Centro 85-1134-4, G41503, 85-1134, G41501 Safe Use, Care And Assembly Manual
WARNING
Failure to follow all of the manufacturer’s
instructions could result in hazardous
fires, explosions, property damage,
or serious personal injury or even death.
WARNING
Follow all leak check procedures carefully
prior to operation of barbecue,
even if barbecue was store assembled.
Do not try to light this barbecue
without reading the Lighting Instructions
section of this manual.
WARNING
1. Do not store or use gasoline or other
flammable liquids or vapors in the
vicinity of this or any other appliance.
2. An LP cylinder not connected for use
shall not be stored in the vicinity of
this or any other appliance.
DANGER
If You Smell Gas
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your
gas supplier or your fire department.
WARNING
Always cook with the lid open.
Lid should only be used for storage once
the unit has cooled down.
THIS BARBECUE IS FOR
OUTDOOR USE ONLY
Outdoor Grilling System
SAFE USE, CARE AND ASSEMBLY MANUAL
SERIAL #:
3 YEAR LIMITED WARRANTY
85-1134-4 (PROPANE) (G41503)
Read and save this manual for future reference.
If pre-assembled, leave this manual with
unit for consumer’s future reference.
For product inquiries, parts, warranty
and troubleshooting support, please call
1-877-707-5463
i i
T ABLE OF CONTENTS
Warranty . . . . . . . . . . . . . . . . . ii
Installation Information . . . . . . 1
Additional Warnings . . . . . . . . 1
Use of LP Gas Cylinder, . . . . . 1-2
Transportation and
Storage of the LP Cylinder,
Filling the LP Cylinder
Prior to Using the Grill . . . . . . . 3
Safety Hose and Regulator . . . . 4
Safety Leak Testing . . . . . . . . . 5
Lighting the Main burners. . . 6-7
Parts List and . . . . . . . . . . . . 8-9
Parts Diagram
Assembly Instructions . . . . 10-13
W ARRANTY
3 Year Limited Warranty
This Centro Barbecue carries a three year limited warranty against defects in manu-
facturing workmanship. This Limited Warranty is nontransferable and becomes void
if used for commercial or rental purposes. This warranty applies only when grill is
used in Canada. The bill of sale or a copy will be required together with the serial
number and model number when making any warranty claims from Trileaf
Distribution. Trileaf Distribution reserves the right to have its representatives inspect
any product or part prior to honouring any warranty claim. Trileaf Distribution shall
not be liable for any transportation charges, shipping and handling charges, or
labour costs. This warranty is for replacement of defective parts only. The
Manufacturer will not be responsible for incidental or consequential damages or
any labor cost. Inability to provide proof of purchase, or if warranty coverage has
expired, any request for parts will be subject to parts, shipping and handling fees.
This limited warranty does not cover damage due to chipping and scratching of
porcelain or painted surfaces including Cooking grates, nor does
it cover corrosion
or discolouration due to misuse, lack of maintenance, grease fires, hostile environ-
ments, accidents, alterations, abuse or neglect, improper installation and failure to
read and/or abide by any product warnings. This limited warranty does not cover
any damage sustained during removal or storage of this BBQ. Part failure due to lack
of cleaning and maintenance, or use of improper cleaning products such as Oven
Cleaner will not be covered under this manufacturers warranty. This limited war-
ranty does not cover any scratches or dents, corrosion or discolouring caused by
heat, abrasive or chemical cleaners. Parts installed from other manufactures will
nullify this warranty.
3 Year Limited Warranty
1 Year Limited Warranty
For one year from the date of original retail purchase Trileaf Distributions will
replace any grill part that fails or is found to be defective to the degree of non-
performance under normal household use, during the limited warranty period.
Trileaf Distributions ltd. are not responsible for any grill damage sustained during
moving, storage, assembling or cleaning. Unless otherwise
noted, as in above lim-
itations, all components are covered for a period of one year.
IMPORTANT: Should you have difficulty operating this product, or have a
part that has become defective within the stated warranty period, DO NOT
RETURN TO STORE. STORES DO NOT STOCK REPLACMENT PARTS AND ARE
UNABLE TO HELP WITH TROUBLESHOOTING ADVICE. PLEASE CALL 1-877-
707-5463. Have your Proff of purchase, serial number and model number
available so that the customer support agent can be of assistance.
Purchaser: By accepting delivery of this Barbecue the purchaser, hereby accepts
the foregoing and expressly waives any other remedy and damages, direct, indi-
rect, and consequential.
The following functional parts are included under this warranty: Burners, manifold
assembly and carryover assembly.
1
ADDITIONAL
WARNINGS
INSTALLATION
INFORMATION
The installation of this appliance must be in accordance with all local codes, or in the
absence of local codes:
•
Canadian installation must conform to the current national standards, which at this time
are CAN/CGA-B149.1/2-Natural Gas/ Propane installation code.
Drawing A
Minimum clearance to adjacent combustible materials:
•
76 cm (30˝ ) from furthest protruding edge on side of barbecue.
•
76 cm (30˝ ) from furthest protruding edge on back of barbecue.
See Drawing A
•
Always keep the area around this barbecue clean and clear of any and all combustible
materials such as gasoline or other inflammable liquids, paper or oily rags.
•
Do not operate this barbecue under any overhanging or unprotected construction.
•
Remember this barbecue is for outdoor use only and is not for use on any boat or
recreational vehicle.
•
Use this barbecue outdoors in a well-ventilated area and at least
3 m (10’) from any dwelling or other building.
•
Do not use in garages, or any other enclosed area.
•
Do not leave your barbecue unattended while in operation.
•
Do not obstruct the flow of combustion and ventilation air to the barbecue.
•
Do not use while under the influence of drugs or alcohol.
•
Do not store any spare L.P. (propane) cylinders, full or empty,
under or near your barbecue.
•
Do not allow children or pets to play anywhere near the barbecue.
USE OF LP GAS CYLINDER
Self-contained
Propane Gas System
The self-contained (propane) gas system barbecue is designed to be used with only a 9.1 kg
(20 lb) propane cylinder equipped with a type-1 cylinder valve. This barbecue cannot be
connected to an existing #510 P.O.L. type valve cylinder (which has left-handed threads).
Do not connect to a propane gas cylinder exceeding 9.1kg capacity or use a cylinder
with any other type of cylinder valve connection device.
The Type-1 valve can easily be recognized by the large external thread on the outside of the
valve. Older existing valves do not have this outer external thread. Any attempt to connect
a regulator to any connector other than the mating Type-1 connector (which comes with a
large, black coupling nut such as the #510 P.O.L.) could result in fires, injuries or property
damage, and could reduce the effectiveness of the important safety features built into the
Type-1 system. Also connecting the #510 P.O.L. fitting to the cylinder will negate the flow
control and the temperature shut-off features built into the new Type-1 connection system.
•
The cylinder should not exceed 472 mm (18 1/2˝ ) in height and
317 mm (12 1/2˝ ) in diameter.
When purchasing a cylinder for your barbecue, it must be constructed and marked
as meeting the specifications of:
•
Canada: Transport Canada.
Minimum clearance of 76 cm (30”)
on both sides and back of the barbeque.
2
FILLING THE
LP CYLINDER
The cylinder must be filled prior to use and must have the air purged. For safety, follow
these instructions when having your cylinder filled:
•
Have only your local qualified LP gas dealer fill or repair a cylinder.
•
Do not overfill the cylinder beyond the safe 80% fill level.
•
Make sure the dealer tests and checks the cylinder for leaks after filling.
WARNING
If the above instructions are not completely adhered to,
it could cause a fire/explosion, resulting in death or serious Injury,
or property damage.
The Cylinder must also be equipped with:
•
A shut-off valve with a correct cylinder valve outlet as specified in current standards.
•
Canada: CAN/ CGA 1.6g-M97 Outdoor Gas Grilles.
a) A safety relief valve with direct connection to the vapour space of the cylinder.
b) A collar to protect the tank shut-off valve.
c) A device for vapour withdrawal.
d) A ring on the bottom to secure the tank to its support assembly.
•
Always turn off the cylinder valve completely when the barbecue is not in use.
•
Always handle the tank valve with utmost care.
•
Never connect an unregulated L.P. gas cylinder to the barbecue.
•
Always keep the cylinder, in use, securely fastened in an upright position.
•
Never store a spare cylinder, empty or full,
near or under the barbecue when in operation.
•
Never expose the cylinders to direct sunlight or excessive heat.
•
Never insert any kind of object into the valve outlet as this may damage the backcheck;
a backcheck that is damaged can leak, and a leaking propane cylinder can result in fires
or explosions, property damage, severe injuries or death.
TRANSPORTATION
AND STORAGE
OF THE LP CYLINDER
The propane cylinder is totally safe when handled properly, but if misused, the result could
be an explosion or fire resulting in serious personal injury and/or property damage.
To Avoid Unnecessary Risks
•
Always recap the cylinder with the cap provided when not connected to the barbecue.
•
Do not store the cylinder in any enclosed area such as a garage, and make sure the
storage area has lots of ventilation.
•
Do not store the cylinder near any appliances, or in any areas that may become hot,
such as the trunk of a vehicle.
•
Make sure the cylinder is out of reach of children.
•
When transporting or storing the cylinder, make sure it is in an upright position and
not on its side.
•
Do not smoke around the cylinder, especially when transporting it in a vehicle.
3
PRIOR TO USING
Drawing E
Do not use your barbecue until you have carefully read and fully understand all the information
in this manual. Please ensure the following:
•
Your barbecue is properly assembled.
•
There are no leaks in the system (see “Leak Test”).
•
The burner is properly assembled, with the Venturi tubes seated over the valve outlets
(Drawing E) and that there is nothing blocking the Venturi tubes (Drawing F).
•
Ensure that all power cords and/or gas supply hoses will not touch or be
near surfaces that will get hot.
•
The barbecue is in a safe location (see Installation).
Ensure that the valve outlets (orifices) are assembled into the Venturi tubes approximately
6 mm (1/4˝ ) and that the valve outlets and Venturi tubes are approximately parallel to the
bottom of the lower body.
Insert valve outlets into Venturi tubes
approximately 6 mm (1/4”)
Orifice Size: The orifice, in conjunction with the control valve, acts to regulate and restrict
the amount of gas delivered to the burner. The hole size in the orifice varies by the gas sup-
ply pressure and by the BTU rating of the burner. Grills equipped for LP gas operate at a
much higher gas pressure and therefore have a smaller size orifice.
Hose and Regulator Inspection
Adjustment: The regulator is factory set at a specified outlet pressure of 11” of water column
and is generally factory sealed and not adjustable. Do not try to adjust. The regulator can be
checked by measuring the pressure with a manometer.
Vent Hole: There is a vent hole on top of the regulator. Check that it is clear of dirt and
debris. If the hole is plugged, erratic and dangerous burning may result.
O-ring Seal: Before attaching the regulator to the cylinder, inspect the rubber O-ring on
the P.O.L. fitting. Do not operate the grill if the O-ring is damaged or missing. Seal damage
is common and we recommend replacement of the seal when the burner is replaced or
when the seal is damaged. Cracks, splits or distortion will allow gas to escape. Additionally,
the seal should be soft, pliable, and protrude slightly from the brass P.O.L. valve.
Chew Marks: The hose should be kept clean of grease and food drippings which attract
squirrels and other animals. The animals will often eat the drippings on the hose and chew
into the hose lining trying to get the last taste. Try cleaning the hose with an ammonia
cleaner solution to minimize the attration.
Drawing F
WARNING
Natural Hazards
Insects and Spiders
During shipment or storage, it’s possible that small insects like spiders could
find their way into the Venturi tubes and nest or make webs. This could block
the flow of gas through the Venturi tube causing a smoky yellowish flame, or
prevent a burner from lighting. It could even cause the gas to burn outside the
Venturi tube, which could seriously damage your barbecue. If these occur, turn
off the gas flow and wait for the barbecue to cool down. When the barbecue
has cooled, remove the burner and clean out the Venturi tubes with a brush or
pipe cleaner. Replace the burner and ensure that the Venturi tubes are seated
over the orifice located on the gas valves. Cleaning the Venturi tubes should be
conducted periodically, especially at the start of the season.
Note: Damage resulting from blocked Venturi tubes is not covered under
the warranty.
Loading...