Page 1
®
®
Boom Arm Mower
Rev 0-11 Part No. 02968915P
PART'S MANUAL
An Operator's Manual was shipped with the equipment in the Manual Canister.
This Operator's Manual is an integral part of the safe operation of this machine
and must be maintained with the unit at all times. READ, UNDERSTAND, and
FOLLOW the Safety and Operation Instructions contained in this manual before
operating the equipment. If the Operator's Manual is not with the equipment,
contact your dealer or Alamo Industrial (800-356-6286) to obtain a Free copy
before operating the equipment.
ALAMO INDUSTRIAL
1502 E. Walnut
Seguin, Texas 78155
210-372-3551
© 2011 Alamo Group Inc.
Page 2
TO THE OWNER/OPERATOR/DEALER
All implements with moving parts are potentially hazardous. There is no substitute for a cautious, safe-minded operator who recognizes the potential hazards and follows reasonable safety practices. The manufacturer has designed this implement to be used with
all its safety equipment properly attached to minimize the chance of accidents.
BEFORE YOU START!! Read the safety messages on the implement and shown in your manual.
Observe the rules of safety and common sense!
WARRANTY INFORMATION:
Read and understand the complete Warranty Statement found in this Manual. Fill out the Warranty Registration Form in full and return
it within 30 Days. Make certain the Serial Number of the Machine is recorded on the Warranty Card and on the Warranty Form that
you retain. The use of "will-t" parts will void your warranty and can cause catastrophic failure with possible injury or death.
Page 3
BOLT TORQUE
Mounting procedures for mowers will require a signicant amount of bolt nut and washer installation.
Frame and structure mounting bolts should be installed using Red Loctite, and torqued to the dry values
listed in the torque chart based on the bolt size and hardness.
Other structures such as pump mounting bolts should be installed with Blue Loctite and torqued to the dry
values indicated in the chart.
Bolt tightness should be completed with and checked with a suitable torque wrench.
Torque checks should be completed throughout the life of the mower in accordance with the maintenance
chart provided in this manual.
Loose bolts on a frame or in a casting may be a result of:
● Vibration from the mower due to imbalance of the mower blades
● Pulled threads due to over tightening
● Distortion of the hole due to under tightening during installation
Bolts broken or sheared in the mounting structure or tractor may be the result of:
● Improper alignment of the Mounting Plate or Structure such that it is not sitting at on the mating
surface
● Distortion of the bolt due to over-tightening
● Under tightening of the bolts
Check the bolt torque during installation and prior to delivery with a suitable torque wrench.
Page 4
PARTS
SECTION
Parts Section – 1
Page 5
PARTS ORDERING GUIDE
®
®
The following instructions are offered to help eliminate needless delay and error in processing
purchase orders for the equipment in this section.
1. The Parts Section is prepared in logical sequence and grouping of parts that belong to the
basic machine featured in this manual. Part Numbers and Descriptions are given to help locate
the parts and quantities required.
2. The Purchase Order must include the name and address of the person or organization ordering
the parts, who should be charged, and if possible, the serial number of the machine for which
the parts are ordered.
3. The Purchase Order must clearly list the quantity of each part, the complete and correct part
number (be sure to include all periods), and the basic name of the part.
4. The Manufacturer reserves the right to substitute parts where applicable.
5. Some parts are unlisted items which are special production items not normally stocked and
are subject to special handling. Request a quotation for such parts before sending a Purchase
Order.
6. The Manufacturer reserves the right to change prices without prior notice.
For maximum safety and to guarantee optimum product reliability, always use
genuine Alamo Industrial Parts. The use of inferior replacement parts may cause
premature or catastrophic failure which could result in serious injury or death.
Direct any questions regarding parts to:
ALAMO INDUSTRIAL
1502 E. Walnut
Seguin, Texas 78155
830-379-1480
©2011 Alamo Group Inc.
Parts Section – 2
Page 6
PART NAME INDEX
50 IN BLADE CARRIER ASY (PAN) - PN 02964457................................................................................................................................. 6
50 IN BOOM AXE HEAD SUB ASSEMBLY............................................................................................................................................. 7
50 IN BOOM AXE HEAD ASSEMBLY...................................................................................................................................................... 9
50 IN MOTOR & SPINDLE ASY............................................................................................................................................................... 11
50 IN MOTOR ASY - PARTS - PN 02979881 (PART 1).......................................................................................................................... 13
50 IN MOTOR ASY - PARTS - PN 02979881 (PART 2).......................................................................................................................... 15
50 IN SPINDLE ASY - PN 02960553B...................................................................................................................................................... 17
60 IN BLADE CARRIER ASY (BAR) - PN 02969230.............................................................................................................................. 18
60 IN DOOR CYL ASY - PN 02961480A.................................................................................................................................................. 19
60 IN HEAD ASY - SN 02050 & DOWN................................................................................................................................................... 21
60 IN HEAD ASY - SN 02051 & UP.......................................................................................................................................................... 23
60 IN HEAD SUB-ASY - SN 02050 & DOWN.......................................................................................................................................... 25
60 IN HEAD SUB-ASY - SN 02051 & UP................................................................................................................................................. 27
60 IN MOTOR ASY - PARTS - PN 02979881 - SN 02051 (PART 1)....................................................................................................... 29
60 IN MOTOR ASY - PARTS - PN 02979881 - SN 02051 (PART 2)....................................................................................................... 31
60 IN SPINDLE ASY - PN 02968859A...................................................................................................................................................... 33
BOOM ASY - 17 FT (OPT ALLOY STEEL) - PN 02980034.................................................................................................................... 35
BOOM ASY - 17 FT (STD STEEL) - PN 02979902.................................................................................................................................. 37
BOOM ASY - 21 FT (STD & ALLOY STEEL) (PART 1)........................................................................................................................ 39
BOOM ASY - 21 FT (STD & ALLOY STEEL) (PART 2)........................................................................................................................ 41
BOOM ASY - 24 FT (STD & ALLOY STEEL) (PART 1)........................................................................................................................ 43
BOOM ASY - 24 FT (STD & ALLOY STEEL) (PART 2)........................................................................................................................ 45
BOOM HOSE SCHEMATIC - 17 FT BOOM ARM.................................................................................................................................. 47
BOOM HOSE SCHEMATIC - 21 FT BOOM ARM.................................................................................................................................. 49
BOOM HOSE SCHEMATIC - 24 FT BOOM ARM.................................................................................................................................. 51
BUZZ BAR - HYD MOTOR PARTS - P/N 02975175............................................................................................................................... 53
BUZZ BAR ASY - 48 IN - GEN 1 (PART 1)............................................................................................................................................. 55
BUZZ BAR ASY - 48 IN - GEN 1 (PART 2)............................................................................................................................................. 57
BUZZ BAR ASY - 48 IN - GEN 1 (PART 3)............................................................................................................................................. 59
BUZZ BAR ASY - 48 IN - GEN 2 (PART 1)............................................................................................................................................. 61
BUZZ BAR ASY - 48 IN - GEN 2 (PART 2)............................................................................................................................................. 63
BUZZ BAR ASY - 69 IN - GEN 1 (PART 1)............................................................................................................................................. 65
BUZZ BAR ASY - 69 IN - GEN 1 (PART 2)............................................................................................................................................. 67
BUZZ BAR ASY - 69 IN - GEN 1 (PART 3)............................................................................................................................................. 69
BUZZ BAR ASY - 69 IN - GEN 2 (PART 1)............................................................................................................................................. 71
BUZZ BAR ASY - 69 IN - GEN 2 (PART 2)............................................................................................................................................. 73
BUZZ BAR ASY - 90 IN - GEN 1 (PART 1)............................................................................................................................................. 75
BUZZ BAR ASY - 90 IN - GEN 1 (PART 2)............................................................................................................................................. 77
BUZZ BAR ASY - 90 IN - GEN 1 (PART 3)............................................................................................................................................. 79
BUZZ BAR ASY - 90 IN - GEN 2 (PART 1)............................................................................................................................................. 81
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -3
Page 7
PART NAME INDEX
BUZZ BAR ASY - 90 IN - GEN 2 (PART 2)............................................................................................................................................. 83
BUZZ BAR MOTOR ASSEMBLY............................................................................................................................................................. 85
BUZZ BAR SPINDLE ASY - SN BB-01219.............................................................................................................................................. 87
DITCHER - BLADE CARRIER ASY......................................................................................................................................................... 88
DITCHER - HOUSING ASY...................................................................................................................................................................... 89
DITCHER - SPINDLE ASY........................................................................................................................................................................ 91
DITCHER BLADE HEAD ASY - ROUGH CUT....................................................................................................................................... 93
DITCHER HEAD ASY - (NEW STYLE)................................................................................................................................................... 95
DITCHER HEAD ASY - (OLD STYLE).................................................................................................................................................... 97
DITCHER HEAD DEFLECTOR CYLINDER........................................................................................................................................... 99
FILTER ASY - PN 02976066.................................................................................................................................................................... 101
FILTER ASY - PN 02985280.................................................................................................................................................................... 103
FLAIL AXE - DOOR CYL ASY - PN 02970710A................................................................................................................................... 104
FLAIL AXE - HEAD ASY (PART 1)....................................................................................................................................................... 105
FLAIL AXE - HEAD ASY (PART 2)....................................................................................................................................................... 107
FLAIL AXE - HOSE CONNECTIONS..................................................................................................................................................... 109
FLAIL AXE - ROTOR W/KNIVES.......................................................................................................................................................... 110
FML100H FLAIL - HEAD ASY (PART 1).............................................................................................................................................. 111
FML100H FLAIL - HEAD ASY (PART 2).............................................................................................................................................. 113
FML100H FLAIL - HEAD ASY (PART 3).............................................................................................................................................. 115
FML100H FLAIL - SPINDLE ASY - PN 02969661................................................................................................................................ 117
GRASS FLAIL - CUTTERSHAFT ASY.................................................................................................................................................. 118
GRASS FLAIL - CUTTERSHAFT BRGS................................................................................................................................................ 119
GRASS FLAIL - HEAD ASY................................................................................................................................................................... 121
GRASS FLAIL - HEAD SUB-ASY.......................................................................................................................................................... 123
GRASS FLAIL - PULLEY ASY............................................................................................................................................................... 125
GRASS FLAIL - ROLLER ASY............................................................................................................................................................... 127
HIGH FRAME ASY - 2 WD & 4 WD....................................................................................................................................................... 129
HYD CYL ASY - DIPPER - PN 02967174A (21 & 24 FT)...................................................................................................................... 131
HYD CYL ASY - DIPPER - PN 02979920 (17 FT).................................................................................................................................. 132
HYD CYL ASY - LIFT - PN 02967173A................................................................................................................................................. 133
HYD CYL ASY - SWING - PN 02967172A............................................................................................................................................. 134
HYD CYL ASY - TILT - PN 02967175A................................................................................................................................................. 135
HYD LOCK VALVE SOLENOID ASY - PN 02972208 (OLD STYLE)................................................................................................ 136
HYD LOCK VALVE SOLENOID ASY - PN 02972208A (NEW STYLE)............................................................................................ 137
HYD TANK ASY - PN 02976712 (OCFD) & PN 02976765 (CCLS)...................................................................................................... 139
HYD TANK SUB-ASY - PN 02976767.................................................................................................................................................... 141
JOYSTICK CONSOLE ASY..................................................................................................................................................................... 143
KING POST SUB-ASY............................................................................................................................................................................. 145
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -4
Page 8
PART NAME INDEX
MOUNTING COMPONENTS - COMMON BOX (PART 1).................................................................................................................. 147
MOUNTING COMPONENTS - COMMON BOX (PART 2).................................................................................................................. 149
MOUNTING COMPONENTS - COMMON BOX (PART 3).................................................................................................................. 151
PUMP ASY - SERVO CONTROLED - PN 02969527A (PART 1)......................................................................................................... 153
PUMP ASY - SERVO CONTROLED - PN 02969527A (PART 2)......................................................................................................... 155
TIMBERCAT - HEAD ASY (PART 1)..................................................................................................................................................... 157
TIMBERCAT - HEAD ASY (PART 2)..................................................................................................................................................... 159
VALVE - PARTS - OPEN & CLOSED CENTER.................................................................................................................................... 161
VALVE ASY - 5 SPOOL (CCLS)............................................................................................................................................................. 163
VALVE ASY - 5 SPOOL (OCFD)............................................................................................................................................................ 165
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -5
Page 9
50 IN BLADE CARRIER ASY (PAN) - PN 02964457
ITEM PART NO. QTY. DESCRIPTION
02964457 - BLADE / SPIDER PAN ASY
1 02964804 1 SPIDER PAN SUB-ASY (W/ ITEMS 7,8,9 & 10)
2 02962722 1 BLADE SET, MATCHED SET OF 3
3 02964330 3 BLADE BOLT
4 00755623 3 WASHER, SPECIAL ( HARDENED )
5 00023200 3 ROLL PIN
6 00020900 3 SLOTTED HEX NUT, 1-1/8"-NF PL GR5
7 02030300 3 LOCKNUT, 1"-NC PLB
8 00748547 3 FLATWASHER, 1-1/32" X 2-3/16" X.22"
9 02964162 3 SPACER
10 7A16824 3 BOLT, HEX HEAD 1"-NC X 3"PL GR5
11 00003901 4 LOCKWASHER, 3/4" PL HEAVY
12 02886600 4 BOLT, SOCKET HEAD 3/4"-NC X 2-1/2" PL GR8
13 02964954 3 KEY
14 02964161 3 BUSHING
15 02965229 3 SPACER
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -6
Page 10
50 IN BOOM AXE HEAD SUB ASSEMBLY
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -7
Page 11
50 IN BOOM AXE HEAD SUB ASSEMBLY
Continued...
ITEM PART NO. QTY. DESCRIPTION
02980202 1 ASY, 50" B/A ROT PISTON
1 02974664 1 X-FRAME SQ. HD. WLDMT. 50"
2 02980205 1 WELDMENT, HITCHPOST ADAPTER
3 02980204 1 ASY, MOTOR/SPINDLE
4 02964457 1 PAN ASSY 50" HEAD
5 02984822 1 SPACER BLADE PAN
6 02960882 1 R.H. SKID SHOE
7 02960883 1 L. H. SKID SHOE
8 00011100 46 FLATWASHER 3/8 STD
9 00015800 39 LOCKNUT TLM 3/8 NC PLC
10 00059700 7 FSCS 3/8 NC X 1-1/4
11 00003901 4 LOCKWASHER 3/4 HEAVY
12 00037200 20 NUT 3/4 NC LOCKNUT
13 02964861 4 SHCS 3/4 NC 4" LG PL8
14 02973438 6 HHCS 3/4 NC 3-1/4 PL8
15 02959390 14 HHCS 3/4 NC 2-1/4 PL8
16 02980373 1 ADP HYD STGHT 10MB-16MJ
17 02968896 1 PLASTIC TIE, ORANGE, 11LG
18 02968895 1 PLASTIC TIE, BLUE, 11LG
19 02968894 1 PLASTIC TIE, RED, 11LG
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -8
Page 12
50 IN BOOM AXE HEAD ASSEMBLY
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -9
Page 13
50 IN BOOM AXE HEAD ASSEMBLY
Continued...
ITEM PART NO. QTY. DESCRIPTION
02980202 1 ASY, 50" B/A ROT PISTON
1 02974664 1 X-FRAME SQ. HD. WLDMT. 50"
2 02974483 1 WLDMT DOOR - BA50
3 02971928 1 WLDMT, HITCHPOST, MACHETE
4 02961480A 1 HYD CYLINDER 2BORE X 9-1/4 STROKE
5 02960885 2 FLAP, FRONT DEFLECTOR
6 02960886 2 REAR FLAP MODIFIED
7 02975227 6 FLAP, 13 X 8
8 02975228 2 FLAP, 13X8-TAPER END
9 02957380 1 SIDE GUARD
10 02957496 1 REAR FLAP RETAINER
11 5710121 1 PLATE, INSPECTION COVER
12 02960018 2 ADP, HYD, ELBOW, 4MB-4MJ90
13 00753642 6 HHCS 3/8 NC 1-1/4 PL5
14 00011100 46 FLATWASHER 3/8 STD
15 00015800 39 LOCKNUT TLM 3/8 NC PLC
16 02035800 23 WASHER, 3/8", SPECIAL PLATED
17 00007000 23 HHCS 3/8 NC 1-3/4 PL5
18 5F5180 2 NUT, 5/16 NC WING
19 00755153 2 PIN, COTTER 3/16 X 1-1/2 PL
20 02976448 1 PIN - MACHINED HEAD
21 651102 1 PIN-DRILLED
22 00037200 20 NUT 3/4 NC LOCKNUT
23 00011400 2 BOLT, HHCS 3/8 NC 1 PL5
24 02959390 14 HHCS 3/4 NC 2-1/4 PL8
25 02970595 1 HHCS 3/8 NC 2-3/4 PL8
26 02971701 1 NUT, SLOTTED 1-3/8 12NF PLB
27 02971702 1 FLATWASHER, 1-3/8 TYPE B PL NARROW
28 02971720 1 PIN WLDMNT, 11-1/2" LONG
29 02971756 1 PIN - 1/2 X 9 CHROME
30 165020 1 PIN, COTTER 5/16 X 2-1/2 PL
31 02968836 1 PLASTIC TIE, YELLOW
32 02968837 1 PLASTIC TIE, YELLOW & WHITE
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -10
Page 14
50 IN MOTOR & SPINDLE ASY
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -11
Page 15
50 IN MOTOR & SPINDLE ASY
Continued...
ITEM PART NO. QTY. DESCRIPTION
02980204 - MOTOR & SPINDLE ASY, F/ 50" ROTARY HEAD
1 02979881 1 MOTOR ASY, PISTON TYPE MOTOR
2 02960553B 1 SPINDLE ASY, SPLINED TYPE
3 02961038 1 GASKET, F/ MOTOR TO SPINDLE
4 02981819 4 ADP HYD STGHT 16FLH-16MJ SPCL
5 02981819 2 ADP HYD STGHT 16FLH-16MJ SPCL
6 02980237 2 O-RING
7 02980373 1 ADAPTER, STRAIGHT
8 02980236 8 BOLT
9 00022200 8 LOCKWASHER
10 02891800 4 BOLT
11 00019600 4 LOCKWASHER
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -12
Page 16
50 IN MOTOR ASY - PARTS - PN 02979881 (PART 1)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -13
Page 17
50 IN MOTOR ASY - PARTS - PN 02979881 (PART 1)
Continued...
ITEM PART NO. QTY. DESCRIPTION
02979881 - MOTOR ASY, PISTON TYPE
1 02980529 1 BARREL HOUSING ASY
2 02980530 1 VALVE PLATE (IN ITEM 39)
4 02980536 1 NOZZLE
5 02980537 1 PLUG ASY, HEXAGON
6 02980538 1 BEARING HOUSING
7 02980539 1 O-RING (IN ITEM 39 & 40)
8 02980540 1 O-RING (IN ITEM 39 & 40)
9 02980541 1 SEAL CARRIER
10 02980542 1 SHAFT SEAL (IN ITEM 39 & 40)
11 02980543 1 SPACER WASHER
02988818 1 SEAL, SHAFT
12 02980544 1 RETAINING RING
13 02980545 1 RETAINING RING
14 02980546 1 SHAFT ASY
15 02980548 1 CYLINDER BARREL (IN ITEM 39)
16 02980549 1 BARREL SUPPORT
17 02980550 7 PISTON ASY (IN ITEM 39)
18 02989112 1 KIT, 21 PISTON RINGS
19 02980552 1 RING GEAR
20 02980553 1 BEARING ASY, CUP & CONE
21 02980554 1 BEARING ASY, CUP & CONE
22 02980555 - SPACER WASHER
23 02980556 1 RETAINING RING
24 02980557 - SHIM, .020" (0.5)
02980558 - SHIM, .007" (0.2)
02980559 - SHIM, .015" (0.4)
02980560 - SHIM, .023" (0.6)
02980561 - SHIM, .030" (0.8)
02980562 - SHIM, .039" (1.0)
02980563 - SHIM, .027" (0.7)
25 02980564 4 BOLT, SOCKET HEAD
26 02980565 4 LOCKWASHER M13 X 19.5
27 02980547 1 GUIDE PIN
28 02980571 1 RELIEF MANIFOLD
02980570 - SEAL KIT, F/ RELIEF VALVE
29 02980568 1 RELIEF VALVE, 4061 PSI (280 BAR)
30 02980569 1 RELIEF VALVE, 4786 PSI (330 BAR)
31 02980237 2 O-RING
32 02980531 1 FLAT KEY
33 02980532 2 BALL
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -14
Page 18
50 IN MOTOR ASY - PARTS - PN 02979881 (PART 2)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -15
Page 19
50 IN MOTOR ASY - PARTS - PN 02979881 (PART 2)
Continued...
ITEM PART NO. QTY. DESCRIPTION
34 02980533 1 HEXAGON PLUG
35 02980534 2 O-RING
36 02980535 2 PLUG ASY
37 02980572 2 PLUG ASY
38 02980573 1 PLUG ASY
39 02980566 1 REBUILD KIT (ITEMS 2,7,8,10,15 & 17)
40 02980567 1 SEAL KIT (ITEMS 7,8 &10)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -16
Page 20
50 IN SPINDLE ASY - PN 02960553B
ITEM PART NO. QTY. DESCRIPTION
02960553B - SPINDLE & HOUSING ASY
1 02963815 1 HOUSING
2 02960561 1 SPINDLE
3 02960558 1 BEARING RING
4 02960559 1 SEAL
5 00754627 1 SNAP RING
6 02960557 1 BEARING ASY, CUP & CONE
7 00769938 1 BEARING ASY, CUP & CONE
8 02962030 1 NUT
9 02979570 1 GREASE RELIEF FITTING
10 00003500 1 GREASE FITTING
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -17
Page 21
60 IN BLADE CARRIER ASY (BAR) - PN 02969230
ITEM PART NO. QTY. DESCRIPTION
02969230 - BLADE BAR ASY
1 00020900 2 NUT
2 00023200 2 ROLL PIN
3 02969234 4 FLATWASHER
4 02761500 1 BLADE SET, MATCHED SET OF 2
5 02971387 1 BLADE BAR LEAF, TOP LEAF
6 02969232 1 BLADE BAR LEAF, MIDDLE LEAF
7 02969233 1 BLADE BAR LEAF, BOTTOM LEAF
8 02969235 2 BOLT, LONG BOLT
9 02969236 2 BOLT, SHORT BOLT
10 02782900 2 BLADE BOLT
11 02957089 2 LOCKWASHER
12 00003901 - LOCKWASHER, 3/4" PL HEAVY
13 02964861 - BOLT, SOCKET HEAD 3/4"-NC X 4" PL GR8
14 02984572 1 BLADE BOLTS, NUTS, ROLLPIN KIT (INCLUDES 2 EACH OF ITEMS 1, 2, & 10)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -18
Page 22
60 IN DOOR CYL ASY - PN 02961480A
ITEM PART NO. QTY. DESCRIPTION
02961480A - DOOR CYLINDER ASY
1 5JRC12160 1 LOCKNUT
2 33309 1 PISTON
3 02975865 1 ROD WLD`MT
4 02975866 1 TUBE / BARRELL WLD`MT
5 02975867 1 CYLINDER HEAD
6 * SEAL KIT 1 ROD WIPER SEAL (IN ITEM 12)
7 * SEAL KIT 1 ROD SEAL (IN ITEM 12)
8 * SEAL KIT 1 O-RING (IN ITEM 12)
9 * SEAL KIT 1 SEAL (IN ITEM 12)
10 * SEAL KIT 1 PISTON SEAL (IN ITEM 12)
11 ---------------- - O-RING F/ O-RING BOSS FITTING
12 02975528 1 SEAL KIT (ITEMS 6 THRU 10)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -19
Page 23
THIS PAGE INTENTIONAL LEFT BLANK
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -20
Page 24
60 IN HEAD ASY - SN 02050 & DOWN
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -21
Page 25
60 IN HEAD ASY - SN 02050 & DOWN
Continued...
ITEM PART NO. QTY. DESCRIPTION
02968858 - ROTARY HEAD ASY, 60" W/ BAR CARRIER (NON-SALABLE)
2 00011100 46 FLATWASHER
3 00015800 24 LOCKNUT
4 00007000 12 BOLT
5 00755153 2 COTTER PIN
6 02970595 1 BOLT
8 NFS 1 SERIAL NUMBER PLATE
9 02971701 1 SLOTTED NUT
10 00023100 11 BOLT
11 00756875 1 FLAP HOLD DOWN BAR
12 00759862 2 SHIELD, DEBRIS DEFLECTOR
13 02767500 1 HEX WRENCH, SPECIAL
14 02976448 1 PIN
15 02885700 2 REAR FLAP
16 02885800 1 REAR CLAMP BAR
17 651102 1 PIN
18 02960018 2 ADAPTER, ELBOW
19 02961480 1 CYLINDER ASY
20 02971720 1 PIN WLD`MT
21 02971756 1 PIN
22 02967775 1 DOOR
23 02967782 1 ROD, HINGE
24 02968836 1 PLASTIC TIE, YELLOW
25 02968837 3 PLASTIC TIE, YELLOW / WHITE
26 02968856 - ROTARY HEAD SUB-ASY, 60" (NON-SALABLE)
27 02968873 - DECALS, (SEE SAFETY SECTION)
28 02968874 1 HOSE, (LARGE) - W/ RED TIE - PRESSURE HOSE
29 02968875 1 HOSE, (LARGE) - W/ ORANGE TIE - RETURN HOSE
30 02968876 1 HOSE, (LARGE) - W/ BLUE TIE - CASE DRAIN
31 02968877 1 HOSE, (SMALL) - W/ YELLOW / WHITE - DOOR CYL
32 02968878 1 HOSE, (SMALL) - W/ YELLOW TIE - DOOR CYL
33 02968894 1 PLASTIC TIE, RED
34 02968895 1 PLASTIC TIE, BLUE
35 02968896 1 PLASTIC TIE, ORANGE
36 02971702 1 WASHER
37 3710151 2 METAL TACK
38 99338S 1 ROLL PIN
39 165020 1 COTTER PIN
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -22
Page 26
60 IN HEAD ASY - SN 02051 & UP
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -23
Page 27
60 IN HEAD ASY - SN 02051 & UP
Continued...
ITEM PART NO. QTY. DESCRIPTION
02968858 - ROTARY HEAD ASY, 60" W/BAR CARRIER (NON-SALABLE)
2 00011100 45 FLATWASHER
3 00015800 23 LOCKNUT
4 00007000 11 BOLT
5 00755153 2 COTTER PIN
6 02970595 1 BOLT
8 02971500 1 PLATE, ALAMO S/N
9 02971701 1 NUT
10 00023100 10 BOLT
11 00756875 1 FLAP HOLD DOWN BAR
12 00759862 2 SHIELD, DEBRIS DEFLECTOR
13 02767500 1 HEX WRENCH, MODIFIED
14 02976448 1 PIN, 2-1/2" LONG
15 02885700 1 REAR FLAP, 10" HIGH X 63" LONG
16 02885800 1 REAR CLAMP BAR
17 651102 1 PIN, 2" LONG
18 02960018 2 ADAPTER, ELBOW
19 02961480 1 CYLINDER ASY, DOOR
20 02971720 1 PIN WLD`MT, 11-1/2" LONG
21 02971756 1 PIN, 9" LONG
22 02971963 1 DOOR WLD`MT
23 02967782 1 ROD, HINGE
24 02968836 1 PLASTIC TIE, YELLOW
25 02968837 1 PLASTIC TIE, YELLOW & WHITE
26 02968856 1 60" SQ. HD SUB-ASY.
27 02968873 1 DECAL KIT
28 02968874 1 HOSE, # 16 W/ RED PLASTIC TIE
29 02968875 1 HOSE, # 16 W/ ORANGE PLASTIC TIE
30 02968876 1 HOSE, # 16 W/ BLUE PLASTIC TIE
31 02968877 1 HOSE, # 4 W/ YELLOW & WHITE PLASTIC TIE
32 02968878 1 HOSE, # 4 W/ YELLOW PLASTIC TIE
33 02968894 1 PLASTIC TIE, RED
34 02968895 1 PLASTIC TIE, BLUE
35 02968896 1 PLASTIC TIE, ORANGE
36 02971702 1 WASHER, NARROW
37 3710151 2 METAL TACK
38 99338S 2 ROLL PIN
39 00010600 2 BOLT
48 165020 1 COTTER PIN
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -24
Page 28
60 IN HEAD SUB-ASY - SN 02050 & DOWN
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -25
Page 29
60 IN HEAD SUB-ASY - SN 02050 & DOWN
Continued...
ITEM PART NO. QTY. DESCRIPTION
02968858 - ROTARY HEAD SUB-ASY, 60" (NON-SALABLE)
1 00003901 4 LOCKWASHER
2 00015800 14 LOCKNUT
3 00037200 16 LOCKNUT
4 00059700 14 BOLT
5 02979020 8 NUT
6 03200269 8 BOLT
7 02969230 1 BLADE BAR ASY
8 02892100 8 BOLT
9 02966899 2 SKID SHOE
10 02966900 1 DECK HEAD
11 02971928 1 HITCH POST
13 02964861 4 BOLT, SOCKET HEAD
14 5312316 16 FLATWASHER, HARDENED SPECIAL
15 15B600 14 WASHER
16 W67 16 WASHER
17 00019600 4 LOCKWASHER
18 00750316 2 HYDRAULIC FITTING, ELBOW
19 00750317 2 SPLIT FLANGE KIT
20 02891800 4 HYDRAULIC FITTING, ELBOW
21 02958782 1 ADAPTER, HYD, STRAIGHT
22 02961038 1 GASKET, SPINDLE / MOTOR
23 02967193B 1 MOTOR ASY
24 02968859A 1 SPINDLE HOUSING
25 02978878 1 MOTOR PLATE
26 02970752 4 TIE ROD
29 02979021 16 NUT
31 02972094 1 SEAL KIT, VALVE BLOCK TO MOTOR
32 02971574 1 CARTRIDGE, RELIEF (4000 PSI)
32A 02981685 1 O-RING
32B 02981686 1 O-RING
32C 02981687 1 O-RING
32D 02981688 2 BACK-UP RING
33 02979511 1 GASKET, END COVER
34 02977905 1 MOTOR SEAL KIT
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -26
Page 30
60 IN HEAD SUB-ASY - SN 02051 & UP
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -27
Page 31
60 IN HEAD SUB-ASY - SN 02051 & UP
Continued...
ITEM PART NO. QTY. DESCRIPTION
02968858 - ROTARY HEAD ASY. W/ BAR CARRIER (NON SALABLE)
1 00003901 4 LOCKWASHER
2 00015800 14 LOCKNUT
3 00037200 16 LOCKNUT
4 00059700 14 BOLT
5 02980237 2 O-RING
6 03200269 8 BOLT
7 02969230 1 BLADE BAR ASY
8 02892100 8 BOLT
9 02966899 2 SKID SHOE
10 02966900 1 DECK HEAD WLD`MT
11 02971928 1 HITCH POST WLD`MT
13 02964861 4 BOLT
14 5312316 16 WASHER, HARDENED
15 15B600 14 WASHER
16 02980236 8 BOLT
17 00019600 4 LOCKWASHER
18 02981819 2 ADP HYD STGHT 16FLH-16MJ SPCL
19 02981819 4 ADP HYD STGHT 16FLH-16MJ SPCL
20 02891800 4 BOLT
21 02980373 1 ADAPTER, HYD.
22 02961038 1 GASKET, SPINDLE TO MOTOR
23 02979881 1 MOTOR ASY, PISTON TYPE
24 02968859A 1 SPINDLE HOUSING, SPLINED
25 00022200 8 LOCKWASHER
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -28
Page 32
60 IN MOTOR ASY - PARTS - PN 02979881 - SN 02051 (PART 1)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -29
Page 33
60 IN MOTOR ASY - PARTS - PN 02979881 - SN 02051 (PART 1)
Continued...
ITEM PART NO. QTY. DESCRIPTION
02979881 - MOTOR ASY, PISTON TYPE
1 02980529 1 BARREL HOUSING ASY
2 02980530 1 VALVE PLATE (IN ITEM 39)
4 02980536 1 NOZZLE PLUG 2.5MM
5 02980537 1 PLUG ASY, HEXAGON
6 02980538 1 BEARING HOUSING
7 02980539 1 O-RING (IN ITEM 39 & 40)
8 02980540 1 O-RING (IN ITEM 39 & 40)
9 02980541 1 SEAL CARRIER
10 02980542 1 SHAFT SEAL (IN ITEM 39 & 40)
11 02980543 1 SPACER WASHER
02988818 1 SEAL, SHAFT
12 02980544 1 RETAINING RING
13 02980545 1 RETAINING RING
14 02980546 1 SHAFT ASY
15 02980548 1 CYLINDER BARREL (IN ITEM 39)
16 02980549 1 BARREL SUPPORT
17 02980550 7 PISTON ASY (IN ITEM 39)
18 02989112 1 KIT, 21 PISTON RINGS
19 02980552 1 RING GEAR
20 02980553 1 BEARING ASY, CUP & CONE
21 02980554 1 BEARING ASY, CUP & CONE
22 02980555 - SPACER WASHER
23 02980556 1 RETAINING RING
24 02980557 - SHIM, .020" (0.5)
02980558 - SHIM, .007" (0.2)
02980559 - SHIM, .015" (0.4)
02980560 - SHIM, .023" (0.6)
02980561 - SHIM, .030" (0.8)
02980562 - SHIM, .039" (1.0)
02980563 - SHIM, .027" (0.7)
25 02980564 4 BOLT, SOCKET HEAD
26 02980565 1 SAFETY VALVE
27 02980547 1 GUIDE PIN
28 02980571 1 RELIEF MANIFOLD
02980570 - SEAL KIT, F/ RELIEF VALVE
29 02980568 1 RELIEF VALVE, 4061 PSI (280 BAR)
30 02980569 1 RELIEF VALVE, 4786 PSI (330 BAR)
31 02980237 2 O-RING
32 02980531 1 FLAT KEY
33 02980532 2 BALL
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -30
Page 34
60 IN MOTOR ASY - PARTS - PN 02979881 - SN 02051 (PART 2)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -31
Page 35
60 IN MOTOR ASY - PARTS - PN 02979881 - SN 02051 (PART 2)
Continued...
ITEM PART NO. QTY. DESCRIPTION
34 02980533 2 PLUG, HEXAGON
35 02980534 2 O-RING
36 02980535 2 PLUG ASY
37 02980572 2 PLUG ASY
38 02980573 1 PLUG ASY
39 02980566 1 REBUILD KIT (ITEMS 2,7,8,10,15 & 17)
40 02980567 1 SEAL KIT (ITEMS 7,8 &10)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -32
Page 36
60 IN SPINDLE ASY - PN 02968859A
ITEM PART NO. QTY. DESCRIPTION
02968859 - SPINDLE ASY, F/ 60" ROTARY HEAD
1 02967204 1 SPINDLE SHAFT
2 02967126 1 SPINDLE HOUSING
3 02967197 1 LOWER BEARING ASY, CUP & CONE
4 02967196 1 UPPER BEARING ASY, CUP & CONE
5 02909500 2 NUT
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -33
Page 37
60 IN SPINDLE ASY - PN 02968859A
Continued...
ITEM PART NO. QTY. DESCRIPTION
6 02909600 1 TANG WASHER
7 02967198 1 SEAL
8 02959018 1 RELIEF PLUG
9 00003500 1 GREASE FITTING
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -34
Page 38
BOOM ASY - 17 FT (OPT ALLOY STEEL) - PN 02980034
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -35
Page 39
BOOM ASY - 17 FT (OPT ALLOY STEEL) - PN 02980034
Continued...
ITEM PART NO. QTY. DESCRIPTION
02980034 - BOOM ARM ASY, ALLOY STEEL OPTIONAL
1 02980033 1 LIFT SECTION WLD`MT, ALLOY STEEL OPTIONAL
2 02980029 1 DIPPER SECTION WLD`MT, ALLOY STEEL OPTIONAL
3 02979920 1 CYLINDER ASY, DIPPER
4 02979916 1 HYDRAULIC TUBE, F/ 17 FT
5 02979917 1 HYDRAULIC TUBE, F/ 17 FT
6 02979918 1 HYDRAULIC TUBE, F/ 17 FT
7 02968803 7 BUSHING, TEFLON
8 02968806 1 CYLINDER & BEARING ASY, TILT CYL
9 02972816 1 LINK ARM MACHINED
10 02968805 1 LINKAGE ARM & BUSHING ASY
11 02965448 2 ADAPTER, HYD
12 02919600 2 CAP, HYD (4FJ)
13 02971705 1 PIN WLD`MT, 12" LG
14 02971755 2 PIN, CHROME 1-1/2" X 9-9/16" LG
15 02971754 1 PIN, CHROME 1-1/2" X 8-5/16" LG
16 02971752 1 PIN, CHROME 1-1/2" X 6-11/16" LG
17 02971753 1 PIN, CHROME 1-1/2" X 7-9/16" LG
18 02971751 1 PIN, CHROME 1-1/2" X 5-3/16" LG
19 02971703 1 PIN WLD`MT, 14-15/16" LG
20 02979922 1 COVER, HYD TUBE
21 02979301 1 CLAMP, HYD TUBE
22 02964673 1 BOLT
23 02968838 1 CYLINDER ROD GUARD ASY
24 03200375 6 CLAMP, TUBE 1 - POSITION
25 02980038 1 HYDRAULIC TUBE, F/ 17 FT
26 02970595 6 BOLT
27 02971701 2 SLOTTED NUT
28 02971702 2 FLATWASHER
29 165020 2 COTTER PIN
30 00015800 6 LOCKNUT
31 02959154 3 ADAPTER, HYD
32 00002700 4 FLATWASHER
33 000245 4 BOLT
34 02968895 4 PLASTIC TIE, BLUE
35 02968894 4 PLASTIC TIE, RED
36 02968896 4 PLASTIC TIE, ORANGE
37 02980039 1 HYDRAULIC TUBE, F/ 17 FT
38 02980040 1 HYDRAULIC TUBE, F/ 17 FT
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -36
Page 40
BOOM ASY - 17 FT (STD STEEL) - PN 02979902
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -37
Page 41
BOOM ASY - 17 FT (STD STEEL) - PN 02979902
Continued...
ITEM PART NO. QTY. DESCRIPTION
02979902 - BOOM ASY, 17 FT. (STD STEEL)
1 02979903 1 LIFT SECTION WLD`MT (STD STEEL)
2 02979911 1 DIPPER SECTION WLD`MT (STD STEEL)
3 02979920 1 CYLINDER ASY, DIPPER
4 02979916 1 HYDRAULIC TUBE, F/ 17 FT
5 02979917 1 HYDRAULIC TUBE, F/ 17 FT
6 02979918 1 HYDRAULIC TUBE, F/ 17 FT
7 02968803 7 BUSHING, TEFLON
8 02968806 1 CYLINDER & BEARING ASY, TILT
9 02972816 1 LINK ARM, MACHINED
10 02968805 1 LINKAGE ARM & BUSHING ASY
11 02965448 2 ADAPTER, HYDRAULIC
12 02919600 2 CAP, HYDRAULIC (4FJ)
13 02971705 1 PIN WLD`MT, 12" LG
14 02971755 2 PIN, CHROME 1-1/2" X 9-9/16" LG
15 02971754 1 PIN, CHROME 1-1/2" X 8-5/16" LG
16 02971752 1 PIN, CHROME 1-1/2" X 6-11/16" LG
17 02971753 1 PIN, CHROME 1-1/2" X 7-9/16" LG
18 02971751 1 PIN, CHROME 1-1/2" X 5-3/16" LG
19 02971703 1 PIN WLD`MT, 14-15/16" LG
20 02979922 1 COVER, HYD TUBE
21 02979301 1 CLAMP, HYD TUBE
22 02964673 1 BOLT
23 02968838 1 CYLINDER ROD GUARD ASY
24 02980040 1 HYDRAULIC TUBE, 17 FT
25 03200375 6 CLAMP, TUBE 1 - POSITION
26 02980039 1 HYDRAULIC TUBE, F/ 17 FT
27 02980038 1 HYDRAULIC TUBE, F/ 17 FT
28 02970595 6 BOLT
29 02971701 2 SLOTTED NUT
30 02971702 2 FLATWASHER
31 165020 2 COTTER PIN
32 00015800 6 LOCKNUT
33 02959154 3 ADAPTER, HYD
34 00002700 4 FLATWASHER
35 000245 4 BOLT
36 02968895 4 PLASTIC TIE, BLUE
37 02968894 4 PLASTIC TIE, RED
38 02968896 4 PLASTIC TIE, ORANGE
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -38
Page 42
BOOM ASY - 21 FT (STD & ALLOY STEEL) (PART 1)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -39
Page 43
BOOM ASY - 21 FT (STD & ALLOY STEEL) (PART 1)
Continued...
ITEM PART NO. QTY. DESCRIPTION
02968801 - BOOM ARM ASY, W/ STD STEEL BOOM
02970852 - BOOM ARM ASY, W/ ALLOY STEEL BOOM
3 00002700 8 FLATWASHER
4 165020 2 COTTER PIN
5 000245 8 BOLT
6 02970595 6 BOLT
9 02971701 2 SLOTTED NUT
10 02964673 1 BOLT
11 02968722 - DIPPER SECTION WLD`MT, F/ STD STEEL BOOM
02970849 - DIPPER SECTION WLD`MT, F/ ALLOY STEEL BOOM
12 02972816 1 LINK ARM WLD`MT
13 02971751 2 PIN, CHROME 1-1/2" X 5-3/16" LONG
14 02971754 1 PIN, CHROME 1-1/2" X 8-5/16" LONG
15 02971753 1 PIN, CHROME 1-1/2" X 7-9/16" LONG
16 02971752 1 PIN, CHROME 1-1/2" X 6-11/16" LONG
17 02971703 1 PIN WLD`MT, 14-15/16" LONG
18 02971705 1 PIN WLD`MT, 12" LONG
19 02971755 2 PIN, CHROME 1-1/2" X 9-9/16" LONG
20 02968717 1 HYDRAULIC TUBE, DIPPER SECTION (RED TIE)
21 02968718 1 HYDRAULIC TUBE, DIPPER SECTION (ORANGE TIE)
22 02968719 1 HYDRAULIC TUBE, DIPPER SECTION (BLUE TIE)
23 02968714 1 HYDRAULIC TUBE, LIFT SECTION (RED TIE)
24 02968715 1 HYDRAULIC TUBE, LIFT SECTION (ORANGE TIE)
25 02968716 1 HYDRAULIC TUBE, LIFT SECTION (BLUE TIE)
26 02972156 1 COVER PLATE
27 02968713 1 LIFT SECTION WLD`MT, F/ STD STEEL BOOM
02970848 1 LIFT SECTION WLD`MT, F/ ALLOY STEEL BOOM
28 02968802 1 DIPPER CYLINDER ASY
29 02968803 7 BUSHING, TEFLON
30 02968805 1 LINKAGE ARM ASY, W/ BUSHINGS
02968803 4 BUSHING, TEFLON (INCLUDED IN LINKAGE ARM ASY)
31 02968806 1 TILT CYLINDER ASY
32 03200375 12 CLAMP
33 02959283 2 TUBE CLAMP
34 02971702 2 WASHER
35 02968838 1 CYLINDER GUARD
36 02965448 2 BULK HEAD FITTING
37 02959154 3 ADAPTER ELBOW, 45 DEG
38 02919600 2 BULK HEAD CAP NUT
39 00015800 7 LOCKNUT
40 02968894 4 PLASTIC TIE, RED
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -40
Page 44
BOOM ASY - 21 FT (STD & ALLOY STEEL) (PART 2)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -41
Page 45
BOOM ASY - 21 FT (STD & ALLOY STEEL) (PART 2)
Continued...
ITEM PART NO. QTY. DESCRIPTION
41 02968895 4 PLASTIC TIE, BLUE
42 02968896 4 PLASTIC TIE, ORANGE
61 02979028 1 BOLT
63 02972157 1 COVER
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -42
Page 46
BOOM ASY - 24 FT (STD & ALLOY STEEL) (PART 1)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -43
Page 47
BOOM ASY - 24 FT (STD & ALLOY STEEL) (PART 1)
Continued...
ITEM PART NO. QTY. DESCRIPTION
02968861 - BOOM ARM ASY, F/ STD STEEL BOOM
02970853 - BOOM ARM ASY, F/ ALLOY STEEL BOOM
3 00002700 8 FLATWASHER
4 165020 2 COTTER PIN
5 000245 8 BOLT
6 02970595 6 BOLT
9 02971701 2 SLOTTED NUT
10 02964673 1 BOLT
11 02967380 - DIPPER SECTION WLD`MT, F/ STD STEEL BOOM
02970851 - DIPPER SECTION WLD`MT, F/ ALLOY STEEL BOOM
12 02972816 1 LINK ARM WLD`MT
13 02971751 2 PIN, CHROME 1-1/2" X 5-3/16" LG
14 02971754 1 PIN, CHROME 1-1/2" X 8-5/16" LG
15 02971753 1 PIN, CHROME 1-1/2" X 7-9/16" LG
16 02971752 1 PIN, CHROME 1-1/2" X 6-11/16" LG
17 02971703 1 PIN WLD`MT, 14-15/16" LG
18 02971705 1 PIN WLD`MT, 12" LG
19 02971755 2 PIN, CHROME 1-1/2" X 9-9/16" LG
20 02967947 1 HYDRAULIC TUBE, DIPPER SECTION (RED TIE)
21 02967948 1 HYDRAULIC TUBE, DIPPER SECTION (ORANGE TIE)
22 02967949 1 HYDRAULIC TUBE, DIPPER SECTION (BLUE TIE)
23 02968145 1 HYDRAULIC TUBE, LIFT SECTION (RED TIE)
24 02968146 1 HYDRAULIC TUBE, LIFT SECTION (ORANGE TIE)
25 02968147 1 HYDRAULIC TUBE, LIFT SECTION (BLUE TIE)
26 02972157 1 COVER PLATE
27 02967640 1 LIFT SECTION WLD`MT, F/ STD STEEL BOOM
02970850 1 LIFT SECTION WLD`MT, F/ ALLOY STEEL BOOM
28 02968802 1 DIPPER CYLINDER ASY
29 02968803 7 BUSHING, TEFLON
30 02968805 1 LINKAGE ARM ASY, W/ BUSHINGS
02968803 4 BUSHING, TEFLON (INCLUDED IN LINKAGE ARM ASY)
31 02968806 1 TILT CYLINDER ASY
32 03200375 12 CLAMP
33 02959283 2 TUBE CLAMP
34 02971702 2 WASHER
35 02968838 1 CYLINDER GUARD
36 02965448 2 BULK HEAD FITTING
37 02959154 3 ADAPTER ELBOW, 45 DEG
38 02919600 2 BULK HEAD CAP NUT
39 00015800 7 LOCKNUT
40 02968894 4 PLASTIC TIE, RED
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -44
Page 48
BOOM ASY - 24 FT (STD & ALLOY STEEL) (PART 2)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -45
Page 49
BOOM ASY - 24 FT (STD & ALLOY STEEL) (PART 2)
Continued...
ITEM PART NO. QTY. DESCRIPTION
41 02968895 4 PLASTIC TIE, BLUE
42 02968896 4 PLASTIC TIE, ORANGE
61 02979028 1 BOLT
63 02972158 1 COVER
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -46
Page 50
BOOM HOSE SCHEMATIC - 17 FT BOOM ARM
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -47
Page 51
BOOM HOSE SCHEMATIC - 17 FT BOOM ARM
Continued...
ITEM PART NO. QTY. DESCRIPTION
02979902 - BOOM ARM ASY, F/ STD STEEL BOOM
02980034 - BOOM ARM ASY, F/ ALLOY STEEL BOOM
43 02753400 6 PLASTIC TIE
44 02980018 1 HOSE, 134" (SMALL) W/ YELLOW / WHITE TIE
45 02980019 1 HOSE, 134" (SMALL) W/ YELLOW TIE
46 02906300 1 HOSE SLEEVING, 48" LG
47 02969124 1 HOSE, 60" (SMALL) W/ YELLOW / WHITE TIE
48 02969124 1 HOSE, 60" (SMALL) W/ YELLOW TIE
49 02961085 1 HOSE SLEEVING, 54" LG
50 02980014 1 HOSE, (LARGE) - W/ RED TIE
51 02980015 1 HOSE, (LARGE) - W/ BLUE TIE
52 02980016 1 HOSE, (LARGE) - W/ ORANGE TIE
53 02980020 1 HOSE, (MEDIUM) - W/ BLUE TIE
54 02980021 1 HOSE, (MEDIUM) - W/ BLUE / WHITE TIE
55 02980022 1 HOSE, (MEDIUM) - W/ RED TIE
56 02980023 1 HOSE, (MEDIUM) - W/ RED / WHITE TIE
57 02968807 2 RUBBER GROMMET
59 02968808 1 HOSE SLEEVING, 36" LG
60 02956918 - CAP NUT, F/ SHIPPING ONLY
61 02979240 1 HOSE SLEEVING, 2-1/2" ID X 36" LG
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -48
Page 52
BOOM HOSE SCHEMATIC - 21 FT BOOM ARM
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -49
Page 53
BOOM HOSE SCHEMATIC - 21 FT BOOM ARM
Continued...
ITEM PART NO. QTY. DESCRIPTION
02968801 - BOOM ARM ASY, STD STEEL (OPTIONAL)
02970852 - BOOM ARM ASY, ALLOY STEEL (OPTIONAL)
43 02753400 6 PLASTIC TIE
44 02969121 1 HOSE, 184" (SMALL) - W/ YELLOW / WHITE TIE
45 02969122 1 HOSE, 184" (SMALL) - W/ YELLOW TIE
46 02906300 1 HOSE SLEEVING, 48" LG
47 02969123 1 HOSE, 60" (SMALL) - W/ YELLOW / WHITE TIE
48 02969124 1 HOSE, 60" (SMALL) - W/ YELLOW TIE
49 02961085 2 HOSE SLEEVING, 54" LG
50 02968159 1 HOSE, (LARGE) - W/ RED TIE
51 02968160 1 HOSE, (LARGE) - W/ BLUE TIE
52 02968827 1 HOSE, (LARGE) - W/ ORANGE TIE
53 02968151 1 HOSE, (MEDIUM) - W/ BLUE TIE
54 02968152 1 HOSE, (MEDIUM) - W/ BLUE / WHITE TIE
55 02968153 1 HOSE, (MEDIUM) - W/ RED TIE
56 02968154 1 HOSE, (MEDIUM) - W/ RED / WHITE TIE
57 02968807 2 RUBBER GROMMET
59 02968808 1 HOSE SLEEVING
60 02956918 - CAP NUT, F/ SHIPPING ONLY
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -50
Page 54
BOOM HOSE SCHEMATIC - 24 FT BOOM ARM
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -51
Page 55
BOOM HOSE SCHEMATIC - 24 FT BOOM ARM
Continued...
ITEM PART NO. QTY. DESCRIPTION
02968861 - BOOM ARM ASY, STD STEEL (OPTIONAL)
02970853 - BOOM ARM ASY, ALLOY STEEL (OPTIONAL)
43 02753400 6 PLASTIC TIE
44 02969121 1 HOSE, 184" (SMALL) - W/ YELLOW / WHITE TIE
45 02969122 1 HOSE, 184" (SMALL) - W/ YELLOW TIE
46 02906300 1 HOSE SLEEVING, 48" LG
47 02969125 1 HOSE, 120" (SMALL) - W/ YELLOW / WHITE TIE
48 02969126 1 HOSE, 120" (SMALL) - W/ YELLOW TIE
49 02961085 2 HOSE SLEEVING, 54" LG
50 02968159 1 HOSE, (LARGE) - W/ RED TIE
51 02968160 1 HOSE, (LARGE) - W/ BLUE TIE
52 02968827 1 HOSE, (LARGE) - W/ ORANGE TIE
53 02968862 1 HOSE, (MEDIUM) - W/ BLUE TIE
54 02968863 1 HOSE, (MEDIUM) - W/ BLUE / WHITE TIE
55 02968864 1 HOSE, (MEDIUM) - W/ RED TIE
56 02968154 1 HOSE, (MEDIUM) - W/ RED / WHITE TIE
57 02968807 2 RUBBER GROMMET
59 00751838 1 HOSE SLEEVING
60 02956918 - CAP NUT, F/ SHIPPING ONLY
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -52
Page 56
BUZZ BAR - HYD MOTOR PARTS - P/N 02975175
ITEM PART NO. QTY. DESCRIPTION
02975175 - MOTOR GEAR ASY
1 02962210 1 SNAP RING
2 02964940 1 * SPACER
3 02976771 1 SEAL RETAINER
4 -------------- 1 * SEAL
5 02964704 1 MOUNTING FLANGE W/ BUSHINGS
6 02961940 1 PLUG
7 02961931 2 CHECK ASY
8 -------------- 4 * SEAL END
9 -------------- 2 * * THRUST PLATE
10 02964937 1 GEAR SET
11 -------------- 2 * SQUARE SEAL
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -53
Page 57
BUZZ BAR - HYD MOTOR PARTS - P/N 02975175
Continued...
ITEM PART NO. QTY. DESCRIPTION
12 02961924 4 DOWEL PIN
13 02962205 1 GEAR HOUSING
14 02976773 1 PORTING FLANGE W/ BUSHINGS
15 02961917 4 WASHER
16 02962208 4 BOLT
17 -------------- 4 * SIDE SEAL ( NOT SHOWN )
18 02964956 1 KEY
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -54
Page 58
BUZZ BAR ASY - 48 IN - GEN 1 (PART 1)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -55
Page 59
BUZZ BAR ASY - 48 IN - GEN 1 (PART 1)
Continued...
ITEM PART NO. QTY. DESCRIPTION
02979265 - SAW HEAD ASY, 48 INCH 2 BLADE
1 02974237 4 END CAP
2 02974238 2 BLADE SPACER
3 02974235 3 SPINDLE ASY
4 02974659 8 BOLT, SOCKET HEAD CNTR-SNK 1/2"-NC X 3-1/2"
5 02974658 8 BOLT, SOCKET HEAD CNTR-SNK 1/2"-NC X 2"
6 02976017 16 SLOTTED NUT, 1/2"-NC PLB
7 00001200 6 HEX NUT, 1/2"-NC PL
8 02979269 1 SAW BODY WLD`MT, 2 BLADE
9 02974225 3 BRACKET TENSION ADJUSTMENT
10 00750614 16 LUG NUT, 1/2"-20NF 90DEG
11 002521 3 BOLT, HEX HEAD 1/2"-NC X 3-1/2" PL GR5
12 02974241 3 V-BELT
13 02974239 4 SHEAVE, W/GROOVE
14 02974240 4 BUSHING QD
15 02979271 1 BELT COVER, LEFT 2
16 02975441 9 STUD, QUICK RELEASE W/RING
17 02975440 9 RETAINER F/ QUICK RELEASE
18 02975439 9 RECEIVER F/ QUICK RELEASE
19 00011400 1 BOLT, HEX HEAD 3/8"-NC X 1" PL GR5
20 00011100 10 FLATWASHER, 3/8" PL STD
21 00001800 6 LOCKNUT, 1/2"-NC PLB
22 02978249 1 DRIVE SPINDLE ASY
23 8301295 1 MOTOR, PISTON-2.48 CU.IN./REV
24 00749130 8 BOLT, HEX HEAD 1/2"-13NC X 1-3/4" PL GR5
25 02978267 1 HUB, 1-1/8" BORE & 1/4" KEY
26 02978268 1 INSERT, URETHANE
27 02978269 1 COVER, PROTECTIVE NYLON
28 02978270 1 HUB, 1-1/8" BORE & 5/16" KEY
29 02979296 1 SHEET, BELT COVER SHORT
30 02976149 1 HITCH POST WLD`MT
31 00037200 6 LOCKNUT, 3/4"-NC PLC
32 02970324 1 HITCH POST CLAMP PLATE
33 02918600 6 BOLT, HEX HEAD 3/4"-10NC X 2" PL GR8
34 02979272 1 MOUNT TUBE WLD`MT, 2 BLADE
35 00015800 9 LOCKNUT, 3/8"-NC PLB
36 00023100 8 BOLT, HEX HEAD 3/8"-16NC X 1-1/2" PL GR5
37 02974207 1 BUMPER
38 02979274 1 REAR SHIELD WLD`MT
39 02975600 - SAW BLADE PACKAGE OF 2
40 02968894 1 PLASTIC TIE, 11" LG (RED TIE)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -56
Page 60
BUZZ BAR ASY - 48 IN - GEN 1 (PART 2)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -57
Page 61
BUZZ BAR ASY - 48 IN - GEN 1 (PART 2)
Continued...
ITEM PART NO. QTY. DESCRIPTION
41 02957622 2 ADAPTER, HYD STRAIGHT
42 02968896 1 PLASTIC TIE, 11" LG (ORANGE TIE)
43 02970466 2 ADAPTER, HYD, TEE
44 02975437 1 HOSE, # 16 - 16FJX - 16FJX45 - 74" LG (RED TIE)
45 02969678 1 HOSE, #16 - 16FJX - 16FJX45 - 74" LG (ORANGE TIE)
46 02969464 3 ADAPTER, HYD REDUCER
47 02972981 1 HOSE, # 8 - 8FJX - 8FJX - 80" LG (BLUE TIE)
48 02975438 1 ADAPTER, HYD STRAIGHT 8MB - 8FJX
49 02962213 1 ADAPTER, HYD ELBOW
50 02158800 1 HOSE, # 8 - 8FJX - 8FJX - 17" LG
51 00758194 1 DECAL, WARNING BELT SHIELD
52 00769736 1 DECAL, USE/REPAIR GUARDS
53 00769737 1 DECAL, BLADES THROWN OBJECTS
54 02925100 1 DECAL, REPLACEMENT PARTS
55 02958241 1 DECAL, TRACTOR OPERATOR SAFETY
56 02962764 1 DECAL, PINCH POINTS
57 00756004 1 DECAL, SHIELD MISSING
58 02965262 1 DECAL, WARNING HOSE BURST
59 02967827 1 DECAL, MULTI HAZ
60 02960766 2 DECAL, ALAMO INDUSTRIAL LOGO
61 02974998 1 DECAL, BUZZBAR
62 D138 1 DECAL, CW BLADE ROTATION
63 02975158 1 DECAL, HEAR PROTECTION REQD
64 02975170 1 DECAL, ROTATING BLADES
65 02975515 1 DECAL, WARNING DISCONNECT
66 02975516 1 DECAL, NO HITCH POST HERE
68 ---NFS----- - PLATE, SERIAL NUMBER BB90
69 ---NFS----- - METAL TACK
70 02979546 1 DECAL, ALAMO IND. GREEN & BLACK
71 1458392 1 DECAL, RED REFLECTOR
72 1458393 1 DECAL, YELLOW REFLECTOR
73 00696800 1 ADAPTER, HYD STRAIGHT
74 02971720 1 PIN WLD`MT, 11-1/2" LG
75 02971702 1 FLATWASHER, 1-3/8" TYPE B NARROW
76 02971701 1 SLOTTED NUT, 1-3/8"-12NF PLB
77 165020 1 COTTER PIN, 5/16" X 2-1/2" PL
78 02970595 1 BOLT, HEX HEAD 3/8"-NC X 2-3/4" PL GR8
79 02971756 1 PIN, CHROME 1-1/2" X 9"
80 02669600 5 KEY, 1/4" X 1/4" X 1-1/4" LG
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -58
Page 62
BUZZ BAR ASY - 48 IN - GEN 1 (PART 3)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -59
Page 63
BUZZ BAR ASY - 48 IN - GEN 1 (PART 3)
Continued...
ITEM PART NO. QTY. DESCRIPTION
82 02975928 1 INSERT SHEET, BUZZBAR MACHETE
83 02975964 1 RELIEF MANIFOLD ASY, 2900 PSI
84 02919600 2 CAP NUT, # 4FJ
85 02968895 1 PLASTIC TIE, 11" LG
86 40010000 16 COTTER PIN, 1/8" X 1"
87 63000500 16 WASHER, PLATED
88 02979262 1 MOTOR MOUNT TUBE, MACHINED
89 02979546 1 DECAL, ALAMO IND. GREEN & BLACK
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -60
Page 64
BUZZ BAR ASY - 48 IN - GEN 2 (PART 1)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -61
Page 65
BUZZ BAR ASY - 48 IN - GEN 2 (PART 1)
Continued...
ITEM PART NO. QTY. DESCRIPTION
02986236 1 ASY, 2 BLADE BUZZBAR, PISTON
1 02983631 1 WELDMENT, SAW BODY 2 BLADE
2 02974207 1 BUMPER
3 02979274 1 WLDMT, REAR SHIELD 2 BLADE
4 02979262 1 MACHINED TUBE, MOTOR MOUNT
5 02978249 1 ASSEMBLY, SPINDLE SHAFT
6 02974238 1 BLADE SPACER
7 02974237 2 PLATE, SHAFT END CAP
8 02974235 1 HUB ASSY
9 02974236 2 BLADES
10 02974225 1 BRACKET TENSION ADJUST
11 00001200 2 NUT HEX 1/2 NC
12 002521 1 HHCS 1/2 NC 3-1/2, FULL THREAD
13 00750614 8 NUT 1/2 NF
14 02974659 4 FLAT SOCKET HEAD 1/2 NC X 3-1/2 W/ HOLE
15 02974658 4 FLAT SOCKET HEAD 1/2 NC X 2" W/ HOLE
16 02976017 8 SLOT NUT
17 02974239 2 SHEAVE
18 02974240 2 QD BUSHING
19 02974241 1 BELT, MICRO-V
20 02669600 3 SQ KEY
21 02978267 1 HUB, 20R10 W/1-1/8" BORE
22 02978268 1 INSERT, URETHANE
23 02978269 1 COVER, NYLON
24 02978270 1 HUB, 20R10 W/1-1/8" BORE
25 02984677 7 SLIP ON RECEPTACLE 9MM
26 02979271 1 SHEET, BELT COVER, LEFT 2 BLADE
27 02979296 1 BELT COVER, SHORT
28 8301295 1 PISTON MOTOR
29 00001800 2 LOCKNUT TLM 1/2 NC PLB
30 00749130 2 HHCS 1/2 -13UNC 1 3/4 PL5
31 02968894 1 PLASTIC TIE, RED, 11LG
32 02968896 1 PLASTIC TIE, ORANGE, 11LG
33 02970324 1 PLATE-CLAMP, HITCHPOST
34 02986218 1 WELDMENT, HITCHPOST
35 00037200 6 NUT 3/4 NC LOCKNUT
36 02918600 6 HHCS 3/4 NC 2 PL8
37 02984678 7 STUD 9MM 1/4 TURN
38 00011400 1 BOLT, HHCS 3/8 NC 1 PL5
39 00011100 10 FLATWASHER 3/8 STD
40 00015800 11 LOCKNUT TLM 3/8 NC PLC
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -62
Page 66
BUZZ BAR ASY - 48 IN - GEN 2 (PART 2)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -63
Page 67
BUZZ BAR ASY - 48 IN - GEN 2 (PART 2)
Continued...
ITEM PART NO. QTY. DESCRIPTION
41 00023100 10 HHCS 3/8 -16UNC 1-1/2 PL5
42 02981757 2 WELDMENT, PIN, HITCH POST
43 165020 2 PIN, COTTER 5/16 X 2-1/2 PL
44 02971701 2 NUT SLOT 1-3/8 12NF PLB
45 02971702 2 FLATWASHER 1-3/8 TYPE B NARROW
46 02969678 1 HOSE #16-16FJX -16FJX45- 74LG
47 02975437 1 HOSE #16-16FJX -16FJX45- 74LG
48 02957622 2 ADP HYD STGHT 16MB-16MJ
49 02970466 2 ADP HYD TEE 16FJX-16MJ-16MJ
50 00696800 1 ADP HYD STGHT 8MB-8MJ
51 02972981 1 HOSE #8 - 8FJX - 8FJX - 80LG
52 02969464 3 ADP HYD STGHT 16FJ-8MJ
53 02975438 1 ADP HYD STGHT 8MB - 8FJX
54 02975964 1 ASY RELIEF MANIFOLD 2900 PSI
55 02962213 1 ADP HYD ELBOW 8MB - 8MJ 90?
56 02158800 1 HOSE #8 - 8FJX - 8FJX - 17LG
57 02968895 1 PLASTIC TIE BLUE 11LG
58 63000500 8 WASHER, FLAT, PLATED
59 40010000 8 PIN, COTTER 1/8 X1
02961085 1 CORDURA SLEEVING-54 LG
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -64
Page 68
BUZZ BAR ASY - 69 IN - GEN 1 (PART 1)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -65
Page 69
BUZZ BAR ASY - 69 IN - GEN 1 (PART 1)
Continued...
ITEM PART NO. QTY. DESCRIPTION
02979249 - SAW BLADE HEAD ASY, 69" (3 BLADE)
1 02974237 4 END CAP
2 02974238 2 BLADE SPACER
3 02974235 3 SPINDLE ASY
4 02974659 4 BOLT, SOCKET CNTR-SNK 1/2"-NC X 3-1/2" W/HOLE
5 02974658 8 BOLT, SOCKET CNTR-SNK 1/2"-NC X 2" W/HOLE
6 02976017 12 SLOTTED NUT, 1/2"-NC PLB
7 00001200 6 HEX NUT, 1/2"-NC PL
8 02979253 1 SAW BODY WLD`MT, 3 BLADE
9 02974225 3 TENSION ADJUSTMENT BRACKET
10 00750614 16 LUG NUT, 1/2"-20NF 90DEG
11 002521 3 BOLT, HEX HEAD 1/2"-NC X 3-1/2" PL GR5
12 02974241 3 V-BELT
13 02974239 3 SHEAVE W/GROOVE
14 02974240 3 BUSHING, QD
15 02979255 1 SHEET, BELT COVER, LEFT 3 BLADE
16 02975441 9 STUD, QUICK RELEASE W/RING
17 02975440 9 RETAINER F/QUICK RELEASE
18 02975439 9 RECEIVER F/ QUICK RELEASE
19 00011400 1 BOLT, HEX HEAD 3/8"-NC X 1 PL GR5
20 00011100 10 FLATWASHER, 3/8" PL STD
21 00001800 6 LOCKNUT, 1/2"-NC PLB
22 02978249 1 DRIVE SPINDLE ASY
23 8301295 1 MOTOR, PISTON-2.48 CU.IN./REV
24 00749130 8 BOLT, HEX HEAD 1/2"-13NC X 1-3/4" PL GR5
25 02978267 1 HUB, 1-1/8" BORE X 1/4" KEY
26 02978268 1 INSERT, URETHANE
27 02978269 1 COVER, PROTECTIVE NYLON
28 02978270 1 HUB, 1-1/8" BORE X 5/16" KEY
29 02979296 1 BELT COVER, SHORT
30 02976149 1 HITCH POST WLD`MT
31 00037200 6 LOCKNUT, 3/4"-NC PLC
32 02970324 1 PLATE, HITCH POST CLAMP
33 02918600 6 BOLT, HEX HEAD 3/4"-10NC X 2" PL GR8
34 02979256 1 HITCH TUBE WLD`MT, 3 BLADE
35 00015800 9 LOCKNUT, 3/8"-NC PLB
36 00023100 8 BOLT, HEX HEAD 3/8"-16NC X 1-1/2" PL GR5
37 02974207 1 BUMPER
38 02979258 1 SHIELD WLD`MT, REAR
39 02975600 - SAW BLADE PACKAGE OF 2
40 02968894 1 PLASTIC TIE, 11" LG
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -66
Page 70
BUZZ BAR ASY - 69 IN - GEN 1 (PART 2)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -67
Page 71
BUZZ BAR ASY - 69 IN - GEN 1 (PART 2)
Continued...
ITEM PART NO. QTY. DESCRIPTION
41 02957622 2 ADAPTER, HYD STRAIGHT
42 02968896 1 PLASTIC TIE, 11" LG
43 02970466 2 ADAPTER, HYD TEE
44 02975437 1 HOSE, # 16 - 16FJX - 16FJX45 - 74" LG (ORANGE TIE)
45 02969678 1 HOSE, # 16 - 16FJX - 16FJX45 - 74" LG (RED TIE)
46 02969464 3 ADAPTER, HYD REDUCER
47 02972981 1 HOSE, # 8 - 8FJX - 8FJX - 80" LG (BLUE TIE)
48 02975438 1 ADAPTER, HYD STRAIGHT 8MB - 8FJX
49 02962213 1 ADAPTER, HYD ELBOW
50 02158800 1 HOSE, # 8 - 8FJX - 8FJX - 17" LG
51 00758194 1 DECAL, WARNING BELT SHIELD
52 00769736 1 DECAL, USE/REPAIR GUARDS
53 00769737 1 DECAL, BLADES THROWN OBJECTS
54 02925100 1 DECAL, REPLACE PARTS
55 02958241 1 DECAL, TRACTOR OPERATOR SAFETY
56 02962764 1 DECAL, PINCH POINTS
57 00756004 1 DECAL, SHIELD MISSING
58 02965262 1 DECAL, WARNING HOSE BURST
59 02967827 1 DECAL, MULTI HAZ
60 02960766 2 DECAL, ALAMO INDUSTRIAL LOGO
61 02974998 1 DECAL, BUZZBAR
62 D138 1 DECAL, BLADE ROTATION
63 02975158 1 DECAL, HEAR PROTECTION REQD
64 02975170 1 DECAL, ROTATING BLADES
65 02975515 1 DECAL, WARNING DISCONNECT
66 02975516 1 DECAL, NO HITCH POST HERE
68 ---NFS----- - SERIAL NUMBER PLATE BB90
69 ---NFS----- - METAL TACK
70 02979546 1 DECAL, ALAMO IND. GREEN & BLACK
71 1458392 1 DECAL, RED REFLECTOR
72 1458393 1 DECAL, YELLOW REFLECTOR
73 00696800 1 ADAPTER, HYD STRAIGHT
74 02971720 1 PIN WLD`MT, 11-1/2" LG
75 02971702 1 FLATWASHER, 1-3/8" TYPE B NARROW
76 02971701 1 SLOTTED NUT, 1-3/8"-12NF PLB
77 165020 1 COTTER PIN, 5/16" X 2-1/2" PL
78 02970595 1 BOLT, HEX HEAD 3/8"-NC X 2-3/4" PL GR8
79 02971756 1 PIN, 1-1/2" X 9" CHROME
80 02669600 4 KEY, 1/4" SQ KEY 1-1/4" LG.
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -68
Page 72
BUZZ BAR ASY - 69 IN - GEN 1 (PART 3)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -69
Page 73
BUZZ BAR ASY - 69 IN - GEN 1 (PART 3)
Continued...
ITEM PART NO. QTY. DESCRIPTION
82 02975928 1 INSERT SHEET, BUZZBAR MACHETE
83 02975964 1 RELIEF MANIFOLD ASY, 2900 PSI
84 02919600 2 CAP NUT, # 4FJ
85 02968895 1 PLASTIC TIE, 11" LG
86 40010000 12 COTTER PIN, 1/8" X 1"
87 63000500 12 WASHER, PLATED
88 02979262 1 MOTOR MOUNT TUBE, MACHINED
89 02979546 1 DECAL, ALAMO IND. GREEN & BLACK
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -70
Page 74
BUZZ BAR ASY - 69 IN - GEN 2 (PART 1)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -71
Page 75
BUZZ BAR ASY - 69 IN - GEN 2 (PART 1)
Continued...
ITEM PART NO. QTY. DESCRIPTION
02986237 1 ASY, 3 BLADE BUZZBAR, PISTON
1 02983632 1 WELDMENT, SAW BODY 3 BLADE
2 02974207 1 BUMPER
3 02979258 1 WLDMT, SHIELD 3 BLADE
4 02974225 2 BRACKET TENSION ADJUST
5 02979262 1 MACHINED TUBE, MOTOR MOUNT
6 02974235 2 HUB ASSY
7 02978249 1 ASSEMBLY, SPINDLE SHAFT
8 02974237 3 PLATE, SHAFT END CAP
9 02974238 1 BLADE SPACER
10 00750614 12 NUT 1/2 NF
11 02974236 3 BLADES
12 02974659 4 FLAT SOCKET HEAD 1/2 NC X 3-1/2 W/ HOLE
13 02974658 8 FLAT SOCKET HEAD 1/2 NC X 2" W/ HOLE
14 02976017 12 SLOT NUT
15 002521 2 HHCS 1/2 NC 3-1/2, FULL THREAD
16 00001200 4 NUT HEX 1/2 NC
17 00011100 10 FLATWASHER 3/8 STD
18 02974239 3 SHEAVE
19 02974240 3 QD BUSHING
20 02974241 2 BELT, MICRO-V
21 02984678 8 STUD 9MM 1/4 TURN
22 02984677 8 SLIP ON RECEPTACLE 9MM
23 02978267 1 HUB, 20R10 W/1-1/8" BORE
24 02669600 4 SQ KEY
25 02978268 1 INSERT, URETHANE
26 02978269 1 COVER, NYLON
27 02978270 1 HUB, 20R10 W/1-1/8" BORE
28 00011400 3 BOLT, HHCS 3/8 NC 1 PL5
29 00023100 8 HHCS 3/8 X 1-1/2 NC PL GR5
30 00015800 9 LOCKNUT TLM 3/8 NC PLC
31 8301295 1 PISTON MOTOR
32 00749130 2 HHCS 1/2 -13UNC 1 3/4 PL5
33 00001800 2 LOCKNUT TLM 1/2 NC PLB
34 02968894 1 PLASTIC TIE, RED, 11LG
35 02968896 1 PLASTIC TIE, ORANGE, 11LG
36 02979296 1 BELT COVER, SHORT
37 02979255 1 BELT COVER, LEFT 3 BLADE
38 02970324 1 PLATE-CLAMP, HITCHPOST
39 02986218 1 WELDMENT, HITCHPOST
40 00037200 6 NUT 3/4 NC LOCKNUT
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -72
Page 76
BUZZ BAR ASY - 69 IN - GEN 2 (PART 2)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -73
Page 77
BUZZ BAR ASY - 69 IN - GEN 2 (PART 2)
Continued...
ITEM PART NO. QTY. DESCRIPTION
41 02918600 6 HEXB 3/4-10UNC 2 PL8
42 02981757 2 WELDMENT, PIN, HITCH POST
43 02971702 2 FLATWASHER 1-3/8 TYPE B NARROW
44 02971701 2 NUT SLOT 1-3/8 12NF PLB
45 165020 2 PIN, COTTER 5/16 X 2-1/2 PL
46 02957622 2 ADP HYD STGHT 16MB-16MJ
47 02970466 2 ADP HYD TEE 16FJX-16MJ-16MJ
48 02969678 1 HOSE #16-16FJX -16FJX45- 74LG
49 02975437 1 HOSE #16-16FJX -16FJX45- 74LG
50 00696800 1 ADP HYD STGHT 8MB-8MJ
51 02972981 1 HOSE #8 - 8FJX - 8FJX - 80LG
52 02968895 1 PLASTIC TIE BLUE 11LG
53 02969464 3 ADP HYD STGHT 16FJ-8MJ
54 02975964 1 ASY RELIEF MANIFOLD 2900 PSI
55 02975438 1 ADP HYD STGHT 8MB - 8FJX
56 02962213 1 ADP HYD ELBOW 8MB - 8MJ 90?
57 02158800 1 HOSE #8 - 8FJX - 8FJX - 17LG
58 63000500 12 WASHER, FLAT, PLATED
59 40010000 2 PIN, COTTER 1/8 X1
- 02961085 12 CORDURA SLEEVING-54 LG
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -74
Page 78
BUZZ BAR ASY - 90 IN - GEN 1 (PART 1)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -75
Page 79
BUZZ BAR ASY - 90 IN - GEN 1 (PART 1)
Continued...
ITEM PART NO. QTY. DESCRIPTION
02974203 1 ASY 4 BLADE SAW HEAD
1 02974237 4 END CAP
2 02974238 2 SPACER
3 02974235 3 ASY SPINDLE
4 02974659 8 CSSH 1/2 NC 3-1/2
5 02974658 8 CSSH 1/2 NC 2
6 02976017 16 NUT, SLOTTED 1/2 NC PLB
7 00001200 6 NUT 1/2 NC HEX PL
8 02979295 1 USE 02983633
9 02974225 3 BRACKET TENSION ADJUSTMENT
10 00750614 16 NUT 1/2-20NF 90DEG.CONE LUG PL
11 002521 3 HHCS 1/2 NC 3-1/2 PL5
12 02974241 3 BELT POLY-V 615L10
13 02974239 4 SHEAVE POLY-V 20L6.00 W/GROOVE
14 02974240 4 BUSHING QD-SK 1-1/8
15 02979297 1 SHEET, BELT COVER LONG, 4
16 02975441 9 @STUD QUICK RELEASE W/RING
17 02975440 9 @RETAINER FOR QUICK RELEASE
18 02975439 9 @RECEIVER FOR QUICK RELEASE
19 00011400 1 HEXB 3/8 NC 1 PL5
20 00011100 10 FLATWASHER STD 3/8
21 00001800 6 LOCKNUT TLM 1/2 NC PLB
22 02978249 1 ASY,DRIVE SPINDLE
23 8301295 1 MOTOR,PISTON-2.48 CU.IN./REV
24 00749130 8 HHCS 1/2-13UNC 1-3/4 PL5
25 02978267 1 HUB 20R10 1-1/8 BORE 1/4 KEY
26 02978268 1 INSERT, URETHANE FOR 20R10
27 02978269 1 COVER, PROTECTIVE NYLON FOR
28 02978270 1 HUB 20R10 1-1/8 BORE 5/16 KEY
29 02979296 1 SHEET, BELT COVER SHORT
30 02976149 1 WLDMT HITCH POST
31 00037200 6 NUT 3/4-NC TOPLOCK GRC PL
32 02970324 1 PLATE,HITCH POST CLAMP
33 02918600 6 HEXB 3/4-10UNC 2 PL8
34 02974215 1 WLDMT HITCH TUBE 4 BLADE SAW
35 00015800 9 LOCKNUT TLM 3/8-NC PLC
36 00023100 8 HHCS 3/8 -16UNC 1-1/2 PL5
37 02974207 1 BUMPER
38 02974212 1 WLDMT SHIELD REAR
39 02975600 1 SAW BLADE PACKAGE OF 2
40 02968894 1 PLASTIC TIE RED 11LG
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -76
Page 80
BUZZ BAR ASY - 90 IN - GEN 1 (PART 2)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -77
Page 81
BUZZ BAR ASY - 90 IN - GEN 1 (PART 2)
Continued...
ITEM PART NO. QTY. DESCRIPTION
41 02957622 2 ADP HYD STGHT 16MB-16MJ
42 02968896 1 PLASTIC TIE ORANGE 11LG
43 02970466 2 ADP HYD TEE 16FJX-16MJ-16MJ
44 02975437 1 HOSE #16-16FJX -16FJX45- 74LG
45 02969678 1 HOSE #16-16FJX -16FJX45- 74LG
46 02969464 3 ADP HYD STGHT 16FJ-8MJ
47 02972981 1 HOSE #8 - 8FJX - 8FJX - 80LG
48 02975438 1 ADP HYD STGHT 8MB - 8FJX
49 02962213 1 ADP HYD ELBOW 8MB - 8MJ 90?
50 02158800 1 HOSE #8 - 8FJX - 8FJX - 17LG
51 00758194 1 DECAL,WARNING BELT SHIELD
52 00769736 1 DECAL,USE/REPAIR GUARDS
53 00769737 1 DECAL,BLADES THROWN OBJECTS
54 02925100 1 DECAL-REPLACEMENT PARTS
55 02958241 1 DECAL-TRACTOR OPERATOR SAFETY
56 02962764 1 DECAL - PINCH POINTS
57 00756004 1 DECAL-SHIELD MISSING
58 02965262 1 DECAL-,WARNING OIL LEAK
59 02967827 1 DECAL, MULTI-HAZARD
60 00757139 2 DECAL, ALAMO INDUSTRIAL
61 02974998 1 DECAL BUZZBAR
62 D138 1 DECAL,CW BLADE ROTATION
63 02975158 1 DECAL HEAR PROTECTION REQD
64 02975170 1 DECAL ROTATING BLADES
65 02975515 1 DECAL WARNING DISCONNECT
66 02975516 1 DECAL NO HITCH POST HERE
68 02975513 1 PLATE SERIAL NUMBER BB90
69 3710151 4 METAL TACK
70 02979546 1 DECAL, ALAMO IND. GREEN &BLACK
71 1458392 1 DECAL,RED REFLECTOR
72 1458393 1 DECAL,YELLOW REFLECTOR
73 00696800 1 ADP HYD STGHT 8MB-8MJ
74 02971720 1 WELDMENT, PIN - 11-1/2LG
75 02971702 1 FLATWASHER 1-3/8 TYPE B NARROW
76 02971701 1 NUT SLOT 1-3/8 12NF PLB
77 165020 1 PIN, COTTER 5/16 X 2-1/2 PL
78 02970595 1 HHCS 3/8 NC 2-3/4 PL8
79 02971756 1 PIN, 1-1/2 X 9 CHROME
80 02669600 5 KEY 1/4 SQ X 1 1/4 LG.
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -78
Page 82
BUZZ BAR ASY - 90 IN - GEN 1 (PART 3)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -79
Page 83
BUZZ BAR ASY - 90 IN - GEN 1 (PART 3)
Continued...
ITEM PART NO. QTY. DESCRIPTION
82 02975928 1 INSERT SHEET BUZZBAR MACHETE
83 02975964 1 ASY RELIEF MANIFOLD 2900 PSI
84 02919600 2 CAP-NUT #4FJ
85 02968895 1 PLASTIC TIE BLUE 11LG
86 40010000 16 PIN, COTTER 1/8 X1
87 63000500 16 WASHER, FLAT, PLATED
88 02979262 1 MACHINED TUBE, MOTOR MOUNT
89 02979546 1 DECAL, ALAMO IND. GREEN &BLACK
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -80
Page 84
BUZZ BAR ASY - 90 IN - GEN 2 (PART 1)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -81
Page 85
BUZZ BAR ASY - 90 IN - GEN 2 (PART 1)
Continued...
ITEM PART NO. QTY. DESCRIPTION
02986245 1 ASY, 4 BLADE BUZZBAR PISTON
1 02983633 1 WELDMENT, SAW BODY 4 BLADE
2 02974212 1 WLDMT, REAR SHIELD
3 02974235 3 HUB ASSY
4 02974207 1 BUMPER
5 02978249 1 ASSEMBLY, SPINDLE SHAFT
6 02974239 4 SHEAVE
7 02974240 4 QD BUSHING
8 02974236 4 BLADES
9 02974238 2 BLADE SPACER
10 02974225 3 BRACKET TENSION ADJUST
11 02974237 4 PLATE, SHAFT END CAP
12 02979262 1 MACHINED TUBE, MOTOR MOUNT
13 02979297 1 BELT COVER, LONG
14 02979296 1 BELT COVER, SHORT
15 02669600 5 SQ KEY
16 02978267 1 HUB, 20R10 W/1-1/8" BORE
17 02978270 1 HUB, 20R10 W/1-1/8" BORE
18 02978269 1 COVER, NYLON
19 02978268 1 INSERT, URETHANE
20 02974241 3 BELT, MICRO-V
21 02984677 9 SLIP ON RECEPTACLE 9MM
22 02968896 1 PLASTIC TIE, ORANGE, 11LG
23 02968894 1 PLASTIC TIE, RED, 11LG
24 02970324 1 PLATE-CLAMP, HITCHPOST
25 02986218 1 WELDMENT, HITCHPOST
26 00749130 2 HHCS 1/2 -13UNC 1 3/4 PL5
27 00001800 2 LOCKNUT TLM 1/2 NC PLB
28 00037200 6 NUT 3/4 NC LOCKNUT
29 02918600 6 HHCS 3/4 NC 2 PL8
30 00011100 10 FLATWASHER 3/8 STD
31 00011400 1 BOLT, HHCS 3/8 NC 1 PL5
32 00015800 11 LOCKNUT TLM 3/8 NC PLC
33 00023100 10 HHCS 3/8 X 1-1/2 NC PL GR5
34 02974659 8 FLAT SOCKET HEAD 1/2 NC X 3-1/2 W/ HOLE
35 02974658 8 FLAT SOCKET HEAD 1/2 NC X 2" W/ HOLE
36 02976017 16 SLOT NUT
37 00750614 16 NUT 1/2 NF
38 002521 3 HHCS 1/2 NC 3-1/2, FULL THREAD
39 00001200 6 NUT HEX 1/2 NC
40 02984678 9 STUD 9MM 1/4 TURN
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -82
Page 86
BUZZ BAR ASY - 90 IN - GEN 2 (PART 2)
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -83
Page 87
BUZZ BAR ASY - 90 IN - GEN 2 (PART 2)
Continued...
ITEM PART NO. QTY. DESCRIPTION
41 02981757 2 WELDMENT, PIN, HITCH POST
42 02971702 2 FLATWASHER 1-3/8 TYPE B NARROW
43 02971701 2 NUT SLOT 1-3/8 12NF PLB
44 165020 2 PIN, COTTER 5/16 X 2-1/2 PL
45 8301295 1 MOTOR,PISTON-2.48 CU.IN./REV
46 02975437 1 HOSE #16-16FJX -16FJX45- 74LG
47 02969678 1 HOSE #16-16FJX -16FJX45- 74LG
48 02957622 2 ADP HYD STGHT 16MB-16MJ
49 02970466 2 ADP HYD TEE 16FJX-16MJ-16MJ
50 00696800 1 ADP HYD STGHT 8MB-8MJ
51 02972981 1 HOSE #8 - 8FJX - 8FJX - 80LG
52 02968895 1 PLASTIC TIE BLUE 11LG
53 02969464 2 ADP HYD STGHT 16FJ-8MJ
54 02975964 1 ASY RELIEF MANIFOLD 2900 PSI
55 02962213 1 ADP HYD ELBOW 8MB - 8MJ 90?
56 02158800 1 HOSE #8 - 8FJX - 8FJX - 17LG
57 40010000 16 PIN, COTTER 1/8 X1
58 63000500 16 WASHER, FLAT, PLATED
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -84
Page 88
BUZZ BAR MOTOR ASSEMBLY
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -85
Page 89
BUZZ BAR MOTOR ASSEMBLY
Continued...
ITEM PART NO. QTY. DESCRIPTION
8301295 1 MOTOR,PISTON-2.48 CU.IN./REV
1 001641 1 ASSY, ROTATING KIT
2 03200409 1 O-RING
3 02988181 1 KIT,HIGH PRESSURE, SEAL & RING
4 03200411 1 WASHER
5 001644 2 BRG. & RACE SET
02975345 1 SEAL KIT
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -86
Page 90
BUZZ BAR SPINDLE ASY - SN BB-01219
ITEM PART NO. QTY. DESCRIPTION
02978249 1 SPINDLE ASY, DRIVE SPINDLE (SHOWN)
02974235 - SPINDLE ASY, NON-DRIVE (NOT SHOWN)
1 02974224 1 SPINDLE HOUSING, MACHINED
2 02978472 - SPINDLE SHAFT, NON-DRIVE SPINDLE
02978257 1 SPINDLE SHAFT, DRIVE SPINDLE
3 02974234 - COLLAR, BEARING PRELOAD
4 70044 - BEARING CUP, UPPER OR LOWER
5 5312314 - BEARING CONE, UPPER OR LOWER
6 15C2000 - WASHER, 1-1/4" HARDEND
7 5D20120 - SLOTTED HEX NUT, 1-1/4"-12NF PL
8 00766549 - SEAL, UPPER OR LOWER
9 00003500 - GREASE FITTING, 1/8" STRAIGHT
10 02959018 - GREASE RELIEF FITTING, 1-5LBS
11 00752177 - BOLT, STUD 1/2"-20NF X 1-7/8"
12 00606000 - COTTER PIN, 3/16" X 2"
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -87
Page 91
DITCHER - BLADE CARRIER ASY
ITEM PART NO. QTY. DESCRIPTION
02875301 - BLADE HEAD ASY, W/ BLADES (FORWARD ROTATION)
1 02875400 1 BLADE HEAD WLD`MT
2 02875900 3 WEAR PLATE
3 02886900 6 BOLT
5 00001800 18 NUT
6 02958680 3 MOUNT BRACKET
7 02958675 3 BLADE, ROUGH CUT
02958685 - SHIM KIT FOR ROUGH CUT BLADES
8 02891800 12 BOLT
9 02958684 6 BOLT
10 00003901 6 LOCKWASHER
11 00037200 6 NUT
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -88
Page 92
DITCHER - HOUSING ASY
ITEM PART NO. QTY. DESCRIPTION
02873900 - DITCHER HOUSING ASY
1 02974000 1 HOUSING WLD`MT
2 02874601 1 DEFLECTOR
3 02875001 1 HINGE PIN
4 00002700 2 FLATWASHER
5 00026200 2 COTTER PIN
6 02875101 2 BACK-UP PLATE
7 02886900 4 BOLT
8 00001300 4 LOCKWASHER
9 00001200 4 NUT
10 02811000 1 CYLINDER ASY
11 02276700 2 CYLINDER PIN
12 37107B13 4 HAIR PIN CLIP
13 02959086 3 RUBBER DEFLECTOR
14 02959087 3 DEFLECTOR CLAMP BAR
15 12621000 3 BOLT
16 00023100 1 BOLT
17 00059700 2 BOLT
18 00012101 14 LOCKWASHER
19 00013901 14 NUT
20 02959089 1 HOUSING COVER
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -89
Page 93
DITCHER - HOUSING ASY
Continued...
ITEM PART NO. QTY. DESCRIPTION
21 00011100 3 FLATWASHER
22 02042500 2 ADAPTER, STRAIGHT
23 000644 8 BOLT
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -90
Page 94
DITCHER - SPINDLE ASY
ITEM PART NO. QTY. DESCRIPTION
02973336 - SPINDLE ASY (ITEMS 1 THRU 14)
1 02883700 1 SPINDLE HSG, W/ BRG CUPS & GREASE FITTING
2 02708100 - BEARING CUP
3 02907700 2 BEARING CONE
4 02707600 3 SEAL
5 02872701 1 SPINDLE SHAFT
6 02873200 1 SPACER
7 02870900 1 NUT
8 00003500 - GREASE FITTING
9 02873301 1 COUPLING HALF, SPINDLE
10 02959017 1 KEY
11 02973318 1 COUPLING HALF, MOTOR
12 02873800 1 CHAIN COUPLING
13 02959014 1 SETSCREW
14 02959018 1 RELIEF FITTING
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -91
Page 95
THIS PAGE INTENTIONAL LEFT BLANK
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -92
Page 96
DITCHER BLADE HEAD ASY - ROUGH CUT
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -93
Page 97
DITCHER BLADE HEAD ASY - ROUGH CUT
Continued...
ITEM PART NO. QTY. DESCRIPTION
1 02875400 1 BLADE HEAD WLD`MT
2 02875900 3 WEAR PLATE
3 02958680 3 MOUNT BRKT-ROUGH CUT BLADE WLD`MT
4 02958675 3 ROUGH CUT, DITCHER BLADE
5 00037200 6 LOCKNUT, 3/4" NC GRC PL
6 00003901 6 LOCKWASHER, 3/4" PL HEAVY
7 00001800 18 LOCKNUT, 1/2" NC PLB
8 02891800 12 HEX HEAD CAP SCREW, 1/2" NC 1-3/4 PL8
9 02886900 6 CARRIAGE BOLT, 1/2" 13UNC 1-1/2" PL5
10 02958684 6 CARRIAGE BOLT, 3/4" NC 2-1/2" PL5
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -94
Page 98
DITCHER HEAD ASY - (NEW STYLE)
ITEM PART NO. QTY. DESCRIPTION
02982531 - MACHETE/MAVERICK DITCHER ASY
1 02984420 1 HITCHPOST WLD`MT, BOOM MOUNT
2 02973583 1 PLATE SPACER ON DITCHER
3 02977703 1 MOTOR GEROLER, 7.95 CID
02983465 1 SEAL KIT, REAR 02977703 MTR
02983466 1 SEAL KIT, SHAFT 02977703 MTR
02983467 1 SHAFT ASY, 1 1/4-14T 02977703
4 02873900 1 BLADE, HSG ASY
5 02973336 1 SPINDLE ASY
6 02875301 1 BLADE, HEAD ASY. ROUGH CUT
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -95
Page 99
DITCHER HEAD ASY - (NEW STYLE)
Continued...
ITEM PART NO. QTY. DESCRIPTION
7 00001300 6 LOCKWASHER, 1/2" PL STD
8 00002701 2 FLATWASHER, 3/4" TYPE AW,ZP
9 00001800 4 LOCKNUT, 1/2" NC PLB
10 00037200 4 LOCKNUT, 3/4" NC GRC PL
11 02891800 6 HEX HEAD BOLT, 1/2" NC 1-3/4" PL8
12 02881000 4 HEX HEAD BOLT, 3/4" NC 3-1/2" PL5
13 02027400 4 HEX HEAD BOLT, 1/2" NC 2-1/4" PL5
14 02980373 2 ADP HYD STRAIGHT, 10MB - 16MJ
15 02980686 1 RELIEF VALVE, INLINE 160 PSI
16 00770346 1 ADAPTER, HYD, STRIAGHT
17 00725739 1 DECAL, WARNING SHIELDS & GRDS
18 02965262 1 DECAL, WARNING HOSE BURST
19 02925100 1 DECAL, REPLACEMENT PARTS
20 02960766 1 DECAL, ALAMO INDUSTRIAL LOGO
21 02970888 1 DECAL, BOOM DITCHER
22 999204 1 DECAL, DITCHER
23 02968894 1 PLASTIC TIE, 11" LG
24 02968896 1 PLASTIC TIE, 11" LG
25 02968895 1 PLASTIC TIE, 11" LG
26 02971720 1 PIN WELDMENT, 11-1/2" LG
27 02971756 1 PIN, 1-1/2" X 9" CHROME
28 00015800 1 LOCKNUT, 3/8" NC PLC
29 02970595 1 HEX HEAD BOLT, 3/8" NC 2-3/4" PL8
30 02971701 1 SLOTTED NUT, 1-3/8" 12NF PLB
31 02971702 1 FLATWASHER, 1-3/8" TYPE B NARROW
32 165020 1 COTTER PIN, 5/16" X 2-1/2" PL
33 02967827 1 DECAL, MULTI HAZ
34 02984539 1 HOSE, #16 - 16FJX - 16FJX 90 - 62" LG
35 02984538 1 HOSE, #16 - 16FJX - 16FJX 90 - 54" LG
36 02984540 1 H0SE, #8 - 8FJX - 8FJX 90 - 54" LG
37 02984541 1 HOSE, #4 - 4FJX - 6FJX 90 - 80" LG
38 02984542 1 HOSE, #4 - 4FJX - 6FJX 90 - 88" LG
39 02968837 1 PLASTIC TIE, 4" LG
40 02968836 1 PLASTIC TIE, 4" LG
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -96
Page 100
DITCHER HEAD ASY - (OLD STYLE)
ITEM PART NO. QTY. DESCRIPTION
02973313 - DITCHER HEAD ASY
1 00001300 6 LOCKWASHER
2 00001800 4 LOCKNUT
3 00002701 2 FLATWASHER
4 00015800 2 LOCKNUT
5 00037200 4 LOCKNUT
Machete Boom 17 21 and 24 04-04 Rev 01-11
©2011 Alamo Group Inc. Parts Section -97
Loading...