Z-Wave ZM5101 Service Manual
ZM5101
General Purpose
®
Z-Wave
SiP Module
The ZM5101 combines a
Z-Wave SD3502 SoC (with
a built-in microcontroller
and Z-Wave RF transceiver),
crystal, and passive RF
components within a single
8mm x 8mm module. This
makes the ZM5101 ideal for
small-footprint, single microcontroller products, such
as thermostats, remote controls, lighting control, and
USB sticks.
The ZM5101 addresses the need for increasingly user-friendly and featurerich Home Control applications by providing 128kB Flash and 16kB SRAM.
The built-in keyscanner and infrared controller are ideal building blocks for
implementing a Universal Remote Control that supports both learning and
sending IR codes, as well as Z-Wave commands. The ZM5101 provides
hardware-assisted frequency agility, enabling the module to switch away from
a noisy channel without communication or software overhead. Furthermore the
very-low sleep current of the ZM5101 addresses the growing need for longer
battery life, allowing existing Z-wave products to experience up to double the
battery life of current products.
KEY BENEFITS
• Integrated RF module for fastest
time-to-market
• High GPIO pin count
• Small form factor: 8mm x 8mm
TARGET APPLICATIONS
• Remote controls
• Door locks
• Lighting control
• Thermostats
• Single-chip applications
KEY FEATURES
• Integrated CPU and RF transceiver
• 128kB Flash, 16kB SRAM
• 1000 step dimmer (TRIAC/FET)
• 4-channel 12-bit rail-to-rail ADC
• 4-channel 16-bit LED PWM
• 30 GPIOs
• Keyscan controller up to 128keys
• Infrared controller with both RX and TX
• USB full-speed device, SPI, UART, PWM
• Hardware AES 128 security engine
• 1µA sleep mode
• 9.6/40/100 kbit/s data rates
• Regional modules for 868/908/921 MHz
• Hardware-assisted frequency agility with
up to 3 channels
• ZM4101 pin-compatible
• Power supply: 2.3-3.6V
• QFN56 8mm x 8mm
• Battery monitor
ACTUAL SIZE
8mm x 8mm
POWERING THE NEW DIGITAL HOME:
SET-TOP BOXES
CONSUMER
ELECTRONICS
AV NETWORKS COMMERCIAL
HOME CONTROL
SYSTEMS
ZM5101
General Purpose Z-Wave® SiP Module
ZM5101
Keyscan
IR
MODULE COMPARISON TABLE
Feature ZM3102 ZM5202 ZM5101 ZM5304
Application General Purpose General Purpose Serial Interface Modem Only
Type PCB Module
Based on SD3301 SD3502 Die SD3503
Package
Frequency (MHz) 868/908/921 868/908/921 868/908/921 868/908/921
Bit-rate (kkbit/s) 9.6/40 9.6/40/100 9.6/40/100 9.6/40/100
FLASH Memory (kB) 32 128 128 N/A
SRAM (kB) 2 16 16 N/A
I/O 10 10 30 N/A
Key-Scan (# Keys) None None 128 N/A
IR Support None None Transmit/Learn N/A
UART/SPI 1/1 1/1 2/2 1/-
USB 2.0 Device None None 1 1
Security 128-bit AES Yes SW Only Yes HW Yes HW Yes HW
Tx RF Power (dBm) -22 to -2 -26 to +4 -24 to +6 -26 to +4
Rx Sensitivity (dBm) -102 @ 9.6kbit/s -103 @ 9.6kbit/s -105 @ 9.6kbit/s -103 @ 9.6kbit/s
Tx/Rx Current (mA) 36(@ -2dBm) /23 41(@ 0dBm) /32 32(@ 0dBm) /32 36(@ 0dBm) /33
Sleep Current (µA) 2.5 1 1 2
Battery to Battery (µA) 80 50 50 N/A
XTAL
Supply
Filtering
USB
SPI UART TRIAC
PCB Module
13x14mm
SD3502
SoC
In
PCB Module
w/ SAW Filter
PCB Module
Out
13x14mm
PWMAnalog
CUSTOMER-REQUIRED
HARDWARE
Regional SAW
Filter Required
SiP w/o
SAW Filter
QFN56
8x8mm
Antenna
PCB Module
w/ Ant. &
SAW Filter
PCB Module
13x30mm
ABOUT SIGMA DESIGNS
Sigma Designs is a leading provider of system-on-chip (SoC) solutions used to deliver entertainment and control
throughout the home:
Media Processing, Smart TV, Video Encoding, Home AV Networking, Video Processing, Home Control
These SoCs are supported with board-level reference designs, sophisticated system software, and technical
documentation to form a complete solution for a variety of set-top boxes, smart TVs, consumer electronics, AV network
devices, and home control systems.
Features subject to change without notice. Sigma Designs, HiDTV, Z-Wave, and the Sigma Designs logo are either registered trademarks or
trademarks of Sigma Designs, Inc. and its subsidiaries in the United States and other countries. All other trademarks or registered trademarks
are the property of their respective owners. These devices incorporate copy protection technology that is protected by U.S. patents and other
intellectual property rights of Rovi Corporation. Reverse engineering and disassembly are prohibited. Devices that incorporate Rovi Corporation’s
Anti-Copy Process (ACP) technology may only be sold to Rovi Authorized Buyers. Copyright © 2015 Sigma Designs, Inc. All rights reserved.
Rev. 07.16.14 PMB12438
FOR REGIONAL SALES OFFICES AND
DISTRIBUTOR CONTACT INFORMATION
Visit: go-z-wave.sigmadesigns.com
Headquarters
47467 Fremont Blvd.
Fremont, CA 94538 USA
Main: +1.510.897.0200
z-wave.sigmadesigns.com
Loading...