SAFETY DATA SHEET
BZ7598 ZC PINE MP CLEANER ZUMPP128 4/1G
Version 1.1
Revision Date 05/28/2015
Print Date 05/09/2017
Material name
:
BZ7598 ZC PINE MP CLEANER ZUMPP128 4/1G
Material number
:
000000000001041695
Company
:
Zep Inc.
Address
:
1310 Seaboard Industrial Blvd., NW
Atlanta, GA 30318
Telephone
:
404-352-1680
Emergency telephone numbers
For SDS Information
:
Compliance Services 1-877-428-9937
For a Medical Emergency
:
877-541-2016 Toll Free - All Calls Recorded
For a Transportation
Emergency
:
CHEMTREC: 800-424-9300 - All Calls Recorded.
In the District of Columbia 202-483-7616
Appearance
liquid
Colour
clear, amber
Odour
characteristic
IARC
No component of this product present at levels greater than or
equal to 0.1% is identified as probable, possible or confirmed
human carcinogen by IARC.
ACGIH
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by ACGIH.
OSHA
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by OSHA.
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Manufacturer or supplier's details
Note: This product is labeled as a consumer product in accordance with the United States
Consumer Product Safety Commission regulations. The warnings presented below in this Safety
Data Sheet (SDS) comply with the 2012 OSHA Hazard Communication Standard (GHS - Globally
Harmonized System of Classification and Labeling). The requirements for the labeling and
warnings of consumer products may differ from those required for GHS based hazard
communication.
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
GHS Classification
Not a hazardous substance or mixture.
GHS Label element
Not a hazardous substance or mixture.
Potential Health Effects
Carcinogenicity:
1 / 9
SAFETY DATA SHEET
BZ7598 ZC PINE MP CLEANER ZUMPP128 4/1G
Version 1.1
Revision Date 05/28/2015
Print Date 05/09/2017
NTP
No component of this product present at levels greater than or
equal to 0.1% is identified as a known or anticipated carcinogen
by NTP.
Substance / Mixture
:
Mixture
Chemical Name
CAS-No.
Concentration [%]
Alcohols, C12-16, ethoxylated
68551-12-2
>= 1 - < 5
General advice
:
Do not leave the victim unattended.
If inhaled
:
If unconscious place in recovery position and seek medical
advice.
If symptoms persist, call a physician.
In case of skin contact
:
If skin irritation persists, call a physician.
Wash off immediately with plenty of water for at least 15
minutes.
If on clothes, remove clothes.
Wash contaminated clothing before re-use.
In case of eye contact
:
Remove contact lenses.
Protect unharmed eye.
Keep eye wide open while rinsing.
If eye irritation persists, consult a specialist.
In case of contact, immediately flush eyes with plenty of water
for at least 15 minutes.
If swallowed
:
Keep respiratory tract clear.
Never give anything by mouth to an unconscious person.
DO NOT induce vomiting unless directed to do so by a
physician or poison control center.
If symptoms persist, call a physician.
Suitable extinguishing media
:
Alcohol-resistant foam
Carbon dioxide (CO2)
Water spray jet
Dry chemical
Unsuitable extinguishing
media
:
High volume water jet
Specific hazards during
firefighting
:
Do not allow run-off from fire fighting to enter drains or water
courses.
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components
SECTION 4. FIRST AID MEASURES
SECTION 5. FIREFIGHTING MEASURES
2 / 9
SAFETY DATA SHEET
BZ7598 ZC PINE MP CLEANER ZUMPP128 4/1G
Version 1.1
Revision Date 05/28/2015
Print Date 05/09/2017
Hazardous combustion
products
:
Carbon dioxide (CO2)
Carbon monoxide
Smoke
Sulphur oxides
Specific extinguishing
methods
:
Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.
Further information
:
Standard procedure for chemical fires.
Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.
Special protective equipment
for firefighters
:
Wear self-contained breathing apparatus for firefighting if
necessary.
Personal precautions,
protective equipment and
emergency procedures
:
Use personal protective equipment.
Ensure adequate ventilation.
Evacuate personnel to safe areas.
Remove all sources of ignition.
Environmental precautions
:
Prevent further leakage or spillage if safe to do so.
Prevent further leakage or spillage.
If the product contaminates rivers and lakes or drains inform
respective authorities.
Methods and materials for
containment and cleaning up
:
Neutralise with acid.
Wipe up with absorbent material (e.g. cloth, fleece).
Keep in suitable, closed containers for disposal.
Advice on safe handling
:
Avoid contact with skin and eyes.
For personal protection see section 8.
Smoking, eating and drinking should be prohibited in the
application area.
Dispose of rinse water in accordance with local and national
regulations.
Conditions for safe storage
:
Keep container tightly closed in a dry and well-ventilated
place.
Electrical installations / working materials must comply with
the technological safety standards.
Materials to avoid
:
Oxidizing agents
SECTION 6. ACCIDENTAL RELEASE MEASURES
SECTION 7. HANDLING AND STORAGE
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
Contains no substances with occupational exposure limit values.
3 / 9
SAFETY DATA SHEET
BZ7598 ZC PINE MP CLEANER ZUMPP128 4/1G
Version 1.1
Revision Date 05/28/2015
Print Date 05/09/2017
Respiratory protection
:
In case of insufficient ventilation, wear suitable respiratory
equipment.
Remarks
:
The suitability for a specific workplace should be discussed
with the producers of the protective gloves.
Eye protection
:
Ensure that eyewash stations and safety showers are close to
the workstation location.
Safety glasses
Skin and body protection
:
impervious clothing
Choose body protection according to the amount and
concentration of the dangerous substance at the work place.
Hygiene measures
:
When using do not eat or drink.
When using do not smoke.
Wash hands before breaks and at the end of workday.
Appearance
:
liquid
Colour
:
clear, amber
Odour
:
characteristic
Odour Threshold
:
no data available
pH : 10 - 11
Melting point/freezing point
:
no data available
Boiling point
:
no data available
Flash point
:
> 93.3 °C
Method: closed cup
Evaporation rate
:
no data available
Upper explosion limit
:
no data available
Lower explosion limit
:
no data available
Vapour pressure
:
no data available
Relative vapour density
:
no data available
Density
:
1 g/cm3
Water solubility
:
soluble
Solubility in other solvents
:
not determined
Partition coefficient: noctanol/water
:
no data available
Personal protective equipment
Hand protection
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Solubility(ies)
4 / 9
SAFETY DATA SHEET
BZ7598 ZC PINE MP CLEANER ZUMPP128 4/1G
Version 1.1
Revision Date 05/28/2015
Print Date 05/09/2017
Auto-ignition temperature
:
not determined
Thermal decomposition
:
no data available
Viscosity, kinematic
:
no data available
Reactivity
:
Stable
Chemical stability
:
Stable under normal conditions.
Possibility of hazardous
reactions
:
No decomposition if stored and applied as directed.
Conditions to avoid
:
no data available
Incompatible materials
:
Oxidizing agents
Hazardous decomposition
products
:
Carbon monoxide
Carbon dioxide (CO2)
Sulphur oxides
Remarks: May cause skin irritation and/or dermatitis.
Remarks: Vapours may cause irritation to the eyes, respiratory system and the skin.
Viscosity
SECTION 10. STABILITY AND REACTIVITY
SECTION 11. TOXICOLOGICAL INFORMATION
Acute toxicity
no data available
Skin corrosion/irritation
Product:
Serious eye damage/eye irritation
Product:
Respiratory or skin sensitisation
no data available
Germ cell mutagenicity
no data available
Carcinogenicity
no data available
Reproductive toxicity
no data available
5 / 9
SAFETY DATA SHEET
BZ7598 ZC PINE MP CLEANER ZUMPP128 4/1G
Version 1.1
Revision Date 05/28/2015
Print Date 05/09/2017
Remarks: no data available
Partition coefficient: noctanol/water
:
Remarks: no data available
Regulation
40 CFR Protection of Environment; Part 82 Protection of
Stratospheric Ozone - CAA Section 602 Class I
Substances
Remarks
This product neither contains, nor was manufactured
with a Class I or Class II ODS as defined by the U.S.
Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A
+ B).
Additional ecological
information
:
no data available
Alcohols, C12-16, ethoxylated:
STOT - single exposure
no data available
STOT - repeated exposure
no data available
Aspiration toxicity
no data available
Further information
Product:
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity
no data available
Persistence and degradability
no data available
Bioaccumulative potential
Product:
Mobility in soil
no data available
Other adverse effects
no data available
Product:
SECTION 13. DISPOSAL CONSIDERATIONS
6 / 9
SAFETY DATA SHEET
BZ7598 ZC PINE MP CLEANER ZUMPP128 4/1G
Version 1.1
Revision Date 05/28/2015
Print Date 05/09/2017
Waste from residues
:
Do not dispose of waste into sewer.
Do not contaminate ponds, waterways or ditches with
chemical or used container.
Dispose of in accordance with local regulations.
Contaminated packaging
:
Empty remaining contents.
Dispose of as unused product.
Do not re-use empty containers.
Transportation Regulation: 49 CFR (USA):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IMDG (Vessel):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IATA (Cargo Air):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IATA (Passenger Air):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: TDG (Canada):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
SARA 311/312 Hazards
:
No SARA Hazards
No SARA Hazards
SARA 302
:
SARA 302: No chemicals in this material are subject to the
reporting requirements of SARA Title III, Section 302.
SARA 313
:
SARA 313: This material does not contain any chemical
components with known CAS numbers that exceed the
threshold (De Minimis) reporting levels established by SARA
Title III, Section 313.
Disposal methods
SECTION 14. TRANSPORT INFORMATION
SECTION 15. REGULATORY INFORMATION
EPCRA - Emergency Planning and Community Right-to-Know Act
CERCLA Reportable Quantity
This material does not contain any components with a CERCLA RQ.
SARA 304 Extremely Hazardous Substances Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
7 / 9
SAFETY DATA SHEET
BZ7598 ZC PINE MP CLEANER ZUMPP128 4/1G
Version 1.1
Revision Date 05/28/2015
Print Date 05/09/2017
California Prop 65
This product does not contain any chemicals known to State of
California to cause cancer, birth defects, or any other
reproductive harm.
TSCA
On TSCA Inventory
DSL
This product contains one or several components that are not on the
Canadian DSL nor NDSL.
AICS
Not in compliance with the inventory
NZIoC
Not in compliance with the inventory
PICCS
Not in compliance with the inventory
IECSC
On the inventory, or in compliance with the inventory
NFPA:
HMIS III:
Version:
1.1
Revision Date:
05/28/2015
Print Date:
05/09/2017
Flammability
Health
Instability
22
11
00
Special hazard.
FLAMMABILITY
PHYSICAL HAZARD
HEALTH
1
0
2
0 = not significant, 1 =Slight,
2 = Moderate, 3 = High
4 = Extreme, * = Chronic
The components of this product are reported in the following inventories:
Inventory Acronym and Validity Area Legend:
AICS (Australia), DSL (Canada), IECSC (China), REACH (European Union), ENCS (Japan), ISHL
(Japan), KECI (Korea), NZIoC (New Zealand), PICCS (Philippines), TSCA (USA)
SECTION 16. OTHER INFORMATION
Further information
OSHA GHS Label Information:
Not a hazardous substance or mixture.
We believe the statements, technical information and recommendations contained herein are
reliable, but they are given without warranty or guarantee of any kind. The information in this
document applies to this specific material as supplied. It may not be valid for this material if it
is used in combination with any other materials. Users should make their own investigations
to determine the suitability and applicability of the information for their particular purposes.
8 / 9
SAFETY DATA SHEET
BZ7598 ZC PINE MP CLEANER ZUMPP128 4/1G
Version 1.1
Revision Date 05/28/2015
Print Date 05/09/2017
This SDS has been prepared by the Compliance Services organization supporting this
manufacturer, supplier or distributor.
Zep Inc. markets products under well recognized and established brand names such as Zep®,
Zep Commercial®,Zep Professional®, Enforcer®, National Chemical™, Selig™, Mis ty®, Next
Dimension™, Petro®, i-Chem®, TimeMist®, TimeWick™, MicrobeMax®, Country Vet®,
Konk®, Original Bike Spirits®, Blue Coral®, Black Magic®, Rain-X®, Niagara National™, FC
Forward Chemicals®,Rexodan®, Mykal™, and a number of private labeled brands.
9 / 9
Loading...