SAFETY DATA SHEET
A07699 ZC FOAMING GLS ZUFGC19A 20N19 STK
Version 3.1
Revision Date 12/14/2016
Print Date 02/15/2017
Material name
:
A07699 ZC FOAMING GLS ZUFGC19A 20N19 STK
Material number
:
000000000001046502
Company
:
Zep Inc.
Address
:
1310 Seaboard Industrial Blvd., NW
Atlanta, GA 30318
Telephone
:
404-352-1680
Emergency telephone numbers
For SDS Information
:
Compliance Services 1-877-428-9937
For a Medical Emergency
:
877-541-2016 Toll Free - All Calls Recorded
For a Transportation
Emergency
:
CHEMTREC: 800-424-9300 - All Calls Recorded.
In the District of Columbia 202-483-7616
Recommended use
:
Glass Cleaner
Appearance
Aerosol containing a liquefied gas
Colour
colourless
Odour
pleasant
Gases under pressure
:
Liquefied gas
Hazard pictograms
:
Signal word
:
Warning
Hazard statements
:
H280 Contains gas under pressure; may explode if heated.
Precautionary statements
:
Storage:
P410 + P403 Protect from sunlight. Store in a well-ventilated
place.
Disposal:
P501 Dispose of contents/ container to an approved waste
disposal plant.
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Manufacturer or supplier's details
Recommended use of the chemical and restrictions on use
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
GHS Classification
GHS label elements
1 / 11
SAFETY DATA SHEET
A07699 ZC FOAMING GLS ZUFGC19A 20N19 STK
Version 3.1
Revision Date 12/14/2016
Print Date 02/15/2017
Substance / Mixture
:
Mixture
Chemical name
CAS-No.
Concentration [%]
ethanol
64-17-5
>= 1 - < 5
butane
106-97-8
>= 1 - < 5
propan-2-ol
67-63-0
>= 1 - < 5
General advice
:
Do not leave the victim unattended.
Move out of dangerous area.
Show this safety data sheet to the doctor in attendance.
If inhaled
:
If unconscious place in recovery position and seek medical
advice.
Consult a physician after significant exposure.
In case of skin contact
:
If skin irritation persists, call a physician.
Wash off immediately with plenty of water for at least 15
minutes.
If on clothes, remove clothes.
In case of eye contact
:
Remove contact lenses.
Protect unharmed eye.
Keep eye wide open while rinsing.
If eye irritation persists, consult a specialist.
Rinse immediately with plenty of water for at least 15 minutes.
If swallowed
:
Keep respiratory tract clear.
Never give anything by mouth to an unconscious person.
If symptoms persist, call a physician.
DO NOT induce vomiting unless directed to do so by a
physician or poison control center.
Take victim immediately to hospital.
Most important symptoms
and effects, both acute and
delayed
:
Effects may be delayed, symptoms may include minor eye or
skin irritation.
Overexposure may cause mild eye or skin irritation.
Notes to physician
:
Treat symptomatically. Symptoms may be delayed.
Suitable extinguishing media
:
Water spray jet
Alcohol-resistant foam
Carbon dioxide (CO2)
Dry chemical
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components
The exact percentages of disclosed substances are withheld as trade secrets.
SECTION 4. FIRST AID MEASURES
SECTION 5. FIREFIGHTING MEASURES
2 / 11
SAFETY DATA SHEET
A07699 ZC FOAMING GLS ZUFGC19A 20N19 STK
Version 3.1
Revision Date 12/14/2016
Print Date 02/15/2017
Unsuitable extinguishing
media
:
High volume water jet
Specific hazards during
firefighting
:
Do not allow run-off from fire fighting to enter drains or water
courses.
Hazardous combustion
products
:
Carbon dioxide (CO2)
Carbon monoxide
Smoke
Specific extinguishing
methods
:
Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.
Further information
:
Standard procedure for chemical fires.
Collect contaminated fire extinguishing water separately. This
must not be discharged into drains.
Fire residues and contaminated fire extinguishing water must
be disposed of in accordance with local regulations.
For safety reasons in case of fire, cans should be stored
separately in closed containments.
Use a water spray to cool fully closed containers.
Special protective equipment
for firefighters
:
Wear self-contained breathing apparatus for firefighting if
necessary.
Personal precautions,
protective equipment and
emergency procedures
:
Use personal protective equipment.
Ensure adequate ventilation.
Remove all sources of ignition.
Evacuate personnel to safe areas.
Beware of vapours accumulating to form explosive
concentrations. Vapours can accumulate in low areas.
Environmental precautions
:
Prevent further leakage or spillage if safe to do so.
Prevent product from entering drains.
If the product contaminates rivers and lakes or drains inform
respective authorities.
Methods and materials for
containment and cleaning up
:
Soak up with inert absorbent material (e.g. sand, silica gel,
acid binder, universal binder, sawdust).
Sweep up or vacuum up spillage and collect in suitable
container for disposal.
Advice on safe handling
:
Avoid exposure - obtain special instructions before use.
Avoid contact with skin and eyes.
For personal protection see section 8.
Smoking, eating and drinking should be prohibited in the
application area.
Do not breathe vapours or spray mist.
Take precautionary measures against static discharges.
Provide sufficient air exchange and/or exhaust in work rooms.
SECTION 6. ACCIDENTAL RELEASE MEASURES
SECTION 7. HANDLING AND STORAGE
3 / 11
SAFETY DATA SHEET
A07699 ZC FOAMING GLS ZUFGC19A 20N19 STK
Version 3.1
Revision Date 12/14/2016
Print Date 02/15/2017
Dispose of rinse water in accordance with local and national
regulations.
Always replace cap after use.
Conditions for safe storage
:
BEWARE: Aerosol is pressurized. Keep away from direct sun
exposure and temperatures over 50 °C. Do not open by force
or throw into fire even after use. Do not spray on flames or
red-hot objects.
Keep container tightly closed in a dry and well-ventilated
place.
Observe label precautions.
Electrical installations / working materials must comply with
the technological safety standards.
Keep in a dry, cool and well-ventilated place.
Materials to avoid
:
Oxidizing agents
Components
CAS-No.
Value type
(Form of
exposure)
Control
parameters /
Permissible
concentration
Basis
ethanol
64-17-5
TWA
1,000 ppm
ACGIH
TWA
1,000 ppm
1,900 mg/m3
NIOSH REL
TWA
1,000 ppm
1,900 mg/m3
OSHA Z-1
TWA
1,000 ppm
1,900 mg/m3
OSHA P0
STEL
1,000 ppm
ACGIH
PEL
1,000 ppm
1,900 mg/m3
CAL PEL
butane
106-97-8
TWA
800 ppm
1,900 mg/m3
NIOSH REL
TWA
800 ppm
1,900 mg/m3
OSHA P0
PEL
800 ppm
1,900 mg/m3
CAL PEL
propan-2-ol
67-63-0
TWA
200 ppm
ACGIH
STEL
400 ppm
ACGIH
TWA
400 ppm
980 mg/m3
NIOSH REL
ST
500 ppm
1,225 mg/m3
NIOSH REL
TWA
400 ppm
980 mg/m3
OSHA Z-1
TWA
400 ppm
980 mg/m3
OSHA P0
STEL
500 ppm
1,225 mg/m3
OSHA P0
PEL
400 ppm
980 mg/m3
CAL PEL
STEL
500 ppm
CAL PEL
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
4 / 11
SAFETY DATA SHEET
A07699 ZC FOAMING GLS ZUFGC19A 20N19 STK
Version 3.1
Revision Date 12/14/2016
Print Date 02/15/2017
1,225 mg/m3
Component
CAS-No.
Control
parameters
Biological
specimen
Sampling
time
Permissible
concentration
Basis
PROPAN-2-OL
67-63-0
Acetone
Urine
End of
shift at
end of
workwee
k
40 mg/l
ACGIH BEI
Engineering measures
:
effective ventilation in all processing areas
Respiratory protection
:
Use respiratory protection unless adequate local exhaust
ventilation is provided or exposure assessment demonstrates
that exposures are within recommended exposure guidelines.
Remarks
:
The suitability for a specific workplace should be discussed
with the producers of the protective gloves.
Eye protection
:
Eye wash bottle with pure water
Safety glasses
Skin and body protection
:
Impervious clothing
Choose body protection according to the amount and
concentration of the dangerous substance at the work place.
Hygiene measures
:
Wash hands before breaks and at the end of workday.
When using do not eat, drink or smoke.
When using do not smoke.
Appearance
:
Aerosol containing a liquefied gas
Colour
:
colourless
Odour
:
pleasant
Odour Threshold
:
No data available
pH : 10 - 11
Melting point/freezing point
:
No data available
Boiling point
:
No data available
Flash point
:
No data available
Evaporation rate
:
No data available
Upper explosion limit
:
No data available
Lower explosion limit
:
No data available
Biological occupational exposure limits
Personal protective equipment
Hand protection
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
5 / 11
SAFETY DATA SHEET
A07699 ZC FOAMING GLS ZUFGC19A 20N19 STK
Version 3.1
Revision Date 12/14/2016
Print Date 02/15/2017
Vapour pressure
:
No data available
Relative vapour density
:
No data available
Density
:
0.986 g/cm3
Water solubility
:
soluble in cold water, soluble in hot water
Partition coefficient: noctanol/water
:
No data available
Auto-ignition temperature
:
not determined
Thermal decomposition
:
No data available
Viscosity, kinematic
:
No data available
Reactivity
:
Stable
Chemical stability
:
Stable under normal conditions.
Possibility of hazardous
reactions
:
No decomposition if stored and applied as directed.
Conditions to avoid
:
Heat, flames and sparks.
Extremes of temperature and direct sunlight.
Incompatible materials
:
Oxidizing agents
Hazardous decomposition
products
:
Carbon oxides
Aggravated Medical
Condition
:
None known.
Symptoms of Overexposure
:
Effects may be delayed, symptoms may include minor eye or
skin irritation.
IARC
No component of this product present at levels greater than or
equal to 0.1% is identified as probable, possible or confirmed
human carcinogen by IARC.
OSHA
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by OSHA.
NTP
No component of this product present at levels greater than or
Solubility(ies)
Viscosity
SECTION 10. STABILITY AND REACTIVITY
SECTION 11. TOXICOLOGICAL INFORMATION
Potential Health Effects
Carcinogenicity:
6 / 11
SAFETY DATA SHEET
A07699 ZC FOAMING GLS ZUFGC19A 20N19 STK
Version 3.1
Revision Date 12/14/2016
Print Date 02/15/2017
equal to 0.1% is identified as a known or anticipated carcinogen
by NTP.
Acute oral toxicity
:
Acute toxicity estimate : > 5,000 mg/kg
Method: Calculation method
Acute oral toxicity
:
LD50 Oral Rat: 7,060 mg/kg
Acute inhalation toxicity
:
LC50 Rat: 124.7 mg/l
Exposure time: 4 h
Acute inhalation toxicity
:
LC50 Mouse: 1,237 mg/l
Exposure time: 2 h
LC50 Rat: 1,355 mg/l
Acute oral toxicity
:
LD50 Oral Rat: 4,396 mg/kg
Method: Calculation method
Acute toxicity
Product:
Components:
ethanol:
butane:
propan-2-ol:
Skin corrosion/irritation
No data available
Serious eye damage/eye irritation
No data available
Respiratory or skin sensitisation
No data available
Germ cell mutagenicity
No data available
Carcinogenicity
No data available
Reproductive toxicity
No data available
ethanol:
butane:
propan-2-ol:
STOT - single exposure
No data available
STOT - repeated exposure
No data available
7 / 11
SAFETY DATA SHEET
A07699 ZC FOAMING GLS ZUFGC19A 20N19 STK
Version 3.1
Revision Date 12/14/2016
Print Date 02/15/2017
Remarks: No data available
Partition coefficient: noctanol/water
:
Remarks: No data available
Partition coefficient: noctanol/water
:
Pow: 2.89
Regulation
40 CFR Protection of Environment; Part 82 Protection of
Stratospheric Ozone - CAA Section 602 Class I
Substances
Remarks
This product neither contains, nor was manufactured
with a Class I or Class II ODS as defined by the U.S.
Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A
+ B).
Additional ecological
information
:
No data available
Waste from residues
:
Do not dispose of waste into sewer.
Aspiration toxicity
No data available
Further information
Product:
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity
No data available
Persistence and degradability
No data available
Bioaccumulative potential
Product:
Components:
butane :
Mobility in soil
No data available
Other adverse effects
No data available
Product:
SECTION 13. DISPOSAL CONSIDERATIONS
Disposal methods
8 / 11
SAFETY DATA SHEET
A07699 ZC FOAMING GLS ZUFGC19A 20N19 STK
Version 3.1
Revision Date 12/14/2016
Print Date 02/15/2017
Do not contaminate ponds, waterways or ditches with
chemical or used container.
Dispose of in accordance with local regulations.
Contaminated packaging
:
Empty remaining contents.
Dispose of as unused product.
Do not re-use empty containers.
Do not burn, or use a cutting torch on, the empty drum.
Transportation Regulation: 49 CFR (USA):
ORM-D, CONSUMER COMMODITY
Transportation Regulation: IMDG (Vessel):
UN1950, AEROSOLS, 2.2, - Limited quantity
Transportation Regulation: IATA (Cargo Air):
UN1950, AEROSOLS, 2.2, - Limited quantity
Transportation Regulation: IATA (Passenger Air):
UN1950, AEROSOLS, 2.2, - Limited quantity
Transportation Regulation: TDG (Canada):
UN1950, AEROSOLS, 2.2, - Limited quantity
TSCA list
:
No substances are subject to a Significant New Use Rule.
No substances are subject to TSCA 12(b) export notification
requirements.
SARA 311/312 Hazards
:
Sudden Release of Pressure Hazard
SARA 302
:
No chemicals in this material are subject to the reporting
requirements of SARA Title III, Section 302.
SECTION 14. TRANSPORT INFORMATION
The product as delivered to the customer conforms to packaging requirements for shipment by road
under US Department of Transportation (DOT) regulations. Additional transportation classifications
noted above are for reference only, and not a certification or warranty of the suitability of the packaging
for shipment under these alternative transport regulations.
SECTION 15. REGULATORY INFORMATION
EPCRA - Emergency Planning and Community Right-to-Know Act
CERCLA Reportable Quantity
This material does not contain any components with a CERCLA RQ.
SARA 304 Extremely Hazardous Substances Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
9 / 11
SAFETY DATA SHEET
A07699 ZC FOAMING GLS ZUFGC19A 20N19 STK
Version 3.1
Revision Date 12/14/2016
Print Date 02/15/2017
SARA 313
:
This material does not contain any chemical components with
known CAS numbers that exceed the threshold (De Minimis)
reporting levels established by SARA Title III, Section 313.
California Prop 65
This product does not contain any chemicals known to State of
California to cause cancer, birth defects, or any other
reproductive harm.
TSCA
On TSCA Inventory
DSL
All components of this product are on the Canadian DSL
NFPA:
HMIS III:
Hazard pictograms
:
Signal word
:
Warning:
Hazard statements
:
Contains gas under pressure; may explode if heated.
Precautionary statements
:
Storage: Protect from sunlight. Store in a well-ventilated place.
Disposal: Dispose of contents/ container to an approved w aste disposal plant.
Version:
3.1
Flammability
Health
Instability
3
0
0
Special hazard.
FLAMMABILITY
PHYSICAL HAZARD
HEALTH
0
2
3
0 = not significant, 1 =Slight,
2 = Moderate, 3 = High
4 = Extreme, * = Chronic
The components of this product are reported in the following inventories:
For information on the country notification status for other regions please contact the
manufacturer’s regulatory group.
Inventory Acronym and Validity Area Legend:
TSCA (USA), DSL (Canada), NDSL (Canada)
SECTION 16. OTHER INFORMATION
Further information
OSHA - GHS Label Information:
10 / 11
SAFETY DATA SHEET
A07699 ZC FOAMING GLS ZUFGC19A 20N19 STK
Version 3.1
Revision Date 12/14/2016
Print Date 02/15/2017
Revision Date:
12/14/2016
Print Date:
02/15/2017
We believe the statements, technical information and recommendations contained herein are
reliable, but they are given without warranty or guarantee of any kind. The information in this
document applies to this specific material as supplied. It may not be valid for this material if it
is used in combination with any other materials. Users should make their own investigations
to determine the suitability and applicability of the information for their particular purposes.
This SDS has been prepared by the Compliance Services organization supporting this
manufacturer, supplier or distributor.
Zep Inc. markets products under well recognized and established brand names such as Zep®,
Zep Commercial®,Zep Professional®, Enforcer®, National Chemical™, Selig™, Mis ty®, Next
Dimension™, Petro®, i-Chem®, TimeMist®, TimeWick™, MicrobeMax®, Country Vet®,
Konk®, Original Bike Spirits®, Blue Coral®, Black Magic®, Rain-X®, Niagara National™, FC
Forward Chemicals®,Rexodan®, Mykal™, and a number of private labeled brands.
11 / 11
Loading...