Aspire EDC24 Installation Manual

DROP-IN COOLER

Installation Instructions

EDC24

IMPORTANT - READ ALL INSTRUCTIONS BEFORE YOU BEGIN
INSTALLER SHOULD LEAVE THESE INSTRUCTIONS WITH THE HOMEOWNER

Some parts have sharp edges. Care must be taken when handling the various components to avoid personal injury. Wear
gloves when handling.

Inspect the product to verify that there is no shipping damage. If any damage is detected, call the shipper and initiate a
damage claim. Hestan Commercial Corp. is not responsible for shipping damage. DO NOT discard any packing material
(box, pallet, straps) until the unit has been inspected.

Remove all exterior packaging materials, banding, tape, etc. Remove all protective film from the inside of your cabinets.
You may leave any exterior protective film on until after installation is complete.

CUTOUT DIMENSIONS AND INSTALLATION

1. Your new Aspire Drop-in Cooler is completely pre-assembled. The cutout dimensions in your island are
shown below. Some provision must be made in the island for drainage. The bottom of the unit has a 1/2”
NPS threaded connection. Be sure to leave enough space around the drain connection for access from
below.

DRAIN ASSEMBLY &

RUBBER STOPPER

©2022 Hestan Commercial Corporation

1

INSTALLATION

2. As seen in this installation, an Aspire Access Door is mounted below the Drop-In Cooler to allow access
to the drain connection. This is not a requirement and your professional outdoor equipment installer
may find another way to drain the unit elsewhere.

The weight of the Drop-In Cooler will hold the unit in place. However, you may want to apply a bead of

clear silicone sealant around the perimeter of the outer frame to your countertop.

(continued)

PARTS LIST

Please visit the Hestan website to access the parts list for your Hestan Outdoor product:

www.hestanaspire.com.www.hestanaspire.com.

SERVICE

All warranty and non-warranty repairs should be performed by qualified service personnel. To locate an authorized
service agent in your area, contact your Hestan dealer, local representative, or the manufacturer. Before you call, please
have the model number information ready. This information is shown on a sticker affixed to one of the inside vertical
surfaces of your product.

Hestan Commercial Corporation
3375 E. La Palma Avenue
Anaheim, CA 92806
[phone]

OUTDOOR GAS PRODUCT LIMITED WARRANTY

WHAT THIS LIMITED WARRANTY COVERS

Hestan Commercial Corporation (“HCC”) warrants to the original consumer purchaser of an Aspire by Hestan outdoor gas
product (the “Product”) from an HCC authorized dealer that the Product is free from defective materials or workmanship
for a period of one (1) year from the date of original retail purchase or closing date for new construction, whichever period
is longer (“Limited Warranty Period”). HCC agrees to repair or replace, at HCC’s sole option, any part or component of the
Product that fails due to defective materials or workmanship during the Limited Warranty Period. This Limited Warranty is
not transferable and does not extend to anyone beyond the original consumer purchaser (“Purchaser”). This Limited Warranty
is valid only on Products purchased and received from an HCC authorized dealer in the fifty United States, the District
of Columbia and Canada. This Limited Warranty applies only to Products in non-commercial use and does not extend to
Products used in commercial applications.

2

©2022 Hestan Commercial Corporation

LIMITED WARRANTY

(continued)

HOW TO OBTAIN WARRANTY SERVICE

If the Product fails during the Limited Warranty Period for reasons covered by this Limited Warranty, the Purchaser must
immediately contact the dealer from whom the Product was purchased or HCC at 888.905.7463.

Purchaser is responsible for making the Product reasonably accessible for service or for paying the cost to make the
Product reasonably accessible for service. Service is to be provided during normal business hours of the authorized
Hestan Commercial Service Provider. To the extent Purchaser requests service outside of the normal business hours of the
authorized Hestan Commercial Service Provider, Purchaser will pay the difference between regular rates and overtime or
premium rates. Purchaser is required to pay all travel costs for travel beyond 50 miles (one way) from the nearest authorized

Hestan Commercial Service Provider.

EXTENSIONS TO ONE YEAR LIMITED WARRANTY PERIOD:

In addition to the One-Year Limited Warranty, the following components have extended warranty coverage as specifically set
forth below:

1. The Product’s stainless steel grill body, stainless tubular grill burners, Sear burners and rotisserie infrared burner (where
applicable) are warranted to be free from defects in material and workmanship under normal non-commercial use and service
for the lifetime of the original Purchaser. This excludes surface corrosion, scratches, and discoloration which may occur
during normal use and is limited to replacement of the defective part(s), with the Purchaser paying all other costs, including
labor, shipping and handling, as applicable.

2. The Product’s cooking grates and warming rack are warranted to be free from defects in material and workmanship under
normal non-commercial use and service, for a period of ten (10) years from the original date of purchase. This excludes surface
corrosion, scratches, and discoloration which may occur during normal use and is limited to replacement of the defective
part(s), with the Purchaser paying all other costs, including labor, shipping and handling, as applicable.

3. The Product’s spit rod, briquette trays, manifolds, gas valves and sealed burner assemblies (where applicable) are warranted
to be free from defects in material and workmanship, under normal non-commercial use and service, for a period of five (5)
years from the original date of purchase. This is limited to replacement of the defective parts, with the Purchaser paying all
other costs, including labor, shipping, and handling, as applicable.

4. All other grill components are warranted to be free from defects in material and workmanship, under normal non­commercial use and service, for a period of two (2) years from the original date of purchase. This is limited to replacement of

the defective parts, with the Purchaser paying all other costs, including labor, shipping, and handling, as applicable.

WHAT THIS LIMITED WARRANTY DOES NOT COVER:

This Limited Warranty does not cover and HCC will not be responsible for and will not pay for: damage to or defects in any
Product not purchased from an HCC authorized dealer; color variations in color finishes or other cosmetic damage; failure
or damage from abuse, misuse, accident, fire, natural disaster, commercial use of the Product, or loss of electrical power or
gas supply to the Product; damage from alteration, improper installation, or improper operation of the Product; damage
from improper or unauthorized repair or replacement of any part or component of the Product; damage from service by
someone other than an authorized agent or representative of the Hestan Commercial Service Network; normal wear and
tear; damage from exposure of the Product to a corrosive atmosphere containing chlorine, fluorine, or any other damaging
chemicals; damage resulting from the failure to provide normal care and maintenance to the Product; damage HCC was not
notified of within the Limited Warranty Period; and incidental and consequential damages caused by any defective material
or workmanship.

ARBITRATION:

This Limited Warranty is governed by the Federal Arbitration Act. Any dispute between Purchaser and HCC regarding or
related to the Product or to this Limited Warranty shall be resolved by binding arbitration only on an individual basis with
Purchaser. Arbitration will be conducted by the American Arbitration Association (“AAA”) in accordance with its Consumer
Arbitration Rules or by JAMS. The arbitration hearing shall be before one arbitrator appointed by the AAA or JAMS. The
arbitrator shall not conduct class arbitration and Purchaser shall not bring any claims against HCC in a representative

capacity on behalf of others.

LIMITATION OF LIABILITY:

This Limited Warranty is the final, complete and exclusive agreement between HCC and Purchaser regarding the Product.

THERE ARE NO EXPRESS WARRANTIES OTHER THAN THOSE LISTED AND DESCRIBED ABOVE. NO WARRANTIES
WHETHER EXPRESS OR IMPLIED, INCLUDING, BUT NOT LIMITED TO, ANY IMPLIED WARRANTIES OF
MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE SHALL APPLY AFTER THE LIMITED WARRANTY
PERIOD STATED ABOVE. NO OTHER EXPRESS WARRANTY OR GUARANTY GIVEN BY ANY PERSON, FIRM OR
CORPORATION WITH RESPECT TO THIS PRODUCT SHALL BE BINDING ON HCC. HCC ASSUMES NO RESPONSIBILITY
THAT THE PRODUCT WILL BE FIT FOR ANY PARTICULAR PURPOSE, EXCEPT AS OTHERWISE PROVIDED BY
APPLICABLE LAW.

©2022 Hestan Commercial Corporation

3

LIMITED WARRANTY

HCC SHALL NOT BE LIABLE FOR LOSS OF REVENUE OR PROFITS, FAILURE TO REALIZE SAVINGS OR OTHER BENEFITS,
OR ANY OTHER SPECIAL, INCIDENTAL OR CONSEQUENTIAL DAMAGES CAUSED BY THE USE, MISUSE OR INABILITY
TO USE THE PRODUCT, REGARDLESS OF THE LEGAL THEORY ON WHICH THE CLAIM IS BASED, AND EVEN IF HCC
HAS BEEN ADVISED OF THE POSSIBILITY OF SUCH DAMAGES. NO RECOVERY OF ANY KIND AGAINST HCC SHALL BE
GREATER IN AMOUNT THAN THE PURCHASE PRICE OF THE PRODUCT.

WITHOUT LIMITING THE FOREGOING, YOU ASSUME ALL RISK AND LIABILITY FOR LOSS, DAMAGE OR INJURY TO YOU
AND YOUR PROPERTY AND TO OTHERS AND THEIR PROPERTY ARISING OUT OF THE USE, MISUSE OR INABILITY TO
USE THE PRODUCT NOT CAUSED DIRECTLY BY THE NEGLIGENCE OF HCC. THIS LIMITED WARRANTY STATES YOUR

EXCLUSIVE REMEDY.

No oral or written representation or commitment given by anyone, including but not limited to, an employee, representative or
agent of HCC will create a warranty or in any way increase the scope of this express Limited One Year Warranty. If there is any
inconsistency between this Limited Warranty and any other agreement or statement included with or relating to the Product,
this Limited Warranty shall govern. If any provision of this Limited Warranty is found invalid or unenforceable, it shall be
deemed modified to the minimum extent necessary to make it enforceable and the remainder of the Limited Warranty shall

remain valid and enforceable according to its terms.

(continued)

INTERACTION OF LAWS WITH THIS LIMITED WARRANTY:

Some states, provinces or territories may not allow limitations on how long an implied warranty lasts or the exclusion or
limitation of incidental or consequential damages, so the above limitations or exclusions may not apply to you. Some states,
provinces or territories may provide for additional warranty rights and remedies, and the provisions contained in this Limited
Warranty are not intended to limit, modify, take away from, disclaim or exclude any mandatory warranty requirements
provided by states, provinces or territories, including certain implied warranties. This warranty gives you specific legal rights,

and you may also have other rights which vary depending on location.

Any questions about this Limited Warranty may be directed to

Hestan Commercial Corporation at [phone]

RETAIN THIS MANUAL FOR FUTURE REFERENCE

Hestan Commercial Corporation

3375 E. La Palma Ave

Anaheim, CA 92806

[phone]

4

©2022 Hestan Commercial Corporation P/N 015455 REV B