Alamo 02983326P User Manual

Page 1

BOOM ARM MOWER

Rev 10-08

Part No. 02983326P

PART'S MANUAL

An Operator's Manual was shipped with the equipment in the Manual Canister . This Operator's Manual is an integral part of the safe operation of this machine and must be maintained with the unit at all times. READ, UNDERSTAND, and FOLLOW the Safety and Operation Instructions contained in this manual before operating the equipment. If the Operator's Manual is not with the equipment, contact your dealer or Servis-Rhino (800446-5158) to obtain a Free copy before operating the equipment.

ALAMO INDUSTRIAL

1502 E. Walnut Seguin, Texas 78155 210-372-3551

Page 2

TO THE OWNER/OPERATOR/DEALER

All implements with moving parts are potentially hazardous. There is no substitute for a cautious, safe-minded operator who recognizes the potential hazards and follows reasonable safety practices. The manufacturer has designed this implement to be used with all its safety equipment properly attached to minimize the chance of accidents.

BEFORE YOU START!! Read the safety messages on the implement and shown in your manual.

Observe the rules of safety and common sense!

FAILING TO FOLLOW SAFETY MESSAGES AND OPERATING INSTRUCTION CAN CAUSE

SERIOUS BODILY INJURY OR EVEN DEATH TO OPERATOR AND OTHERS IN THE AREA.

1. 2.NO RIDERS. NO

READ

1. Study and understand Operator’s Manuals, Safety Decals, and Instructional Decals for tractor and implement to prevent misuse, abuse, and accidents. Practice before operating in a confined area or near passersby.

¥ Learn how to stop engine suddenly in an emergency. Be alert for passersby and especially children.

2. Allow no children on or near folding mower or tractor. Allow no riders on tractor or implement. Falling off may cause serious injury or death from being run over by tractor or mower or contact with rotating blades.

3. Operate only with tractor having Roll-Over Protective Structure (ROPS) and with seat belt securely fastened to prevent injury and possible death from falling off or tractor overturn.

¥ Personal Protective Equipment such as Hard Hat, Safety Glasses, Safety Shoes, & Ear Plugs are recommended.

4. Block up or support raised machine and all lifted components securely before putting hands or feet under or working underneath any lifted component to prevent crushing injury or death from sudden dropping or inadvertent operation of controls. Make certain area is clear before lowering or folding.

5. Before transporting, put Lift Lever in detent or full-lift position. Install Transport Safety Devices securely on folding mowers. Put Booms securely in Transport Rest.

¥ Folding and Boom Mowers have raised center of gravity. Slow down when turning and on hillsides.

6. Make certain that SMV sign, warning lights, and reflectors are clearly visible. Follow local traffic codes.

7. Never operate with Cutting Head or Folding Section raised if passersby, bystanders, or traffic are in the area to reduce possibility of injury or death from objects thrown by Blades under Guards or mower structure.

8. Before dismounting, secure implement in transport position or lower to ground.

¥ Put tractor in park or set brake, disengage PTO, stop engine, remove key,and wait until noise of rotation has ceased to

prevent crushing by entanglement in rotating parts which could cause injury or death.

¥ Never mount or dismount a moving vehicle. Crushing form runover may cause serious injury or death.

MANUAL

CHILDREN OPERATORS.

3. USE SAFETY SHOES,

HARD HAT, SAFETY GLASSES, SEATBELTS, ROPS & OPS.

4. BLOCK UP SECURELY

BEFORE WORKING UNDER.

5. TRANSPORT SAFELY,

LOCK UP.

6. USE SMV, LIGHTS, &

REFLECTORS.

7. DO NOT OPERATE

WITH CUTTER OR WING RAISED

8. DO NOT MOUNT OR

DISMOUNT WHILE MOVING.

02967827

WARRANTY INFORMATION:

Read and understand the complete Warranty Statement found in this Manual. Fill out the Warranty Registration Form in full and return it within 30 Days. Make certain the Serial Number of the Machine is recorded on the Warranty Card and on the Warranty Form that you retain. The use of "will-fit" parts will void your warranty and can cause catastrophic failure with possible injury or death.

Page 3

PARTS

SECTION

Parts Section – 1

Page 4

PARTS ORDERING GUIDE

The following instructions are offered to help eliminate needless delay and error in processing purchase orders for the equipment in this section.

1. The Parts Section is prepared in logical sequence and grouping of parts that belong to the basic machine featured in this manual. Part Numbers and Descriptions are given to help locate the parts and quantities required.

2. The Purchase Order must include the name and address of the person or organization ordering the parts, who should be charged, and if possible, the serial number of the machine for which the parts are ordered.

3. The Purchase Order must clearly list the quantity of each part, the complete and correct part number (be sure to include all periods), and the basic name of the part.

4. The Manufacturer reserves the right to substitute parts where applicable.

5. Some parts are unlisted items which are special production items not normally stocked and are subject to special handling. Request a quotation for such parts before sending a Purchase Order.

6. The Manufacturer reserves the right to change prices without prior notice.

NOTE: Please refer to The Safety Section in the front of this Manual for the proper

Part Number when ordering Replacement Safety Decals.

For maximum safety and to guarantee optimum product reliability, always use genuine Servis-Rhino Parts. The use of inferior replacement parts may cause premature or catastrophic failure which could result in serious injury or death. Direct any questions regarding parts to:

ALAMO INDUSTRIAL

1502 E. Walnut Seguin, Texas 78155 830-379-1480

Parts Section – 2

Page 5

Page 6

PART NAME INDEX

48 IN FLAIL - HEAD ASY (SOLID MNT) (PART 1).................................................................................................................................. 5

48 IN FLAIL - HEAD ASY (SOLID MNT) (PART 2)................................................................................................................................. 7

48 IN FLAIL - HEAD ASY (SWIVEL MNT) (PART 1).............................................................................................................................. 9

48 IN FLAIL - HEAD ASY (SWIVEL MNT) (PART 2)............................................................................................................................ 11

48 IN FLAIL - HEAD ASY (SWIVEL MNT) (PART 3)............................................................................................................................ 13

48 IN FLAIL - HEAD ASY DECALS......................................................................................................................................................... 15

60 IN ROTARY - BLADE BAR ASY......................................................................................................................................................... 17

60 IN ROTARY - HEAD ASY (SOLID MNT)........................................................................................................................................... 19

60 IN ROTARY - HEAD ASY (SWIVEL MNT)....................................................................................................................................... 21

60 IN ROTARY - HEAD SUB-ASY (SOLID MNT).................................................................................................................................. 23

60 IN ROTARY - HEAD SUB-ASY (SWIVEL MNT).............................................................................................................................. 25

60 IN ROTARY - MOTOR (PARTS) - PN 02961747................................................................................................................................ 27

60 IN ROTARY - MOTOR (W-FITTINGS) - PN 02961747...................................................................................................................... 29

BOOM ASY - 18 FT BOOM - PN 02982733 (PART 1)............................................................................................................................. 31

BOOM ASY - 18 FT BOOM - PN 02982733 (PART 2)............................................................................................................................. 33

BOOM ASY - 22 FT BOOM - PN 02982736 (PART 1)............................................................................................................................. 35

BOOM ASY - 22 FT BOOM - PN 02982736 (PART 2)............................................................................................................................. 37

BOOM ASY - 25 FT BOOM - PN 02982739 (PART 1)............................................................................................................................. 39

BOOM ASY - 25 FT BOOM - PN 02982739 (PART 2)............................................................................................................................. 41

COMMON CRATE COMPONENTS - ELECT VALVE (PART 1).......................................................................................................... 43

COMMON CRATE COMPONENTS - ELECT VALVE (PART 2).......................................................................................................... 45

COMMON CRATE COMPONENTS - MAN VALVE (PART 1)............................................................................................................. 47

COMMON CRATE COMPONENTS - MAN VALVE (PART 2)............................................................................................................. 49

COUNTER WEIGHT W-DECALS............................................................................................................................................................. 51

CUTTER CONTROL VALVE BLOCK - PN 02982553............................................................................................................................ 52

DECALS - 18-22-25 FT BOOM.................................................................................................................................................................. 53

DECALS - 60 IN ROTARY HEAD - SOLID MNT................................................................................................................................... 54

DECALS - 60 IN ROTARY HEAD - SWIVEL MNT................................................................................................................................ 55

DECALS - HYD TANK & PUMP - ELECT VALVE................................................................................................................................ 56

DECALS - HYD TANK & PUMP - MAN VALVE................................................................................................................................... 57

DECALS - JOYSTICK OPERATION - PN 02983489............................................................................................................................... 58

DECALS - SAFETY BOOK LISTING....................................................................................................................................................... 59

DECALS - VALVE MAN HANDLE OPERATION - PN 02983408......................................................................................................... 61

DIVERTER VALVE - DOOR & SWIVEL - PN 02977622....................................................................................................................... 62

FILTER ASY - RETURN - PN 02964748................................................................................................................................................... 63

FILTER ASY - PRESSURE - PN 02976066............................................................................................................................................... 64

FILTER ASY - PRESSURE - PN 02985280............................................................................................................................................... 65

HOSE ROUTING - 18 FT BOOM............................................................................................................................................................... 67

HOSE ROUTING - 22 FT BOOM............................................................................................................................................................... 69

HOSE ROUTING - 25 FT BOOM............................................................................................................................................................... 71

Page 7

PART NAME INDEX

HOSE ROUTING - SWING CYL (18-22-25 FT BOOM).......................................................................................................................... 73

HYD CYL ASY - DIPPER (18 FT BOOM) - PN 02979920....................................................................................................................... 75

HYD CYL ASY - HEAD SWIVEL (OPTIONAL) - PN 02981315............................................................................................................ 76

HYD CYL ASY - LIFT (18-22-25 FT BOOM) - PN 02981279................................................................................................................. 77

HYD CYL ASY - SWING W/ SPHERICAL ROD END - PN 02981275A............................................................................................... 78

HYD CYL ASY - SWING W/ TUBE ROD END - PN 02981275.............................................................................................................. 79

HYD CYL ASY - TILT (18-22-25 FT BOOM) - PN 02981280................................................................................................................. 80

HYD OIL COOLER & FAN ASY - PN 02981377..................................................................................................................................... 81

HYD SCHEMATIC - SOLID MNT HEAD (STD) - 18-22-25 FT BOOM................................................................................................ 82

HYD SCHEMATIC - SWIVEL MNT HEAD (OPT) - 18-22-25 FT BOOM............................................................................................. 83

HYD TANK SUB-ASY - PN 02982882...................................................................................................................................................... 85

HYD TANK W-PUMP & ELECT VALVE ASY - P/N 02983488............................................................................................................. 87

HYD TANK W-PUMP & MAN VALVE ASY - P/N 02983487................................................................................................................ 89

HYD VALVE CABLE & MOUNTING KIT.............................................................................................................................................. 91

JOYSTICK CONSOLE ASY - PN 02983014............................................................................................................................................. 93

PUMP ASY (PARTS) - PN 02982575......................................................................................................................................................... 95

PUMP-TANK-VALVE COVER - PN 02981381........................................................................................................................................ 97

UNDER MOUNT FRAME ASY - PN 02986426 (PART 1)....................................................................................................................... 99

UNDER MOUNT FRAME ASY - PN 02986426 (PART 2)..................................................................................................................... 101

VALVE ASSEMBLY - ELECTRO-HYDRAULIC VALVE - P/N 02985869......................................................................................... 103

VALVE ASSEMBLY - MANUAL-HYDRAULIC VALVE - P/N 02985870......................................................................................... 104

WIRE HARNESS (ELECT-HYD VALVE OPT) - PN 02982923............................................................................................................ 105

WIRE HARNESS (MAN-HYD VALVE STD) - PN 02982922............................................................................................................... 107

WIRE HARNESS - JOYSTICK RESISTER (OPT) - PN 02981990........................................................................................................ 109

Page 8

48 IN FLAIL - HEAD ASY (SOLID MNT) (PART 1)

Page 9

48 IN FLAIL - HEAD ASY (SOLID MNT) (PART 1)

Continued... ITEM PART NO. QTY. DESCRIPTION

02983542 1 ASY,48" FLAIL AXE, GEAR 1 02970301 1 WLDMT, FLAIL AXE HEAD 2 02957655M 1 ASY, CUTTERSHAFT, 48" F/A 3 02970465 1 WLDMT DOOR, 48" FLAIL AXE 4 02973544 1 WLDMT, MOTOR MOUNT 5 02970709 1 PLATE, COVER FLAIL AXE 6 10119000 2 HHCS 5/16 NC 1 PL5 7 00023500 6 FLATWASHER 5/16, TYPE AW, ZP 8 00750940 2 NUT, TOPLOCK 5/16 NC PL B 9 02958131A 2 FLANG BEARING ASY 10 02956714 1 CLAMP BAR 11 02956712 1 RUBBER FLAP 12 02970326 1 ROD-HINGE, F/A DOOR 13 02958198 1 1/2 X 1/2 X 1 7/8 LG 14 02970585 1 WLDM SKIDSHOE INSIDE FLAIL AXE 15 02956748 1 SKID SHOE WLDMT 16 02970540 1 WLDMT - REAR ROLLER 17 02967325 2 PULLEY, 3G5V - 8.50 DIA 18 02970325 1 PLATE-BELT & PULLEY COVER 19 02972442 1 FLAIL AXE BEARING GUARD 20 02675800 2 HHCS 5/8 X 1-1/2 PL GR5 21 00010300 2 LOCKWASHER 5/8 22 00001400 4 FLATWASHER 5/8 PL STD 23 00019300 8 HHCS 1/2 X 1-1/2 NF GR5 PL 24 000642 8 LOCKNUT TLM 1/2 NC PLB 25 00752670 1 GREASE FITTING 1/4-28 BOLT THD 26 00008300 6 BOLT, HHCS 5/8" NC X 1-3/4" PL5 27 00695100 5 LOCKNUT TOPLOCK 5/8NC PLB 28 02970710A 1 CYL, DOOR, 48" F/A 29 02970324 1 PLATE-CLAMP, HITCHPOST 30 000941 1 GREASE ZERK 1/4-28 90 BOLT THD 31 02970583 4 SHCS 3/8 NF 1-1/2 PL GR5 32 23504500 8 JAMNUT 3/8 NF 33 03200925 1 CARR 5/8 NC X 3 PL GR5 34 02967328 1 BUSHIN, QD HUB SF 1-15/16 ID 35 02970537 1 BUSHING, QD HUB SF 1 ID 36 00013500 3 NUT, 3/8 NC JAMNUT 37 02970539 3 V BELT 38 02956768 2 PIN, ROLL 5/32X1 39 00011700 4 LOCKWASHER 5/16 PL STD 40 00035900 4 HHCS 5/16 NC X 3/4 GR5

Page 10

48 IN FLAIL - HEAD ASY (SOLID MNT) (PART 2)

Page 11

48 IN FLAIL - HEAD ASY (SOLID MNT) (PART 2)

Continued... ITEM PART NO. QTY. DESCRIPTION

Page 12

48 IN FLAIL - HEAD ASY (SWIVEL MNT) (PART 1)

Page 13

48 IN FLAIL - HEAD ASY (SWIVEL MNT) (PART 1)

Continued... ITEM PART NO. QTY. DESCRIPTION

1 02970301 1 WLDMT, FLAIL AXE HEAD 2 02957655M 1 ASY, CUTTERSHAFT, 48" F/A 3 02970465 1 WLDMT DOOR, 48" FLAIL AXE 4 02973544 1 WLDMT, MOTOR MOUNT 5 02970709 1 PLATE, COVER FLAIL AXE 6 10119000 2 HHCS 5/16 NC 1 PL5 7 00023500 6 FLATWASHER 5/16, TYPE AW, ZP 8 00750940 2 NUT, TOPLOCK 5/16 NC PL B 9 02958131A 2 FLANG BEARING ASY 10 02956714 1 CLAMP BAR 11 02956712 1 RUBBER FLAP 12 02970326 1 ROD-HINGE, F/A DOOR 13 02958198 1 1/2 X 1/2 X 1 7/8 LG 14 02970585 1 WLDM SKIDSHOE INSIDE FLAIL AXE 15 02956748 1 SKID SHOE WLDMT 16 02970540 1 WLDMT - REAR ROLLER 17 02967325 2 PULLEY, 3G5V - 8.50 DIA 18 02970325 1 PLATE-BELT & PULLEY COVER 19 02972442 1 FLAIL AXE BEARING GUARD 20 02675800 2 HHCS 5/8 X 1-1/2 PL GR5 21 00010300 2 LOCKWASHER 5/8 22 00001400 4 FLATWASHER 5/8 PL STD 23 00019300 8 HHCS 1/2 X 1-1/2 NF GR5 PL 24 000642 8 LOCKNUT TLM 1/2 NC PLB 25 00752670 1 GREASE FITTING 1/4-28 BOLT THD 26 00008300 6 BOLT, HHCS 5/8" NC X 1-3/4" PL5 27 00695100 5 LOCKNUT TOPLOCK 5/8NC PLB 28 02970710A 1 CYL, DOOR, 48" F/A 29 02970324 1 PLATE-CLAMP, HITCHPOST 30 000941 1 GREASE ZERK 1/4-28 90 BOLT THD 31 02970583 4 SHCS 3/8 NF 1-1/2 PL GR5 32 23504500 8 JAMNUT 3/8 NF 33 03200925 1 CARR 5/8 NC X 3 PL GR5 34 02967328 1 BUSHIN, QD HUB SF 1-15/16 ID 35 02970537 1 BUSHING, QD HUB SF 1 ID 36 00013500 3 NUT, 3/8 NC JAMNUT 37 02970539 3 V BELT 38 02956768 2 PIN, ROLL 5/32X1 39 00011700 4 LOCKWASHER 5/16 PL STD 40 00035900 4 HHCS 5/16 NC X 3/4 GR5

Page 14

48 IN FLAIL - HEAD ASY (SWIVEL MNT) (PART 2)

Page 15

48 IN FLAIL - HEAD ASY (SWIVEL MNT) (PART 2)

Continued... ITEM PART NO. QTY. DESCRIPTION

41 00001800 12 LOCKNUT TLM 1/2 NC PLB 42 00002700 7 FLATWASHER, 1/2 PL STD 43 02892000 7 HHCS 1/2 X 1-1/2 NC GR8 PL 44 02957041 2 ROLLER BEARING & FLANGE 45 00013300 4 BOLT, HHCS 1/2" NC X 2" PL5 46 00753642 2 HHCS 3/8 NC 1-1/4 PL5 47 02970586 2 WASHER, 2 X 7/16 X 3/16 48 00023100 6 HHCS 3/8 X 1-1/2 NC PL GR5 49 00015800 6 LOCKNUT TLM 3/8 NC PLC 50 00003300 1 HHCS 3/4" X 4" LG 51 00037200 13 NUT 3/4 NC LOCKNUT 52 00008200 1 BOLT, HHCS 1/2" NC X 3-3/4" PL5 53 02960018 4 ADP, HYD, ELBOW, 4MB-4MJ90 54 02918600 10 HHCS 3/4 NC 2 PL8 55 02981757 2 WELDMENT, PIN, HITCH POST 56 02971702 2 FLATWASHER, 1-3/8 TYPE B PL NARROW 57 02971701 2 NUT, SLOTTED 1-3/8 12NF PLB 58 165020 2 PIN, COTTER 5/16 X 2-1/2 PL 59 02968896 1 PLASTIC TIE, ORANGE, 11LG 60 02968894 1 PLASTIC TIE, RED, 11LG 61 02984370 1 ADP, SWIVEL, FLAIL AXE 62 02981318 1 BEARING, 12OD X 5.8ID 63 02981741 1 WELDMENT, HITCH POST, MAVERICK 64 02981315 1 CYLINDER, 2.5B X 1.5R X 14.38S 65 02984374 1 WLDMNT, SWIVEL, CYL BRKT 66 02981820 28 SHCS 1/2 NC X 1 1/2" LG PL8 67 02963646 1 HHCS 3/4 NC 2-1/2 PL8 68 00754105 1 HHCS 3/4 NC 4 1/2 PL8 69 02984382 1 CLAMP, PLATE, SWIVEL 70 02984470 2 STOP, FLAIL AXE SWIVEL 71 00021400 2 BOLT, HHCS 1/4" NC X 3/4" PL 72 02959924 2 NUT, TOPLOCK 1/4 NC PLB 73 02968832 1 PLASTIC TIE, GREEN 74 02968833 1 PLASTIC TIE, GREEN & WHITE 75 02968836 1 PLASTIC TIE, YELLOW 76 02968837 1 PLASTIC TIE, YELLOW & WHITE 77 002369 1 DECAL, DANGER, MULTI-HAZARD 78 02965141 1 DECAL, DANGER THROWN OBJ 79 02967668 1 DECAL, DANGER, SAFETY SHIELD 80 02967867 1 DECAL, DANGER SAFETY SHIELD 81 00725739 1 DECAL WARN. SHEILD&GUARDS

Page 16

48 IN FLAIL - HEAD ASY (SWIVEL MNT) (PART 3)

Page 17

48 IN FLAIL - HEAD ASY (SWIVEL MNT) (PART 3)

Continued... ITEM PART NO. QTY. DESCRIPTION

82 00758194 1 DECAL,WARNING BELT SHIELD 83 02925100 1 DECAL-REPLACEMENT PARTS 84 000108 1 DECAL-OPERATING INSTRUCTIONS 85 000678 1 DECAL- GREASE FITTING INSIDE 86 00757139 1 DECAL, ALAMO INDUSTRIAL 87 02970887 1 DECAL, FLAIL AXE 48 88 3710151 4 METAL TACK 89 02971498 1 PLATE,S/N 48 FLAIL AXE 90 02979551 1 DECAL, ALAMO IND. SQ. GREEN & 91 02987315 1 MOTOR, GEAR 3.0 CU/IN F/A 92 00749103 2 SPLIT FLG KIT #20 93 02985030 2 ADP HYD 20FL-20MJ FLANGE

Page 18

48 IN FLAIL - HEAD ASY DECALS

Page 19

48 IN FLAIL - HEAD ASY DECALS

Continued... ITEM PART NO. QTY. DESCRIPTION

1 002369 1 DECAL, DANGER, MULTI-HAZARD 2 02965141 1 DECAL, DANGER THROWN OBJ 3 02967668 1 DECAL, DANGER, SAFETY SHIELD 4 02967867 1 DECAL, DANGER SAFETY SHIELD 5 00725739 1 DECAL WARN. SHEILD&GUARDS 6 00758194 1 DECAL, WARNING, BELT SHIELD 7 02925100 1 DECAL, REPLACEMENT PARTS 8 000108 1 DECAL, INSTRUC, FLAIL OPER 9 000678 1 DECAL, GREASE FITTING INSIDE 10 00757139 1 DECAL, LOGO (ALAMO BY T.K.) 11 02970887 1 DECAL, LOGO, FLAIL AXE 48" 12 3710151 4 METAL TACK 13 02971498 1 PLATE, S/N FLAIL AXE 48" 14 02979551 1 DECAL, ALAMO INDUSTRIAL LOGO

Page 20

60 IN ROTARY - BLADE BAR ASY

ITEM PART NO. QTY. DESCRIPTION

02969230 1 BLADE BAR ASY, W/ BLADES 1 00020900 2 HEX SLOTTED NUT, HVY 1-1/8"-NF PL GR5 2 00023200 2 ROLL PIN, 3/16" X 1-3/4" 3 02969234 4 FLATWASHER, 1-1/4" HARDENED PL 4 02761500 1 BLADE SET, MATCHED SET OF TWO 5 02971387 1 LEAF BLADE BAR, TOP 6 02969232 1 LEAF BLADE BAR, MIDDLE 7 02969233 1 LEAF BLADE BAR, BOTTOM 8 02969235 2 BOLT, HEX HEAD 1-1/4"-NC X 3" PL GR8 9 02969236 2 BOLT, HEX HEAD 1-1/4"-NC X 2-1/4" PL GR8 10 02782900 2 BLADE BOLT, SHOULDERED 11 02957089 2 LOCKWASHER, 1-1/8" PL STD 12 00003901 4 LOCKWASHER, 3/4" PL HEAVY 13 02964861 4 BOLT, SOCKET HEAD 3/4"-NC X 4" PL GR8 14 02984572 1 BLADE BOLTS, NUTS, ROLLPIN KIT (INCLUDES 2 EACH OF ITEMS 1, 2, & 10)

Page 21

THIS PAGE INTENTIONAL LEFT BLANK

Page 22

60 IN ROTARY - HEAD ASY (SOLID MNT)

Page 23

60 IN ROTARY - HEAD ASY (SOLID MNT)

Continued... ITEM PART NO. QTY. DESCRIPTION

02983222 1 60 IN ROTARY HEAD ASY, W/ STD SOLID MOUNT 1 02983221 1 60 IN HEAD SUB-ASY 2 02971963 1 DOOR WELDMENT 3 02967782 1 HINGE ROD 4 99338S 2 ROLL PIN, 1/4" X 3/4" 5 02961480A 1 CYL ASY, 2" BORE X 9-1/4" STROKE 6 02981757 2 PIN WELDMENT, HITCH POST 7 02971702 2 FLATWASHER, 1-3/8" TYPE B NARROW 8 02971701 2 HEX SLOTTED NUT, 1-3/8"-12NF PLB 9 165020 2 COTTER PIN, 5/16" X 2-1/2" PL 10 651102 1 PIN, DRILLED 11 02976448 1 PIN, 5/8" X 2-1/2" DRILLED 12 00755153 2 COTTER PIN, 3/16" X 1-1/2" PLATED 13 02885700 2 REAR FLAP 10" X 63" X 3/8" THK 14 02885800 1 REAR CLAMP BAR 15 00759862 2 SHIELD, DEBRIS DEFLECTOR REAR C 16 00756875 1 FLAP, HOLD DOWN BAR 17 00023100 11 BOLT, HEX HEAD 3/8"-16NC X 1-1/2" PL GR5 18 00011100 46 FLATWASHER, 3/8" PL STD 19 00015800 23 LOCKNUT, 3/8"-NC PLB 20 00007000 12 BOLT, HEX HEAD 3/8"-NC X 1-3/4" PL GR5 21 02960018 2 ADAPTER, HYD ELBOW 22 02767500 1 HEX WRENCH, 5/8" MODIFIED 23 02968836 1 PLASTIC TIE, 4" LG - YELLOW 24 02968837 1 PLASTIC TIE, 4" LG - YELLOW & WHITE 25 02968894 1 PLASTIC TIE, 11" LG - RED 26 02968896 1 PLASTIC TIE, 11" LG - ORANGE 27 ----N/S---- 1 S/N PLATE (NON-SALEABLE ITEM) 28 02972949 2 BOLT 3/8 NC GR8 X 1-1/4 29 00012101 2 LOCKWASHER 3/8 PL HVY

Page 24

60 IN ROTARY - HEAD ASY (SWIVEL MNT)

Page 25

60 IN ROTARY - HEAD ASY (SWIVEL MNT)

Continued... ITEM PART NO. QTY. DESCRIPTION

02983208 1 60" ROTARY HEAD ASY, OPT SWIVEL MOUNT 1 02983207 1 60" ROTARY HEAD SUB ASY 2 02971963 1 DOOR WELDMENT 3 02967782 1 HINGE ROD 4 99338S 2 ROLL PIN, 1/4" X 3/4" 5 02961480A 1 CYL ASY, 9-1/4" STROKE 6 02981315 1 CYL ASY, 14-3/4" STROKE 7 02981757 2 PIN WELDMENT, HITCH POST 8 02971702 2 FLATWASHER, 1-3/8" TYPE B NARROW 9 02971701 2 HEX SLOTTED NUT, 1-3/8"-12NF PLB 10 165020 2 COTTER PIN, 5/16" X 2-1/2" PL 11 651102 1 PIN, DRILLED 12 02976448 1 PIN, DRILLED 5/8" X 2-1/2" 13 00755153 2 COTTER PIN, 3/16" X 1-1/2" PLATED 14 02960916 1 BOLT, HEX HEAD 3/4"-NC X 5" PL GR8 15 02963646 1 BOLT, HEX HEAD 3/4"-NC X 2-1/2" PL GR8 16 00037200 2 LOCKNUT, 3/4"-NC PLC 17 02887500 2 REAR FLAP, 10" X 63" X 3/8" THK 18 02885800 1 REAR CLAMP BAR 19 00759862 2 SHIELD, DEBRIS DEFLECTOR REAR C 20 00756875 1 FLAP HOLD DOWN BAR 21 00023100 11 BOLT, HEX HEAD 3/8"-16NC X 1-1/2" PL GR5 22 00011100 46 FLATWASHER, 3/8" PL STD 23 00015800 23 LOCKNUT, 3/8"-NC PLB 24 00007000 12 BOLT, HEX HEAD 3/8"-NC X 1-3/4" PL GR5 25 02960018 2 ADAPTER, HYD ELBOW 26 03200762 2 ADAPTER, HYD ELBOW 6MB - 4MJ 90 DEG 27 02767500 1 HEX WRENCH, 5/8" MODIFIED 28 02968836 1 PLASTIC TIE, 4" LG - YELLOW 29 02968837 1 PLASTIC TIE, 4" LG - YELLOW & WHITE 30 02968832 1 PLASTIC TIE, 4" LG - GREEN 31 02968833 1 PLASTIC TIE, 4" LG - GREEN & WHITE 32 02968894 1 PLASTIC TIE, 11" LG - RED 33 02968896 1 PLASTIC TIE, 11" LG - ORANGE 34 ----N/S---- 1 S/N PLATE (REF ONLY NON-SALEABLE ITEM) 35 02972949 2 BOLT 3/8 NC GR8 X 1-1/4 36 00012101 2 LOCKWASHER 3/8 PL HVY

Page 26

60 IN ROTARY - HEAD SUB-ASY (SOLID MNT)

Page 27

60 IN ROTARY - HEAD SUB-ASY (SOLID MNT)

Continued... ITEM PART NO. QTY. DESCRIPTION

02983221 1 60" ROTARY HEAD SUB-ASY. W/ STR SOLID MOUNT 1 02981410 1 DECK WELDMENT 2 02982749 1 HITCH POST WELDMENT, STD SOLID MOUNT 3 02892100 8 BOLT, HEX HEAD 3/4"-NC X 1-3/4" PL GR5 4 00037200 16 LOCKNUT, 3/4"-NC PLC 5 02968859A 1 SPINDLE HOUSING ASY, SPLINED 6 5312316 16 WASHER, (SPECIAL) 7 02966899 2 SKID SHOE 8 02969230 1 BLADE BAR ASY, W/ BLADES 9 02964861 4 BOLT, SOCKET HEAD 3/4"-NC X 4" PL GR8 10 00003901 4 LOCKWASHER, 3/4 PL HEAVY 11 00059700 14 BOLT, FLAT SOCKET HEAD 3/8"-NC X 1-1/4" 12 00015800 14 LOCKNUT, 3/8"-NC PLB 13 15B600 14 WASHER, 3/8" SAE P 14 02961747 1 MOTOR ASY, CAST IRON W/SPLINED SHAFT 15 00019600 4 LOCKWASHER, 1/2" HEAVY 16 02891800 4 BOLT, HEX HEAD 1/2"-NC X 1-3/4" PL GR8 17 02961038 1 GASKET, SPINDLE TO MOTOR 18 03200269 8 BOLT, HEX HEAD 3/4"-NC X 3" PL GR8 19 00749101 2 SPLIT FLANGE KIT, 1-1/2" 20 02962774 2 ADAPTER, HYD ELBOW

Page 28

60 IN ROTARY - HEAD SUB-ASY (SWIVEL MNT)

Page 29

60 IN ROTARY - HEAD SUB-ASY (SWIVEL MNT)

Continued... ITEM PART NO. QTY. DESCRIPTION

02983207 1 60" HEAD SUB-ASY, W/ OPT SWIVEL MOUNT 1 02981410 1 DECK WELDMENT 2 02981752 1 PLATE, HITCH POST BOTTOM 3 02981820 28 BOLT, SOCKET HEAD 1/2"-NC X 1-1/2" PL GR8 4 02981318 1 SLEWING BEARING 5 02981741 1 HITCH POST WELDMENT, (OPT SWIVEL MOUNT) 6 02892100 8 BOLT, HEX HEAD 3/4"-NC X 1-3/4" PL GR5 7 00037200 16 LOCKNUT, 3/4"-NC PLC 8 02968859A 1 SPINDLE HOUSING ASY, SPLINED SHAFT 9 5312316 16 WASHER, (SPECIAL) 10 02966899 2 SKID SHOE 11 02969230 1 BLADE BAR ASY, W/ BLADES 12 02964861 4 BOLT, SOCKET HEAD 3/4"-NC X 4" PL GR8 13 00003901 4 LOCKWASHER, 3/4" PL HEAVY 14 00059700 14 BOLT, FLAT SOCKET HEAD 3/8"-NC X 1-1/4" 15 00015800 14 LOCKNUT, 3/8"-NC PLB 16 15B600 14 WASHER, 3/8" SAE P 17 02961747 1 MOTOR ASY, CAST IRON W/ SPLINED SHAFT 18 00019600 4 LOCKWASHER, 1/2" HEAVY 19 02891800 4 BOLT, HEX HEAD 1/2"-NC X 1-3/4" PL GR8 20 02961038 1 GASKET, SPINDLE TO MOTOR 21 03200269 8 BOLT, HEX HEAD 3/4"-NC X 3" PL GR8 22 00749101 2 SPLIT FLANGE KIT, 1-1/2" 23 02962774 2 ADAPTER, HYD ELBOW

Page 30

60 IN ROTARY - MOTOR (PARTS) - PN 02961747

ITEM PART NO. QTY. DESCRIPTION

02961747 1 MOTOR ASY, CAST IRON W/ SPLINED SHAFT 1 02962200 1 SNAP RING 2 -------------- 1 O-RING (SEE SEAL KIT) 3 02962199 1 SEAL RETAINER 4 -------------- 2 SEAL (SEE SEAL KIT) 5 02962192 1 MOUNTING FLANGE 6 02961940 1 PLUG, HEX SOCKET HEAD 4MB 7 02961931 2 CHECK ASY 8 -------------- 4 SEAL END (SEE SEAL KIT) 9 -------------- 2 THRUST PLATE (SEE SEAL KIT) 10 02962195 1 GEAR SET 11 ------------- 2 SQUARE SEAL, (SEE SEAL KIT) 12 02962201 4 DOWEL PIN 13 02962194 1 GEAR HOUSING

Page 31

60 IN ROTARY - MOTOR (PARTS) - PN 02961747

Continued... ITEM PART NO. QTY. DESCRIPTION

14 02962193 1 PORTING FLANGE 15 02962196 4 WASHER 16 02962197 4 BOLT, HEX HEAD 17 -------------- 4 SIDE SEAL, (SEE SEAL KIT) NOT SHOWN 18 02962291 1 SEAL RETAINER 19 02962540 1 SEAL KIT, MINOR REBUILD (ITEMS 2,4,8,11&17)

02962202 1 SEAL KIT, MAJOR REBUILD (ITEMS 2,4,8,9,11&17)

Page 32

60 IN ROTARY - MOTOR (W-FITTINGS) - PN 02961747

ITEM PART NO. QTY. DESCRIPTION

1 02961747 1 MOTOR ASY, CAST IRON W/ SPLINED SHAFT 2 02962774 2 ADAPTER, HYD ELBOW 24FL - 20MJ45 3 00749101 2 SPLIT FLANGE KIT, 1-1/2"

Page 33

THIS PAGE INTENTIONAL LEFT BLANK

Page 34

BOOM ASY - 18 FT BOOM - PN 02982733 (PART 1)

Page 35

BOOM ASY - 18 FT BOOM - PN 02982733 (PART 1)

Continued... ITEM PART NO. QTY. DESCRIPTION

1 02982731 1 WELDMENT, LIFT, 18` AXTREME 2 02982732 1 WELDMENT, DIPPER, 18` AXTREME 3 02972816 1 WELDMENT, LINK ARM 4 02982979 1 WELDMENT, CYLINDER PIN, NEW BOOM 5 02982980 1 WELDMENT, CYLINDER PIN SHORT, NEW BOOM 6 02982981 1 WELDMENT, CYLINDER PIN LONG, NEW BOOM 7 02981294 1 WELDMENT, PIN, LIFT/ DIPPER 8 02971751 1 PIN, 1-1/2 X 5-3/16 & 13/32 HOLE 9 02981279 1 CYLINDER, 4.0B X 2.25R X 24.63S 10 02981280 1 CYLINDER, 3.0B X 1.5R X 16.0S 11 02981695 1 WELDMENT, LINKAGE ARM, MAVERICK 12 02981420 4 CONNEX BUSHING, 2 1/4 X 2 X 3 13 02983320 1 CYL, 3.5B X 1.5R X 30.0S 14 02981424 8 CONNEX BUSHING, 1 3/4 X 1 1/2 X 3 15 02981273 1 SPACER, PIN, DIPPER, MAVERICK 16 02981702 1 SLOTTED NUT, 1-1/2 NF 17 02971754 1 PIN 1-1/2 X 8-5/16 & 13/32 HOLE 18 02971755 2 PIN, 1-1/2 X 9-9/16 & 13/32 HOLE 19 02960869 1 1 1/4" TUBE TWIN SET 20 02963154 2 CLAMP, 1.25 TUBING 21 02982712 1 TUBING, 18` LIFT 22 02982713 1 TUBING, 18` LIFT 23 02983266 1 PLATE, LIFT TUBE COVER, 18` AXTREME 24 02982714 1 TUBING, 18` DIPPER 25 02982715 1 TUBING, 18` DIPPER 26 281324 2 CARB 1/2 - 13 X 3 27 02981735 1 ASSEMBLY, TILIT CYLINDER COVER, MAVERICK 28 02965448 4 ADP, HYD 4MJ -4MJ BULKHEAD 29 02919600 4 CAP, HYD 4FJ 30 165020 1 PIN, COTTER 5/16 X 2-1/2 PL 31 02960506 2 CAP, #20FJIC 32 63149100 3 ADP, HYD ELBOW 6MB-6MJ 90 33 00002700 3 FLATWASHER, 1/2 PL STD 34 02975436 1 HHCS 1/2 NC X 2 1/4 PL8 35 00001800 1 LOCKNUT TLM 1/2 NC PLB 36 00023100 3 HHCS 3/8 X 1-1/2 NC PL GR5 37 02970595 4 HHCS 3/8 NC 2-3/4 PL8 38 00015800 7 LOCKNUT TLM 3/8 NC PLC 39 001921 1 ADAPTER 6MJ - 6FJX 90 40 000941 1 GREASE ZERK 1/4-28 90 BOLT THD 41 00752670 9 GREASE FITTING 1/4-28 BOLT THD

Page 36

BOOM ASY - 18 FT BOOM - PN 02982733 (PART 2)

Page 37

BOOM ASY - 18 FT BOOM - PN 02982733 (PART 2)

Continued... ITEM PART NO. QTY. DESCRIPTION

42 02968835 1 PLASTIC TIE O/W 4LG 43 02968831 1 PLASTIC TIE B/W 4LG 44 02968834 1 PLASTIC TIE ORG 4LG 45 02968830 1 PLASTIC TIE BLU 4LG 46 02968829 1 PLASTIC TIE R/W 4LG 47 02968828 1 PLASTIC TIE RED 4LG 48 02968837 1 PLASTIC TIE Y/W 4LG 49 02968836 1 PLASTIC TIE YEL 4LG 50 02968894 4 PLASTIC TIE RED 11LG 51 02968896 4 PLASTIC TIE ORANGE 11LG 52 02983080 2 ACORN NUT, 1/2-13 53 02983263 2 DECAL, 18 LOGO, AXTREME 54 02962764 6 DECAL - PINCH POINTS 55 02976532 4 ADP HYD ELBOW 4MJ - 4FJX 45DEG 56 02968832 1 PLASTIC TIE GRN 4" 57 02968833 1 PLASTIC TIE G/W 4LG 58 63161900 2 SPRING NUT 1/2 59 00019600 2 LOCKWASHER 1/2 HEAVY PL

Page 38

BOOM ASY - 22 FT BOOM - PN 02982736 (PART 1)

Page 39

BOOM ASY - 22 FT BOOM - PN 02982736 (PART 1)

Continued... ITEM PART NO. QTY. DESCRIPTION

1 02982734 1 WELDMENT, 22` LIFT 2 02982735 1 WELDMENT, 22` DIPPER 3 02981294 1 WELDMENT, PIN, LIFT/ DIPPER 4 02972816 1 WELDMENT, LINK ARM 5 02981279 1 CYLINDER, 4.0B X 2.25R X 24.63S 6 02982979 2 WELDMENT, CYLINDER PIN, NEW BOOM 7 02982980 2 WELDMENT, CYLINDER PIN SHORT, NEW BOOM 8 02981273 1 SPACER, PIN, DIPPER, MAVERICK 9 02981277 1 CYLINDER, 4.0B X 2.25R X 21.5S 10 02981702 1 SLOTTED NUT, 1-1/2 NF 11 02981280 1 CYLINDER, 3.0B X 1.5R X 16.0S 12 02981695 1 WELDMENT, LINKAGE ARM, MAVERICK 13 02981420 4 CONNEX BUSHING, 2 1/4 X 2 X 3 14 02981424 8 CONNEX BUSHING, 1 3/4 X 1 1/2 X 3 15 02971754 1 PIN 1-1/2 X 8-5/16 & 13/32 HOLE 16 02971755 2 PIN, 1-1/2 X 9-9/16 & 13/32 HOLE 17 02960869 1 1 1/4" TUBE TWIN SET 18 02982706 1 TUBING, 22` DIPPER 19 02982707 1 TUBING, 22` DIPPER 20 02963154 4 CLAMP, 1.25 TUBING 21 281324 4 CARB 1/2 - 13 X 3 22 02982704 1 TUBING, 22` LIFT 23 02982705 1 TUBING, 22` LIFT 24 02983105 1 PLATE, LIFT TUBE COVER, 22` AXTREME 25 02983106 1 PLATE, LIFT TUBING COVER, 22` AXTREME 26 02981735 1 ASSEMBLY, TILIT CYLINDER COVER, MAVERICK 27 02965448 4 ADP, HYD 4MJ -4MJ BULKHEAD 28 02919600 4 CAP, HYD 4FJ 29 02960506 4 CAP #20FJIC 30 63149100 3 ADP, HYD ELBOW 6MB-6MJ 90 31 00002700 5 FLATWASHER, 1/2 PL STD 34 02957042 1 HHCS 3/8NC 1-3/4 PL GR8 35 00023100 3 HHCS 3/8 X 1-1/2 NC PL GR5 36 02970595 3 HHCS 3/8 NC 2-3/4 PL8 37 00015800 7 LOCKNUT TLM 3/8 NC PLC 38 000941 1 GREASE ZERK 1/4-28 90 BOLT THD 39 00752670 11 GREASE FITTING 1/4-28 BOLT THD 40 02968835 1 PLASTIC TIE, ORANGE & WHITE 41 165020 1 PIN, COTTER 5/16 X 2-1/2 PL

Page 40

BOOM ASY - 22 FT BOOM - PN 02982736 (PART 2)

Page 41

BOOM ASY - 22 FT BOOM - PN 02982736 (PART 2)

Continued... ITEM PART NO. QTY. DESCRIPTION

42 02968834 1 PLASTIC TIE ORG 4LG 43 02968831 1 PLASTIC TIE B/W 4LG 44 02968830 1 PLASTIC TIE BLU 4LG 45 02968829 1 PLASTIC TIE R/W 4LG 46 02968828 1 PLASTIC TIE RED 4LG 47 02968837 1 PLASTIC TIE Y/W 4LG 48 02968836 1 PLASTIC TIE YEL 4LG 49 02968894 4 PLASTIC TIE RED 11LG 50 02968896 4 PLASTIC TIE ORANGE 11LG 51 02983080 4 ACORN NUT, 1/2-13 52 001921 1 ADP HYD ELBOW 6MJ - 6FJX 90 53 02976532 3 ADP HYD ELBOW 4MJ - 4FJX 45DEG 54 02968833 1 PLASTIC TIE G/W 4LG 55 02961085 1 CORDURA SLEEVING-54 LG

02968832 1 PLASTIC TIE GRN 4" 56 00019600 5 LOCKWASHER 1/2 HEAVY PL 57 63161900 4 SPRING NUT 1/2

Page 42

BOOM ASY - 25 FT BOOM - PN 02982739 (PART 1)

Page 43

BOOM ASY - 25 FT BOOM - PN 02982739 (PART 1)

Continued... ITEM PART NO. QTY. DESCRIPTION

1 02982737 1 WELDMENT, 25` LIFT, AXTREME 2 02982738 1 WELDMENT, 25` DIPPER, AXTREME 3 02972816 1 WELDMENT, LINK ARM 4 02981279 1 CYLINDER, 4.0B X 2.25R X 24.63S 5 02981277 1 CYLINDER, 4.0B X 2.25R X 21.5S 6 02981280 1 CYLINDER, 3.0B X 1.5R X 16.0S 7 02981695 1 WELDMENT, LINKAGE ARM, MAVERICK 8 02981420 4 CONNEX BUSHING, 2 1/4 X 2 X 3 9 02981424 8 CONNEX BUSHING, 1 3/4 X 1 1/2 X 3 10 02981294 1 WELDMENT, PIN, LIFT/ DIPPER 11 02981273 1 SPACER, PIN, DIPPER, MAVERICK 12 02981702 1 SLOTTED NUT, 1-1/2 NF 13 02982979 2 WELDMENT, CYLINDER PIN, NEW BOOM 14 02982980 2 WELDMENT, CYLINDER PIN SHORT, NEW BOOM 15 02971754 1 PIN 1-1/2 X 8-5/16 & 13/32 HOLE 16 02971755 2 PIN, 1-1/2 X 9-9/16 & 13/32 HOLE 17 02960869 1 1 1/4" TUBE TWIN SET 18 02982710 1 TUBING, 25` DIPPER 19 02982711 1 TUBING, 25` DIPPER 20 02963154 4 CLAMP, 1.25 TUBING 21 281324 4 CARB 1/2 - 13 X 3 22 02982708 1 TUBING, 25` LIFT 23 02982709 1 TUBING, 25` LIFT 24 02983141 1 PLATE, LIFT TUBE COVER, 25` AXTREME 25 02983142 1 PLATE, LIFT TUBING COVER, 25` AXTREME 26 02981735 1 ASSEMBLY, TILIT CYLINDER COVER, MAVERICK 27 02965448 4 ADP, HYD 4MJ -4MJ BULKHEAD 28 02919600 4 CAP, HYD 4FJ 29 02960506 2 CAP, #20FJIC 30 63149100 3 ADP, HYD ELBOW 6MB-6MJ 90 31 00002700 5 FLATWASHER, 1/2 PL STD 32 02975436 1 HHCS 1/2 NC X 2 1/4 PL8 33 00001800 1 LOCKNUT TLM 1/2 NC PLB 34 02957042 1 HHCS 3/8NC 1-3/4 PL GR8 35 00023100 3 HHCS 3/8 X 1-1/2 NC PL GR5 36 02970595 3 HHCS 3/8 NC 2-3/4 PL8 37 00015800 7 LOCKNUT TLM 3/8 NC PLC 38 000941 1 GREASE ZERK 1/4-28 90 BOLT THD 39 00752670 11 GREASE FITTING 1/4-28 BOLT THD 40 02983080 4 NUT, 1/2-13 ACORN 41 165020 1 PIN, COTTER 5/16 X 2-1/2 PL

Page 44

BOOM ASY - 25 FT BOOM - PN 02982739 (PART 2)

Page 45

BOOM ASY - 25 FT BOOM - PN 02982739 (PART 2)

Continued... ITEM PART NO. QTY. DESCRIPTION

42 02968835 1 PLASTIC TIE O/W 4LG 43 02968834 1 PLASTIC TIE ORG 4LG 44 02968831 1 PLASTIC TIE B/W 4LG 45 02968830 1 PLASTIC TIE BLU 4LG 46 02968828 1 PLASTIC TIE RED 4LG 47 02968829 1 PLASTIC TIE R/W 4LG 48 02968836 1 PLASTIC TIE YEL 4LG 49 02968837 1 PLASTIC TIE Y/W 4LG 50 02968894 4 PLASTIC TIE RED 11LG 51 02968896 4 PLASTIC TIE ORANGE 11LG 52 001921 1 ADP HYD ELBOW 6MJ - 6FJX 90 53 02976532 4 ADP HYD ELBOW 4MJ - 4FJX 45DEG 54 02968832 1 PLASTIC TIE GRN 4" 55 02961085 1 CORDURA SLEEVING-54 LG

02968833 1 PLASTIC TIE G/W 4LG 56 00019600 4 LOCKWASHER 1/2 HEAVY PL 57 63161900 4 SPRING NUT 1/2

Page 46

COMMON CRATE COMPONENTS - ELECT VALVE (PART 1)

Page 47

COMMON CRATE COMPONENTS - ELECT VALVE (PART 1)

Continued... ITEM PART NO. QTY. DESCRIPTION

1 02982575 1 PUMP ASY, TANDEM 2 02982553 1 CUTTER CONTROL VALVE BLOCK ASY 5 02982875 1 SWITCH, FAN 6 02981381 1 PUMP COVER ASY 7 02981441 2 KNOB 10 02981377 1 COOLER, OIL/AIR W/FAN 11 00015800 8 LOCKNUT TLM 3/8-NC PLC 12 00011100 8 FLATWASHER, 3/8" STD 13 02981383 1 MOUNT, RH (F/ OIL COOLER) 14 02981384 1 MOUNT, LH (F/ OIL COOLER) 15 02981517 2 BOLT, EYE TURNED 1/4"-20 X 1" LG 16 02981953 4 HOSE HANGER, FORMED 17 107079 1 WIRE, BLACK 14 GA-24"LG 18 02982339 2 SLEEVE, OVAL 20 02981822 1 HOSE BRACKET WELDMENT 21 00019600 2 LOCKWASHER, 1/2" HEAVY 22 02892000 2 BOLT, HEX HEAD 1/2"-NC X 1-1/2" PL GR8 23 02982581 1 HOSE GUIDE WELDMENT 25 02982576 1 VALVE ASY, ELECTRO-HYD 26 02983368 1 MODULE PROGRAM ASY 27 02982882 1 HYDRAULIC TANK ASY 28 02983014 1 JOYSTICK ASY 29 02983212 1 HOSE ASY, #12 - 12FJX - 12FJX90 - 30" LG 30 02983213 1 HOSE ASY, # 8 - 8FJX - 8FJX90 - 32" LG 31 02983214 1 HOSE ASY, #12 - 12FJX - 12FJX - 16" LG 32 02983215 1 HOSE ASY, #20 - 2FJX - 20FJX90 - 12" LG 33 02972177 6 ADAPTER, HYD STGHT 10MB - 6MJ 34 02972179 4 ADAPTER, HYD STGHT 10MB - 4MJ 35 02042300 1 ADAPTER, HYD STGHT 36 00011400 4 BOLT, HEX HEAD 3/8"-NC X 1" 37 02976531 6 ADAPTER, HYD ELBOW 6MJ - 6FJX45 38 02976532 4 ADAPTER, HYD ELBOW 4MJ - 4FJX45 39 02983325 1 PLATE, ELECT VALVE MOUNT, REAR 40 02983329 1 PLATE, ELECT VALVE MOUNT, FRONT 41 00015800 8 LOCKNUT, 3/8" 42 00023100 8 BOLT, HEX HEAD 3/8"-NC X 1-1/2" PL GR5 45 00776031 1 CANISTER, PARTS MANUAL 46 00776481 1 SHEET, MANUAL CANNISTER DECAL 47 00776583 1 MANUAL CANISTER DECAL SHEET 48 02977417 1 DECAL, OPERATORS MANUAL INSIDE 49 02981787 1 BOLT, HEX HEAD 3/4"-NC X 1-1/2" PL GR8

Page 48

COMMON CRATE COMPONENTS - ELECT VALVE (PART 2)

Page 49

COMMON CRATE COMPONENTS - ELECT VALVE (PART 2)

Continued... ITEM PART NO. QTY. DESCRIPTION

50 02982581 1 WLDMT. HOSE GUIDE 51 02983328 1 MANUAL , OPERATORS AXTREME 52 02983328CA 1 ASSEMBLY AXTREME CANISTER 53 02962774 1 ADP HYD ELBOW 24FL-20MJ45 54 00749101 1 SPLIT FLANGE KIT 1-1/2 55 02960807 2 ADP HYD STGHT 20MB -20MJ 56 63042700 1 ADP HYD STGHT 12MB-8MJ 57 02961098 1 ADP HYD ELBOW 20MB -20MJ 90 58 02090800 3 ADP HYD ELBOW 12MB-12MJ90 59 02960409 1 ADP TUBE ELBOW 20MJ-20FJX 90? 60 02959924 2 NUT TOPLOCK 1/4 NC PLB 61 02970451 4 HHCS 7/16NC 4-1/2 PL8 62 0100204 4 SPRING WASHER, 7/16 BZP 63 02972565 4 HHCS 3/8 NC 4-1/2 PL5 64 00012101 4 LOCKWASHER 3/8 PL HVY 65 02983355 1 BOLT BAG, AXTREME, COMMON

5312316 60 WASHER, 3/4" HARDENED

02963646 12 HHCS 3/4 NC 2-1/2 PL8

00037200 32 NUT 3/4-NC TOPLOCK GRC PL

02972088 8 HHCS 3/4 NC 3-1/2 PL8

02918600 8 HEXB 3/4-10UNC 2 PL8

02959587 2 HEXB, 3/4-10 NC x 6" PL8

03200269 4 HHCS 3/4 NC 3 PL8 66 02986130 1 CABLE, MANUAL CANISTER, 24" LG 67 02986111 1 CABLE, PUMP COVER 36" LG

Page 50

COMMON CRATE COMPONENTS - MAN VALVE (PART 1)

Page 51

COMMON CRATE COMPONENTS - MAN VALVE (PART 1)

Continued... ITEM PART NO. QTY. DESCRIPTION

1 02982575 1 PUMP ASY, TANDEM 2 02982553 1 CUTTER CONTROL VALVE BLOCK ASY 3 02982922 1 WIRE HARNESS, MANUAL VALVE 4 02981381 1 PUMP COVER ASY 5 02981441 2 KNOB STUD, 3/8"-NC X 1-1/2" 8 02981377 1 FAN & OIL COOLER ASY 9 00015800 8 LOCKNUT, 3/8"-NC PLB 10 02981383 1 COOLER MOUNT, RH 11 02981384 1 COOLER MOUNT, LH 12 02981517 2 BOLT, EYE TURNED 1/4"-20 X 1" LG 13 02981953 4 HANGER, FORMED HOSE 15 02982339 2 OVAL SLEEVE, 5/32" DIA. 16 D377 1 BOOKLET, DECAL BOOM MOWER 17 02981822 1 HOSE BRACKET WELDMENT 18 00019600 2 LOCKWASHER, 1/2" HEAVY 19 02892000 2 BOLT, HEX HEAD 1/2"-13NC X 1-1/2" PL GR8 20 02982581 1 HOSE GUIDE WELDMENT 21 02983084 5 CLEVIS, F/ MANUAL VALVE 22 02983354 1 VALVE ASY, MANUAL (F/ CABLE CONTROL) 23 02982882 1 HYD TANK ASY 24 02983212 1 HOSE, # 12 - 12FJX - 12FJX90 - 30" LG 25 02983213 1 HOSE, # 8 - 8FJX - 8FJX90 - 28" LG 26 02981314 1 HOSE, # 12 - 12FJX - 12FJX - 12" LG 27 02981315 1 HOSE, # 20 - 20FJX - 20FJX90 - 12" LG 28 02972177 6 ADAPTER, HYD STRAIGHT 10MB - 6MJ 29 02972179 4 ADAPTER, HYD STRAIGHT 10MB - 4MJ 30 02042300 1 ADAPTER, HYD STRAIGHT 31 00011400 1 BOLT, HEX HEAD 3/8"-NC X 1" 32 02976531 6 ADAPTER, HYD ELBOW 6MJ - 6FJX 45DEG 33 02976532 4 ADAPTER, HYD ELBOW 4MJ - 4FJX 45DEG 34 02983341 1 PLATE MANUAL VALVE MOUNT 35 0039100 8 BOLT, HEX HEAD 3/8"-NC X 1" PL GR5 36 00023100 8 BOLT, HEX HEAD 3/8"-16UNC X 1-1/2" PL GR5 37 00015800 11 LOCKNUT, 3/8"-NC PLB 38 02983342 1 PLATE, MANUAL VALVE STRAP 39 00776031 1 CANISTER, PARTS MANUAL 40 00776483 1 SHEET, MANUAL CANNISTER DECAL 41 00776583 1 MANUAL CANISTER DECAL SHEET 42 02977417 1 DECAL OPERATORS MANUAL INSIDE 43 02981787 1 BOLT, HEX HEAD 3/4"-NC X 1-1/2" PL GR8 44 02983328A 1 OPERATORS MANUAL ASY

Page 52

COMMON CRATE COMPONENTS - MAN VALVE (PART 2)

Page 53

COMMON CRATE COMPONENTS - MAN VALVE (PART 2)

Continued... ITEM PART NO. QTY. DESCRIPTION

46 02982581 1 WLDMT. HOSE GUIDE 47 02971191 1 WELDMENT,SWITCH MOUNT 48 02964028 1 SWITCH PUSH-PULL SPDT 10A@12V 50 02962748 1 DECAL-ON-OFF SWITCH CUTTER VLV 51 00749101 1 SPLIT FLANGE KIT 1-1/2 52 63042700 1 ADP HYD STGHT 12MB-8MJ 53 02961098 3 ADP HYD ELBOW 20MB -20MJ 90 54 02090800 3 ADP HYD ELBOW 12MB-12MJ90 55 02960409 2 ADP TUBE ELBOW 20MJ-20FJX 90? 56 02970451 4 HHCS 7/16NC 4-1/2 PL8 57 0100204 4 SPRING WASHER, 7/16 BZP 58 02972565 4 HHCS 3/8 NC 4-1/2 PL5 59 00012101 4 LOCKWASHER 3/8 PL HVY 60 02971243 5 CONTROL, ASY, SNGL AXIS 61 00023500 6 FLATWASHER 5/16 PL 62 02971272 3 HHCS 5/16NC 9-1/2 PL5 63 00750940 3 LOCKNUT TLM 5/16 NC PLB 64 02983355 1 BOLT BAG, AXTREME, COMMON

5312316 60 WASHER, 3/4" HARDENED

00037200 32 NUT 3/4-NC TOPLOCK GRC PL

02963646 4 HHCS 3/4 NC 2-1/2 PL8

02972088 8 HHCS 3/4 NC 3-1/2 PL8

02918600 8 HEXB 3/4-10UNC 2 PL8

02959587 2 HEXB, 3/4-10 NC x 6" PL8

03200269 4 HHCS 3/4 NC 3 PL8

02963646 6 HHCS 3/4 NC 2-1/2 PL8 65 02986130 1 CABLE, MANUAL CANISTER, 24" LG 66 02986111 1 CABLE, PUMP COVER 36" LG

Page 54

COUNTER WEIGHT W-DECALS

ITEM PART NO. QTY. DESCRIPTION

1 002508 1 DECAL, ALAMO LOGO (SQUARE) 2 1458393 1 DECAL, REFLECTOR - YELLOW 3 02967827 1 DECAL, MULTI-DANGER 4 02958241 1 DECAL, TRACTOR OPERATOR SAFETY 5 1458392 1 DECAL, REFLECTOR - RED 6 02971943 1 DECAL, ALAMO INDUSTRIAL - YELLOW 7 03200285 1 DECAL, WATCH YOUR STEP 8 02981421 1 COUNTER WEIGHT WELDMENT F/ 24 & 30 FT. MODELS 9 02981422 1 COUNTER WEIGHT ADD FOR 30 FT MODELS

Page 55

CUTTER CONTROL VALVE BLOCK - PN 02982553

ITEM PART NO. QTY. DESCRIPTION

1 02982553 1 CUTTER VALVE BLOCK ASY 2 02983513 1 COIL SOLENOID 12VDC DUAL SPADE 3 02984339 1 SOLENOID, CARTRIDGE 2P3W 4 02983516 1 LOGIC CART, 25 PSI, CUT VAL 5 02983517 1 LOGIC CART, 50 PSI, CUT VAL 6 02983515 1 RELIEF, MAIN, CUT VALVE, AXT 7 02983514 1 RELIEF, BRAKE, CUT VALVE, AXT 8 02986284A 1 KIT SEALS, LOGIC, RELIEF, AND SOLENOID

02987375 1 SEAL KIT, SOLENOID CARTRIDGE

02980979 1 SEAL KIT LOGIC VALVE

02987165 1 SEAL KIT, RELIEF VALVE

Page 56

DECALS - 18-22-25 FT BOOM

ITEM PART NO. QTY. DESCRIPTION

1 02983263 2 DECAL, LOGO - (18 FT BOOM ONLY)

02983264 2 DECAL, LOGO - (22 FT BOOM ONLY)

02983265 2 DECAL, LOGO - (25 FT BOOM ONLY) 2 02962764 6 DECAL, PINCH POINTS (18-22-25 FT BOOMS)

Page 57

DECALS - 60 IN ROTARY HEAD - SOLID MNT

ITEM PART NO. QTY. DESCRIPTION

1 00757139 2 DECAL, LOGO (ALAMO BY T.K.) 2 00757140 1 DECAL, ALAMO INDUSTRIAL LOGO 3 00769736 1 DECAL, USE/REPAIR GUARDS 4 00769737 2 DECAL, BLADES THROWN OBJECTS 5 02925100 1 DECAL, REPLACEMENT PARTS 6 02967827 1 DECAL, MULTI HAZARD 7 02967867 1 DECAL, DANGER SAFETY SHIELD 8 2738332 1 DECAL, RED OBLONG REFLECTOR 9 2738333 1 DECAL, YELLOW OBLONG REFLECTOR 10 02970889 1 DECAL, 60 ROTARY

Page 58

DECALS - 60 IN ROTARY HEAD - SWIVEL MNT

ITEM PART NO. QTY. DESCRIPTION

Page 59

DECALS - HYD TANK & PUMP - ELECT VALVE

ITEM PART NO. QTY. DESCRIPTION

1 02983409 1 DECAL, VALVE LAYOUT 2 02971943 1 DECAL, ALAMO INDUSTRIAL YELLOW 3 02965262 1 DECAL, WARNING HOSE BURST 4 02971123 1 DECAL, WARNING PRESSURIZED TANK 5 02982828 1 DECAL, TEMPERATURE RANGE 6 02982583 1 DECAL, CAUTION - DO NOT WELD

Page 60

DECALS - HYD TANK & PUMP - MAN VALVE

ITEM PART NO. QTY. DESCRIPTION

Page 61

DECALS - JOYSTICK OPERATION - PN 02983489

ITEM PART NO. QTY. DESCRIPTION

1 02983489 1 DECAL, JOYSTICK OPERATION

Page 62

DECALS - SAFETY BOOK LISTING

Page 63

DECALS - SAFETY BOOK LISTING

Continued... ITEM PART NO. QTY. DESCRIPTION

1 00725746 1 DECAL, PELIGRO 2 02965132 1 DECAL, SWINGING GUARD 3 33743 1 DECAL, MOWING SAFETY TIPS 4 00769737 1 DECAL, BLADES THROWN OBJECTS 5 02967827 1 DECAL, MULTI HAZARD 6 6T3221 1 DECAL, CAUTION - SPINDLE LUBE 7 02965141 1 DECAL, DANGER BOOM FLAILS 8 D352 1 DECAL, IMPORTANT - BE TRAINED 9 22840 1 DECAL, WARNING - FOREIGN OBJECTS 10 ---------- 1 DECAL, DANGER - THROWN OBJECT / CUTTING BLADES 11 D376 1 DECAL, WARNING - MAINTAIN SHIELDS IN GOOD CONDITION 12 24028 1 DECAL, WARNING - REPLACE WORN FLAP 13 02965262 1 DECAL, WARNING - HOSE BURST 14 33512 1 DECAL, INSPECT BLADE BOLTS - TORQUE 15 02967867 1 DECAL, DANGER - SAFETY SHIELD OPER 16 D375 1 DECAL, WARNING - REPLACE BLADE BOLTS W/BLADES 17 02962765 1 DECAL, MULTIPLE HAZARD 18 25387 1 DECAL, WARNING - RELIEVE PRES ACCUM 19 02975515 1 DECAL, WARNING DISCONNECT HYD SOLENOID BEFORE STARTING WORK 20 02971123 1 DECAL, WARNING - PRESSURIZED TANK 21 02965093 1 DECAL, PROPER ENGINE OPERATING 22 6T3225 1 DECAL, DANGER - 10 VOLTAGE LINES 23 32709 1 DECAL, REPLACEMENT PARTS 24 02958141 1 DECAL, DANGER - MAIN FRAME EXTâ€™N WLDMT 25 D377 1 SAFETY PAMPLET, NOT SHOWN - ATTACHEED TO TRACTOR

Page 64

DECALS - VALVE MAN HANDLE OPERATION - PN 02983408

ITEM PART NO. QTY. DESCRIPTION

1 02983408 1 DECAL, MAN VALVE CABLE OPERATION

Page 65

DIVERTER VALVE - DOOR & SWIVEL - PN 02977622

ITEM PART NO. QTY. DESCRIPTION

1 02977622 1 VALVE SOLENOID DIVERTER SOLENOID VALVE ASY (INCLUDES ITEMS 2 & 3) 2 -------------- 1 SOLENOID 3 --------------- 1 SOLENOID RETAINING KNOB

Page 66

FILTER ASY - RETURN - PN 02964748

ITEM PART NO. QTY. DESCRIPTION

02964748 1 FILTER ASY, RETURN FILTER 1 02978349 1 FILTER TOP COVER 2 02978355 1 NUT & BOLT KIT, F/ TOP COVER 3 02972678 1 SPRING, FILTER CARTRIDGE 4 02973782 1 VALVE, FILTER BYPASS 5 02978354 1 SEAL KIT 6 02963662 1 GASKET, FILTER ASY TO TANK, FIBER 7 02962963 1 DIAL INDICATOR, RETURN FLOW (NOT INCLUDED IN FILTER ASY) 8 02961001 1 FILTER ELEMENT, REPLACEMENT CARTRIDGE 9 ------------- 1 O-RING, TOP COVER SEAL (INCLUDED IN ITEM 5) 10 ------------- 2 O-RING, CANNISTER SEAL (INCLUDED IN ITEM 5)

Page 67

FILTER ASY - PRESSURE - PN 02976066

ITEM PART NO. QTY. DESCRIPTION

02976066 1 FILTER ASY IN-LINE MACHETE 1 02983979 1 VISUAL INDICATOR W/BYPASS 2 02978266 1 HUB, 20R10 1BORE WITH 3 02976585 1 FILTER HEAD FOR 02976066 4 02651700 1 O-RING 5 02982038 1 FILTER REPLACEMENT ELEMENT 6 02976583 1 BACK UP RING 7 02976582 1 O-RING 8 02976584 1 BOWL 4 FOR 02976066 FILTER

Page 68

FILTER ASY - PRESSURE - PN 02985280

ITEM PART NO. QTY. DESCRIPTION

1 02985281 1 FILTER ASY, HEAD 2 02985282 1 BOWL, FILTER ASY 3 02985283 1 FILTER, ELEMENT 4 02985285 1 INDICATOR, VISUAL

Page 69

THIS PAGE INTENTIONAL LEFT BLANK

Page 70

HOSE ROUTING - 18 FT BOOM

Page 71

HOSE ROUTING - 18 FT BOOM

Continued... ITEM PART NO. QTY. DESCRIPTION

1 02983346 1 HOSE, TILT (RED TIE) - CONNECT TO ITEM 7 2 02983347 1 HOSE, TILT (RED / WHITE TIE) - CONECT TO ITEM 8 3 02983348 1 HOSE, DOOR (YELLOW TIE) - CONNECT TO ITEM 9 4 02983349 1 HOSE, DOOR (YELLOW / WHITE TIE) - CONNECT TO ITEM 10 5 02983531 1 HOSE, HEAD SWIVEL (GREEN TIE) - CONNECT TO ITEM 11 6 02983532 1 HOSE, HEAD SWIVEL (GREEN / WHITE TIE) -CONNECT TO ITEM 12 7 02983350 1 HOSE, TILT (RED TIE) - CONNECT TO ITEM 1 8 02983351 1 HOSE, TILT (RED / WHITE TIE) - CONNECT TO ITEM 2 9 02983352 1 HOSE, DOOR (YELLOW TIE) - CONNECT TO ITEM 3 10 02983353 1 HOSE, DOOR (YELLOW / WHITE TIE) - CONNEC TO ITEM 4 11 02983533 1 HOSE, HEAD SWIVEL (GREEN TIE) - CONNECT TO ITEM 5 12 02983534 1 HOSE, HEAD SWIVEL (GREEN / WHITE TIE) - CONNECT OT ITEM 6 13 02984266 1 HOSE, PRESSURE (RED TIE) - CONNECTES TO 13 & 13 14 02984266 1 HOSE, RETURN (ORANGE TIE) - CONNECTS TO 14 & 14 15 02982414 1 STEEL TUBE, (ORANGE TIE) RETURN SIDE (DIPPER BOOM) 16 02982415 1 STEEL TUBE, (RED TIE) PRESSURE SIDE (DIPPER BOOM) 17 -------------- 1 HOSE, PRESSURE SUPPLY (RED TIE) - IN MOUNT KIT 18 -------------- 1 HOSE, RETURN (ORANGE TIE) - VARY W/ MOUNT KITMOUNT KIT 19 -------------- 1 HOSE, BOOM LIFT CYL (ORANGE TIE) - VARY W/ MOUNT KIT 20 -------------- 1 HOSE, BOOM LIFT CYL (ORANGE / WHITE) TIE) - VARY W/ MOUNT KIT 21 -------------- 1 HOSE, DIPPER LIFT CYL (BLUETIE) - VARY W/ MOUNT KIT 22 -------------- 1 HOSE, DIPPER LIFT CYLINDER (BLUE / WHITE TIE) - VARYS W/ MOUNT KIT 23 -------------- 1 HOSE, MOTOR PRESSURE SUPPLY (RED TIE) - VARY W/ HEAD OPTION 24 -------------- 1 HOSE, MOTOR RETURN (ORANGE TIE) - VARY W/ HEAD OPTION

Page 72

HOSE ROUTING - 22 FT BOOM

Page 73

HOSE ROUTING - 22 FT BOOM

Continued... ITEM PART NO. QTY. DESCRIPTION

1 02983178 1 HOSE, DIPPER CYL (BLUE TIE) - CONNECT TO ITEM 1 2 02983179 1 HOSE, DIPPER CYL (BLUE / WHITE TIE) - CONNECT TO ITEM 2 3 02983180 1 HOSE, TILT - LIFT BOOM (RED TIE) - CONNECT TO ITEM 9 4 02983181 1 HOSE, TILT - LIFT BOOM (RED / WHITE TIE) - CONNECT TO ITEM 10 5 02983182 1 HOSE, DOOR - LIFT BOOM (YELLOW TIE) - CONNECT TO ITEM 11 6 02983183 1 HOSE, DOOR - LIFT BOOM (YELLOW / WHITE TIE) - CONNECT TO ITEM12 7 02983503 1 HOSE, HEAD SWIVEL - LIFT BOOM (GREEN TIE) - CONNECT TO ITEM 13 8 02983504 1 HOSE, HEAD SWIVEL - LIFT BOOM (GREEN / WHITE TIE) - CONNECT TO ITEM 14 9 02983184 1 HOSE, TILT - DIPPER BOOM (RED TIE) CONNECT TO ITEM 3 10 02983185 1 HOSE, TILT - DIPPER BOOM (RED / WHITE TIE) - CONNECT TO ITEM 4 11 02983186 1 HOSE, DOOR - DIPPER BOOM (YELLOW TIE) - CONNECT TO ITEM 5 12 02983187 1 HOSE, DOOR - DIPPER BOOM (YELLOW / WHITE TIE CONNECTS TO ITEM 6 13 02983499 1 HOSE, HEAD SWIVEL - DIPPER BOOM (GREEN TIE) - CONNECT TO ITEM 7 14 02983500 1 HOSE, HEAD SWIVEL - DIPPER BOOM (GREEN / WHITE TIE) - CONNECT TO ITEM 8 15 02961054 1 HOSE, MOTOR PRESSURE - LIFT TO DIPPER BOOM (RED TIE) - CONNECT 15 TO 15 16 02961054 1 HOSE, MOTOR RETURN - LIFT TO DIPPER BOOM (ORANGE TIE) - CONNECT 16 TO 16

------------- 1 HOSE, MOTOR PRESSURE (RED TIE) - VARY W/ TYPE MOUNT KIT 17 ------------- 1 HOSE, MOTOR RETURN (ORANGE TIE) - VARY W/ TYPE MOUNT KIT 18 ------------- 1 HOSE, LIFT CYL (ORANGE / WHITE TIE) - VARY W/ TYPE MOUNT KIT 19 -------------- 1 HOSE, LIFT CYL (ORANGE TIE) - VARY W/ TYPE MOUNT KIT 20 02982704 1 STEEL TUBE, MOTOR PRESSURE - LIFT BOOM 21 02982705 1 STEEL TUBE, MOTOR RETURN - LIFT BOOM 22 02982706 1 STEEL TUBE, MOTOR PRESSURE - DIPPER BOOM 23 02982707 1 STEEL TUBE, MOTOR RETURN - DIPPER BOOM 24 -------------- 1 HOSE, MOTOR PRESSURE TO HEAD - VARY W/ HEAD OPTION 25 -------------- 1 HOSE, MOTOR RETURN FROM HEAD - VARY W/ HEAD OPTION

Page 74

HOSE ROUTING - 25 FT BOOM

Page 75

HOSE ROUTING - 25 FT BOOM

Continued... ITEM PART NO. QTY. DESCRIPTION

1 02983188 1 HOSE, DIPPER CYL (BLUE TIE) 2 02983189 1 HOSE, DIPPER CYL (BLUE / WHITE TIE) 3 02983190 1 HOSE, TILT - LIFT BOOM (RED TIE) - CONNECTS TO ITEM 7 4 02983191 1 HOSE, TILT - LIFT BOOM (RED / WHITE TIE) - CONNECTS TO ITEM 8 5 02983192 1 HOSE, DOOR - LIFT BOOM (YELLOW TIE) - CONNECTS TO ITEM 9 6 02983193 1 HOSE, DOOR - LIFT BOOM (YELLOW / WHITE TIE) - CONNECTS TO ITEM 10 7 02983194 1 HOSE, TILT - DIPPER BOOM (RED TIE) - CONNECTS TO 3 & 7 8 02983195 1 HOSE, TILT - DIPPER BOOM (RED / WHITE TIE) - CONNECTS TO ITEMS 4 & 8 9 02983196 1 HOSE, DOOR - DIPPER BOOM (YELLOW TIE) - CONNECTS TO ITEMS 5 & 9 10 02983197 1 HOSE, DOOR - DIPPER BOOM (YELLOW / WHITE TIE) - CONNECTS TO ITEM 6 & 10 11 02961054 1 HOSE, PRESSURE (RED TIE) #20 - 20FJX - 20FJX90 - 52" LG 12 02961054 1 HOSE, RETURN (ORANGE TIE) #20 - 20FJX - 20FJX90 - 52" LG 13 -------------- 1 HOSE, MOTOR PRESSURE (RED TIE) IN MOUNT KIT 14 -------------- 1 HOSE, MOTOR RETURN (ORANGE TIE) IN MOUNT KIT 15 -------------- 1 HOSE, MOTOR PRESSURE (RED TIE) VARIES WITH TYPE HEAD 16 -------------- 1 HOSE, MOTOR RETURN (ORANGE TIE) VARIES WITH TYPE HEAD 17 ------------ 1 HOSE, LIFT CYL - IN MOUNT KIT 18 ------------ 1 HOSE, LIFT CYL - IN MOUNT KIT 19 02982708 1 STEEL TUBE, MOTOR PRESSURE (LIFT BOOM) 20 02982709 1 STEEL TUBE, MOTOR RETURN (LIFT BOOM) 21 02982711 1 STEEL TUBE, MOTOR PRESSURE (DIPPER BOOM) 22 02982710 1 STEEL TUBE, MOTOR RETURN (DIPPER BOOM) 23 02983501 1 HOSE, #4 - 4FJX - 4MJ - 158" LG 24 02983502 1 HOSE, #4 - 4FJX - 4MJ - 158" LG 25 02983505 1 HOSE, #4 - 4FJX - 4MJ - 102" LG

02983506 1 HOSE, #4 - 4FJX - 4MJ - 102" LG

Page 76

HOSE ROUTING - SWING CYL (18-22-25 FT BOOM)

Page 77

HOSE ROUTING - SWING CYL (18-22-25 FT BOOM)

Continued... ITEM PART NO. QTY. DESCRIPTION

A1 02981825 1 HOSE #6-6FJX-6FJX-28LG B1 02981825 1 HOSE #6-6FJX-6FJX-28LG C1 02981826 1 HOSE #6-6FJX-6MJ-22LG C2 02981827 1 HOSE #6-6FJX-6MJ-16LG F1 02983024 1 LINE,GREASE,MANIFOLD,SHORT G1 02983026 1 LINE,GREASE,MANIFOLD,LONG H1 02983025 1 LINE,GREASE,MANIFOLD,MED J1 02983026 1 LINE,GREASE,MANIFOLD,LONG

Page 78

HYD CYL ASY - DIPPER (18 FT BOOM) - PN 02979920

ITEM PART NO. QTY. DESCRIPTION

02979920 1 DIPPER CYLINDER ASY. 1 02979784 1 CYLINDER HEAD 2 63149100 1 ADAPTER, ELBOW 3 02968830 1 PLASTIC TIE - W/ BLUE TIE 4 02968831 1 PLASTIC TIE - W/ BLUE / WHITE TIE 5 02968803 2 BUSHING 6 5JRC16140 1 LOCKNUT 7 002625 1 PISTON 8 02978823 1 ROD WLDâ€™MT 9 02979947 1 CYLINDER HEAD 10 02979924 1 TUBE / BARREL WLDâ€™MT 11 02975531 1 SEAL KIT

Page 79

HYD CYL ASY - HEAD SWIVEL (OPTIONAL) - PN 02981315

ITEM PART NO. QTY. DESCRIPTION

02981315 1 HYD CYL ASY, HEAD SWIVEL (OPTIONAL) 1 ------------- 1 WEAR RING, (SEE SEAL KIT) 2 ------------- 1 BACK-UP RING, (SEE SEAL KIT) 3 ------------- 1 O-RING, (SEE SEAL KIT) 4 ------------- 1 O-RING, (SEE SEAL KIT) 5 ------------- 1 O-RING, (SEE SEAL KIT) 6 ------------- 1 BACK-UP RING, (SEE SEAL KIT) 7 ------------- 1 WEAR RING, (SEE SEAL KIT) 8 ------------- 1 LOADED U-CUP, (SEE SEAL KIT) 9 ------------- 1 ROD WIPER, (SEE SEAL KIT) 10 ----N/S---- 1 LOCKNUT, (NON-SALEABLE) 11 ----N/S---- 1 PISTON, (NON-SALEABLE) 12 ----N/S---- 1 PISTON WASHER, (NON-SALEABLE) 13 02981935 1 BARREL WLDâ€™MT 14 02981934 1 ROD WLDâ€™MT 15 ----N/S---- 1 INTERNAL HEAD, (NON-SALEABLE) 16 02982072 1 SEAL KIT (ITEMS 1 THRU 9)

Page 80

HYD CYL ASY - LIFT (18-22-25 FT BOOM) - PN 02981279

ITEM PART NO. QTY. DESCRIPTION

02981279 1 CYLINDER ASY, 4" BORE X 24.63" STROKE 1 02981929 1 BARREL WLDâ€™MT 2 02981930 1 ROD WLDâ€™MT 3 02982250 2 BUSHING, ROD END 1-1/2" LG 4 02982251 2 BUSHING, BARREL END 2" LG 5 02982068 1 SEAL KIT

Page 81

HYD CYL ASY - SWING W/ SPHERICAL ROD END - PN 02981275A

ITEM PART NO. QTY. DESCRIPTION

02981275A 1 HYD CYL ASY, SWING CYL (W/ SPHERICAL ROD END) 1 02981921 1 BARREL WELDMENT 2 02981922A 1 ROD ASY (W/ SPHERICAL ROD END) 3 00752670 1 GREASE FITTING 4 02982068 1 SEAL KIT

Page 82

HYD CYL ASY - SWING W/ TUBE ROD END - PN 02981275

ITEM PART NO. QTY. DESCRIPTION

02981275 1 HYD CYL ASY, SWING CYL (W/ TUBE ROD END) 1 02981921 1 BARREL ASY 2 02981922 1 ROD ASY (W/ TUBE ROD END) 3 00752670 1 GREASE FITTING 1/4-28 BOLT THD 4 02982068 1 SEAL KIT

Page 83

HYD CYL ASY - TILT (18-22-25 FT BOOM) - PN 02981280

ITEM PART NO. QTY. DESCRIPTION

02981280 1 HYD CYLINDER ASY, 3" BORE X 16" STROKE (TILT CYL) 1 02981931 1 BARREL WLDâ€™MT 2 02981932 1 ROD WLDâ€™MT 3 02982250 2 BUSHING, ROD END 1-1/2" LG 4 02982071 1 SEAL KIT

Page 84

HYD OIL COOLER & FAN ASY - PN 02981377

ITEM PART NO. QTY. DESCRIPTION

1 02981377 1 HYD OIL COOLER & ELECTRIC FAN ASY.

02981886 1 HEAT EXCHANGE CORE

02981887 1 HEAT EXCHANGE FAN

Page 85

HYD SCHEMATIC - SOLID MNT HEAD (STD) - 18-22-25 FT BOOM

Page 86

HYD SCHEMATIC - SWIVEL MNT HEAD (OPT) - 18-22-25 FT BOOM

Page 87

THIS PAGE INTENTIONAL LEFT BLANK

Page 88

HYD TANK SUB-ASY - PN 02982882

Page 89

HYD TANK SUB-ASY - PN 02982882

Continued... ITEM PART NO. QTY. DESCRIPTION

1 02981389 1 TANK, WELDMENT, HYDRAULIC 2 02981413 1 WELDMENT, COVER, CLEANOUT 3 02964748 1 FILTER ASSEMBLY, MODIFIED 4 02982884 1 PIPE PLUG 2" 5 02979618 1 PIPE PLUG 1-1/4" 6 00012101 10 LOCKWASHER, 3/8" PL 7 00002000 10 HHCS 3/8 NC 3/4 PL5 8 02981400 1 O-RING, CLEANOUT SEAL 9 02968880 1 GAUGE, TEMP LEVEL INDICATOR 10 0221900 1 PIPE PLUG 3/4" 11 02963659 1 PLUG, MAGNETIC 1" NPT 12 00749508 1 PLUG 1/2" NPT 13 02981386 1 ASY, SHIELD FORMED 14 00753642 4 HHCS 3/8 NC 1-1/4 PL5 15 00015800 4 LOCKNUT TLM 3/8 NC PLC 16 00011100 4 FLATWASHER 3/8 STD 17 02982847 1 STRAINER, SUCTION 3 WITH 2 OUTLET 18 02982871 1 DRIVER SIDE COVER WELDMENT 19 02963662 1 GASKET, FILTER ASY, FIBER 20 02962963 1 DIAL INDICATOR - IN TANK FILTER 21 02960809 1 ADP, HYD STGHT 20MP-20MJ 22 02982990 1 HYD, ELBOW 32 MP - 24 MJ 90 23 02983078 1 NYLON BREATHER FILTER NY-4 24 02962864 4 WASHER, SEALING 3/8 25 00011400 4 BOLT, HHCS 3/8 NC 1 PL5 26 02983378 1 HHCS M10-P1.0-20MM

Page 90

HYD TANK W-PUMP & ELECT VALVE ASY - P/N 02983488

Page 91

HYD TANK W-PUMP & ELECT VALVE ASY - P/N 02983488

Continued... ITEM PART NO. QTY. DESCRIPTION

02983488 1 HYDRAULIC TANK, PUMP & VALVE ASY F/ ELECTRIC CONTROLS 1 02982882 1 ASY, TANK, HYDRAULIC 2 02981468 1 BRACKET, SHIPPING 3 02982575 1 FRT PUMP ASY - TANDEM 4 02982553 1 CUTTER BLOCK, AXTREME 5 02891800 2 HHCS 1/2 NC 1-3/4 PL8 6 02776600 2 HHCS 1/2 NC X 1 1/4 PL8 7 00001800 4 LOCKNUT TLM 1/2 NC PLB 8 00022200 4 LOCKWASHER 7/16 PL 9 00012101 4 LOCKWASHER, 3/8" PL 10 02970451 4 HHCS 7/16 NC 4-1/2 PL8 11 02972565 4 HHCS 3/8 NC 4-1/2 PL5 12 02972177 6 ADP, HYD ST 10MB - 6MJ 13 02972179 4 ADP, HYD ST 10MB - 4MJ 14 02976532 4 ADP, HYD, 4MJ-4FJX 45 15 02042300 1 ADP, HYD ST 10MB - 8MJ 16 02090800 2 ADP, HYD ELBOW 12MB - 12MJ 90 17 02960807 1 ADP HYD STGHT 20MB-20MJ 18 02961098 2 20 MB - 20 MJ 90° 19 02976531 6 ADP HYD ELBOW 6MJ-6FJX 45 20 02983377 1 ADAPTER, 12MJ-10MB90 21 02976522 1 ADP HYD ELBOW 12MB - 8MJ90 22 02983325 1 PLATE, ELECTRO VALVE MOUNT, REAR, AXTREME 23 02983329 1 PLATE, ELECTRO VALVE MOUNT, FRONT, AXTREME 24 00011400 4 BOLT, HHCS 3/8 NC 1 PL5 25 00015800 7 LOCKNUT TLM 3/8 NC PLC 26 02985869 1 VALVE, ELECTROHYD, AX GEN II 27 02983368 1 ASY, PROGRAM/MODULE, TOC8 28 00023100 3 HHCS 3/8 X 1-1/2 NC PL GR5 29 02959924 2 NUT, TOPLOCK 1/4 NC PLB 30 02981412 1 SENSOR, TEMPERATURE 31 02964135 1 ADP, HYD ELBOW 12MB - 12FJX 32 02976066 1 FILTER, ASY MED. PRESSURE 33 02983409 1 DECAL, VALVE LAYOUT, P70 34 02971943 1 DECAL, LOGO RECT CLEAR Y/W, 2 7/8 X 20 35 02965262 1 DECAL - WARNING - HOSE BURST 36 02971123 1 DECAL WARNING PRESS TANK 37 02982828 1 DECAL, TEMP RANGE 38 02982583 1 DO NOT WELD MAVERICK

Page 92

HYD TANK W-PUMP & MAN VALVE ASY - P/N 02983487

Page 93

HYD TANK W-PUMP & MAN VALVE ASY - P/N 02983487

Continued... ITEM PART NO. QTY. DESCRIPTION

02983487 1 HYDRAULIC TANK, PUMP & VALVE ASY F/ MANUAL CONTROLS 1 02982882 1 ASY, TANK, HYDRAULIC 2 02981468 1 BRACKET, SHIPPING 3 02983342 1 PLATE, MANUAL VALVE STRAP, AXTREME 4 02983341 1 PLATE, MANUAL VALVE MOUNT, AXTREME 5 00011400 8 BOLT, HHCS 3/8 NC 1 PL5 6 00015800 12 LOCKNUT TLM 3/8 NC PLC 7 02982575 1 FRT PUMP ASY - TANDEM 8 02982553 1 CUTTER BLOCK, AXTREME 9 02985870 1 VALVE, MANUAL, AXTREME GEN II 10 00023100 3 HHCS 3/8 X 1-1/2 NC PL GR5 11 02891800 2 HHCS 1/2 NC 1-3/4 PL8 12 02776600 2 HHCS 1/2 NC X 1 1/4 PL8 13 00001800 4 LOCKNUT TLM 1/2 NC PLB 14 00022200 4 LOCKWASHER 7/16 PL 15 00012101 4 LOCKWASHER, 3/8" PL 16 02970451 4 HHCS 7/16 NC 4-1/2 PL8 17 02972565 4 HHCS 3/8 NC 4-1/2 PL5 18 02972177 6 ADP, HYD ST 10MB - 6MJ 19 02972179 4 ADP, HYD ST 10MB - 4MJ 20 02976532 4 ADP, HYD, 4MJ-4FJX 45 21 02042300 1 ADP, HYD ST 10MB - 8MJ 22 02090800 2 ADP, HYD ELBOW 12MB - 12MJ 90 23 02960807 1 ADP HYD STGHT 20MB-20MJ 24 02961098 2 20 MB - 20 MJ 90° 25 02976531 6 ADP HYD ELBOW 6MJ-6FJX 45 26 02983377 1 ADAPTER, 12MJ-10MB90 27 02976522 1 ADP HYD ELBOW 12MB - 8MJ90 28 02964135 1 ADP, HYD ELBOW 12MB - 12FJX 29 02976066 1 FILTER, ASY MED. PRESSURE 30 00011100 1 FLATWASHER STD 3/8

Page 94

HYD VALVE CABLE & MOUNTING KIT

ITEM PART NO. QTY. DESCRIPTION

1 02971188 1 ARM REST MOUNT BRACKET 2 02971189 1 CONTROL STICK EXTENSION PLATE 3 02971190 1 PIVOT MOUNT BRACKET 4 02971191 1 SWITCH MOUNT WLDâ€™MT 5 02971243 5 CONTROL, ASY, SINGLE AXIS 6 02971260 1 ARM REST ASY 7 02971272 3 BOLT, USE W/ 5 REMOTE HANDLES 8 00023500 10 FLATWASHER 9 00035900 2 BOLT 10 10119000 2 BOLT 11 00011400 2 BOLT 12 00011100 2 FLATWASHER 13 00059900 2 BOLT 14 00015800 4 LOCKNUT 15 00750940 7 LOCKNUT

Page 95

HYD VALVE CABLE & MOUNTING KIT

Continued... ITEM PART NO. QTY. DESCRIPTION

16 02964028 1 SWITCH, PUSH PULL 17 02964063 1 KNOB, SWITCH 18 02961489 1 PIVOT PLATE WLDâ€™MT 19 02962748 1 DECAL, ON-OFF SWITCH CUTTER VALVE 20 02958203 1 SOLENOID WIRE HARNESS KIT 21 02971274 5 CABLE CONNECTION KIT 22 02971197 - CABLE, REMOTE CNTRL - 48" LG (USE LENGTH REQUIRED)

02971198 - CABLE, REMOTE CNTRL - 60" LG (USE LENGTH REQUIRED)

02969130 - CABLE, REMOTE CNTRL - 72" LG (USE LENGTH REQUIRED)

02971199 - CABLE, REMOTE CNTRL - 102" LG (USE LENGTH REQUIRED)

Page 96

JOYSTICK CONSOLE ASY - PN 02983014

Page 97

JOYSTICK CONSOLE ASY - PN 02983014

Continued... ITEM PART NO. QTY. DESCRIPTION

02983014 1 JOYSTICK CONSOLE ASY. W/ COMPONENTS 1 02981020 1 LED DISPLAY LIGHT, RED 2 02981021 1 DECAL, JOYSTICK OPERATION CONSOLE 4 02983519 2 SWITCH, MOMENTARY PUSH BUTTON,YELLOW 4A 02983522 2 PUSH BUTTON CAP, YELLOW 5 02981023 2 SWITCH, MOMENTARY PUSH BUTTON, BLACK 5A 02983473 2 PUSH BUTTON CAP, BLACK 6 02981024 1 SOCKET RELAY, (INSIDE CONSOLE NOT SEEN) 7 02981025 1 RELAY, SPDT 12VDC 20A 8 02981026 1 CIRCUIT BREAKER, 10A PANEL MOUNT 9 02981027 1 BOOT, CIRCUIT BREAKER COVER 11 02977043 1 SWITCH ROCKER DPDT, W/ GREEN LED 12 02981028 1 SWITCH, PUSH PULL 13 02983518 1 JOYSTICK ASY. (W/O CONSOLE) 14 02981990 1 RESISTER HARNESS 15 02981032 1 DECAL, SWITCH OPERATION HANDLE 17 02981030 1 SWITCH, MOMENTARY PUSH BUTTON 18 02977644 1 LOCKWASHER 19 02977643 1 CONNECTOR NUT 20 02983475 1 POTENTIOMETER - SWING 21 02983476 2 POTENTIOMETER - LIFT & DIPPER 22 02963584 1 LOCKNUT, # 8-32 23 02983477 8 SCREW, # 10-32, 5/8LG 24 02983478 8 WASHER, # 10 - NYLON

Page 98

PUMP ASY (PARTS) - PN 02982575

Page 99

PUMP ASY (PARTS) - PN 02982575

Continued... ITEM PART NO. QTY. DESCRIPTION

02961735 1 TANDEM PUMP ASY, (FRONT MOUNTED) 1 * MINOR/MAJOR1 SEAL, (IN ITEM 18 & 19) 2 02961913 1 MOUNTING FLANGE, W/ BUSHINGS 3 02961920 2 PLUG 4 * MINOR/MAJOR4 SEAL END, (IN ITEM 18 & 19) 5 02962187 1 GEAR SET, ( FRONT SET) 6 02961924 8 DOWEL PIN 7 02961915 1 GEAR HOUSING, (FRONT HOUSING) 8 * MINOR/MAJOR4 SQUARE SEAL, (IN ITEM 18 & 19) 9 --------------- 1 BEARING CARRIER HOUSING, W/BUSHINGS 10 02962188 1 GEAR SET, (REAR SET) 11 02962216 1 CONNECTOR SHAFT, (F/ CONNECTING GEAR SETS) 12 02962186 1 GEAR HOUSING, (REAR HOUSING) 13 * MAJOR 4 THRUST PLATE, (IN ITEM 19 ONLY) 14 02962184 1 END FLANGE, W/ BUSHING 15 02961917 4 WASHER 16 02962189 4 STUD 17 02962190 4 NUT 18 02962539 1 MINOR SEAL KIT, (ITEMS 1,4 & 8) 19 02962191 1 MAJOR SEAL KIT, (ITEMS 1,4,8 & 13)

Page 100

PUMP-TANK-VALVE COVER - PN 02981381

ITEM PART NO. QTY. DESCRIPTION

1 02981381 1 PUMP COVER ASY 2 02981441 2 KNOB STUD, 3/8"-NC X 1-1/2" 3 02986111 3ft CABLE, PUMP COVER STOP 4 00001000 2 CABLE CLAMP

Alamo 02983326P User Manual

Specifications and Main Features

Frequently Asked Questions

User Manual