Blue Rhino GBT1860L Owner's Manual
OWNER’S MANUAL
Outdoor Portable LP Gas Griddle
Model No. GBT1860L
WARNING
FOR YOUR SAFETY:
For Outdoor Use Only
(outside any enclosure)
WARNING
FOR YOUR SAFETY:
1. Improper installation, adjustment,
alteration, service or maintenance can
cause injury or property damage.
2. Read the installation, operation, and
maintenance instructions thoroughly
before installing or servicing this
equipment.
3. Failure to follow these instructions could
result in fire or explosion, which could
cause property damage, personal injury, or
death.
4. This instruction manual contains important
information necessary for the proper
assembly and safe use of the appliance.
5. Read and follow all warnings and
instructions before assembling and using
the appliance.
6. Follow all warnings and instructions when
using the appliance.
7. Keep this manual for future reference.
DANGER
If you smell gas -
1. Shut off gas to appliance.
2. Extinguish any open flame.
3. If odor continues, keep away from the
appliance and immediately call your fire
department.
Failure to follow these instructions could result
in fire or explosion which could cause property
damage, personal injury or death.
IMPORTANT
After each use, always season your griddle per “Seasoning
Griddle” section.
Table of Contents
Important Safeguards ...........................................................Page 2
Expanded View & Hardware .......................................................... 4
Assembly Instructions............................................................... 5
Installing LP Gas Tank............................................................... 6
Operating Instructions............................................................... 6
Cleaning and Care ................................................................. 7
Product Registration ................................................................ 8
Replacement Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Limited Warranty .................................................................. 8
Troubleshooting ................................................................... 9
The use and installation must conform with local codes or, in the absence of local codes, with either the
National Fuel Gas Code, ANSI Z223.1/NFPA 54, Storage and Handling of Liquefied Petroleum Gases, ANSI/
NFPA 58, Natural Gas and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code,
B149.2, or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA 1192, and CSA Z240 RV Series, as
applicable.
THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT SAFETY INFORMATION. PLEASE READ AND KEEP
FOR FUTURE REFERENCE.
If you are assembling this unit for someone else, give this manual to them to read and save for future
reference.
¸ WARNING: This product can expose you to chemicals, including carbon monoxide and
soot which are known to the State of California to cause cancer, birth defects, and
other reproductive harm. For more information go to www.P65Warnings.ca.gov.
WARNING
FOR YOUR SAFETY:
1. Do NOT store or use gasoline or other
flammable liquids or vapors in the vicinity
of this or any other appliance.
2. An LP cylinder not connected for use shall
not be stored in the vicinity of this or any
other appliance.
DANGER
Never operate this appliance unattended.
Manufactured in China for: RevoAce Inc. Limited
Hong Kong, China • 1.800.694.0013 • service@revoace.com
© RevoAce Inc. Limited
Blue Rhino
Razor® is a trademark of Blue Rhino Global Sourcing, Inc. Used with permission. GBT1860L-RA-ES-OM-F107
®
is a registered trademark of Ferrellgas, L.P. Used with permission.
Made from 75% Bagasse
(environmentally friendly sugar
cane pulp by-product)
2
Outdoor Portable LP Gas Griddle
Model No. GBT1860L
Important Safeguards - LP Gas
W DANGER: Failure to follow the dangers, warnings and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion
causing damage to property.
W WARNINGS:
W This griddle is for outdoor use only, and should not be used in a
building, garage or any other enclosed area.
W Do NOT operate, light or use this appliance within ten feet (3.05 m) of
walls, structures or buildings.
W For residential use only. This griddle is NOT for commercial use.
W This griddle is not intended for and should never be used as a heater.
TOXIC fumes can accumulate and cause asphyxiation.
W This is NOT a tabletop griddle. Therefore, do NOT operate this griddle on
any type of tabletop surface.
W This griddle is safety certified for use in the United States and/or
Canada only. Do NOT modify for use in any other location. Modification
will result in a safety hazard and will void your warranty.
W This griddle is for use with liquid propane (LP) gas only. The conversion
to or attempted use of natural gas in this LP gas griddle is dangerous,
may cause bodily harm and will void your warranty.
W Your griddle has been checked at all factory connections for leaks.
Recheck all connections as described in the “Operating Instructions”
section of the manual, as shipping can loosen connections.
W Check for leaks even if your unit was assembled for you by someone
else.
W Do NOT operate if a gas leak is present. Gas leaks may cause a fire or
explosion.
W You must follow all instructions in the “Checking for Leaks” section
before operating. To prevent a fire or explosion hazard when testing for
a leak:
a. Always perform a leak test before lighting the griddle and each time
the cylinder is connected for use.
b. No smoking. Do NOT use or permit sources of ignition in the area
while conducting a leak test.
c. Conduct the leak test outdoors in a well-ventilated area.
W Do NOT over heat this griddle as this will damage the griddle and could
cause a fire or an explosion which can cause death, serious bodily
injury or damage to property.
W LP gas characteristics:
a. LP gas is flammable and hazardous if handled improperly. Become
aware of the characteristics before using any LP gas product.
b. LP gas is explosive under pressure, heavier than air, and settles and
pools in low areas.
c. LP gas in its natural state has no odor. For your safety, an odorant is
added that smells like rotten cabbage.
d. Contact with LP gas can cause freeze burns to skin.
W Apartment dwellers: Check with management to learn the requirements
and fire codes for using a LP gas griddle in your apartment complex.
If allowed, use outside on the ground floor with a ten foot (3.05 m)
clearance from any structure. Do NOT use on or under balconies.
W LP gas cylinder needed to operate. Only cylinders marked “propane”
may be used.
W The LP gas cylinder must be constructed and marked in accordance
with the Specifications for LP-gas Cylinders of the U.S. Department
of Transportation (D.O.T.), Cylinders, Spheres and Tubes for the
Transportation of Dangerous Goods; or the National Standard of Canada,
CAN/CSA-B339.
W LP gas cylinder must be arranged for vapor withdrawal.
d. Do NOT use matches, lighters, or a flame to check for leaks.
e. The use of alcohol, prescription or non-prescription drugs may
impair the consumer’s ability to properly assemble or safely operate
the appliance.
f. Strong odors, colds, sinus congestion, etc. may prevent the
detection of propane. Use caution and common sense when testing
for leaks.
g. Do NOT use griddle until any and all leaks are corrected. If you are
unable to stop a leak, disconnect the LP gas supply. Call a gas
appliance serviceman or your local LP gas supplier.
W Do NOT store or use gasoline or other flammable liquids or vapors
within 25 feet (7.62 m) of this appliance.
W Do NOT use in an explosive atmosphere. Keep griddle area clear and
free from combustible materials, gasoline and other flammable vapors
and liquids.
W Minimum clearance from sides and back of unit to combustible
construction is 21 inches (53 cm). Do NOT use this appliance under any
type of overhang or roof.
W It is essential to keep the griddle’s regulator and valve assembly,
burners and circulating air passages clean.
W Inspect griddle before each use.
W Do NOT alter griddle in any manner. Any alteration will void your
warranty.
W Dented or rusted LP gas cylinders may be hazardous and should be
checked by your LP gas supplier prior to use.
W The LP gas cylinder should not be dropped or handled roughly.
W LP gas cylinders must be stored outdoors out of the reach of children
and must not be stored in a building, garage or any other enclosed area.
Your cylinder must never be stored where temperatures can reach over
125°F.
W Do NOT insert any tool or foreign object into the valve outlet or safety
relief valve. You may damage the valve and cause a leak. Leaking
propane may result in an explosion, fire, severe personal injury or death.
W Do NOT block holes in sides, bottom or back of griddle.
W Never keep an LP gas cylinder in a hot car or trunk. Heat will cause the
gas pressure to increase, which may open the relief valve and allow gas
to escape.
W Do NOT store a spare LP gas tank under or within 25 feet (7.62 m) of this
appliance.
W Never attempt to attach this griddle to the self-contained LP gas system
of a camper trailer, motor home or house.
W The use of alcohol, prescription or non-prescription drugs may impair
the consumer’s ability to properly assemble or safely operate the
appliance.
W Strong odors, colds, sinus congestion, etc. may prevent the detection of
propane. Use caution and common sense when testing for leaks.
W NEVER use lighter fluid, lava rocks, gasoline, kerosene or alcohol with
this product.
W Do NOT use the griddle unless it is COMPLETELY assembled and all parts
are securely fastened and tightened.
W This griddle should be thoroughly cleaned and inspected on a regular
basis.
W Clean and inspect the hose before each use of the appliance. If there
is evidence of abrasion, wear, cuts or leaks, the hose must be replaced
prior to operation.
W Use only the pressure regulator provided. Use only the replacement
pressure regulator specified by RevoAce Inc. Limited
W Do NOT attempt to repair or alter the pressure regulator for any
assumed defect. Any modification to this assembly will void your
warranty and create the risk of a gas leak and fire. Use only authorized
replacement parts supplied by manufacturer.
W Use only RevoAce Inc. Limited factory-authorized parts. The use of any
part that is not factory-authorized can be dangerous and will void your
warranty.
W Do NOT operate this appliance without reading “Operating Instructions”
in this manual.
W Do NOT touch metal parts of griddle until they have completely cooled
to avoid burns, unless you are wearing protective gear (pot holders,
gloves, BBQ mitts, etc.).
W Do NOT install or use in or on boats or recreational vehicles (RV).
W Do NOT use griddle in a vehicle trunk, station wagon, mini-van or sport
utility vehicle (SUV).
Need help? Call 1.800.694.0013
Do not return to place of purchase.
W When cooking, fire extinguishing materials should be readily accessible.
In the event of an oil/grease fire, do NOT attempt to extinguish with
water. Use type BC or ABC dry chemical fire extinguisher or smother
with dirt, sand or baking soda.
W Move gas hoses as far away as possible from hot surfaces and dripping
hot grease.
W Do NOT use griddle in high winds.
W Never lean over the griddle when lighting.
W Do NOT leave a lit griddle unattended. Keep children and pets away from
griddle at all times.
W Do NOT leave griddle unattended while preheating or burning off food
residue on high. If griddle has not been cleaned, a grease fire can occur
that may damage the product.
Replacement Parts
1.800.694.0013
3
W Do NOT place empty cooking vessels on the appliance while in
operation.
W Use caution when placing anything on the griddle while the appliance is
in operation.
W Do NOT attempt to move griddle when in use. Allow the griddle to cool
before moving or storing.
W LP gas cylinder must be properly disconnected and removed prior to
moving this griddle.
W Storage of griddle indoors is permissible only if the cylinder is
disconnected, removed from the griddle and properly stored outdoors.
W Do NOT attempt to disconnect the gas regulator from the cylinder or any
gas fitting while the griddle is in use.
W Disconnect LP gas tank when not in use.
W Always place your griddle on a hard, non-combustible, level surface. An
asphalt or blacktop surface may not be acceptable for this purpose.
W Do NOT use directly on wooden decks.
W Keep all electrical cords away from a hot griddle.
W After a period of storage and/or non-use, check for leaks, burner
obstructions and inspect for any abrasion, wear or cuts to the hose.
W Failure to not wait five minutes to allow the gas to clear if the griddle
does not light, may result in an explosive flame-up.
W Never operate griddle without griddle surface installed.
W Always use a meat thermometer to ensure food is cooked to a safe
temperature.
W Use protective gloves when assembling this product.
W Do NOT force parts together as this can result in personal injury or
damage to the product.
W Never cover entire cooking area with aluminum foil.
W Deaths, serious injury or damage to property may occur if the above is
not followed exactly.
4
Outdoor Portable LP Gas Griddle
Model No. GBT1860L
Parts List
1
Griddle Surface*
2
Side Handle (2)
3
Burner*
4
Griddle Body Assembly*
5
Control Knob Bezel*
6
Regulator
7
Grease Cup
8
Control Knob
9
Leg (4)
* Pre-assembled
G1860-010
G1860-020
G1860-030
G1860-040
G1205-200
G1860-050
G1860-060
G0900-080
G1860-070
Expanded View
1
2
3
4
2
5
7
8
6
9
Hardware
A
Screw
M6x15 Nickel Plated Phillips Truss Head
8 pcs
Tools Required for Assembly (Not Included)
#2 Phillips Head Screwdriver 1 pc
Need help? Call 1.800.694.0013
Do not return to place of purchase.
Assembly Instructions
Replacement Parts
1.800.694.0013
5
1
DO NOT RETURN TO PLACE OF PURCHASE.
For assistance, call 1.800.694.0013 toll-free. Please have
your owner’s manual and model number available for
reference.
Note: The model number can be found on the back of the griddle.
Assembly Tips:
1. Select an area where you will assemble this product. To
protect components, choose a smooth surface that’s free of
cracks or openings.
2. Spread out all parts.
3. Tighten all hardware connections by hand first. Then, before
completing each step, go back and fully tighten all hardware.
Be careful not to over-tighten. That could damage surfaces or
strip threads.
4. For best results, complete each step in the order presented.
After assembly you will need:
• (1) Leak Detection Solution (instructions on how to make
solution are included in “Operating Instructions” section).
• (1) 14.1 oz or (1) 16.4 oz LP gas tank (not included).
Attach Legs
2
3
Typical assembly is approximately 30 minutes.
Attach Side Handles
Insert Grease Cup and Control Knob
4
A
x 8
6
1 lb
453 g
7.75 in. / 19,7 cm
3.875 in. / 9,8 cm
2.9 in. / 7,4 cm
1 lb
465 g
10.6 in. / 27 cm
Outdoor Portable LP Gas Griddle
Model No. GBT1860L
Assembly Instructions (continued)
Assembly Instructions (continued)
Attach Regulator
Note: Once attached, the regulator/control valve will freely rotate to accomodate the
LP gas tank.
5
Installing LP Gas Tank
This griddle is designed to operate with a 1 lb. 7.75
in. or 10.6 in. high disposable / 16.4 oz. or 14.1 oz.
propane gas tank (DOT 39 Cylinder) (Figure 1).
DO NOT ATTEMPT TO REFILL ANY 1 lb. (16.4 oz. or
14.1 oz.) PROPANE GAS TANKS!
Connecting LP Gas Tank
Only cylinders marked “propane” may be used.
Note: 1 lb cylinders may form frost when near empty.
1. Make sure the control knob is in the
OFF” position (Figure 3).
“
2. Lubricate the threads of the regulator with
petroleum jelly. Line up threads on LP gas tank
with regulator.
3. Insert and rotate LP gas tank clockwise until
they fit snugly together. HAND TIGHTEN ONLY. Be
careful not to crossthread when screwing in tank
(Figure 4).
4. Perform leak test per “Checking for Leaks”
section.
Figure 1
Figure 2
LP Gas
Valve with
Orifice
IMPORTANT
Before first use and after each use, always
season your griddle per “Seasoning Griddle”
section.
Disconnecting LP Gas Tank
W CAUTION: The LP gas tank must be
removed when this appliance is not in
use.
1. Turn the control knob to the “ OFF” position
(Figure 3).
2. Rotate LP gas tank counterclockwise until it is
detached (Figure 5).
3. Store the LP gas tank in a proper location, per
instructions on the LP gas tank.
Operating Instructions
Checking for Leaks
Burner Connections
1. Make sure the regulator is securely fastened.
Note: The brass nut should be ¼ to ½ turn past
tight. The regulator will rotate 360º even when the
brass nut is tightened.
2. Visually check the connection between the burner
and regulator (Figure 6).
3. Make sure the burner/venturi tube fits over the
orifice (Figure 2).
W WARNING: Failure to inspect this
connection or follow these instructions
could cause a fire or an explosion
which can cause death, serious bodily
injury or damage to property.
4. Please refer to diagram for proper installation
(Figures 2 and 6)
5. If the burner/venturi tube does not rest flush
to the orifice, as shown, please contact
1.800.694.0013 for assistance
6. If the burner and regulator do not fit properly
or if you have any questions, please contact
1.800.694.0013 for assistance.
Burner/
Venturi Tube
Figure 3
OFF
APAGADO
Figure 4
Figure 5
LP Gas
Connection
Tank/Gas Line Connection
1. Make 2-3 oz. of leak detection solution by mixing
one part liquid dishwashing soap with three parts
water.
2. Make sure control knob is in the “
(Figure 3).
3. Apply the leak detection check solution on all “X”
locations (Figure 6).
a. If any bubbles appear, remove the LP
gas tank and reconnect, making sure the
connection is secure.
b. If you continue to see bubbles after several
attempts, remove the LP gas tank per
“Disconnecting LP Gas Tank” section, and
contact 1.800.694.0013 for assistance.
c. If no bubbles appear after one minute, turn
control knob to the “
OFF” position, wipe away solution and proceed.
OFF” position
Figure 6
Loading...