Page 1
1048DD SERIES
GAS DECK OVEN
REPLACEMENT PARTS LIST
SEPTEMBER 12, 2002
BLODGETT OVEN COMPANY, 44 Lakeside Avenue, Burlington, Vermont 05401 USA
Telephone: (802) 860-3700 (800) 331-5842 Fax: (802) 860-3732
www.blodgett.com
Superseding All Previous Parts Lists.
The Company reserves the right to make substitution in the event that items specified are not available.
ERRORS: Descriptive and/or typographic errors are subject to correction.
www.blodgett.com
Page 2
IMPORTANT: When ordering parts, please provide the model, gas type
and serial number of the oven. The identification plate is located on
the inside of the burner compartment door on the right.
þ ASAP Distributor Required Stocking Parts
t Doors Are Not Returnable
* Item Is Too Large For UPS
1048DD
Revised September 12, 2002
BURNER & PIPING ASSEMBLY
Ref. Part
No. No. Description
33900 Steel Tube Burners (Set of 2)
4013 Air Shutter Only
3001 Locknut for Air Shutter
18419 Manifold Assy.
8717 Orifice, Main Burner (Set of 2) (Specify Model
& Gas Type)
19964 Manifold Tube w/ Fittings
10815 Nipple 1/2" x 1-3/4"
31742 Gas Valve, LP
30455 Gas Valve, Nat
R4435 Manual Gas Valve
BURNER COMPARTMENT
COMPONENTS
Ref. Part
No. No. Description
33451 Deflector Assy. (3 Piece)
32742 Deflector, Side Panel (Each)
32743 Deflector, Center Panel
33938 Manifold Shield Assy.
32879 Bar, Deck Support (4 Req'd)
32878 Insulation Kit, Deck
33135 Hot Surface Ignitor & Bracket
33133 Flame Sensing Kit
33850 Burner Divider Assy.
BAKING COMPARTMENT
Ref. Part
No. No. Description
* 33189 Ultra Rokite Deck Assy. (1-1/2" x 24" x 36")
(2 Piece)
32670 Flue Plate, LH
32671 Flue Plate, RH
32895 Baking Door Seal (Crumb Catcher)
32745 Center Panel (Porcelain)
32761 Rear Panel
32679 Trim, Liner Support
32752 Liner Assy., Top Sides
32899 Retainer, Deck Insulation
32512 Steam Pipe Assy.
34333 Kit, Uneven Bake/Burner/Crumb Tray
34097 Diverter
STEAM GENERATOR COMPONENTS
Ref. Part
No. No. Description
þ 33256 Valve, Safety 15#, Generator
þ 33257 Gasket, Element Generator
þ 33258 Valve, Solenoid 120V, 3/8" Generator
þ 33259 Valve, Check Flow
þ 33260 Control, Water Level Generator
þ 33261 Contactor, 120V 50A Generator
þ 33262 Relay, Latching Generator
33305 Element, 9500W 208V Kit (Generator)
33248 Element, 9500W 240V Kit (Generator)
33136 Cord Set, NEMA-15-50P
15183 Strain Relief
33265 Site Glass, Generator
þ 33266 Pressure Control Generator
33267 Pressure Gauge Generator
33268 Ball Valve w/Latch 3/4"
33269 Globe Valve, 3/8"
33272 Ball Valve w/out Latch 1/2"
þ 33273 Sensor, Liquid Level
33274 Relay Base, Latching
33275 Toggle Switch
33276 Indicator Light, Amber 240V
33277 Indicator Light, Red 120V
33278 Manual Reset Switch, Red L.W.
33279 Manual Reset Switch, Black H.P.
32930 Steam Manifold Assy.
29 32893 Solenoid, Steam
21 32900 Condensor, Steam Generator
20 33264 Steam Trap
33271 Strainer, 3/8" Y
33188 Steam Generator Shelf & Bracket Assy.
24 32881 Coupling Socket, Female
25 32976 Ell, Brass Street 3/8
26 32978 Nipple , 3/8 Aluminum 12.375
27 32964 Tee, 3/8 Brass
28 32979 Nipple, 3/8 Aluminum 9.00"
30 32986 Nipple 3/8 Aluminum 4.00"
31 32985 Union, 3/8 Brass
32882 Coupling, Plug Female
33124 Drain Pipe Assy.
33127 Pipe Assy, Blowout
33123 Steam Pipe (Copper)
33248 Steam Generator Conv. Kit (to 240V, 1PH)
33587 Pressure Regulator Kit
Page 3
ELECTRICAL COMPONENTS
EXTERIOR COMPONENTS
Ref. Part
No. No. Description
19 21134 Axial Fan , 115V, 3" (Qty 3)
33029 Cord Set Assy.
32863 Probe, Upper
32901 Probe, Deck
1 32922 Body Assy., Control Box
2 32890 Relay, Solid State
32926 Body Top, Control Box
32929 Control Box Assy. w/ all Components
3 4888 Lug, Grounding
4 3574 Terminal Block 65A, 600V
5 31274 Transformer, 120V/240V
6 19619 Rocker Switch, DPST
7 32889 Control, Solid State Digital w/Steam
FW532 Reconditioned Control, SSD w/Steam
8 30851 Control, Hot Surface Ignitor
12 32510 Decal, Lexan
32959 Harness, Wiring Front
32960 Harness, Wiring Rear
32961 Harness, Wiring Control
32962 Harness, Wiring Control
34749 Phase II, Retrofit Kit
DOOR COMPONENTS
Ref. Part
No. No. Description
Ref. Part
No. No. Description
7840 Draft Diverter, Canopy Venting, S/S
7839 Draft Hood, Direct Venting, S/S (6" Diameter)
32933 Legs w/ Casters (Set of 4)
32887 Access Panel, LH Front
33059 Control Cover Panel
33134 Steam Manifold Assy.
21242 Gas Connector Kit, 48"
11255 Nameplate, Blodgett 12-3/4"
32987 Instruction Decal
33035 Control Spacer, Plastic
33125 Insulation Kit, Steam Pipe
32931 Shelf Assy. Kit
13 32948 Shelf
14 32954 Channel, Shelf RH
15 32953 Channel, Shelf LH
16 32947 Slide, Nylon Top
17 33053 Slide, Nylon Bottom/Front
18 33054 Slide, Nylon Bottom Rear
33190 Flue Box Assy., GZL on 1048DD
33191 Flue Box Assy., FA-100 on 1048DD
The Following Parts Are For Stacking on DFG100
ONLY
19528 Casters, Low Profile (Set of 4)
33022 Flue Connector, DFG100
33027 Flue Plate, Plastic
5878 Spirol Pin
32796 Holder Assy, Spring
19780 Spring 6-1/2"
17623 Bearing, Cylindrical
17624 Bearing, Flanged Door
32883 Door Assy.
33058 Handle Assy.
Shelf
Steam
Generator
Page 4
CONTROL BOX ASSEMBLY
3574 4
31274 5
19619 6
21134
19
4888
3
32890
2
32922
1
30851
8
32889
7
12
32510
XX
33035
Page 5
STEAM GENERATOR AND PIPING
21
32900
XXXXX
23
33125
XX
33258 XX
22
XXXXX
33259 XX
33269
XX
33256
XX
32881
32985 XX
XX
XX
33275
33267XX
29
32893
XX
XX
32976
32964XX
32930
XX
33123
33127 XX
XX
33271
20
33264
33272
33124 XX
XX
XX
33265
XX
33271
XX
33188
33268XX
Page 6
SHELF ASSEMBLY
33054
33054
18
18
32954
14
16
32947
17
33053
13
32948
15
32953
17
33053
BLODGETT OVEN COMPANY, 44 Lakeside Avenue, Burlington, Vermont 05401 USA
Telephone: (802) 860-3700 (800) 331-5842 Fax: (802) 860-3732
A Division of G.S. Blodgett Corporation
16
32947
Loading...