Zoeller 508 Specification Sheet
Product information presented
here reects conditions at time
of publication. Consult factory
regarding discrepancies or
inconsistencies.
SECTION: 2.65.013
FM3124
0619
Supersedes
0918
Patent No. D740329
TECHNICAL DATA SHEET
MODEL 508 12-VOLT BACKUP
Submersible Sump Pump System
CONTROLLER
The Aquanot® Fit 508 with Z Control® technology is a premium high
performance, self-testing internet-connected battery backup pump
system.
PUMP
• 12 volt, highly efcient, non-corrodible pump construction.
Supplied with 9' (2.7 m) leads.
• Legs allow free-standing installation
• Quick disconnect discharge
• Aluminum seal pocket and cooling plate
• Integrated check valve
CONTROLLER
The Aquanot® Fit DC Controller keeps the battery charged. The
controller has many built-in features such as:
• Monitors the switches,runs the pump
• Performs Self-testing diagnostics
• Communicates with the Z Control® Cloud; receives
commands from user through Cloud such as "Silence",
"Reset", "Test", and many conguration changes
• 7 amp
AQUANOT® FIT
Solid Flashing Off
System
Ready
Battery
DC pump
Float
Status
Z Control Connected Searching
No Faults (Green)
Charged (Green)
Charging (Yellow)
Bad Battery (Red)
Pump Ran
(Yellow)
High Water (Red) Float Fault (Red) --
AC off with no
faults (Green)
Low Battery (Red) No AC Power
Pump Running
(Yellow)
Pump Fault (Red)
--
--
Broadcasting
SSID or
Dormant
ALERTS
• Pump cycled
• High water
• Battery fault
• Switch fault
• Pump fault
• Connection fault
• Power outage/restored
• Pump activation
BUTTONS
• Alarm Silence/Reset - press to silence alarms. Press and hold
for three seconds to reset alarms.
• Test - Press to initiate pump test
SWITCHES
• Reliable, vertical oat switch for adjustable operation.
• High water reed sensor provides high water signal and
redundant pump run.
BATTERY CASE
The included battery case will accommodate maximum battery
dimensions of 13" (330 mm) L x 7-1/2" (191 mm) W x 9-1/2" (241
mm) H and ts all group size 27, 29 and 31 batteries. Made from
non-corrodible polyethylene. To use multiple batteries, order extra
battery case with hookup wire (P/N 007861).
FITTINGS
An integrated DC pump discharge check valve, additional thread-in
AC pump check valve, tee, and adapter are included.
Aquanot® Fit 508 system
Aquanot® Deep-cycle Battery (purchase separately)
P/N 10-1450 - AGM (shown)
P/N 10-0761 - Wet
502-778-2731 | 800-928-7867 | 3649 Cane Run Road | Louisville, KY 40211-1961 | zoellerpumps.com
© Copyright 2019 Zoeller® Co. All rights reserved.
TOTAL DYNAMIC HEAD FLOW
TOTAL DYNAMIC HEAD/FLOW
PER MINUTE
EFFLUENT AND DEWATERING
22ft. (6.7m)
508
Shut-off Head:
MODEL
15
10
Feet
5
4.6
3.0 30
20
1.5
Meters39Gal.
76
114
148
Liters
20 6.1 6 23
METERS
PER MINUTE
CAUTION
PER MINUTE @ 12.1 VOLTS
MODEL
Feet
5
10
15
20 6.1 6 23
Shut-off Head:
Shipping weight: 17 lbs. (7.7 kg)
NOTE: Not recommended for installation with over 20' (6 m) Total Dynamic
Head.
Performance chart based upon actual performance achieved with a 12 volt
deep-cycle battery. Some manufacturers publish performance data based upon
D.C. Pump testing according to Marine Industry standards which can reflect a
performance of 40% - 80% higher than actual battery powered performance.
See FM3120 (Aquanot
Minimum pit size recommendation: 18" (46 cm) diameter X 22" (56 cm)
deep. Minimum battery requirements: deep-cycle, size 27, 175 minute
reserve capacity.
Meters39Gal.
1.5
3.0 30
4.6
®
Fit 508) Installation Instructions.
508
Liters
148
114
20
76
22ft. (6.7m)
152944
PUMP PERFORMANCE CURVE
FEET
8
25
20
6
15
4
10
TOTAL DYNAMIC HEAD
2
5
0
GALLONS
LITERS
0 80
MODEL 508 @ 12.1 VOLTS
10 20 30
FLOW PER MINUTE
40
160
50
WARRANTY
3 years from date of purchase. Battery warranty is 3 years.
BATTERY LIFE
The estimated life of a fully charged (175 minute reserve capacity)
battery when the pump is operating continuously is approximately
5.5 hours. However, most backup system pump operation is
intermittent.The system will provide protection for extended periods
of time dependent upon stop-start requirements and multiple
battery arrangements.
PERFORMANCE DATA
Pump performance is based on the use of a fully charged 12 volt,
(200-minute reserve capacity) deep-cycle battery with no deciency
and less than two years old.
AQUANOT® BATTERY
• Size 31 “Wet” P/N 10-0761 (69 lbs. [31 kg]) (shipped via
truckline only) 200 minute reserve capacity
• Size 27 “AGM” P/N 10-1450 (66 lbs. [30 kg]) 175-minute
reserve capacity
All installation of controls, protection devices and wiring should be done by a qualified licensed electrician. All electrical and safety codes should be
followed including the most recent National Electrical Code (NEC) and the Occupational Safety and Health Act (OSHA).
DC PUMP INSTALLED IN LINE WITH SUBMERSIBLE PUMP
CONTROLLER
OUTLET
PRIMARY PUMP
OUTLET
HIGH-WATER
REED SENSOR
IMPORTANT: OFF LEVEL
OF FLOAT ASSEMBLY
MUST BE HIGHER THAN
DC BACKUP PUMP
1" MIN.
FIG. 1
AQUANOT FIT CONTROLLER
BATTERY BOX
SK3182
502-778-2731 | 800-928-7867 | 3649 Cane Run Road | Louisville, KY 40211-1961 | zoellerpumps.com
© Copyright 2019 Zoeller® Co. All rights reserved.
Loading...