Cal Flame LTR50001006 Owner's Manual
Copyright 2011 LMS, Inc. All rights reserved. Duplication without written consent
is strictly prohibited.
Cal Flame ® is a registered trademark.
Due to continuous improvement programs,
all models, operation, and/or specications
are subject to change without prior notice.
LTR50001006, Rev. C
6/21/11
250-407
Operation
Lighting Instructions for Automatic Starter ...........23
Lighting Your Wood Burning Fireplace................25
Maintenance
Appendix
Replacement Parts ...............................27
Limited Warranty.................................30
Save these instructions!
California Proposition 65 Warning:
Chemicals known to the State of
California to cause cancer, birth
defects or other reproductive
harm are found in and/or created by the combustion of natural
gas, propane, butane and other
fuels. Always operate this unit as
described in the owner’s manual
and in well ventilated areas.
Read this before installing or operating your
new Cal Flame repit or replace.
Safety Instructions
1
Fireplaces and Firepits
LTR50001006, Rev. C
www.ca l s p a s .com
Safety Instructions
What To Do If You Smell Gas
Shut off gas to the repit or replace.•
Extinguish any open ame.•
Do not try to light the appliance.•
If odor continues, keep away from the appliance and •
immediately call your gas supplier or your re depart-
ment.
WARNING: Improper installation, adjustment,
alteration, service or maintenance can cause in-
jury or property damage. Read the installation,
operating and maintenance instructions thoroughly before installing or servicing this equipment.
Cal Flame replaces and repits are
designed for outdoor use only.
Do not store combustible materials, gasoline
and any other ammable vapors and liquids.
A propane gas cylinder not connected for use shall not be
stored in the vicinity of this or any other appliance.
Carbon Monoxide Hazard
This appliance can produce carbon monoxide
which has no odor.
Using it in an enclosed space can kill
you.
Never use this appliance in an enclosed space such as a camper, tent,
car, or home.
2
Safety Instructions
Fireplaces and Firepits
LTR50001006, Rev. C
www.ca l s p a s .com
Operation
Do not use charcoal or other solid fuel in gas burning re-•
places and re pits.
Do not operate the replace with the propane tank on, near, or •
under the hearth! This could result in re, explosion, or severe
injury.
Do not use your repit or replace for cooking.•
In the event that a burner goes out, turn burner knobs to the full •
OFF position and let it air out. Do not attempt to use the repit or
replace until the gas has had time to dissipate.
Keep all electrical supply cords away from the heated areas of the •
replace or repit.
Never use the replace or repit in windy conditions. If used in a •
consistently windy area a windbreak will be required. Always ad-
here to the specied clearances listed in this manual.
When handling propane gas line and connectors, do not allow them •
to come in contact with any metal surfaces. Do not drop propane
connectors.
Propane gas sources to the replace or repit must be regulated. •
Do not operate if regulator has been removed. Fire or explosion
can occur.
Never leave the replace or repit unattended when in use.•
Never allow clothing or other ammable materials come in contact •
with any hot surface until it has fully cooled. Never wear loose
tting or hanging garments while using your replace or repit.
Fabric may ignite and result in personal injury.
Clothing or other ammable materials should not be hung from the •
appliance, or placed on or near the appliance.
When using the repit or replace, do not touch the rock, re •
screen, or immediate surroundings, as these areas become extremely hot and could cause burns.
Do not heat any unopened glass or metal container of food in the •
replace or repit. Pressure may build up and cause the container
to burst, possibly resulting in serious personal injury or damage to
the replace or repit.
Do not reach over your repit when hot or in use.•
Never line repit or replace with aluminum foil.•
Safety Instructions
3
Fireplaces and Firepits
LTR50001006, Rev. C
www.ca l s p a s .com
Maintenance and Repair
Spiders and other insects can nest in the burners and block the gas •
and airow to the burner ports. This creates a dangerous condition that can result in a re from behind the valve panel. Inspect
and clean the burners periodically and follow the guidelines in the
maintenance section of this manual.
The appliance should be inspected before use and at least annually •
by a qualied service person.
More frequent cleaning may be required as necessary. It is impera-•
tive the control compartment, burner and circulation air passageways of the appliance be kept clean and free.
Any guard or other protective device removed for servicing the ap-•
pliance must be replaced prior to operating the appliance.
If it is evident there is excessive abrasion or wear of any of the •
components, if the fuel supply hose is cut or cracked, it must be
replaced prior to the appliance being put into operation.
Inspect the fuel supply connection for signs of leakage (including •
the hose for propane models) before each use of the appliance.
Unless specically recommended in this manual, do not repair or •
replace any part of your repit or replace. Have a qualied techni-
cian perform all service. Any repairs made by a non-LMS approved
dealer technician will void your warranty.
4
Safety Instructions
Fireplaces and Firepits
LTR50001006, Rev. C
www.ca l s p a s .com
Storage
When your replace or repit is not in use, turn off the gas at the •
source.
Do not store the propane cylinder in the vicinity of this or any other •
appliance when it is not being used.
This appliance can be store indoors only if it has been discon-•
nected from its fuel supply.
Store propane cylinders outdoors in a well-ventilated area out of •
reach of children. Disconnected sylinders must have threaded valve
plugs tightly installed and must not be stored in a building, garage,
or any other enclosed area.
To extend the life of your replace or repit, protect and cover •
it from the elements when not in use. Ensure the appliance has
ample time to cool off after use and prior to installing storage
cover. Damage caused to storage cover due to heat or burns are
not covered by warranty.
Precautions Regarding Children
Never leave children unattended in the area where the replace •
or re pit is being used. Close supervision of children is necessary
when any appliance is used near children.
Do not store items of interest to children around or below the re-•
place or re pit.
Never allow children to sit or stand on any part of the replace or •
re pit.
Loading...