Page 1
•
BETTCHER
Industries, Inc.
MATERIAL SAFETY DATA SHEET 6801 St. Rt. 60
WHIZARD SPECIAL GREASE Birmingham, Ohio 44816
SECTION 1 – PRODUCT IDENTIFICATION
PRODUCT NAME:
WHIZARD SPECIAL GREASE
CHEMICAL NAME:
LUBRICATING GREASE
CHEMICAL FAMILY:
Hydrocarbon
PRODUCT CODES:
100608 –8 oz. Tube 163328 – 14 oz. Case
163329 – 8 oz. Case 100640 – 35 lb. Pail
143631 – 14 oz. Cartridge
EMERGENCY PHONE NUMBERS:
800-321-8763
800-424-9300 (CHEMTREC)
SECTION 2 – INGREDIENTS
COMPONENTS
Calcium 12-Hydroxystearate
USP Mineral Oil
Zinc oxide USP
Triphenyl Phosphorothionate
CAS NUMBER
3159-62-4
8042-47-5
1314-13-2
597-82-0
%W
10-12%
80-90%
4-6%
<1%
CARCINOGEN
No
No
No
No
SECTION 3 – HAZARDS IDENTIFICATION
NFPA HAZARD RATING: NFPA HAZARD RATING CODES:
Health ………………………….. 0 Least ………………………….. 0
Flammability …………………... 1 Slight ………………………….. 1
Reactivity …………………….. 0 Moderate …………………….. 2
High ………………………….... 3
Extreme …………………..…... 4
Specific Hazards: Not Restricted
SECTION 4 – FIRST AID MEASURES
INGESTION:
• Do Not Induce Vomiting
• Get Medical Attention
EYE CONTACT:
• Flush With Plenty of Water For
DERMAL:
• Flush With Soap & Water
Contaminated Clothing-Remove & Launder
INHALATION:
• N/A
At Least 15 Minutes
• Get Medical Attention
SECTION 5 – FIRE FIGHTING MEASURES
FLASH POINT:
• 420°F
FLAMMABLE LIMITS:
• Lower – N/A
EXTINGUISHING MEDIA:
• Water Fog
• Dry Chemical
• Foam
• Earth or Sand
AUTO-IGNITION TEMPERATURE/FIRE POINT:
• 450°F
SPECIAL FIRE FIGHTING PROCEDURES:
• Water May Cause Frothing
UNUSUAL FIRE AND EXPLOSION HAZARDS:
• None
1
ECN 9435 REV. A A173524
Reaffirmed 2/09
Page 2
BETTCHER
Industries, Inc.
MATERIAL SAFETY DATA SHEET 6801 St. Rt. 60
WHIZARD SPECIAL GREASE Birmingham, Ohio 44816
SECTION 6 – ACCIDENTAL RELEASE MEASURES
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED :
• Absorb with Sand or Inert Material
• Sweep or Scoop Up and Remove
PERSONAL PRECAUTIONS :
• Not Applicable
ENVIRONMENTAL PRECAUTIONS :
• Not Applicable
SECTION 7 – HANDLING AND STORAGE
PRECAUTIONARY NOTES :
• Wash Thoroughly After Handling
• Do Not Get in Eyes or On Clothing
• Keep Container Closed
• Keep Away From Sparks and Open Flames
OTHER HANDLING AND STORAGE CONDITIONS :
• None – No Special Conditions
SECTION 8 – EXPOSURE CONTROLS/PERSONAL PROTECTION
PERMISSIBLE EXPOSURE LIMIT:
ACGIH 20 OSHA 2002
5mg/m3 For Mineral Oil
SENSITIZATION:
None
VENTILATION REQUIREMENTS:
(Always maintain exposure below
permissible exposure limits:
• Use With Adequate Ventilation
INHALATION EFFECTS:
None
IRRITATION:
• Skin-Mild (Transient)
• Eye-Mild (Transient)
LUNG EFFECTS:
N/A
HAND (Glove Type) PROTECTION:
• Butyl Rubber
• Neoprene
• Polyethylene
EYE PROTECTION:
• None required
RESPIRATOR TYPE:
• N/A
CORROSITIVITY:
• Not Corrosive
SECTION 9 – PHYSICAL AND CHEMICAL PROPERTIES
BOILING POINT/RANGE:
700°F
SPECIFIC GRAVITY
(H2O=1):
0.89 @ / 16°C
SOLUBILITY IN H2O=1:
Nil
FLAMMABLE LIMITS:
MELTING POINT:
280°F
VAPOR PRESSURE (mm Hg):
NA
% VOLATILES BY
VOLUME :
0
Lower N/A %Upper %
FREEZING POINT:
+10°F
VAPOR DENSITY:
N/A
FLASH POINT:
420°F
EVAPORATION RATE:
N/A
MOLECULAR WEIGHT:
N/A
AUTO-IGNITION TEMP/
FIRE POINT: 450°F
APPEARANCE & ODOR:
White Semi-Solid-Bland
2
ECN 9435 REV. A A173524
Reaffirmed 2/09
Page 3
BETTCHER
Industries, Inc.
MATERIAL SAFETY DATA SHEET 6801 St. Rt. 60
WHIZARD SPECIAL GREASE Birmingham, Ohio 44816
SECTION 10 – STABILITY AND REACTIVITY
STABILITY: Stable CONDITIONS TO AVOID: Open Flame
INCOMPATIBILITY (Avoid Contact With): Strong Oxidizers
HAZARDOUS DECOMPOSITION PRODUCTS (Thermal and Other): CO
and CO2 If Incomplete Combustion
2
SECTION 11 – TOXICOLOGICAL INFORMATION
CONDITIONS TO AVOID: None Known PRIMARY ROUTES OF ENTRY: Skin Contact
This product has been used for years with no known ill effects.
It contains no known carcinogens or mutagens as defined by OSHA or IARC.
This product contains the following toxic chemicals subject to the reporting requirements of Section 313
of the Emergency Planning and Community Right-To-Know Act of 1986 (40 CFR 372)
CAS #
1314-13-2 Zinc Oxide USP 4-6
Chemical Name Percent By Weight
SECTION 12 –ECOLOGICAL INFORMATION
ENVIRONMENTAL EFFECTS – None Known
SECTION 13 –DISPOSAL CONSIDERATIONS
WASTE DISPOSAL METHOD – Consult federal, state, or local authorities for proper disposal procedures :
ALL DISPOSALS MUST COMPLY WITH FEDERAL, STATE AND LOCAL REGULATIONS
SECTION 14 – TRANSPORT INFORMATION
SHIPPING INFORMATION: Not restricted.
SECTION 15 – REGULATORY INFORMATION
This product contains 100% FDA approved ingredients and meets the requirements
as set forth by NSF International as a continuation of the USDA product approval program
and based on the regulatory requirements of FDA 21 CFR for appropriate use, ingredi ent and labeling.
The information and recommendations contained herein are, to the best of Bettcher Industries’ and the manufacturer of this product, accurate
and reliable as of the date issued. Bettcher and the manufacturer shall not be liable for any loss or damage arising out of the use thereof. The
information and recommendations are offered for the user’s consideration and examination, and it is the user’s responsibility to satisfy itself
that they are suitable and complete for its particular use.
PLEASE NOTE: “The above information is accurate to the best of our knowledge. However, since data, safety standards and government
regulations are subject to change and the conditions of handling and use, or misuse are beyond our control, Bettcher Industries, Inc. MAKES
NO WARRANTY, EITHER EXPRESS OR IMPLIED, WITH RESPECT TO THE COMPLETENESS OR CONTINUING ACCURACY OF THE
INFORMATION CONTAINED HEREIN AND DISCLAIMS ALL LIABILITY FOR RELIANCE THEREON. User should satisfy himself that he has
all current data relevant to his particular use.”
3
ECN 9435 REV. A A173524
Reaffirmed 2/09
Loading...