CDA RV 901, RV 1001 User Manual

Customer Care Department • The Group Ltd. • Harby Road • Langar • Nottinghamshire • NG13 9HY

T : 01949 862 012 F : 01949 862 003 E : service@cda.eu W : www.cda.eu

RV 901 .. - RV 1001 .. Twin Cavity Dual Fuel Cookers

Manual for Installation, Use and Maintenance

Important

This appliance is designed and manufactured solely for the cooking of domestic (household) food and is not suitable for any non domestic application and therefore should not be used in a commercial environment.

The appliance guarantee will be void if the appliance is used within a non domestic environment i.e. a semi commercial, commercial or communal environment.

The CDA Group Ltd cannot be held responsible for injuries or losses caused by incorrect use or installation of this product. Please note that CDA reserve the right to invalidate the guarantee supplied with this product following incorrect installation or misuse of the appliance.

Appliance information:

Please enter the details on the appliance rating plate below for reference, to assist CDA Customer Care in the event of a fault with your appliance and to register your appliance for guarantee purposes.

Appliance Model

Serial Number

Declaration of CE conformity

This cooker has been designed, constructed and marketed in compliance with:

- Safety requirements of EU Directive “Gas” 2009/142/EC;

- Safety requirements of EU Directive “Low Voltage” 2006/95/EC;

- Protection requirements of EU Directive “EMC” 2004/108/EC;

- Requirements of EU Directive 93/68/EEC.

Important information for correct disposal of the product in accordance with EC Directive 2002/96/EC.

At the end of its working life, the product must not be disposed of as urban waste. It must be taken to a special local authority differentiated waste collection centre or to a dealer providing this service. Disposing of a household appliance separately avoids possible negative consequences for the environment and health deriving from inappropriate disposal and enables the constituent materials to be recovered to obtain signiﬁcant savings in energy and resources. As a reminder of the need to dispose of household appliances separately, the product is marked with a crossed-out wheeled dustbin.

Features and Technical Data - mod. RV 901 ..

Gas Burners

1. Auxiliary burner (A) 1.00 kW

2. Semi-Rapid burner (SR) 1.75 kW

3. Semi-Rapid burner (SR) 1.75 kW

4. Rapid burner (R) 3.00 kW

5. Triple Ring burner (TR) 3.50 kW

Note:

The electric ignition is incorporated in the knobs. The appliance has a safety valve system ﬁtted, the ﬂow of gas will be stopped if and when the ﬂame should accidentally go out.

Fig. 1a

Conventional Oven

Multifunction Main Oven

Features and Technical Data - mod. RV 1001 ..

Gas Burners

1. Auxiliary burner (A) 1.00 kW

2. Semi-Rapid burner (SR) 1.75 kW

3. Rapid burner (R) 3.00 kW

4. Triple Ring burner (TR) 3.50 kW

Note:

The electric ignition is incorporated in the knobs. The appliance has a safety valve system ﬁtted, the ﬂow of gas will be stopped if and when the ﬂame should accidentally go out.

Fig. 1b

Conventional Oven

Multifunction Main Oven

Control Panel

810 7 6 5 9 2 1 12 11

1413

810 7 6 5 34 2 1 12 11

1413

Controls Description

1. Front right burner control knob

2. Rear right burner control knob

3. Central rear burner control knob

4. Central front burner control knob

5. Rear left burner control knob

6. Front left burner control knob

7. Multifunction main oven switch knob

8. Multifunction main oven thermostat knob

9. Central burner control knob

10. Clock and timer with “Touch-Control” keys (main oven only)

11. Conventional oven thermostat knob

12. Conventional oven switch knob

Pilot Lamps:

13. Main oven thermostat indicator light

14. Conventional oven thermostat indicator light

Please note: This appliance incorporates a safety cooling fan which you will hear operating whenever the oven or grill are in use. The cooling fan may also operate when the oven is switched off. This fan is to reduce the external temperature of the appliance and cool the internal components.

Fig. 2a

Fig. 2b

mod. RV 901 ..

mod. RV 1001 ..

Clock and Timer with “Touch-Control” Keys

(Multifunction Main Oven only)

Keys:

and – Touched simultaneously (for more than 2 seconds):

 •settingtheclock;  •settingthe timer volume (by touching once, along

with the “MODE” key);

 •tocancelautomaticcookingatanytime.

MODE Function selection (touched for more than 2

seconds):

 •settingtheclock(onlyafterrstconnectionorafter

a power failure);

 •timer;  •automaticcooking“dur” (duration) - how long the

food will take to cook (by touching the “MODE” key again);

 •automaticcooking“End” - the time you would like

the oven turns off (by touching the “MODE” key two more times);

+ Increases the number shown on the display

– Decreases the number shown on the display

Fig. 3

Illuminated Symbols:

AUTO

“

”

“

”

“

”

“

” and AUTO AUTO

“

” and AUTO

ﬂashing

steady illumination

ﬂashing

steady illumination

- Automatic cooking completed, oven in automatic position but not set

- Oven set for automatic cooking, cooking still not taking place

- Timer being set

- Timer in operation

- Oven set for manual cooking

ﬂashing

- Automatic cooking being set

- Oven set for automatic cooking, cooking taking place.

“Touch-Control” Keys

The “touch-control” keys shall be operated by the ﬁngers (just by touching the key). When using touch controls it is best to use the ball of your ﬁnger rather than the tip. The keys are automatically deactivated:

- 8 seconds after the last selection; the deactivation is indicated by an acoustic signal (“beep”). To reactivate just touch the “MODE” key or the “+” and “–” keys.

Setting the Clock

When ﬁrst connected, or after a power failure, the digits and “AUTO” will shown on the display. To set the clock, touch the “MODE“ key, for more than 2 seconds, and then the “+” or “–” keys. Important: The oven does not operate, in manual cooking, without ﬁrst having set the clock. To set the clock, with the appliance already connected, touch the “+” and “–” keys simultaneously (for more than 2 seconds), then “+” or “–” keys.

Important: - changing the time will delete any automatic program;

- after setting the clock, the oven starts to operate in the selected function (manual cooking). The “ ” symbol is steady illuminated.

Using the Timer

You can use the timer at any time, even when the oven is not in use. The timer does not turn the oven off. The timer can be set for up to 23 hours and 59 minutes.

- To set the timer, touch the “MODE” key for more than 2 seconds (the “ ” symbol ﬂashes), than the “+”

or “–” keys.

- After about 8 seconds an acoustic signal (“beep”) will sound conﬁrming the regulation (“ ” symbol

steady illuminated).

- To check the remaining time touch the “MODE“ key for more than 2 seconds. If the remaining time is

more than a minute the display will show hours and minutes; if less than a minute the display will show seconds.

- When the time is up, the timer will beep. Touch the “MODE” key , for more then 2 seconds, to turn it

off; or press the “+” or “–” key to stop the beep and than the “MODE” key, for more than 2 seconds, to deactivate the “ ” symbol ﬂashing on the display.

- Turn off the oven manually (function and thermostat knobs in the off position) if the manual cooking

has been completed.

Setting the Timer Volume

You can select from three volume levels.

- Touch the “+” and “–” keys simultaneously for more than 2 seconds.

- Touch the “MODE” key; you can read on the display the current timer volume (“ton1”, “ton2” or

“ton3”).

- Touch the “–” key to listen or change the timer volume.

- Timer volume activated: the last displayed.

- After about 8 seconds an acoustic signal (“beep”) will sound conﬁrming the volume setting; then the

time of day will be displayed.

Automatic Cooking

Use automatic cooking to automatically turn the oven on, cook, and then turn the oven off.

1. Check the clock shows the correct time.

2. Select the function and temperature (function and temperature knobs). The oven will come on.

3. Decide how long the food will take to cook, allowing time for preheating if necessary.

4. Touch the “MODE” key for more than 2 seconds and then touch again. “dur” will show (duration).

Using the “+” and “–” keys, set the stop time.

5. Decide the time you would like the oven to turn off; touch the “MODE” key for more than 2 seconds

and then touch it two times again. “End” will show. Using the “+” and “–” keys, set the stop time.

Note: While “dur” is displayed you can change to “End” just by touching one time the “MODE” key (within 8 seconds from the last selection).

If there is time to wait before cooking starts, the current time of day and “AUTO” will show in the clock display. The oven will switch off but is now set for automatic cooking. If you are already at home to turn the oven on and only want the oven to turn off automatically, start cooking as normal, then follow step 4 or step 5 to set a time to stop the oven.

When automatic cooking starts, “

- To see the remaining cook time, follow step 4 up to display “dur” (duration).

- To see the set stop time, follow step 5 up to display “End”.

- To cancel automatic cooking at any time, touch the “+” and “–” keys simultaneously (for more than 2

seconds) and turn the temperature and function knobs to the off position.

When the stop time is reached, the oven will turn off, the timer will beep and “AUTO” will ﬂash:

- Touch any key to stop the beeping.

- Touch the “MODE” key, for more than 2 seconds, to return the oven to the manual mode (“ ” symbol

steady illuminated on the display).

- Turn the temperature and function knobs to the off position.

Attention: after a power failure any automatic program is deleted. Turn off the oven manually.

” will be displayed and the oven will turn on.

How to Use the Hob Burners

Hob Burners

Each hob burner is controlled by a separate gas valve operated by a control knob (ﬁg. 4) which has 3 positions marked on the control panel, these are:

– Symbol

: Tap closed (burner off)

– Symbol

Push in and turn the knob anti-clockwise to the selected position. The maximum aperture position permits rapid boiling of liquids, whereas the minimum aperture position allows slower warming of food or maintaining boiling conditions of liquids. To reduce the gas ﬂow to minimum, rotate the knob further anticlockwise to point the indicator towards the small ﬂame symbol. Other intermediate operating adjustments can be achieved by positioning the indicator between the maximum and minimum aperture positions, not between the maximum aperture and closed positions.

Note: When the hob is not being used, set the gas knobs to their closed positions and also close the cock valve on the gas bottle or the main gas supply line.

: High (maximum)

: Low (minimum)

Fig. 4

Lighting of the Hob Burners

To ignite the burner, the following instructions are to be followed: 1 - Press in the corresponding knob and turn counter-clockwise to the full ﬂame position marked by the

symbol (ﬁg. 4) and hold the knob in until the ﬂame has been lit.

In the case of a mains failure light the burner with a match or lighted taper. 2 - Wait about ten seconds after the gas lighting before releasing the knob (starting time for the valve). 3 - Adjust the gas valve to the desired power.

Important

If the burner ﬂame should go out for some reason, the safety valve will automatically stop the gas ﬂow. To re-light the burner, return the knob to the closed position, wait for at least 1 minute and then repeat the lighting procedure. If your local gas supply makes it difﬁcult to light the burner with the knob set to maximum, set the knob to minimum and repeat the operation.

AIR FLOW

(coolin

fan)

AIR FLOW

(coolin

fan)

AIR FLOW

(coolin

fan)

Choice of Burner

The burner must be choosen according to the diameter of the pans and energy required. Saucepans with handles which are excessively heavy, in relationship to the weight of the pan, are safer as they are less likely to tip. Pans which are positioned centrally on burners are more stable than those which are offset. It is far safer to position the pan handles in such a way that they cannot be accidentally knocked. When deep fat frying ﬁll the pan only one third full of oil. DO NOT cover the pan with a lid and DO NOT leave the pan unattended. In the unfortunate event of a ﬁre, leave the pan where it is and turn off all controls. Place a damp cloth or correct ﬁtting lid over the pan to smother the ﬂames. DO NOT use water on the ﬁre. Leave the pan to cool for at least 30 minutes.

Do not use pans with concave or convex bases

Burner Size Minimum Pan Diameter (cm) Maximum Pan Diameter (cm)

Auxiliary 12 14

Semi-Rapid 16 24

Rapid (RV 901 .. model) 24 26

Rapid (RV 1001 .. model) 24 24

Triple Ring 26 28

Wok - 36

Fig. 5

Fig. 6

CORRECT USE OF RAPID BURNER (mod. RV 1001 .. only)

Correct Use of Triple-Ring Burner

The ﬂat-bottomed pans are to be placed directly onto the pan-support. To use the WOK you need to place the proper stand in order to avoid any faulty operation of the triplering burner (Figs. 7 - 8). Important: The wok pan stand (ﬁg. 8) MUST BE PLACED ONLY over the pan-rest for the triple-ring burner.

WRONG CORRECT

Fig. 7

Fig. 8

How to Use the Multifunction Main Oven

General Features

As its name indicates, this is an oven that presents particular features from an operational point of view. In fact, it is possible to insert 7 different programmes to satisfy every cooking need. The 7 positions, thermostatically controlled, are obtained by 4 heating elements which are: – Bottom element 1200 W – Top element 1000 W – Grill element 2000 W – Circular element 2200 W

Note:

Upon ﬁrst use, it is advisable to operate the oven for 30 minutes in the position and for another 30 minutes at the maximum temperature (thermostat knob on position 250) in the positions and , to eliminate possible traces of grease on the heating elements. Clean the oven and accessories with warm water and washing-up liquid.

WARNING: The door is hot, use the handle.

ATTENTION - MOST IMPORTANT Pay special attention not to touch the hot heating element inside the oven cavity.

Attention:

The oven door becomes very hot during operation.

Operating Principles

Heating and cooking in the MULTI-FUNCTION oven are obtained in the following ways: a. by normal convection The heat is produced by the upper and lower heating elements.

b. by forced convection

A fan sucks in the air contained in the oven mufﬂe, which sends it through the circular heating element

and then sends it back through the mufﬂe. Before the hot air is sucked back again by the fan to repeat

the described cycle, it envelops the food in the oven, provoking a complete and rapid cooking. It is possible to cook several dishes simultaneously.

c. by semi-forced convection

The heat produced by the upper and lower heating elements is distributed throughout the oven by the

fan.

d. by radiation The heat is radiated by the infra red grill element.

e. by radiation and ventilation

The irradiated heat from the infra red grill element is distributed throughout the oven by the fan.

f. by ventilation

The food is defrosted by using the fan only function without heat.

Thermostat Knob (ﬁg. 9)

This only sets the cooking temperature and does not switch the oven on. Rotate clockwise until the required temperature is reached (from 50 to 250°C). The light between the thermostat and the function selector will illuminate when the oven is switched on and turns off when the oven reaches the correct temperature. The light will cycle on and off during cooking in line with the oven temperature.

Fig. 9 Fig. 10

Function Selector knob (ﬁg. 10)

Rotate the knob clockwise to set the oven for one of the following functions.

Oven Light

By setting the knob to this position, only the oven light comes on. It remains on in all the cooking modes.

Traditional Convection Cooking

The upper and lower heating elements come on. The heat is dispersed by natural convection and the temperature must be set to between 50° and 250°C via the thermostat knob. The oven must be preheated before cooking.

Recommended for:

Food that requires the same degree of cooking both inside and out, for example roasts, spare pork ribs, meringues etc.

Grilling

The infrared grill element comes on. The heat is dispersed by radiation.

Use with the oven door closed and the thermostat knob to position 225°C for max 15 minutes, then to position 175°C. For cooking hints, see the chapter “USE OF THE GRILL”.

Recommended for:

Intense grilling, browning, cooking au gratin and toasting etc.

It is recommended that you do not grill for longer than 30 minutes at any one time. Caution: the oven door becomes very hot during operation. Keep children well out of reach.

Defrosting Frozen Foods

Only the oven fan comes on. Use with the thermostat knob set to “ ” - other positions have no effect. The food is thawed by ventilation without heating.

Recommended for:

Quick thawing of frozen foods; one kg requires approximately 1 hour. Thawing times vary according to the quantity and type of food to be thawed.

Hot Air Cooking

The circular element and fan come on. The heat is dispersed by forced convection and the temperature can be regulated to between 50° and 250°C via the thermostat knob. The oven does not require preheating.

Recommended for:

Food which has to be well-cooked outside and soft or rosy inside, for example lasagne, lamb, roast beef, whole ﬁsh etc.

Ventilated Grill Cooking

The infrared grill element and the fan come on. The heat is dispersed mainly by radiation and the fan then distributes it all over the oven. Use with the door closed. The temperature can be regulated via the thermostat knob to between 50° and 175° max. The oven must be preheated for approximately 5 minutes. For cooking hints, see the chapter “GRILLING AND AU GRATIN.

Recommended for:

Grilling where quick browning on the outside is required to keep the juices in. For example: veal steaks, chops, hamburgers etc.

It is recommended that you do not grill for longer than 30 minutes at any one time. Caution: the oven door becomes very hot during operation. Keep children well out of reach.

Maintaining Temperature After Cooking or Slowly Heating Foods

The upper heating element, the circular element and the fan come on. The heat is dispersed by forced convection with greater intensity in the upper part. The temperature can be set to between 50° and 150°C via the thermostat knob.

Recommended for:

Keeping food warm after any type of cooking. Slow heating of cooked food.

Convection Cooking with Ventilation

The upper and lower heating elements come on and the fan. The heat coming from above and below is dispersed by convection with ventilation. The temperature can be set to between 50° and 250°C via the thermostat knob.

Recommended for:

Voluminous dishes and large quantities which require the same degree of cooking both inside and out, for example rolled roasts, turkey, roast legs, cakes etc.

Cooking Advice

Sterilization

Sterilization of foods to be conserved, in full and hermetically sealed jars, is done in the following way: a. Set the switch to position . b. Set the thermostat knob to position 185 °C and preheat the oven. c. Fill the dripping pan with hot water. d. Set the jars onto the dripping pan making sure they do not touch each other and the door and set the

thermostat knob to position 135 °C.

When sterilization has begun, that is, when the contents of the jars start to bubble, turn off the oven and let cool.

Regeneration

Set the switch to position and the thermostat knob to position 150° C. Bread becomes fragrant again if wet with a few drops of water and put into the oven for about 10 minutes at the highest temperature.

Simultaneous Cooking of Different Foods

The MULTI-FUNCTION oven set on position and gives a simultaneous heterogeneous cooking of different foods. Different foods such as ﬁsh, cake and meat can be cooked together without mixing the smells and ﬂavors together. This is possible since the fats and vapors are oxidized while passing through the electrical element and therefore are not deposited onto the foods. The only precaution to follow are: – The cooking temperatures of the different foods must be as close to as possible, with a maximum

difference of 20° - 25 °C. – The introduction of the different dishes in the oven must be done at different times in relation to the

cooking times of each one.

The time and energy saved with this type of cooking is obvious.

Grilling and “Au Gratin”

Grilling may be done without the roasting jack on position of the switch, because the hot air completely envelops the food that is to be cooked. Set the thermostat to position 175 °C and after having preheated the oven, simply place the food on the rack. Close the door and let the oven operate with the thermostat on position 175 °C, until grilling is done. Adding a few dabs of butter before the end of the cooking time gives the golden “au gratin” effect.

Grilling with the oven door closed. It is recommended that you do not grill for longer than 30 minutes at any one time. Caution: the oven door becomes very hot during operation. Keep children well out of reach.

+ 36 hidden pages