Blue Rhino NBC1402-C User Manual
OWNER’S MANUAL
Outdoor Charcoal Barbecue Grill
Model No. NBC1402-C
WARNING
FOR YOUR SAFETY:
For Outdoor Use Only
(outside any enclosure)
WARNING
WARNING
FOR YOUR SAFETY:
FOR YOUR SAFETY:
1. Improper installation, adjustment, alteration,
1. Improper installation, adjustment, alteration,
service or maintenance can cause injury or
service or maintenance can cause injury or
property damage.
property damage.
2. Read the installation, operation, and
2. Read the installation, operation, and
maintenance instructions thoroughly before
maintenance instructions thoroughly before
installing or servicing this equipment.
installing or servicing this equipment.
3. Failure to follow these instructions could
3. Failure to follow these instructions could
result in fire or explosion, which could
result in fire or explosion, which could
cause property damage, personal injury, or
cause property damage, personal injury, or
death.
death.
Table of Contents
Important Safeguards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Exploded View & Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Assembly Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Operating Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Clean and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Product Registration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Save these instructions for future reference.
If you are assembling this unit for someone else,
give this manual to him or her to read and save
for future reference.
Manufactured in China for:
Blue Rhino Global Sourcing, LLC
104 Cambridge Plaza Drive, Winston-Salem, NC 27104 USA
1.800.762.1142, www.bluerhino.com
© 2005 Blue Rhino Global Sourcing, LLC. All Rights Reserved
UniFlame® is a Registered Trademark of Blue Rhino Global Sourcing, LLC. All Rights Reserved
NBC1402-C-OM-100 EF
Outdoor Charcoal Barbecue Grill Model No. NBC1402-C
WARNING
FOR YOUR SAFETY
1. This grill is for outdoor use only, and shall not be used in a building,
garage, or any other enclosed area.
2. This grill is NOT for commercial use.
3. This is not a tabletop grill. Therefore, do not place this grill on any
type of tabletop surface
4. Do not use grill for indoor cooking or heating. Toxic carbon monoxide
fumes can accumulate and cause asphyxiation.
5. Do not use gasoline, kerosene, or alcohol for lighting.
6. Do not use in an explosive atmosphere. Keep grill area clear and free
from combustible materials, gasoline and other flammable vapors and
liquids.
7. Do not store or use gasoline or other flammable liquids or vapors
within 25 feet (7.62 m) of this appliance.
8. Instant light charcoal can burn at very high temperatures during
initial startup. Make sure lid is open until charcoal turns to hot coals.
9. Keep all combustible items and surfaces at least 21 inches (53 cm)
away from the grill at all times. DO NOT use this grill or any gas
product under any overhead or near any unprotected combustible
constructions.
10. Do not alter grill in any manner.
11. Do not use the grill unless it is completely assembled and all parts
are securely fastened and tightened.
12. This grill should be thoroughly cleaned and inspected on a regular
basis.
13. Use only Blue Rhino Global Sourcing, LLC. factory authorized parts.
The use of any part that is not factory authorized can be dangerous.
This will also void your warranty. Contact 1.800.762.1142.
14. Do not use this appliance without reading “Operating Instructions” in
this manual.
15. Do not touch metal parts of grill until it has completely cooled (about
45 min.) to avoid burns, unless you are wearing protective gear (pot
holders, gloves, BBQ mittens, etc.).
17. Do not use on wooden decks, wooden furniture or other combustible
surfaces.
18. Do not use in or on boats or recreational vehicles.
19. Position grill so wind can not carry ashes to combustible surfaces.
20. Do not use in high winds.
21. Never lean over the grill when lighting.
22. Do not leave a lit grill unattended, especially keep children and pets
away from grill at all times.
23. Do not attempt to move grill when in use. Allow the grill to cool
before moving or storing.
24. Always open grill lid carefully and slowly as heat and steam trapped
within grill can severely burn you.
25. Always place your grill on a hard, non combustible level surface. An
asphalt or blacktop surface may not be acceptable for this purpose.
26. Do not remove the ashes until they are completely and fully
extinguished.
27. Live hot briquettes and coals can create a fire hazard.
28. Always empty the ashes after each use, once extinguished and cool.
29. Do not place fuel (charcoal briquets, wood or lump charcoal) directly
into bottom of grill. Place fuel only on the charcoal pan/grid.
30. Check to make sure the air vents are free of debris and ash before
and while you are using the grill.
31. Always wear protective gloves when adding fuel to retain desired
heat level.
32. Keep all electrical cords away from a hot grill.
33 Always use a meat thermometer to ensure food is cooked to a safe
temperature.
34. Deaths, serious injury or damage to property may occur if the above
is not followed exactly.
16. Never touch grates (charcoal or cooking), ashes or coals to see if
they are hot.
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
Exploded View
1. Lid . . . . . . . . . . . . . . . . . . . . . . . . . 55-14-765
2. Bottom Bowl. . . . . . . . . . . . . . . . . . 55-14-766
3. Cooking Grid. . . . . . . . . . . . . . . . . . 55-14-767
page no.
3
6
4. Charcoal Grid . . . . . . . . . . . . . . . . . 55-14-768
5. Warming Rack . . . . . . . . . . . . . . . . 55-14-769
6. Lid Handle . . . . . . . . . . . . . . . . . . . 55-14-770
7. Legs and Base . . . . . . . . . . . . . . . . 55-14-771
8. Wire Handle . . . . . . . . . . . . . . . . . . 55-14-772
9. Top Hinge. . . . . . . . . . . . . . . . . . . . 55-14-773
10. Bottom Hinge . . . . . . . . . . . . . . . . . 55-14-774
5
1
9
3
4
10
2
8
7
Hardware / Actual Size
A. Screw 6 pcs
M5x12 Zinc Plated Phillips Truss Head Screw
B. Small Wing Nut 6 pcs
M5 Steel Wing Nut
C. Large Wing Nut 2 pcs
M6 Steel Wing Nut
Outdoor Charcoal Barbecue Grill Model No. NBC1402-C
Step
1
Step
Unfold legs
Attach bottom bowl
Attach bottom bowl to base using 2 sets of screws (A), small washers (D), small
lock washes (G), and small wing nuts (B).
2
Loading...