Belkin F5D7010CE1 User Manual

CETECOM Inc.

CETECOM Inc.

411 Dixon Landing Road, Milpitas, CA-95035, USA
Phone: [phone] Fax: [phone]
www.cetecom.com

Issued test report consists of 33 Pages Page 1 (33)

FCC LISTED, REG. NO.: 101450

&

RECOGNIZED BY INDUSTRY CANADA

IC – 3925

Test report no.:

ETSI EN 300 328 V1.4.1 (2002-11)

ETSI EN 300 328-2 V1.2.1 (2001-12)

EMC_381EN328_2002

(BCM94306CB)

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 2 (33)

Table of Contents

1 General information

1.1 Notes

1.2 Testing laboratory

1.3 Details of applicant

1.4 Application details

1.5 Test item

1.6 Test standards

2 Technical test

2.1 Summary of test results

2.2 Test report

1 General information

1.1 Notes

The test results of this test report relate exclusively to the test item specified in 1.5. The CETECOM
Inc. USA does not assume responsibility for any conclusions and generalisations drawn from the test
results with regard to other specimens or samples of the type of the equipment represented by the test
item. The test report may only be reproduced or published in full. Reproduction or publication of
extracts from the report requires the prior written approval of the CETECOM Inc USA.

TEST REPORT PREPARED BY:
EMC Engineer: Harpreet Sidhu

1.2 Testing laboratory
CETECOM Inc.
411 Dixon Landing Road, Milpitas, CA-95035, USA
Phone: [phone] Fax: [phone]
E-mail: [e-mail]
Internet: www.cetecom.com

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 3 (33)

1.3 Details of applicant

Name : Broadcom corporation

Street : 190 Mathilda Place

City / Zip Code : Sunnyvale, 94086

Country : USA

Contact : Chris McGough

Telephone : [phone]

Tele-fax : [phone]

e-mail : [e-mail]

1.4 Application details

Date of receipt of application : 2002-12-16
Date of receipt test item : 2002-11-21
Date of test : 2002-12-06/13 and 2003-01-02

1.5 Test item

Manufacturer : See Applicant
Model No. : BCM94306CB

Description : 54g Wireless Lan cardbus PC card

Additional information
Frequency : 2412MHz – 2472MHz
Type of modulation : DSSS / OFDM (orthognal frequency division multiplexing)
Number of channels : 13
Antenna : 1dBi antenna
Power supply : From Host
Output power : 16.09dBm (40.64mW) max. EIRP
Extreme temp. Tolerance : 0 to +70oC

1.6 Test standards:

Note: All radiated measurements were made in all three orthogonal planes. The values
reported are the maximum values.

ETSI EN 300 328 V1.4.1 (2002-11)
ETSI EN 300 328-2 V1.2.1 (2001-12)

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 4 (33)

2 Technical test

2.1 Summary of test results

No deviations from the technical specification(s) were ascertained in the course of the tests

Performed

Final Verdict:

(only “passed” if all single measurements are “passed”)

Technical responsibility for area of testing:

2003-01-10 EMC & Radio Lothar Schmidt (Manager)

Date Section Name Signature

Responsible for test report and project leader:

Passed

2003-01-10 EMC & Radio Harpreet Sidhu (EMC Engineer)

Date Section Name Signature

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 5 (33)

2.2 Test report

TEST REPORT

Test report no. : EMC_381EN328_2002

(BCM94306CB)

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 6 (33)

TEST REPORT REFERENCE

LIST OF MEASUREMENTS PAGE

EFFECTIVE ISOTROPIC RADIATED POWER CLAUSE 5.2.1 7

PEAK POWER DENSITY CLAUSE 5.2.2 9

FREQUENCY RANGE CLAUSE 5.2.3 13

SPURIOUS EMISSIONS CLAUSE 5.2.4 16

RECEIVER SPURIOUS EMISSIONS CLAUSE 5.3.2 24

TEST EQUIPMENT AND ANCILLARIES USED FOR TESTS 28

PHOTOGRAPHS 29

BLOCK DIAGRAMS 32

Note: The clause numbers are referenced to ETSI EN 300 328 V1.4.1 (2002-11)

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 7 (33)

EFFECTIVE ISOTROPIC RADIATED POWER CLAUSE 5.2.1

EIRP is calculated by method described under sub clause 7.2.1.2, using following formulae;

P = A + G + 10 log (1/x);
Where;
A = Average power (measured)

Freq.(MHz) Average Power measured using wide band Power meter (dBm)

2412 13.9

2442 14.4

2472 14.4

G = Antenna gain = 1dBi (Provided by Broadcom)

x = Duty cycle = 0.945 (measured)

x = Txon / Tx

on

+ Tx

off

Txon 2.08msec

Tx

on

+ Tx

2.2msec

off

x 0.945

10log(1/x) 0.24

Worst case variance (delts) at extreme temperatures from nominal power measured at 23ºC
(Provided by Broadcom)

Freq.(MHz)

Delta in dB @ 0ºC Delta in dB @ +70ºC

2412 +0.01 +0.27

2442 +0.45 +0.29

2472 +0.21 +0.07

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 8 (33)

EFFECTIVE ISOTROPIC RADIATED POWER CLAUSE 5.2.1

TEST CONDITIONS

TRANSMITTER POWER (dBm)

EIRP

T

( 23 )0C V

nom

T

( 0 )0C V

min

T

( +70 )0C V

max

Av – Average power during Burst

nom

nom

nom

(3.3)

(3.3)

(3.3)

Low frequency

2412MHz

Pk

Pk

Pk

15.14

15.15

15.41

Mid frequency

2442MHz

Pk

Pk

Pk

15.64

16.09

15.93

High frequency

2472MHz

Pk

Pk

Pk

15.64

15.85

15.71

LIMITS: CLAUSE 5.2.1

Under all test conditions

≤ 20dBm / -10dBW / 100mW

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 9 (33)

PEAK POWER DENSITY CLAUSE 5.2.2

For DSSS Systems

TEST CONDITIONS

Peak Power Density (dBm/MHz)

T

( 23 )0C V

nom

Under normal test conditions only

(3.3) 8.04 9.35 8.22

nom

Low frequency

2412MHz

Mid frequency

2442MHz

≤-20dBW/MHz (10dBm/MHz)

High frequency

2472MHz

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 10 (33)

PEAK POWER DENSITY CLAUSE 5.2.2

Lowest Channel: 2412MHz

Notes: -51.96 dBm/Hz is added with 60dB to compensate for the dBm/MHz, therefore 8.04dBm/MHz.

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 11 (33)

PEAK POWER DENSITY CLAUSE 5.2.2

Mid Channel: 2442MHz

Notes: -50.57 dBm/Hz is added with 60dB to compensate for the dBm/MHz, therefore 9.35dBm/MHz.

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 12 (33)

PEAK POWER DENSITY CLAUSE 5.2.2

Highest Channel: 2472MHz

Notes: -51.78 dBm/Hz is added with 60dB to compensate for the dBm/MHz, therefore 8.22dBm/MHz.

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 13 (33)

FREQUENCY RANGE CLAUSE 5.2.3

For DSSS Systems

FREQUENCY (MHz)

at which –80dBm/Hz occurs

TEST CONDITIONS

)

High Frequency (fH)

L

2472MHz

T

( 23 )0C V

nom

T

( 0 )0C V

min

T

( +70 )0C V

max

Low Frequency (f

2412 MHz

(3.3)

nom

(3.3) 2404MHz 2480MHz

nom

(3.3) 2402MHz 2482MHz

nom

2403MHz 2481MHz

LIMITS CLAUSE 5.2.3

f

Under all test conditions

> 2400 MHz fH < 2483.5 MHz

L

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 14 (33)

FREQUECY RANGE CLAUSE 5.2.3

Lowest Channel: 2412MHz
Temp.:23 C
Voltage:3.3Vdc

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 15 (33)

FREQUECY RANGE CLAUSE 5.2.3

Highest Channel: 2472MHz
Temp.:23 C
Voltage:3.3Vdc

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 16 (33)

SPURIOUS EMISSIONS CLAUSE 5.2.4
(Radiated)

Transmitter operating

NOTE:

1. Measurements were done on low & high channels, but plots depicting the worst case are submitted in the test report.

2. The spurious emissions were done with different settings, using the relevant pre-amplifiers for the relevant frequency
ranges. This is the reason that the graphs show different noise levels.

Lowest Frequecy Highest Frequecy

f

(MHz)

NF
NF

NF

NF

NF

NF

NF

NF

NF

NF

NF

Band-

width
(kHz)

Level

(dBm)

f

(MHz)

NF

NF

NF

NF

NF

NF

NF

NF

NF

NF

NF

Band-

width
(kHz)

Level

(dBm)

± 6 dB

Wideband spurious emissions

Limit when

operating

-97 dBm/Hz -97 dBm/Hz

Limit when

in standby

Measurement
uncertainty

Note: NF = No Significant Peak was found.

LIMITS Clause 5.2.4

Frequency Range

30 MHz - 1 GHz

above 1 GHz - 12,75 GHz

1,8 - 1,9 GHz

5,15 - 5,3 GhZ

Narrowband spurious

emissions

Limit when

operating

-36 dBm -57 dBm -86 dBm/Hz -107 dBm/Hz

-30 dBm -47 dBm -80 dBm/Hz -97 dBm/Hz

-47 dBm

Limit when

in standby

-47 dBm

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 17 (33)

SPURIOUS EMISSIONS CLAUSE 5.2.4

Transmitter operating @ lowest frequency (2412MHz)

30MHz – 1GHz

Marker: 455.711423 MHz -59.84 dBm

Level [dBm]

0

-20

-40

-60

-80

-100

-110
30M 50M 70M 100M 200M 300M 500M 700M 1G

Frequency [Hz]

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 18 (33)

SPURIOUS EMISSIONS CLAUSE 5.2.4

Transmitter operating @ lowest frequency (2412MHz)

1GHz – 7GHz

Notes: Marked frequency is the carrier @ 2412MHz.

Marker: 2.418837675 GHz -4.23 dBm

Level [dBm]

15

0

-10

-20

-30

-40

-50

-60

-70

-80

1G 2G 3G 4G 5G 6G 7G

Frequency [Hz]

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 19 (33)

SPURIOUS EMISSIONS CLAUSE 5.2.4

Transmitter operating @ lowest frequency (2412MHz)

7GHz – 12.75GHz

Marker: 7.414829659 GHz -46.96 dBm

Level [dBm]

0

-20

-100

-40

-60

-80

7G 8G 9G 10G 11G 12.75G

Frequency [Hz]

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 20 (33)

SPURIOUS EMISSIONS CLAUSE 5.2.4

Transmitter operating @ highest frequency (2472MHz)

30MHz-1GHz

Marker: 397.39479 MHz -60.82 dBm

Level [dBm]

0

-20

-40

-60

-80

-100

-110
30M 50M 70M 100M 200M 300M 500M 700M 1G

Frequency [Hz]

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 21 (33)

SPURIOUS EMISSIONS CLAUSE 5.2.4

Transmitter operating @ highest frequency (2472MHz)

1GHz – 7GHz

Notes: Marked frequency is the carrier @ 2472MHz.

Marker: 2.466933868 GHz -4.16 dBm

Level [dBm]

15

0

-10

-20

-30

-40

-50

-60

-70

-80

1G 2G 3G 4G 5G 6G 7G

Frequency [Hz]

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 22 (33)

SPURIOUS EMISSIONS CLAUSE 5.2.4

Transmitter operating @ highest frequency (2472MHz)

7GHz – 12.75GHz

Marker: 7.414829659 GHz -46.96 dBm

Level [dBm]

0

-20

-40

-60

-80

-100
7G 8G 9G 10G 11G 12.75G

Frequency [Hz]

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 23 (33)

SPURIOUS EMISSIONS CLAUSE 5.2.4
(Radiated)

Transmitter Standby

NOTE: Plots under section Receiver spurious emissions are valid for this section also.

Lowest Frequecy Highest Frequecy

f

(MHz)

Band-

width
(kHz)

Level

(dBm)

f

(MHz)

Band-

width
(kHz)

Level

(dBm)

Measurement
uncertainty

LIMITS Clause 5.2.4

Frequency Range

30 MHz - 1 GHz

above 1 GHz - 12,75 GHz

1,8 - 1,9 GHz

5,15 - 5,3 GhZ

± 6 dB

Narrowband spurious

emissions

Limit when

operating

-36 dBm -57 dBm -86 dBm/Hz -107 dBm/Hz

-30 dBm -47 dBm -80 dBm/Hz -97 dBm/Hz

-47 dBm

Limit when

in standby

-47 dBm

Wideband spurious emissions

Limit when

operating

-97 dBm/Hz -97 dBm/Hz

Limit when

in standby

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 24 (33)

RECEIVER SPURIOUS EMISSIONS CLAUSE 5.3.2
(Radiated)

NOTE:

1. Measurements were done on low & high channels, but plots depicting the worst case are submitted in the test report.

2. The receiver spurious emissions were done with different settings, using the relevant pre-amplifiers for the relevant
frequency ranges. This is the reason that the graphs show different noise levels.

Lowest Frequecy Highest Frequecy

f

(MHz)

455.7 100 -5878

Band-

width
(kHz)

Level

(dBm)

f

(MHz)

Band-

width
(kHz)

Level

(dBm)

399.3 100 -59.47

333.2

325.4

292.4

197.1

133.0

603.4

665.7

Measurement
uncertainty

LIMITS Clause 5.3.2

Frequency range Narrowband spurious

30 MHz - 1 GHz -57 dBm -107 dBm/Hz

above 1 GHz – 12.75 GHz -47 dBm -97 dBm/Hz

100

100

100

100

100

100

100

-62.08-

-67.83

-70.30

-67.99

-66.19

-64.15

-67.88

± 6 dB

emission

Wideband spurious emission

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 25 (33)

RECEIVER SPURIOUS EMISSIONS CLAUSE 5.3.2
30MHz – 1GHz

Marker: 133.026052 MHz -66.19 dBm

Level [dBm]

-30

-40

-50

-60

-70

-80

-90

-100

-110
30M 50M 70M 100M 200M 300M 500M 700M 1G

Frequency [Hz]

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 26 (33)

RECEIVER SPURIOUS EMISSIONS CLAUSE 5.3.2
1GHz – 7GHz

Marker: 1.276553106 GHz -66.44 dBm

Level [dBm]

0

-20

-100

-40

-60

-80

1G 2G 3G 4G 5G 6G 7G

Frequency [Hz]

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 27 (33)

RECEIVER SPURIOUS EMISSIONS CLAUSE 5.3.2
7GHz – 12.75GHz

Marker: 9.051102204 GHz -61.15 dBm

Level [dBm]

0

-20

-40

-100

-120

-140

-60

-80

7G 8G 9G 10G 11G 12.75G

Frequency [Hz]

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 28 (33)

TEST EQUIPMENT AND ANCILLARIES USED FOR TESTS

No Instrument/Ancillary Type Manufacturer Serial No.

01
02
03
04
05
06
07
08
09

Spectrum Analyzer ESIB 40 Rohde & Schwarz 100107
Spectrum Analyzer FSEM 30 Rohde & Schwarz 826880/010
Signal Generator SMY02 Rohde & Schwarz 836878/011
Power-Meter EPM-442A Hewlett Packard GB37170232
Power Amlifier 250W1000 Amplifier Research 300031
Biconilog Antenna 3141 EMCO 0005-1186
Horn Antenna SAS-200/571 AH Systems 325
Power Splitter 11667B Hewlett Packard 645348
Pre-Amplifier JS4-00102600 Miteq 00616

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 29 (33)

PHOTOGRAPHS

Radiated Measurement Setup

Conducted Measurement

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 30 (33)

EUT (Top - shielded)

EUT (Bottom - shielded)

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 31 (33)

EUT (Top – unshielded)

EUT (Bottom – unshielded)

CETECOM Inc.

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 32 (33)

BLOCK DIAGRAMS
Conducted Testing

EUT

SPECTRUM
ANALYZER

POWER
METER

CETECOM Inc.

R

Test report no.:EMC_381EN328-2002 Issue date:2003-01-10 Page 33 (33)

Radiated Testing

ANECHOIC CHAMBE

EUT Antenna

Turn Table

Measurement Antenna

Spectrum Analyzer