Bradford White BMGH1600, BMGH2000, BMGH3500, BMGH2500, BMGH3000 User Manual

User’s Manual Doc. 1294A

User’s Manual for

MagnaTech

Brute MagnaTech

®

Modulating Boiler Water Heater

Model BMGH1600 Model BMGV1600

1,599 MBTU/h 1,599 MBTU/h

Model BMGH2000 Model BMGV2000

1,999 MBTU/h 1,999 MBTU/h

Model BMGH2500 Model BMGV2500

2,499 MBTU/h 2,499 MBTU/h

Model BMGH3000 Model BMGV3000

3,000 MBTU/h 3,000 MBTU/h

Model BMGH3500 Model BMGV3500

3,500 MBTU/h 3,500 MBTU/h

Model BMGH4000 Model BMGV4000

4,000 MBTU/h 4,000 MBTU/h

FOR YOUR SAFETY: This product must be installed and serviced by a professional service technician,

qualied in hot water boiler and heater installation and maintenance. Improper installation and/or operation
could create carbon monoxide gas in ue gases which could cause serious injury, property damage, or
death. Improper installation and/or operation will void the warranty.

WARNING

If the information in these instructions is

not followed exactly, a re or explosion
may result causing property damage,
personal injury or death.

Do not store or use gasoline or other

ammable vapors and liquids in the vicinity
of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do not

use any phone in your building.

• Immediately call your gas supplier from
a neighbor’s phone. Follow the gas
supplier’s instructions.

• If you cannot reach your gas supplier, call
the re department.

Installation and service must be performed
by a qualied installer, service agency, or gas
supplier.

AVERTISSEMENT

Assurez-vous de bien suivres les instructions
données dans cette notice pour réduire au
minimum le risque d’incendie ou d’explosion ou
pour éviter tout dommage matériel, toute blessure
ou la mort.

Ne pas entreposer ni utiliser d’essence ou ni
d’autres vapeurs ou liquides inammables dans
le à proximité de cet appareil ou de tout autre
appareil.

QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:

• Ne pas tenter d’allumer d’appareils.

• Ne touchez à aucun interrupteur. Ne pas vous servir
des téléphones dans le bâtiment où vous vous trovez.

• Appelez immédiatement votre fournisseur de
gaz depuis un voisin. Suivez les instructions du
fournisseur.

• Si vous ne pouvez rejoindre le fournisseur de
gaz, appelez le sservice des incendies.

L’installation et l’entretien doivent être assurés par
un installateur ou un service d’entretien qualié ou
par le fournisseur de gaz.

H2359301A

The MagnaTech

CONTENTS

Familiarizing yourself with the MagnaTech .......................1

FOR YOUR SAFETY,

PLEASE READ THIS BEFORE OPERATING .................2

What to Do If You Smell Gas .............................................2

Lighting the Unit .................................................................2

Turning Off the Gas to the Unit ..........................................2

POUR VOTRE SÉCURITÉ,

LISEZ AVANT DE METTRE EN MARCHE ........................3

Que Faire si Vous Sentez une Odeur de Gaz ......................3

Instructions de Mise en Marche ..........................................3

Fermeture de l’Alimentation en Gaz ...................................3

Shutting Down the MagnaTech ..........................................4

Restarting the MagnaTech ..................................................4

In the Event of Power Failure .............................................4

THE TOUCH SCREEN AND INDICATORS ....................5

About Lockouts, Holds, and Alerts .....................................6

Care, Inspection, and Service ..............................................7

FAMILIARIZING YOURSELF
WITH THE

MagnaTech

Page 1

Power
Switch

Door
Latch

For full instructions regarding the MagnaTech, please reference
the MagnaTech Installation and Operation Manual.
Document #1293. If not available at or near the MagnaTech,
it can be downloaded at www.bradfordwhite.com

Blower

Touch Screen

Display

Automatic High

Limit Reset

Manual High

Limit Reset

Variable Speed

Pump Control

Voltage Pack

Start-Up and
Shutdown Decal

Manual
Gas Valve

Automatic
Gas Valve

Heat

Exchanger

Condensate
Trap

Condensing
Unit

Location of Components

Note - Model 3000 shown for reference.

Some components will vary slightly between the various sizes, but the User Interface & Front Panel remain the same.

Shown without jacket.

Page 2

WARNING: If you do not follow these instructions exactly, a fire or explosion may result

causing property damage, personal injury or loss of life.

A. This appliance is equipped with an ignition device which automatically lights the pilot.

B. BEFORE OPERATING smell all around the appliance area for gas. Be sure to smell next to

the floor because some gas is heavier than air and will settle on the floor.

WHAT TO DO IF YOU SMELL GAS

Do not try to light any appliance.
Do not touch any electric switch; do not use any phone in your building.
Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.
If you cannot reach your gas supplier, ca

ll the fire department.

C. Use only your hand to turn the gas valve handle. Never use tools. If the valve handle will

not turn by hand, don’t try to repair it, call a qualified service technician. Force or
attempted repair may result in a fire or explosion.

D. Do not use this appliance if any part has been under water. Immediately call a qualified

service technician to inspect the appliance and to replace any part of the control system
and any ga

s control which has been under water.

1. STOP! Read the safety information above on this label.

2. Turn off all electric power to the appliance.

3. Set the thermostat to lowest setting.

4.

5. Open front doors.

6. Turn off manual gas valve. Valve is off when valve handle is at a
right angle to gas pipe.

7. Wait five (5) minutes to clear out any gas. Then smell for gas,
including near the floor. If you do smell gas, STOP! Follow “B” in th

e
safety information above on this label. If you don’t smell gas, go to
next step.

8. Slowly turn manual gas valve to “ON”. Valve handle will be parallel to gas pipe.

9. Replace front panel.

10. Set mechanical thermostats to desired settings.

11. Turn on all electric power to the appliance.

13. If the appliance will not operate, follow the instructions “To Turn O Gas To Appliance”

12. Set operating thermostat to desired settings using boiler display.

and call your service technician or gas supplier.

1. Turn off all electric power to the appliance if service is to be performed.

2.
Set the thermostat to lowest setting.

3.

4. Turn off manual gas valve. Valve is off when valve handle is at a right angle to gas pipe.

5. Close front doors.

FOR YOUR SAFETY READ BEFORE OPERATING

OPERATING INSTRUCTIONS

TO TURN OFF GAS TO APPLIANCE

Gas inlet

Manual Gas Valve

Shown in the

“OFF” Position

Do not try to light the pilot by hand.

Open front doors.

This appliance is equipped with an ignition device which automatically
lights the pilot. Do not try to light the pilot by hand.

Start-Up and Shut-Down Decal. Located on the inside of the right side door.

BRADFORD WHITE CORP

.