum foil or any other material. This will block burner ventilation and create a potentially dangerous condition resulting in property damage and/or personal injury.

• Use grill at least 3 ft. from any wall or surface.

10 ft. clearance to objects that can catch fire or sources of ignition such as pilot lights on water heaters, live electrical appliances, etc..

Maintain

LP (Liquefied Petroleum Gas)

Is nontoxic, odorless and colorless when produced.

• For Your Safety

, LP gas has been given an odor (similar to rotten

cabbage) so that it can be smelled.

• LP gas is highly flammable and may ignite unexpectedly when mixed with air.

Propane Cylinder Use (1 lb. Disposable)

Use only cylinder marked “Propane Fuel”.

•

Cylinder must be constructed and marked in accordance with the specifications for LP-gas cylinders of the U.S. Department of Transportation (DOT) or the National Standard of Canada, CAN/CSA-B339, Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods.

•

Size should be 4” diameter, 8” height, or 3” diameter, 10” height.

•

Save cylinder cap and reinstall when not in use.

•

Cylinder supply system must be arranged for vapor withdrawal. Gas cylinder must be upright in use.

3 ft. (1m) minimum

• Apartment Dwellers:

Check with management to learn the requirements and fire codes for using an LP gas grill in your apartment complex. If allowed, use outside on the ground floor with a three (3) foot clearance from walls or rails. Do not use on or under balconies.

• NEVER attempt to light burner with lid closed. A buildup of non-ignited gas inside a closed grill is hazardous.

• Never operate grill with LP cylinder out of correct position specified in assembly instructions

Page 4

Propane Cylinder Installation/Removal

Propane Cylinder Installation:

1. Remove cap from end of Propane cylinder (sold separately).

2. Cap should be kept on cylinder when not in use to prevent dirt and debris from entering Regulator/Valve.

3. Check end of cylinder attachment for dirt and debris. Clean out if necessary.

4. Insert threaded end of Propane Cylinder into Regulator/Valve and hand-tighten turning cylinder clockwise as shown below. DO NOT USE TOOLS! Over tightening can damage threads on Regulator/Valve.

Regulator/Valve Installation/Removal

1. With knob pointing to back of grill, insert Regulator/Valve into end of burner (A)

Notch in Regulator/Valve MUST engage dimple in end of

burner.

2.Once Regulator/Valve has completely engaged burner, turn Regulator/Valve clockwise (B) to lock in position with knob pointing as shown (C).

3. To remove reverse steps.

Leak Testing (1 lb. Disposable)

IMPORTANT!

• During leak test, keep grill away from open flames or sparks and do not smoke. Grill must be leak tested outdoors in a well ventilated area.

Leak test must be repeated each time gas cylinder is replaced

•

or after storage.

Materials needed include clean paint brush and 50/50 soap and water solution. Use mild soap and water.

household cleaning agents.

Damage to components can

Do not use

result.

Be sure on regulator is in "OFF" position.

1. control knob

Brush soapy solution onto between gas cylinder

2. connection

and regulator at .

Brush soapy solution onto between regulator pipe

3. connection

threads and regulator, and burner tube and orifice at .

(A)

(B)

If growing bubbles appear, there is a leak. Retighten connections and repeat

steps 1 , 2, and 3.

Red notch

Dimple

Full engagement

If you cannot stop a leak, remove gas

cylinder from regulator and check for damaged threads, dirt and debris on regulator and gas cylinder. Also check to see if anything is obstructing flow of gas at regulator and gas cylinder openings. Remove any obstruction that may be found and repeat leak test.

If threads are damaged on either regulator or gas cylinder, replace.

Order new parts by giving the serial, model number and name of items needed to the Grill Service Center at .

1-888-430-7870

IMPORTANT: REMOVE PROPANE CYLINDER FROM REGULATOR/VALVE WHEN NOT IN USE.

Propane Cylinder Removal:

1. Turn regulator OFF.

2. Allow Grill to cool.

3. Remove the propane cylinder by turning counter-clockwise until disengaged from the Regulator/Valve.

4. Install cap on cylinder. Cap should be kept on cylinder when not in use to prevent dirt and debris from entering Regulator/Valve.

Page 5

+ 11 hidden pages