Atlas Metal WH-2, WIH-D-M-17, WH, WIH-D-17 Installation Manual
Subsidiary of Mercury Aircraft, Inc.
R
R
R
1135 N.W. 159th DR., MIAMI, FL 33169
PHONE (305) 625-2451, (800) 762-7565, FAX (305) 623-0475, E-mail: sales@atlasfoodserv.com
PARTS LIST ELECTRICAL HEATED UNITS
WH/ WIH/ WIHD/ WIHD&M/ WIHL AND WIH 17-67 SERIES
2
1
4
3
24
5
6
WIHD-4 SHOWN
ITEM
NUMBE
1 7002-0+Model # Vinyl Bead Gasket
2 86-3202 Perforated Snap in Drain
3 1097-0 Dial
4 1099-0 Pilot Light
5 3006-2 3/4" Brass Nipple
6 3016-1 Brass Gate Valve
7 1088-0 P-136 Terminal (#22 & 18 wire)
8 1089-0 P-151 Terminal (#10 & 12 wire)
9 1090-0 P-144 Terminal (#14 & 16 wire)
10 1098-0 S Screw Thermostat Mounting
11 2500-0 Remote Thermostat
12 1014-4 14" Nickel Wire
13 1012-3 12" Nickel Wire
14 1096-0 Thermostat
15 2500-5 Remote Thermostat with 72” Bulb
16 S81113-1 Element Holder
PART
NUMBER
DESCRIPTION
ITEM
NUMBE
17 SC0099-238 S/S Element Holder
18 1053-0 120V-850W Element
19 1054-0 208V-850W Element
20 1055-0 240V-850W Element
21 1056-0 120V-1000W Element
22 1057-0 240V-1000W Element
23 1058-0 208V-1000W Element
24
25 12-228 Plug 20Amp 240V
26 1022-0 Plug 30Amp 240V
27 12-256 Plug 30Amp 120V
28 1014-7 #12 Green Wire (Ground)
29 1014-8 #14 Green Wire (Ground)
30 1001-1 50 Amp Cord & Plug
PART
NUMBE
1002-0 Power Cord 14/3
1004-0 Power Cord 12/3
1004-4 Power Cord 10/3
DESCRIPTION
ELECTRICAL HEATED UNITS
WH/ WIH/ WIHD/ WIHD&M/ WIHL AND WIH 17-67 SERIES
----------------------------------------------------------------------------------------------------------------------------------------------------------
INSTALLATION
Provide the correct counter cut-out opening (see chart below) and drop in. The vinyl gasket assures
complete seating. A non-toxic silicone seal may be used between the gasket and counter top (not
required). The unit is supplied with a power cord and NEMA plug. Refer to the data plate on the control
panel for the amperage and voltage information. Use a licensed electrician when installing power source.
MODEL NUMBER CUT-OUT SIZE
WIH-1/ WIHD-1 * 22 1/4 X14 1/4
WH-2/ WIH-2/ WIHD-2/ WIH-D&M-2 22 1/4 X 28
WH-3/ WIH-3/ WIHD-3/ WIH-D&M-3 22 1/4 X 41 3/4
WH-4/ WIH-4/ WIHD-4/ WIH-D&M-4 22 1/4 X 55 1/2
WH-5/ WIH-5/ WIHD-5/ WIH-D&M-5 22 1/4 X 69 1/4
WH-6/ WIH-6/ WIHD-6/ WIH-D&M-6 22 1/4 X 83
WIHL-2/ WIHL-D-2/ WIHL-D&M-2 14 1/4 X 44 1/4
WIHL-3/ WIHL-D-3/ WIHL-D&M-3 14 1/4 X 66
WIHL-4/ WIHL-D-4/ WIHL-D&M-4 14 1/4 X 87 3/4
WIH-17/ WIHD-17/ WIH-D&M-17 * 29 3/8 X 14 1/4
WIH-27/ WIHD-27/ WIH-D&M-27 29 3/8 X 28
WIH-37/ WIHD-37/ WIH-D&M-37 29 3/8 X 41 1/4
WIH-47/ WIHD-47/ WIH-D&M-47 29 3/8 X 55 1/2
WIH-57/ WIHD-57/ WIH-D&M-57 29 3/8 X 69 1/4
WIH-67/ WIHD-67/ WIH-D&M-67 29 3/8 X 83
* Control box on 14 1/4" side.
----------------------------------------------------------------------------------------------------------------------------------------------------------
SIDE SECTIONAL VIEW
OPERATION
The unit can be used wet or dry, however the use of water is recommended. When using wet, 1 to 2 inches
of water in pan is sufficient see water level line, in S/S liner. The thermostat dial has an off position and
numbers from 1 to 10. (Number 10 is the highest setting).
--------------------------------------------------------------------------------------------------------------------------------
MAINTENANCE
NEVER CLEAN PANS WITH A CHLORIDE BASED PRODUCT. CHLORIDES OR IMPROPER
CLEANING COULD SCAR, MARK AND/OR CORRODE PANS. DO NOT
ABRASIVE PRODUCTS.TO CLEAN USE SOAPY WARM WATER, RINSE THOROUGHLY TO
REMOVE ALL RESIDUES. FAILURE TO MEET THESE CONDITIONS WILL VOID
WARRANTY.
USE STEEL WOOL OR
Loading...