BOSCH
INSTALLATION INSTRUCTION' MANUAL
for
Bosch Electric Built-in
Single & Double Oven Models HBN 64.J65,.166.,
BEFORE YOU BEGIN, READ THESE INSTRUCTIONS COMPLETELY AND CAREFULLY
IMPORTANT: Save these instructions for _e local electrical inspector's nse'_
INSTALLER: Please leave this manual w_th owner for future reference. |
OWNER: Please keep this manual for future reference /
J
Table of Contents
INTRODUCTION .............................................................................................................................
Tools You Will Need ...................................................................................................................
Power Requirements ............. .........
Choosing Oven Location .............................................................................................................
Steps for Installation ....................................................................................................................
TECHNICAL DATA .................................................................................................................... [....
Single oven ...................................................................................................................................
Double oven ..................................................................................................................................
UNDERCOUNTER INSTALLATION ..........................................................................................
SINGLE OVEN ............................................................................................................................
WALL INSTALLATION .................................................................................. ...............................
SINGLE OVEN ............................................................................................................................
DOUBLE OVEN ......................................................................................... .................................
.i A . . ........... ,. ,.°,***°°,,(ELECTRIC L SUPPLY ......
WIRING REQUIREMENTS ......................................................................................................
CONNECTING TO 208 VOLT CIRCUIT ............................. :.................................................
ELECTRICAL CONNECTIONS .................................................................
3-WIRE BRANCH CIRCUIT ..............................
4-WIRE BRANCH CIRCUIT .....................................................................................................
,
3
3
3
3
4
4
4
5
5
6
6
7
8
8
9
10
10
FINAL CHECKLIST ........................................................................................................................
2
11
INTRODUCTION
Please read these instructions COMPLETELY
AND CAREFULLY. They will save you time .and
effort and help to ensure optimum oven perform-
mace. Be sure to observe all WARNINGS.
These installation instructions are int_ndad for
• use by a qualified installer. In addition to these in-
structions the oven shall be installed:
• In the United States, in accordance with the Na-
tional Electric Code/State and Municipal codes
and/or local codes.
• In Canada, in accordance with Canadian Elec-
tric Code C22.1-1ateSt edition/Provincial and
Municipal codes and/or local codes.
The,_ shall be carefully followed at all times.
Note: If installing your oven in Canada please
check tO make sure that you have a model
with the UL Canadian listing mark, as
shown below:
•,aT208 volt circuit must be used, wiring inside the
oven must be modified. See Connection to a 208
Volt Circuit, in this manuai. A circui[ breaker or
time-delay fuse sized not to exceed the circuit rat-
ing of the appliance specified on the rating plate
located on the frame behind the door of the oven
is recommended.
The oven must be supplied with copper wires
ONLY.
It is recommended that you have the electrical
wiring and hook-up of your oven performed by a
qualified elcc_iciam After installation is com-
flete have the electrician show you where the
main disconnect is and which of the circuit break-
ers/fuses are for the oven.
CHOOSING OVEN LOCATION
Carefully select the location where the oven will
be placed. The oven should be located for conven-
ient use in the kitchen, but away from strong
drafts. Strong drafts may be caused by open doors
or windows, or by heating and/or air conditioning
vents or fans. Make sure that electrical power can
be provided to the location selected.
The UL Canadian listing mark consists of the cir-
cled UL symbol preceded by the letter "C", as
showm This should appear on the oven's rating
plate along with the UL United States listing
mark, which is the circled UL symbol above but
not preceded by the letter "C".
TOOLS YOU WILL NEED
The following tools "areneeded to install your new
oven:
• Tape measure and straightedge or ruler
• Pencil
• Phillips screwdriver
• Level
• Wire cutters and wire stripper
• I" hole saw
• Hand or saber saw.
POWER REQUIREMENTS
The oven must be supplied with the proper volt-
age and frequency. The oven is manufactured to
be connected to a three wire or four wire, single
phase, 240 volt, 60 Hz AC electrical supply on a
separate, circuit fused on both sides of the line. If
STEPS FOR INSTALLATION .'
The following pages provide the necessary infor-
mation for proper installation of the oven ar-
ranged as follows:
• Technical Data
• Installation Cutout Dimensions, Required
Clearances and Mounting instructions for:
> Undercounter Installation, Single Oven
>Wall Installation, Single Oven
>Wall Installation, Double Oven
• Electrical Supply and Wiring Requirements
• Modifications required if Connecting to 208
Volt Circuit.
• Electrical Connections for 3-wire or 4-wire
B'ranch Circuit.
• Final Checklist.
TECHNICAL DATA
SINGLE OVEN
For cutout dimensions see following sections titled:
Preparing Location
Electrical Ratings
Single Oven
Models
HBN 642A UC
HBN 645A UC
HBN 646A UC
and Maximum Connected Load
Volts Hertz Amperes
240/208 60 13.1/13.3
240/208 60 13.1/13.3
2401208 60 13.1/13.3
@240V/208V
Watts
@240V/208V
3,150/2,775
3,150/2,775
3,150/2,775
Convection
Oven
Yes
Yes
Yes
DOUBLE OVEN
For cutout dimensions sec following sections titled:
Preparing Location
Electrical Ratings
Double Oven
Models
HBN 652A UC
HBN 655A UC
[-IBN 656A UC
HBN 662A UC
HBN 665A UC
HBN 666A UC
and Maximum Connected Load
Volts Hertz Amperes
2401208 60 26.3/24.8
240/208 60 26.3/24.8
240/208 60 26.3/24.8
240/208 60 26.3/24.8
240/208 60 26.3/24.8
240/208 60 26.3/24.8
@240V/208V
Watts
@240V/208V
6,300/5,150
6,300/5,150
6,300/5,150
6,300/5,150
6,300/5,150
6,300/5,150
Convection
Oven
(_p_ot_m)
Yes/No
Yes/No
Yes/No
Yes/Yes
Yes/Yes
Yes/Yes
4