BlueRhino GGC1643B Owner's Manual
TM
OWNER’S MANUAL
Outdoor LP Gas Griddle
Model No. GGC1643B
BlueRhino.com
WARNING
FOR YOUR SAFETY:
For Outdoor Use Only
(outside any enclosure)
WARNING
FOR YOUR SAFETY:
1. Improper installation, adjustment,
alteration, service or maintenance can
cause injury or property damage.
2. Read the installation, operation, and
maintenance instructions thoroughly
before installing or servicing this
equipment.
3. Failure to follow these instructions could
result in fire or explosion, which could
cause property damage, personal injury, or
death.
4. This instruction manual contains important
information necessary for the proper
assembly and safe use of the appliance.
5. Read and follow all warnings and
instructions before assembling and using
the appliance.
6. Follow all warnings and instructions when
using the appliance.
7. Keep this manual for future reference.
Table of Contents
Important Safeguards ...........................................................Page 2
Expanded View & Hardware .......................................................... 4
Assembly Instructions............................................................... 5
Transporting & Storage Instructions .................................................... 8
Installing LP Gas Tank.............................................................. 11
Operating Instructions.............................................................. 11
Cleaning and Care ................................................................ 12
Product Registration ............................................................... 13
Replacement Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Limited Warranty ................................................................. 14
Troubleshooting .................................................................. 15
DANGER
If you smell gas -
1. Shut off gas to appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
WARNING
FOR YOUR SAFETY:
1. Do NOT store or use gasoline or other
flammable liquids or vapors in the vicinity
of this or any other appliance.
2. An LP cylinder not connected for use shall
NOT be stored in the vicinity of this or any
other appliance.
DANGER
Never operate this appliance unattended.
The use and installation must conform with local codes or, in the absence of local codes, with either the
National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane Installation Code, CSA B149.1,
or Propane Storage and Handling Code, B149.2, or the Standard for Recreational Vehicles, ANSI A 119.2/
NFPA 1192, and CSA Z240 RV Series, Recreational Vehicle Code, as applicable.
THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT SAFETY INFORMATION. PLEASE READ AND KEEP
FOR FUTURE REFERENCE.
If you are assembling this unit for someone else, give this manual to them to read and save for future
reference.
California Proposition 65: Combustion by-products produced when using this product contain chemicals
known to the State of California to cause cancer, birth defects, and other reproductive harm.
California Proposition 65: Wash your hands after handling this product.
California Proposition 65: Handling the brass material on this product exposes you to lead, a chemical
known to the State of California to cause cancer, birth defects, or other reproductive harm.
Manufactured in China for: Blue Rhino Global Sourcing, Inc.
Winston-Salem, NC 27105 USA • 1.800.762.1142 • BlueRhino.com
© Blue Rhino Global Sourcing, Inc.
Blue Rhino
Razor™ is a trademark of Blue Rhino Global Sourcing, Inc. GGC1643B-ES-OM-F122
®
is a trademark of Ferrellgas L.P.
Made from 75% Bagasse
(environmentally friendly sugar
cane pulp by-product)
2
TM
Outdoor LP Gas Griddle
Model No. GGC1643B
Important Safeguards
W DANGER: Failure to follow the dangers, warnings and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion
causing damage to property.
W WARNINGS:
W This griddle is for outdoor use only, and should not be used in a
building, garage or any other enclosed area.
W A fire causing serious injury or damage to property may occur if the
above is not followed exactly.
W Do NOT operate, light or use this appliance within ten feet (3.05 m) of
walls, structures or buildings.
W For residential use only. This griddle is NOT for commercial use.
W This griddle is not intended for and should never be used as a heater.
TOXIC fumes can accumulate and cause asphyxiation.
W This griddle is safety certified for use in the United States and/or
Canada only. Do NOT modify for use in any other location. Modification
will result in a safety hazard and will void your warranty.
W This griddle is for use with liquid propane (LP) gas only. The conversion
to or attempted use of natural gas in this LP gas griddle is dangerous,
may cause bodily harm and will void your warranty.
W LP gas characteristics:
a. LP gas is flammable and hazardous if handled improperly. Become
aware of the characteristics before using any LP gas product.
b. LP gas is explosive under pressure, heavier than air, and settles/
pools in low areas.
c. LP gas in its natural state has no odor. For your safety, an odorant is
added that smells like rotten cabbage.
d. Contact with LP gas can cause freeze burns to skin.
W Apartment dwellers: Check with management to learn the requirements
and fire codes for using a LP gas griddle in your apartment complex.
If allowed, use outside on the ground floor with a ten foot (3.05 m)
clearance from any structure. Do NOT use on or under balconies.
W Never attempt to attach this griddle to the self-contained LP gas system
of a camper trailer, motor home or house.
W Never use charcoal, lighter fluid, lava rocks, gasoline, kerosene or
alcohol with this product.
W Your griddle has been checked at all factory connections for leaks.
Re-check all connections as described in the “Operating Instructions”
section, as shipping can loosen connections.
W Check for leaks even if your unit was assembled for you by someone
else.
W Do NOT operate if a gas leak is present. Gas leaks may cause a fire or
explosion.
W You must follow all instructions in the “Checking for Leaks” section
before operating. To prevent fire or explosion hazard when testing for a
leak:
a. Always perform a leak test before lighting the griddle and each time
the cylinder is connected for use.
b. No smoking. Do NOT use or permit sources of ignition in the area
while conducting a leak test.
c. Conduct the leak test outdoors in a well-ventilated area.
d. Do NOT use matches, lighters, or a flame to check for leaks.
e. The use of alcohol, prescription or non-prescription drugs may
impair the consumer’s ability to properly assemble or safely operate
the appliance.
W LP gas cylinder needed to operate. Only cylinders marked “propane”
may be used.
W The LP gas cylinder must be constructed and marked in accordance
with the Specifications for LP-gas Cylinders of the U.S. Department
of Transportation (D.O.T.) or the National Standard of Canada, CAN/
CSA-B339, Cylinders, Spheres and Tubes for the Transportation of
Dangerous Goods; and Commission.
W LP gas cylinder must be arranged for vapor withdrawal.
W The LP gas cylinder must have a listed overfilling prevention device
(OPD).
W Only use LP gas cylinders equipped with a cylinder connection device
compatible with the connection for outdoor cooking appliances.
W The LP gas cylinder must have a cylinder collar to protect the cylinder
valve.
W Never use an LP gas cylinder with a damaged body, valve, collar or
footing.
W Dented or rusted LP gas cylinders may be hazardous and should be
checked by your LP gas supplier prior to use.
W The LP gas cylinder should not be dropped or handled roughly.
W LP gas cylinders must be stored outdoors out of the reach of children
and must not be stored in a building, garage or any other enclosed area.
Your cylinder must never be stored where temperatures can reach over
125°F.
f. Strong odors, colds, sinus congestion, etc. may prevent the
detection of propane. Use caution and common sense when testing
for leaks.
g. Do NOT use griddle until any and all leaks are corrected.
If you are unable to stop a leak, disconnect the LP gas supply. Call a
gas appliance serviceman or your local LP gas supplier.
W This griddle is designed to operate at an inlet pressure of: 11 inches
water column.
W Do NOT store or use gasoline or other flammable liquids or vapors
within 25 feet (7.62 m) of this appliance.
W Do NOT use in an explosive atmosphere. Keep griddle area clear and
free from combustible materials, gasoline and other flammable vapors
and liquids.
W Minimum clearance from sides and back of unit to combustible
construction is 36 inches (91.4 cm). Do NOT use this appliance under
any type of overhang or roof.
W It is essential to keep the griddle’s valve compartment, burners and
circulating air passages clean.
W Inspect griddle before each use.
W Do NOT alter griddle in any manner. Any alteration will void your
warranty.
W Do NOT use the griddle unless it is COMPLETELY assembled and all parts
are securely fastened and tightened.
W Do NOT insert any tool or foreign object into the valve outlet or safety
relief valve. You may damage the valve and cause a leak. Leaking
propane may result in an explosion, fire, severe personal injury or death.
W Do NOT block holes in sides or back of griddle.
W Never keep an LP gas cylinder in a hot car or trunk. Heat will cause the
gas pressure to increase, which may open the relief valve and allow gas
to escape.
W Place dust cap on cylinder valve outlet whenever the cylinder is not in
use. Only install the type of dust cap on the cylinder valve outlet that is
provided with the cylinder valve. Other types of caps or plugs may result
in leakage of propane.
W If griddle is not in use, the gas must be turned off at the supply cylinder
and disconnected.
W Do NOT store a spare LP gas cylinder under or near this appliance.
W Never fill the cylinder beyond 80 percent full.
W Do NOT build this model of griddle in any built-in or slide-in
construction. Ignoring this warning could cause a fire or an explosion
that can damage property and cause serious bodily injury or death.
W This griddle should be thoroughly cleaned and inspected on a regular
basis.
W Clean and inspect the hose before each use of the appliance. If there
is evidence of abrasion, wear, cuts or leaks, the hose must be replaced
prior to operation.
W Use only the regulator and hose assembly provided. Use only the
replacement regulator and hose assembly specified by Blue Rhino
Global Sourcing, Inc.
W Use only Blue Rhino Global Sourcing, Inc. factory-authorized parts. The
use of any part that is not factory-authorized can be dangerous and will
void your warranty.
W Do NOT operate this appliance without reading “Operating Instructions”
in this manual.
Recipes
BlueRhino.com/recipes
Need help? 1.800.762.1142
Do not return to place of purchase.
Replacement Parts
parts.BlueRhino.com
1.800.762.1142
3
W Do NOT touch metal parts of griddle until they have completely cooled
to avoid burns, unless you are wearing protective gear (pot holders,
gloves, BBQ mittens, etc.).
W Do NOT install or use in or on boats or recreational vehicles.
W When cooking, fire extinguishing materials should be readily accessible.
In the event of an oil/grease fire, do NOT attempt to extinguish with
water. Use type BC dry chemical fire extinguisher or smother with dirt,
sand or baking soda.
W Do NOT use griddle in high winds.
W Never lean over the griddle when lighting.
W Do NOT leave a lit griddle unattended. Keep children and pets away from
griddle at all times.
W Do NOT leave griddle unattended while preheating or burning off food
residue on high. If griddle has not been cleaned, a grease fire can occur
that may damage the product.
W Do NOT place empty cooking vessels on the appliance while in
operation.
W Use caution when placing anything on the griddle while the appliance is
in operation.
W Do NOT attempt to move griddle when in use. Allow the griddle to cool
before moving or storing.
W Do NOT attempt to disconnect the gas regulator from the cylinder or any
gas fitting while the griddle is in use.
W Always place your griddle on a hard, non-combustible, level surface. An
asphalt or blacktop surface may not be acceptable for this purpose.
W Move gas hoses as far away as possible from hot surfaces and dripping
hot grease.
W Keep all electrical cords away from a hot griddle.
W After a period of storage and/or nonuse, check for leaks, burner
obstructions and inspect for any abrasion, wear or cuts to the hose.
W Failure to open side shelves while igniting the griddle’s burners, or not
waiting 5 minutes to allow the gas to clear if the griddle does not light,
may result in an explosive flame-up.
W Always use a meat thermometer to ensure food is cooked to a safe
temperature.
W Use protective gloves when assembling this product.
W Do NOT force parts together as this can result in personal injury or
damage to the product.
W Never cover entire cooking area with aluminum foil.
W Deaths, serious injury or damage to property may occur if the above is
not followed exactly.
W LP gas cylinder must be properly disconnected and removed prior to
moving this griddle.
W Storage of griddle indoors is permissible only if the cylinder is
disconnected, removed from the griddle and properly stored outdoors.
4
Outdoor LP Gas Griddle
TM
Model No. GGC1643B
Parts List
1
Griddle Surface*
2
Left Side Shelf*
3
Towel Bar (2)*
4
U Burner*
5
Burner (3)*
6
Griddle Body Assembly*
7
Right Side Shelf*
Main Control Knob
8
Bezel (3)*
9
Sear Control Knob Bezel*
10
Brand Plate*
11
Locking Wheel (2)*
12
Left Cart Frame*
55-25-139
55-25-140
55-25-141
55-25-142
55-25-143
55-25-144
55-25-145
55-09-006
55-25-146
55-25-147
55-25-148
55-25-149
Expanded View
24
3
24
1
2
19
6
28
4
5
13
Right Cart Frame*
14
Side Handle (2)
15
Control Knob (4)
16
Grease Cup
Regulator/Hose
17
Assembly*
18
Lighting Hook*
19
Upper LP Gas Tank Support*
20
Leg Locking Assembly*
21
Lower LP Gas Tank Support*
22
Wheel (2)
23
Bottom Shelf
24
Side Shelf Lock A (2)*
25
Side Shelf Lock B (2)*
†
†
55-25-150
55-25-151
55-24-529
55-25-152
55-23-033
55-25-153
†
55-25-155
†
55-25-157
55-25-158
14
26
11
23
12
8
25
10
11
8
9
7
18
16
15
13
14
3
17
22
25
20
26
21
22
27
26
Bottom Shelf Screw (2)
27
Axle
28
LP Gas Tank Heat Shield*
* Pre-assembled
†
Not replaceable
Hardware
A
Screw
55-25-161
55-25-162
55-25-163
M6x16 Nickel Plated Phillips Truss Head
8 pcs
Tools Required for Assembly (Included)
#2 Phillips Head Screwdriver 1 pc
B
Nut
M10 Nickel Plated
2 pcs
M10 Wrench 2 pcs
Recipes
BlueRhino.com/recipes
Assembly Instructions
Need help? 1.800.762.1142
Do not return to place of purchase.
Replacement Parts
parts.BlueRhino.com
1.800.762.1142
5
1
DO NOT RETURN TO PLACE OF PURCHASE.
For assistance, call 1.800.762.1142 toll-free. Please have
your owner’s manual and model number available for
reference.
Note: The model number is printed on a label which can be found on
the botom shelf.
Assembly Tips:
1. Select an area where you will assemble this product. To
protect components, choose a smooth surface that’s free of
cracks or openings.
2. Spread out all parts.
3. Tighten all hardware connections by hand first. Then, before
completing each step, go back and fully tighten all hardware.
Be careful not to over-tighten. That could damage surfaces or
strip threads.
4. For best results, complete each step in the order presented.
To complete assembly you will need:
• (1) Leak detection solution (instructions on how to make the
solution are included in the “Operating Instructions” section of
this manual).
• (1) Precision-filled LP gas grill tank with Acme Type 1 external
threaded valve connection (standard grill size) (not included).
Attach Wheels
2
3
Typical assembly is approximately one hour.
W CAUTION: Two (2) people are required for
assembly.
Unlock and Open Side Shelves
Note: Open right side shelf first.
4
B
Remove Bottom Shelf
x 2
6
TM
Assembly Instructions (continued)
Outdoor LP Gas Griddle
Model No. GGC1643B
5
Close and Lock Side Shelves
Note: Close left side shelf first.
6
Open Legs
W CAUTION: Two (2) people will be required to lay griddle on
back.
Note: Open right leg first.
7
Attach Bottom Shelf
Attach Side Handles and Insert Control Knobs
W CAUTION: Two (2) people will be required to stand griddle
upright.
8
A
x 8
Recipes
BlueRhino.com/recipes
Need help? 1.800.762.1142
Do not return to place of purchase.
Replacement Parts
parts.BlueRhino.com
1.800.762.1142
7
9
Insert Grease Cup
Unlock and Open Side Shelves
Note: Open right side shelf first.
10
8
TM
Transporting & Storage Instructions
Outdoor LP Gas Griddle
Model No. GGC1643B
1
W WARNING: Before transporting or storing this
griddle:
a. Always season griddle per “Seasoning
Griddle” section.
b. Always clean griddle per “Cleaning
Instructions” section.
c. Always wait till griddle is cool.
d. Always turn griddle off per “Turning Off”
section.
e. Always disconnect tank per “Disconnecting
LP Gas Tank” section.
f. Always empty and properly dispose of all
items in grease cup.
W WARNING: When transporting or storing this
Secure LP Gas Tank Supports
2
3
unit, always follow the instructions found in
this section.
W CAUTION: Two (2) people will be required to
prepare for transportation and/or storage.
Close and Lock Side Shelves
Note: Close left side shelf first.
Remove Bottom Shelf
W CAUTION: Two (2) people will be required to lay griddle on
back.
4
Recipes
BlueRhino.com/recipes
Need help? 1.800.762.1142
Do not return to place of purchase.
Replacement Parts
parts.BlueRhino.com
1.800.762.1142
9
5
Attach Bottom Shelf Screws
Close Legs
Note: Close left leg first.
6
7
Unlock and Open Side Shelves
W CAUTION: Two (2) people will be required to stand griddle
upright.
Note: Open right side shelf first.
Place Bottom Shelf
8
10
TM
Transporting & Storage Instructions (continued)
Outdoor LP Gas Griddle
Model No. GGC1643B
9
Close and Lock Side Shelves
Note: Close left side shelf first
Transport or Store your Griddle
10
Loading...