Burnham 3 1099-01R1--10 User Manual

USER'S INFORMATION MANUAL

SERIES 3™

Gas - Fired Boiler

WARNING: If the information in this manual

is not followed exactly, a  re or explosion
may result causing property damage,
personal injury or loss of life.

-

Do not store or use gasoline or other

fl ammable vapors and liquids in the
vicinity of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do

not use any phone in your building.

• Immediately call your gas supplier

from a neighbor's phone. Follow the
gas supplier's instructions.

• If you cannot reach your gas supplier,

call the  re department.

-

Installation and service must be
performed by a quali ed installer,
service agency or the gas supplier.

AVERTISSEMENT. Assurez-vous de bien
suivre les instructions données dans cette
notice pour réduire au minimum le risque
d'incendie ou d'explosion ou pour éviter
tout dommage matériel, toute blessure ou
la mort.

Ne pas entreposer ni utiliser d'essence ni

-

d'autres vapeurs ou liquides infl am-mables
dans le voisinage de cet appareil ou de tout
autre appareil.

QUE FAIRE SI VOUS SENTEZ UNE ODEUR
DE GAZ:

• Ne pas tenter d'allumer d'appareils.

• Ne touchez à aucun interrupteur. Ne pas

vous servir des téléphones dans le
bâtiment où vous vous trouvez.

• Appelez immédiatement votre

fournisseur de gaz depuis un voisin.
Suivez les instructions du fournisseur.

• Si vous ne pouvez rejoindre le

fournisseur de gaz, appelez le service
des incendies.

L'installation et I'entretien doivent être

-

assuréx par un installateur ou un service
d'entretien quali é ou par le fournisseur de
gaz.

102997-01R1-7/10

The following terms are used throughout this manual to bring attention to the presence of hazards of various risk
levels.

WARNING

Indicates a potentially hazardous situation which,
if not avoided, could result in death, serious injury
or substantial property damage.

Indicates a potentially hazardous situation which,
if not avoided, may result in moderate or minor
injury or property damage.

CAUTION

Basic Operation

CAUTION

Should overheating occur or the gas supply fail to shut off, do not turn off or disconnect the electrical
supply to the pump. Instead, shut off the gas supply at a location external to the appliance.
En cas de surchauffe ou si I'admission de gaz ne peut étre coupée, ne pas couper ni débrancher
l'alimentation électrique de la pompe. Fermer plutôt le robinet d'admission de gaz à l'extérieur de I'appareil.

Do not use this boiler if any part has been under water. Immediately call a qualied service technician to
inspect the boiler and to replace any part of the control system and any gas control which has been under
water.

A. General. This water boiler is equipped with controls

for proper operation. All controls must be in proper

working order. Contact a qualied service agency to
provide annual maintenance as specied in Installation,
Operating and Service Instructions.

1. Limit. See Figure 1. A device which automatically

interrupts boiler operation when the water
temperature exceeds the set point. Maximum
allowable temperature is 220°F.

Original equipment with this boiler is U.S. Boiler

IQ Control and Limit Rated Sensor combination.
The IQ Control shuts off boiler main burners when

boiler water temperature exceeds pre-programmed

IQ control water temperature set point. Boiler main
burners will re-light automatically, providing the call
for heat is present, when boiler water temperature

falls below pre-programmed control water
temperature set point less the set point differential.

2. Flame Rollout Switch. See Figure 1. A device

which automatically interrupts boiler operation
when ames or excessive heat are present in the

combustion area enclosure. The control is a single

use device. The control is located in the combustion
area enclosure. If the control was activated to
interrupt boiler operation, do not attempt to place
boiler in operation. Contact a qualied service
agency.

Do not reset Blocked Vent Switch unless a
qualied service agency has determined and
corrected the cause of any blockage in the vent
system or chimney.

3. Blocked Vent Switch See Figure 1. A device

which automatically interrupts boiler operation
when excessive vent system blockage occurs. If the
control was activated to interrupt boiler operation,

do

not attempt to place boiler in operation. Contact

a qualied service agency.

4. Electronic Ignition System - see Figure 1. The

Electronic Ignition (EI) System consists of:

a. a solid state ignition control with integral

ignition module to initiate, monitor and stop

burner operation.

b. a combination gas valve to regulate gas ow to

the main burners.

c. a pilot burner to provide the ignition source for

the main burners.

B. Instructions to place the boiler in operation and to turn

off the boiler are shown on the Operating Instruction
Label posted on the left jacket panel of the boiler. The
Operating Instruction Label is shown in Figure 2.

WARNING

WARNING

Service on this boiler should be undertaken only
by trained and skilled personnel from a qualied
service agency.

2

C. The Sequence of Operation is shown in Figure 3.

Figure 1: Control Locations

3