Antunes DC-14A Operators Manual

Display Cabinet
Model DC-14A
owner’s manual
Manufacturing Numbers:
9500711
www.antunes.com
P/N 1011440 Rev. A 12/16
DC-14A DISPLAY CASE
OWNER INFORMATION
General
This manual provides the safety, installation, and operating procedures for this unit. Please read this manual prior to installing and operating the unit.
This unit is manufactured from the finest materials available and assembled to Roundup’s strict quality standards. This unit has been tested at the factory to ensure dependable trouble-free operation.
Service/Technical Assistance
If you experience any problems with the installation or operation of your unit, contact your Authorized Service Agency.
Warranty Information
Please read the full text of the Limited Warranty in this manual.
If the unit arrives damaged, contact the carrier imme­diately and file a damage claim with them. Save all packing materials when filing a claim. Freight damage claims are the responsibility of the purchaser and are not covered under warranty.
The warranty does NOT extend to:
Fill in the information below and have it handy when calling Antunes Technical Service for assistance. The serial number is on the specification plate located on the rear of the unit.
Purchased From:
Date of Purchase:
Model No.:
Serial No.:
Mfg. No.:
Network ID Number:
Use only genuine Antunes replacement parts in this unit. Use of replacement parts other than those sup­plied by the manufacturer will void the warranty.
• Damages caused in shipment or damage as result of improper use.
• Normal maintenance as outlined in this manual.
• Malfunction resulting from improper maintenance.
• Damage caused by abuse or careless handling.
IMPORTANT! Keep these instructions for future reference. If the unit
changes ownership, be sure this manual accompanies the equipment.
P/N 1011440 Rev. A 12/16
Dimensions
A
DC-14A DISPLAY CASE
SPECIFICATIONS
B C
Model & Mfg. No. Height
(A)
DC-14A
9500711
17.5”
(443.8 mm)
Width
(B)
13.86”
(352 mm)
Depth
(C)
18.04”
(458.1 mm)
P/N 1011440 Rev. A 12/16
DC-14A DISPLAY CASE
INSTALLATION
Unpacking
1. Open the large box. It contains:
• DC-14A Display Case
• Three shelves
• Owner’s Manual
2. Remove the foam inserts from the box.
3. Carefully remove the display case from the large box.
4. Perform the Daily Cleaning steps found in the Maintenance section of this manual.
NOTE: If any parts are missing or damaged, con­tact Antunes Customer Service IMMEDIATELY at 1-877-392-7856 (North America only), or 630-784-1000.
Location
When placing the toaster into service, pay attention to the following guidelines:
• Do NOT block or cover any openings on the unit.
• Keep away from heated surfaces.
1. Place the display case in the required position.
2. Load product into the display case. Insert appro­priate card into the display card holder.
Figure 1. DC-14A Display Case
P/N 1011440 Rev. A 12/16
Daily Cleaning
Follow these steps to clean the Display Case.
1. Remove food product from the display case and store properly.
2. Remove the shelves from the display case. Remove the crumbs from the shelves with a clean, sanitizer-soaked towel and dispose the crumbs into the trash receptacle.
3. Take the shelves to the 3-compartment sink to wash with hot water and an approved all pur­pose cleaning solution. For heavier soils, pre­spray with an approved heavy duty degreaser solution prior to washing.
4. Rinse the shelves with clean, hot water at the 3-compartment sink.
5. Sanitize the shelves with sanitizer solution for one minute at the 3-compartment sink and allow to air dry.
DC-14A DISPLAY CASE
MAINTENANCE
6. Using a clean, sanitizer-soaked towel; sweep crumbs out of the display case and empty into the trash receptacle.
7. Spray and wipe the interior and exterior walls of the display case with an approved all pur­pose cleaning solution and a clean, sanitizer­soaked towel. For heavy soils, scrub the dis­play case walls with non-scratch pad that will not damage the display case surfaces.
8. Rinse the interior and exterior walls of the display case with a separate, clean sanitizer­soaked towel.
9. Spray the interior and exterior walls of the dis­play case with sanitizer solution and allow to air dry.
10. Reinstall the shelves and load food product.
P/N 1011440 Rev. A 12/16
DC-14A DISPLAY CASE
6
9
14
11
13
5
12
3
15
8
10
1
4
2
7
REPLACEMENT PARTS
Item Part No. Description Qty.
1 0013201 Door Assembly 1 2 2100247 Knob 1 3 0013202 Front Acrylic Assembly 1 4 2180456 Shelf Rest 12 5 2100285 Rubber Head Screw Bumper 4 6 0900335 Shelf Panel 3 7 0900336 Acrylic Side Panel LH 1 8 0900331 Acrylic Panel, Top 1 9 0900330 Acrylic Side Panel RH 1 10 3080104 8-32 X .38 LG Truss Head S.S. 14 11 3100123 10-24 X .50 LG Truss Head S.S. 8 12 3100134 10-32 Acorn Nut S.S. 4 13 0022214 Base Weldment For Display Case 1 14 050728 Mounting Clip Lower 2 15 050729 Mounting Clip Upper 2
P/N 1011440 Rev. A 12/16
NOTES
DC-14A DISPLAY CASE
P/N 1011440 Rev. A 12/16
Limited Warranty
This Display Case has a 90 day warranty from date of purchase. This warranty does not cover misuse/abuse, dam­age due to dropping, or damage resulting from improper maintenance. The warranty for this Display Case does not cover travel time or mileage. Contact the Technical Service Department at (630) 784-1000, (877) 392-7854 (toll free in the U.S.), or Tech.Service@antunes.com for any warranty issues.
+1 (630) 784-1000
+1 (800) 253-2991
+1 (630) 784-1650
+86-512-6841-3637
+400-0-7878-22
+86-512-6841-3907
Loading...