CHAMPION PUMP
PUMP PERFORMANCE CURVE
in FT |
40 |
|
|
|
|
|
|
|
|
|
|
|
|
30 |
|
|
CPWH5 |
|
|
|
|
|
|
|
|
||
Head |
20 |
|
|
|
CPS5 |
|
|
|
|
|
CPW5 |
|
|
|
|
|
|
|
|
|
|
|
|
||||
Total |
10 |
|
CPW4R |
|
|
|
|
|
|
|
|
|
|
0 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
0 |
10 |
20 |
30 |
40 |
50 |
60 |
70 |
80 |
90 |
100 |
110 |
120 |
Gallons Per Minute
Product Warranty
Date of Manufacture and Warranty Tag is on pump cord.
LIMITED WARRANTY: We warrant to our immediate customer and to the ultimate consumer that products of our manufacture will be free of defects in material and workmanship under normal use and service for one year (12 months) from the date of installation, or 18 months from the date of manufacture, which ever comes first. We will repair or replace, at our option, to the original purchaser any part or parts of our product found upon our examination to be defective. Please call Champion Pump Company, Inc. (419-281-4500) for instructions. Be prepared to provide the model number, the date code and/or serial number and proof of the date installed when exercising this warranty. Warranty tag (Required) is on the pump power cord. All transportation charges on products or parts submitted for repair or replacement must be paid by purchaser. This limited warranty does not cover products which have been damaged as a result of accident, abuse, misuse, neglect, improper installation, improper maintenance, or failure to operate in
accordance with Champion Pump Company, Inc. written instructions. UNDER NO CIRCUMSTANCES WILL WE BE RESPONSIBLE FOR ANY OTHER DIRECT OR CONSEQUENTIAL DAMAGES, INCLUDING BUT NOT LIMITED TO LOST PROFITS, LOST INCOME, LABOR CHARGES, DELAYS IN PRODUCTION, IDLE PRODUCTION WHICH DAMAGES ARE CAUSED BY ANY DEFECTS IN MATERIAL AND/OR WORKMANSHIP AND/OR DAMAGE OR DELAYS IN SHIPMENT. THIS WARRANTY IS EXPRESSLY IN LIEU OF ANY OTHER EXPRESS OR IMPLIED WARRANTY, INCLUDING ANY WARRANTY OF MERCHANTABILTIY OR FITNESS FOR A PARTICULAR PURPOSE. Some states do not allow limitations on how long an
implied warranty lasts, or do not allow the exclusions or limitations of incidental or consequential damages, so the above limitations might not apply to you. This limited warranty gives you legal rights, and you may also have other legal rights which vary from state to state.
12-0011-0000 |
www.championpump.com |
4 |
05/12 |
Installation and Operation Manual
Models: CPS5, CPWH5, CPW4,CPW5
Submersible Sump/Effluent/Sewage Pump
Thank you for purchasing this CHAMPION PUMP! The CPS5/CPWH5 pumps are heavy duty cast iron ½ HP sump/effluent pumps. The CPW4R and CPW5
models are heavy duty cast iron 4/10HP and ½ HP, respectively, sewage pumps capable of full 2” solids. We back these Champion products with Champion service and a Champion attitude. Please read, save, and follow these instructions to ensure Champion performance.
BEFORE OPERATION – Important Product and Safety Information – WARNINGS – Personal Injury
and/or property damage could result if not adhered to.
!Risk of Electric Shock – Fatal electric shock could occur. Always disconnect the power source before attempting to install, service, relocate or check the pump. Never touch pump, pump motor, water, or discharge piping when pump is connected to electrical power. Never enter a wet or flooded area, basement, basin, etc. that is in contact with the pump or electrical circuit before power supply has been disconnected.
!Pump has not been investigated for use in swimming pool areas or any area that might reasonably expect aquatic, animal, or human entrance. Precautions should be taken to prevent such entrance during use.
!Connect only to a properly grounded, grounding type receptacle. Use of a ground fault circuit interrupter (GFCI) is required for maximum safety.
!All wiring must be performed by qualified electrician in accordance with all local and national electric code.
!When power source or supply is turned off (in open position) a lock and tag out should be used to prevent accidental power application or activation.
!Do not use extension cord or cut off grounding pin. Should be installed on separate 15 AMP circuit breaker.
!Use only with a properly sized (input AMPS, volts, HP) motor controller.
!Do not use to pump flammable/explosive liquids such as gasoline, fuel oil, kerosene, and /or chemicals, salt water, etc.
!Do not use pump in an explosive atmosphere or classified as hazardous per NEC, ANSI/NFPA 70.
!Make sure pump is on hard level bottom in sump, do not set directly on earth, gravel, or other debris. This could cause excessive wear or possible jamming and flooding.
!Make sure pump is secure in basin and piping is firmly supported so that pump cannot move, not allowing liquid level switch to interfere with basin all or other obstacle preventing proper operation. Flooding or overheating could occur if not prevented.
CHAMPION PUMP COMPANY |
Phone: 419-281-4500 |
|
1102 Myers Pkwy. Ashland, Oh 44805 |
Fax: |
419-616-1100 |
1
Loading...