Avtec VDV User Manual
Exhaust Only V-Bank Island Canopy
for Light and Medium
Duty Cooking Equipment
CHINOOK Value Ventilation Exhaust Only Filter model VDV
Description:
This is a V-bank exhaust only single Island style
canopy.
This V-Bank island style canopy is best suited for use
over a single bank of cooking equipment. This hood
is recommended for use over light and medium duty
cooking appliances.
Specifications:
A single shell exhaust only Type I island canopy. The hood(s) shall be UL 710 Listed without (with) re damper for 400 or 600
degree Fahrenheit rated cooking appliances. Canopy constructed of stainless steel on all exposed surfaces and aluminized steel
on all non-exposed surfaces. Canopy shall have all welded exterior joints and seams. Canopy construction shall conform to NFPA
96 standards. All exposed welds are to be ground and polished to match nish requirements. Canopy is to meet NSF standards
for construction and UL standards for operation. UL Listed aluminum bafe style grease lters to run full length of exhaust hood.
Grease trough(s) to be easily removable and sloped to removable grease cup(s). UL Listed globe type incandescent light xtures
mounted on 36” center lines.
Standard Features: Optional Accessories:
• UL Listed aluminum grease lters
• UL Listed globe light(s)
• Removable grease trough & cup(s)
• Hanging brackets
• Exhaust and supply collars installed
• 1” Thick supply air plenum insulation
• Stainless steel construction where visible
All stainless steel construction
UL Listed stainless steel grease lters
14” Utility cabinet
Electrical control panel
Pre-plumbed re suppression
Stainless steel top enclosures
Light and fan switches
Recessed uorescent light xtures
Recessed incandescent light xtures
Stainless steel wall panel
Stainless steel side skirts
Exhaust fan / cooking equipment interlock control
UL Listed exhaust volume damper available on
all units with (2) exhaust collars
Melink Intelli-Hood® control systems
1055 Mendell Davis Drive, Jackson, MS 39272
888-994-7636, unifiedbrands.net
Please reference our website for the most
updated product information and specifications.
Avtec CHINOOK Value Ventilation, Page 2
PP SPEC1026 Rev. C
Revised 05/09
Model VDV
Light Duty Temperature Cooking Equipment – 400°F (
Medium Duty Temperature Cooking Equipment – 400-600°F (
Heavy Duty Temperature Cooking Equipment – 600°F (
400 Degree Light Duty
Cooking Equipment
Exhaust CFM
Length
4’-0” 1400 10 x 12 1800 12 x 14 2000 12 x 16
5’-0” 1750 12 x 14 2250 12 x 16 2500 12 x 18
6’-0” 2100 12 x 16 2700 12 x 20 3000 12 x 22
7’-0” 2450 12 x 18 3150 12 x 24 3500 12 x 26
8’-0” 2800 12 x 22 3600 12 x 28 4000 12 x 30
9’-0” 3150 12 x 24 4050 12 x 30 4500 12 x 34
10’-0” 3500 12 x 26 4500 12 x 34 5000 12 x 38
11’-0” 3850 12 x 28 4950 12 x 38 5500 12 x 42
12’-0” 4200 12 x 32 5400 2 12 x 20 6000 2-12 x 22
13’-0 4550 2-12 x 18 5850 2 -12 x 22 6500 2-12 x 24
14’-0” 4900 2-12 x 18 6300 2 -12 x 24 7000 2-12 x 26
15’-0” 5250 2-12 x 20 6750 2 -12 x 26 7500 2-12 x 28
16’-0” 5600 2-12 x 22 7200 2 - 12 x 28 8000 2-12 x 30
Note: Greater exhaust air ow rates may be required for each specic installation to obtain complete vapor and smoke removal.
Note: Hoods over 12’-0”in length require two exhaust duct collars. Exhaust collar sizing is based on an average range of 1600 FPM. Duct collars are
located on centerline of canopy, unless otherwise specied. Hoods with two exhaust collars have them located on ¼ hood length lines unless otherwise
specied. Canopy is to have a minimum 6” overhang on all exposed sides and the front and rear leading edge of the hood to the perimeter of the cooking
equipment surface.
CFM @
.75 SP
Light duty ranges, roasters, ovens, steamers, etc.)
Rotisseries, ranges, grills, fryers, etc.)
Gas char-broilers, woks, upright broilers, etc.)
400-600 Medium Duty
Cooking Equipment
Exhaust CFM
Duct Collar
1055 Mendell Davis Drive, Jackson, MS 39272, 888-994-7636, unifiedbrands.net
© 2009 Unified Brands. All Rights Reserved. DOVER® and the DOVER® Logo are registered
trademarks in the United States [and various other countries] of Unified Brands, a
wholly-owned subsidiary of Dover Corporation.
CFM @
1.00” SP
Duct Collar
600 Degree Heavy Duty
Cooking Equipment
CFM @
1.25”SP
Exhaust CFM
Duct Collar
NFPA-96
Loading...