|
|
® |
BX-Line |
||||||
|
|
|
|
||||||
|
|
|
|
|
Condensing Units |
||||
PRODUCT DATA & |
|||||||||
|
|
|
|
||||||
|
|
|
|
||||||
|
|
|
|
||||||
|
|
Indoor Water Cooled |
|||||||
|
|
||||||||
SPECIFICATIONS |
|
|
|||||||
|
|
Coaxial Semi-Hermetic & |
|||||||
Bulletin B40-BX-PDS-50-1 |
|
|
Hermetic Condensing Units |
||||||
|
|
||||||||
1082041-50
1/2 to 5 HP
High, Medium and Low Temperature Refrigeration
CONTENTS
|
Page |
Nomenclature........................................................................................................................ |
2 |
Features & Options.............................................................................................................. |
2, 3 |
Capacity Data...................................................................................................................... |
4 - 8 |
Hermetic Units ............................................................................................................. |
4, 6 |
Semi-Hermetic Units .................................................................................................. |
7 - 8 |
Electrical Data..................................................................................................................... |
9 - 12 |
Hermetic Units ............................................................................................................. |
9, 10 |
Semi-Hermetic Units ................................................................................................... |
11, 12 |
Dimensional Data................................................................................................................ |
13 |
Specifications...................................................................................................................... |
14, 15 |
Wiring Diagram................................................................................................................... |
16-18 |
Project Information.............................................................................................................. |
BACK |
NOMENCLATURE
|
|
|
|
|
|
|
B X H A |
050 L 6 - I T3 A |
|||||||||||||||||||||||||||||||||
B = Bally |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Design version |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
A = 1st Generation |
Product Family |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Voltage * |
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||
X = Coaxial water cooled |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||||||||
condensing unit line |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
S2 = 208/230-1-60 |
||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
S3 =230/1/60 |
|||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Type of Compressor |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
S6 = 200/220-1-50 |
||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
S7 = 200/1/50 |
||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||||||
H = Hermetic |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
T3 = 208-230/3/60 |
||||||||||||||||||
S = Semi hermetic |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
T4 = 460/3/60 |
|||||||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Compressor Manufacturer |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
T5 = 575/3/60 |
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
T7 = 200-220/3/50 |
||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||||
A - Copeland |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
T9 = 380-400/3/50 |
||||||||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Nominal HP |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
* Subject to compressor |
|||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||||
050 = 5 HP |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
availability |
|||||||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||||||||||||
Application |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
I = Indoor |
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||
H = High and Med Temp |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||||||||||||||
M = Med Temp |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Refrigerant |
|||||||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||||||||||||||||
E = Extended Medium Temperature |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
2 = R22 |
|||||||||||||||||||
L = Low Temp |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
6 = R404A / R507* , |
|||||||||||||||||||
BXH HERMETIC CO-AXIAL
WATER COOLED CONDENSING UNIT
STANDARD FEATURES
•Weatherproof electrical control box with compressor contactor and fused control circuit
•Pre-formed piping
•Welded hermetic compressor
•Base valve on suction line (BXH)
•Copper tubing secured with cushion clamps
•Co-Axial condenser
•Receiver with fusible plug and liquid shut off valve
•Adjustable dual high / low pressure control
•Each Unit subjected to a thorough leak test with Helium leak-detectors
•Units are shipped with Helium holding charge
FACTORY MOUNTED OPTIONAL FEATURES
•Sealed suction filter
•Suction accumulator
•Suction accumulator with boil-out coil
•Sealed liquid line filter drier and sight glass
•Liquid line solenoid valve with 230 volt coil (shipped loose)
•Compressor circuit breaker
•Compressor time delay relay
•Pump down toggle switch
•Electric defrost kit with electronic or mechanical time clock and contactors, as required
•Lockout control circuit (for liquid solenoid valve)
•Disconnect switch (fused or non-fused)
•3 Lead electronic phase / voltage monitor
•Water reg valve (shipped loose)
- 2 -
BXS SEMI-HERMETIC CO-AXIAL WATER COOLED CONDENSING UNIT STANDARD FEATURES
•Weatherproof electrical control box with compressor contactor and fused control circuit
•Pre-formed piping
•Solid mounted accessible semi-hermetic compressor up to 2 HP models
•Spring mounted accessible semi-hermetic compressor with suction and discharge vibration eliminator on 3HP and over models
•Suction service valve.
•Copper tubing secured with cushion clamps
•Co-Axial condenser
•Receiver with fusible plug and liquid shut off valve
•Adjustable dual high / low pressure control
•Each Unit subjected to a thorough leak test with Helium leak-detectors
•Units are shipped with Helium holding charge
FACTORY MOUNTED OPTIONAL FEATURES
•Spring mounted accessible compressor with suction and discharge vibration eliminator on up to 2 HP
•Suction accumulator
•Suction accumulator with boil-out coil
•Discharge line check valve
•Oil separator
•Oil separator c/w oil return filter & solenoid valve
•Receiver inlet ball valve
•Over-sized receiver
•Sealed liquid line filter drier & sight glass
•Ball valve – liquid line (shipped loose) Insulated suction lines
•Flex hoses – for all pressure controls
•Liquid line solenoid valve (with standard 230 volt coil) – shipped loose
•Compressor circuit breaker
•Current sensing relay – for use with oil safety control (where applicable)
•Defrost heater contactor c/w fuse block
•Evaporator fan contactor c/w fuse block
•Disconnect switch
•Disconnect fusing
•Pump down toggle switch
•Lock out control circuit – Liquid solenoid valve with separate HP and LP controls
•Time delay relay for compressor
•Mechanical time clock
•Electronic time clock
•Electronic defrost kit
•Electronic voltage/phase monitor
•Water reg valve (shipped loose)
- 3 -
H
HERMETIC
CAPACITY DATA - R22 |
50Hz |
HIGH/MEDIUM TEMPERATURE |
UNIT |
COMPRESSOR |
|
|
|
SATURATED SUCTION TEMPERATURE ° C |
|
|
||
MODEL |
MODEL |
|
|
|
|
|
|
|
|
|
-17.8 |
-12.2 |
-6.7 |
-3.9 |
-1.1 |
4.4 |
7.2 |
||
|
|
|
|||||||
|
|
WATTS |
770 |
1011 |
1289 |
1456 |
1640 |
2097 |
2372 |
BXHA005H2 |
ART82C1 |
L/HR |
2.2 |
2.7 |
3.5 |
4.0 |
4.8 |
7.1 |
8.8 |
|
|
kPa |
1.9 |
2.6 |
3.8 |
4.8 |
6.3 |
11.7 |
16.6 |
|
|
WATTS |
1078 |
1421 |
1839 |
2074 |
2337 |
2929 |
3280 |
BXHA008H2 |
RS64C2 |
L/HR |
4.3 |
4.4 |
5.0 |
5.5 |
6.2 |
8.3 |
9.8 |
|
|
kPa |
6.6 |
7.1 |
8.7 |
10.1 |
12.1 |
19.1 |
24.9 |
|
|
WATTS |
1019 |
1514 |
2071 |
2378 |
2709 |
3456 |
3866 |
BXHA010H2 |
RS70C1 |
L/HR |
4.3 |
4.4 |
5.2 |
6.0 |
6.9 |
9.9 |
12.0 |
|
|
kPa |
6.7 |
7.0 |
9.2 |
11.3 |
14.3 |
25.2 |
34.4 |
|
|
WATTS |
899 |
1784 |
2686 |
3163 |
3661 |
4774 |
5360 |
BXHA015H2 |
CR18KQ |
L/HR |
5.7 |
5.3 |
6.7 |
8.0 |
9.9 |
15.2 |
19.0 |
|
|
kPa |
2.7 |
2.4 |
3.7 |
5.2 |
7.4 |
15.7 |
23.1 |
|
|
WATTS |
1936 |
2686 |
3632 |
4188 |
4774 |
6092 |
6795 |
BXHA020H2 |
CR24KQ |
L/HR |
3.5 |
5.2 |
8.2 |
10.4 |
13.1 |
20.6 |
25.4 |
|
|
kPa |
2.9 |
3.9 |
6.4 |
8.9 |
12.7 |
27.1 |
39.7 |
|
|
WATTS |
2613 |
3749 |
4950 |
5653 |
6356 |
7967 |
8875 |
BXHA025H2 |
CR32KQ |
L/HR |
5.1 |
7.5 |
12.1 |
15.4 |
19.6 |
31.3 |
39.3 |
|
|
kPa |
3.4 |
5.7 |
11.3 |
16.4 |
23.8 |
51.2 |
75.5 |
|
|
WATTS |
2988 |
4276 |
5741 |
6561 |
7410 |
9314 |
10339 |
BXHA030H2 |
CR37KQ |
L/HR |
16.5 |
12.4 |
11.9 |
13.4 |
16.2 |
26.7 |
34.8 |
|
|
kPa |
11.8 |
6.9 |
6.4 |
8.0 |
11.5 |
27.3 |
42.6 |
|
|
WATTS |
3456 |
4774 |
6385 |
7293 |
8260 |
10427 |
11628 |
BXHA035H2 |
CR41KQ |
L/HR |
14.3 |
11.7 |
13.3 |
16.2 |
20.9 |
37.0 |
49.1 |
|
|
kPa |
9.1 |
6.1 |
7.9 |
11.5 |
18.0 |
47.2 |
76.4 |
|
|
WATTS |
4481 |
6297 |
8289 |
9431 |
10662 |
13532 |
15202 |
BXHA040H2 |
CR53KQ |
L/HR |
33.0 |
26.3 |
25.2 |
27.2 |
31.3 |
48.8 |
64.1 |
|
|
kPa |
26.2 |
18.3 |
17.2 |
19.2 |
24.1 |
52.4 |
87.8 |
|
|
WATTS |
5272 |
7498 |
9900 |
11189 |
12595 |
15758 |
17545 |
BXHA050H2 |
CRN5-0500 |
L/HR |
14.5 |
17.4 |
24.0 |
29.0 |
35.4 |
53.2 |
65.4 |
|
|
kPa |
4.7 |
6.5 |
11.3 |
15.6 |
22.1 |
45.5 |
66.1 |
Capacity rating conditions: 29.4 °C entering water, 37.8 °C condensing, -17.8 °C subcooling
- 4 -
H
HERMETIC
CAPACITY DATA - R404A |
50Hz |
EXTENDED MEDIUM TEMPERATURE |
UNIT |
COMPRESSOR |
|
|
|
SATURATED SUCTION TEMPERATURE ° C |
|
|
|||
MODEL |
MODEL |
|
|
|
|
|
|
|
|
|
|
-32.1 |
-28.9 |
-23.3 |
-17.8 |
-12.2 |
-6.7 |
-3.9 |
-1.1 |
||
|
|
|
||||||||
|
|
WATTS |
305 |
381 |
554 |
764 |
1008 |
1289 |
1444 |
1608 |
BXHA006E6 |
RS43C2E |
L/HR |
2.0 |
2.0 |
2.2 |
2.6 |
3.5 |
4.9 |
5.9 |
7.0 |
|
|
kPa |
1.6 |
1.6 |
1.8 |
2.5 |
3.9 |
6.6 |
8.7 |
11.6 |
|
|
WATTS |
390 |
483 |
709 |
975 |
1298 |
1675 |
1883 |
2112 |
BXHA008E6 |
RS55C2E |
L/HR |
4.9 |
4.7 |
4.3 |
4.3 |
4.6 |
5.5 |
6.2 |
7.2 |
|
|
kPa |
8.2 |
7.6 |
6.8 |
6.7 |
7.6 |
10.0 |
12.1 |
15.0 |
|
|
WATTS |
489 |
609 |
876 |
1175 |
1517 |
1907 |
2121 |
2355 |
BXHA009E6 |
RS64C2E |
L/HR |
4.5 |
4.3 |
4.3 |
4.6 |
5.3 |
6.7 |
7.7 |
9.0 |
|
|
kPa |
7.2 |
6.8 |
6.7 |
7.4 |
9.5 |
13.7 |
17.0 |
21.5 |
|
|
WATTS |
384 |
565 |
905 |
1251 |
1634 |
2103 |
2378 |
2686 |
BXHA010E6 |
RS70C1E |
L/HR |
4.9 |
4.5 |
4.3 |
4.5 |
5.4 |
7.2 |
8.5 |
10.3 |
|
|
kPa |
8.2 |
7.3 |
6.6 |
7.3 |
9.7 |
15.0 |
19.7 |
26.9 |
|
|
WATTS |
480 |
662 |
1119 |
1693 |
2370 |
3163 |
3573 |
3983 |
BXHA015E6 |
CS10K6E |
L/HR |
2.6 |
2.5 |
2.8 |
3.9 |
6.1 |
9.5 |
11.7 |
14.2 |
|
|
kPa |
2.5 |
2.5 |
2.6 |
3.1 |
4.5 |
7.8 |
10.5 |
14.4 |
|
|
WATTS |
639 |
855 |
1385 |
2036 |
2806 |
3691 |
4188 |
4686 |
BXHA020E6 |
CS12K6E |
L/HR |
2.5 |
2.6 |
3.3 |
5.1 |
8.2 |
13.1 |
16.2 |
19.9 |
|
|
kPa |
2.5 |
2.5 |
2.8 |
3.8 |
6.5 |
12.6 |
18.0 |
25.5 |
|
|
WATTS |
923 |
1160 |
1749 |
2466 |
3310 |
4276 |
4774 |
5331 |
BXHA025E6 |
CS14K6E |
L/HR |
5.1 |
4.8 |
4.8 |
6.0 |
9.0 |
14.1 |
17.5 |
21.6 |
|
|
kPa |
3.4 |
3.1 |
3.1 |
4.2 |
7.4 |
14.3 |
20.0 |
27.7 |
|
|
WATTS |
1107 |
1365 |
2106 |
3105 |
4276 |
5594 |
6268 |
6971 |
BXHA030E6 |
CS18K6E |
L/HR |
26.2 |
23.5 |
17.6 |
13.0 |
11.7 |
14.8 |
18.1 |
22.4 |
|
|
kPa |
26.3 |
21.9 |
13.3 |
7.6 |
6.1 |
9.7 |
14.0 |
20.3 |
|
|
WATTS |
1119 |
1567 |
2466 |
3456 |
4686 |
6239 |
7205 |
8289 |
BXHA035E6 |
CS20K6E |
L/HR |
25.4 |
21.1 |
15.1 |
11.9 |
12.4 |
19.2 |
26.4 |
37.6 |
|
|
kPa |
25.1 |
18.3 |
10.1 |
6.4 |
6.9 |
15.5 |
26.8 |
48.6 |
|
|
WATTS |
1687 |
2103 |
3134 |
4423 |
6004 |
7967 |
9051 |
10252 |
BXHA040E6 |
CS27K3E |
L/HR |
49.0 |
44.3 |
34.9 |
27.5 |
24.9 |
30.1 |
36.6 |
46.2 |
|
|
kPa |
52.7 |
43.8 |
28.8 |
19.6 |
16.9 |
22.6 |
31.2 |
47.4 |
|
|
WATTS |
2039 |
2636 |
3925 |
5507 |
7410 |
9666 |
10984 |
12390 |
BXHA050E6 |
CS33K3E |
L/HR |
18.2 |
17.3 |
16.8 |
18.2 |
22.6 |
31.3 |
37.7 |
45.8 |
|
|
kPa |
3.0 |
2.5 |
2.2 |
3.0 |
5.7 |
11.6 |
16.7 |
23.9 |
Capacity rating conditions: 29.4 °C entering water, 37.8 °C condensing, -17.8 °C subcooling
- 5 -
H
HERMETIC
CAPACITY DATA |
50Hz |
R404A - LOW TEMPERATURE |
UNIT |
COMPRESSOR |
|
|
|
SATURATED SUCTION TEMPERATURE ° C |
|
|
|||
MODEL |
MODEL |
|
|
|
|
|
|
|
|
|
|
-34.4 |
-28.9 |
|
-23.3 |
-17.8 |
|
-12.2 |
-9.4 |
||
|
|
|
|
|
||||||
|
|
WATTS |
|
463 |
|
618 |
811 |
|
1078 |
1245 |
BXHA006L6 |
AFT22C1E |
L/HR |
N/A |
2.6 |
|
2.7 |
3.5 |
|
5.3 |
6.9 |
|
|
kPa |
|
2.5 |
|
2.6 |
3.1 |
|
5.4 |
8.6 |
|
|
WATTS |
|
580 |
|
785 |
1052 |
|
1400 |
1605 |
BXHA008L6 |
AFT26C1E |
L/HR |
N/A |
2.7 |
|
3.4 |
5.2 |
|
9.1 |
12.3 |
|
|
kPa |
|
2.6 |
|
3.1 |
5.3 |
|
14.8 |
27.5 |
|
|
WATTS |
507 |
873 |
|
1298 |
1854 |
|
2613 |
|
BXHA010L6 |
CF04K6E |
L/HR |
2.1 |
2.7 |
|
4.3 |
7.4 |
|
13.3 |
N/A |
|
|
kPa |
1.7 |
2.6 |
|
5.3 |
12.6 |
|
33.2 |
|
|
|
WATTS |
893 |
1397 |
|
2033 |
2783 |
|
3632 |
|
BXHA020L6 |
CF06K6E |
L/HR |
4.3 |
4.6 |
|
6.3 |
9.8 |
|
15.4 |
N/A |
|
|
kPa |
6.6 |
7.5 |
|
12.2 |
24.9 |
|
52.5 |
|
|
|
WATTS |
1421 |
2150 |
|
3017 |
4071 |
|
5272 |
|
BXHA025L6 |
CF09K6E |
L/HR |
5.3 |
6.8 |
|
10.7 |
17.6 |
|
28.4 |
N/A |
|
|
kPa |
2.4 |
3.9 |
|
8.5 |
20.2 |
|
47.2 |
|
|
|
WATTS |
1916 |
2856 |
|
3896 |
5155 |
|
6678 |
|
BXHA030L6 |
CF12K6E |
L/HR |
4.6 |
8.3 |
|
14.3 |
23.7 |
|
37.9 |
N/A |
|
|
kPa |
3.5 |
6.5 |
|
14.6 |
34.9 |
|
83.7 |
|
Capacity rating conditions: 29.4 °C entering water, 37.8 °C condensing, -17.8 °C subcooling
- 6 -
Loading...