Baumatic B45 User Manual

B45 Circular 52 cm
frameless ceramic hob

1

ELECTRIC HOBS

AS6.2-B13-B14-BH14-B15-

BF15-B16-BF16-B45

LIB30045

1

Contents

User Instructions and Installation information.

Page.

3. Important Safety Notes

4. General Information
5 – 7 Appliance Description
8 – 10 Instructions For Use

11. Helpful Hints

12. Cleaning and Maintenance

13. Trouble Shooting Guide
14 – 15 Installation Instructions

16. Electrical Connection

17. Technical Data

18. Conditions of Guarantee

RATING PLATE

The appliance rating plate is located on the underside of the hob, once the appliance is
fitted into its housing then the rating plate is no longer visible. For future reference
please write the rating plate information in the box below.

Model Number ……………………………….

Serial Number ……………………………….

Date of Purchase ……………………………….

Supplier ……………………………….

2

! Important safety notes.

We have included this safety information for the purpose of your safety. Please read this information
carefully before installing your hob. Should you be unsure of any of these notes please contact the
Baumatic Ltd Technical department.

Baumatic Ltd Technical Department Tel: [phone]

Installation

¾ It is important that this appliance is installed by a qualified / competent person, such as one

holding NICEIC registration and that the appliance is installed in accordance with the latest
edition of the IEE WIRING regulations and the manufactures installation instructions. Before
connecting the appliance to the electricity supply, make sure that the supply voltage on the
rating plate corresponds with the mains supply voltage.

¾ Do not install the appliance if the ceramic glass top is damaged in any way.
¾ Do not modify the appliance in any way, this will void your warranty and possibly render the

appliance dangerous.

¾ Ensure that all packaging is removed before installing or using the appliance.

Use of the hob

¾ Do not use the appliance until the installation is complete.
¾ Ensure that the appliance is switched OFF when not in use.
¾ Never leave the hob unattended when in use, particularly when cooking with oil and fat.
¾ Always use pans that are suited to the heating zone being used, never use pans that are

unstable or defective in any way.

¾ Never use plastic or aluminium foil dishes on the appliance.
¾ This appliance has been manufactured for domestic use only and is therefore not suitable for

use in a commercial or industrial environment.

¾ Only turn the cooking zones ON when a saucepan is on the cooking zone.
¾ Never store flammable materials such as aerosols and detergents in draws or cupboards under

the hob.

¾ Do not drop saucepans or cooking utensils onto the ceramic cooking surface.
¾ Never use the ceramic cooking surface as a storage or worktop area.
¾ Do not use the appliance if the ceramic surface is accidentally damaged, call the Baumatic

service department, as the ceramic glass will need to be replaced.

¾ Only clean the hob in accordance with the cleaning and maintenance instructions.
¾ Never allow sugar or acidic foodstuffs to be spilled onto the ceramic cooking surface as it eats

into the glass and is impossible to remove.

¾ Do not use the appliance as a space heater or to dry clothes.
¾ Do not install this appliance next to soft furnishings or curtains.

Child Care

¾ Never allow children to play near or with the appliance. This appliance is designed to be used

by adults.

¾ The hob gets hot when in use and children should be kept well during use.
¾ Cooking pots and pans should be kept out of reach of children when in use to avoid injury.

Servicing

¾ This appliance should only be repaired or serviced by a Baumatic Ltd Technician or one of

there authorised service agents

Environment

¾ Please dispose of all waste packing materials and old appliances at an authorised disposal site

giving due regard for the environment. (Advice on such issues is available from your local
authority).

3

General Information

Please read this booklet thoroughly before you use this appliance. It is important that you
understand all the control functions before commencing to cook with your Baumatic
appliance. The information and warnings contained in this booklet are designed to assist you
in obtaining the best use of your new Baumatic appliance.

This appliance complies with all current European safety legislation, however Baumatic Ltd wish to
emphasise that compliance does not remove the fact that surfaces will become hot during use and retain
heat after operation.

Baumatic Ltd declines any responsibility for injury or damage to persons or property as a result
of improper use or installation of this appliance.

Heat, steam and moisture will be created during use, take care to avoid injury and ensure that
the room is adequately ventilated. If prolonged use occurs, additional ventilation may be
required. Please consult your Qualified Installer if you are in any doubt about the amount
required.

NOTE: The appliance housing, adjacent furniture and all materials used in the installation must be able
to withstand a minimum temperature rise of 85°C above ambient during periods of operation. This
information is for guidance only and the actual withstand temperature will depend on the
performance rating for the surface finish of the worktop. Certain types of kitchen furniture surface
finishes are particularly prone to heat damage or discoloration at temperatures lower than the above
guidelines. Installing the appliance in contravention of the guidance given will be at the liability of the
owner. The use for any other purpose or in any other environment without the express agreement of
Baumatic Ltd, would invalidate any warrantee or liability claim.

Your new appliance is guaranteed against electrical or mechanical defects subject to certain
exclusions noted in Baumatic Ltd Conditions of Guarantee.

The aforegoing does not affect your statutory rights. The Warrantee applies to Great Britain and
Northern Ireland only.

In the event that you require any After Sales Service or repairs, please contact the Baumatic
Service Department on telephone number – 0118 933 6911.

When first used, an odor may be emitted by any residual protective finish or moisture, which
will cease after a short period of time.

This appliance has been constructed and distributed in compliance with the essential requirements of
the following EEC DIRECTIVES and EUROPEAN NORMS:

CE Marking – 93/68 Low Voltage – 73/23 EMC – 89/336
Materials that can touch food – 89/109.
Safety Standards – EN 60 335-1, EN 60 335 – 2 – 6.

This appliance is marked according to the European directive 20002/96/EC on waste Electrical
and electronic Equipment (WEEE). This guideline is the frame of a europeanwide validity of
return and recycling on Waste electrical and electronic Equipment

As Baumatic have a policy of continued product improvement, the right is reserved to adjust and make
any modifications deemed necessary without notification.

4

Appliance Description

The following models are covered by this installation and instruction for use manual:

B13 / B14SS/BH14SS B15SS BF15SS / AS6.2SS

1

2

1

2 3

2

3

11 1

4

B16SS BF16SS

1

5

4

2

3

1

1

3

B45

Zone identification. Power and Diameter

2

1

33

4

6

4

1

2

5

2

2

5

MODEL 1 2 3 4 5 6
AS6.2SS 1.20kW – 140mm 1.20kW – 140mm 0.70kW – 120mm 1.70kW – 180mm 1.80kW – 180mm
B13 1.20kW – 140mm 1.80kW – 180mm
B14SS 1.20kW – 140mm 1.80kW – 180mm
BH14SS 1.20kW – 140mm 1.80kW – 180mm
B15SS 1.20kW – 140mm 1.80kW – 180mm 0.75kW - 120mm 2.20kW – 210mm
BF15SS 1.20kW – 140mm 1.80kW – 180mm 0.75kW – 120mm 2.20kW – 210mm
B16SS 1.20kW – 140mm 1.10kW – 140mm 2.00kW – 250mm 0.75kW – 120mm 2.20kW – 210mm
BF16SS 1.10kW – 140mm 1.80kW – 180mm 0.75kW – 120mm 2.20kW – 210mm 1.10kW – 140mm 2.00kW-240mm
B45 0.70kW – 120mm 1.70kW – 180mm 1.20kW – 140mm

All the models covered in this manual have individual residual heat indicators.

Voltage 230 V ac 50Hz
Total electrical connected load AS6.2 – 6.6kW B13/B14 - 6.0 kW B15/BF15 – 6.4kW
B16/BF16 – 7.2kW B45 – 4.8kW
Supply connection must be via a switched double-pole isolator with 3mm contact
separation.
Mains supply connection cable: 3 x 2.5mm2 type H05 RR-F <HAR> marked

Unpacking the appliance.

When unpacking the appliance please check that the following items are contained within the
packaging:

1 Baumatic hob
1 Ceramic hob scraper
1 Installation / Instruction manual
1 Baumatic guarantee card
4 Fixing brackets
4 Fixing screws
4 Spring clips
1 Sealing strip

Before using your hob for the first time.

We recommend that before using your new appliance for the first time that you clean the hob surface
using hot soapy water (do not use any abrasive cleaners) this will remove any remnants that have
been left behind during the manufacturing process. Ensure that any labels and protective films are also
removed.

Check each cooking zone individually in turn, by turning each zone to the maximum setting, The first
time the appliance is switched on it may emit an odor this will only last for a short period and will
disappear with use.

Do not install this product if there are obvious signs of transportation damage, in such rare cases
please refer this to your supplier.

6

BH14

7