Page 1
SAFETY DATA SHEET
BZ7423 ZEP ODOR ELMNTR ZUAIR32 12Q/CS
Version 2.0
Revision Date 08/27/2015
Print Date 10/14/2015
Material name
:
BZ7423 ZEP ODOR ELMNTR ZUAIR32 12Q/CS
Material number
:
000000000001042496
Company
:
Zep Inc.
Address
:
1310 Seaboard Industrial Blvd., NW
Atlanta, GA 30318
Telephone
:
404-352-1680
Emergency telephone numbers
For SDS Information
:
Compliance Services 1-877-428-9937
For a Medical Emergency
:
877-541-2016 Toll Free - All Calls Recorded
For a Transportation
Emergency
:
CHEMTREC: 800-424-9300 - All Calls Recorded.
In the District of Columbia 202-483-7616
Appearance
liquid
Colour
colourless
Odour
pleasant
Eye irritation
:
Category 2A
Hazard pictograms
:
Signal word
:
Warning
Hazard statements
:
H319 Causes serious eye irritation.
Precautionary statements
:
Prevention:
P264 Wash skin thoroughly after handling.
P280 Wear eye protection/ face protection.
Response:
P305 + P351 + P338 IF IN EYES: Rinse cautiously with water
for several minutes. Remove contact lenses, if present and
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Manufacturer or supplier's details
Note: This product is labeled as a consumer product in accordance with the United States
Consumer Product Safety Commission regulations. The warnings presented below in this Safety
Data Sheet (SDS) comply with the 2012 OSHA Hazard Communication Standard (GHS - Globally
Harmonized System of Classification and Labeling). The requirements for the labeling and
warnings of consumer products may differ from those required for GHS based hazard
communication.
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
GHS Classification
GHS Label element
1 / 10
Page 2
SAFETY DATA SHEET
BZ7423 ZEP ODOR ELMNTR ZUAIR32 12Q/CS
Version 2.0
Revision Date 08/27/2015
Print Date 10/14/2015
easy to do. Continue rinsing.
P337 + P313 If eye irritation persists: Get medical advice/
attention.
IARC
No component of this product present at levels greater than or
equal to 0.1% is identified as probable, possible or confirmed
human carcinogen by IARC.
ACGIH
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by ACGIH.
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by ACGIH.
OSHA
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by OSHA.
NTP
No component of this product present at levels greater than or
equal to 0.1% is identified as a known or anticipated carcinogen
by NTP.
Substance / Mixture
:
Mixture
Chemical Name
CAS-No.
Concentration [%]
ethanol
64-17-5
>= 30 - < 50
Alcohols, C12-16, ethoxylated
68551-12-2
>= 1 - < 5
D-Glucopyranose, oligomers, decyl octyl
glycosides
68515-73-1
>= 1 - < 5
General advice
:
Do not leave the victim unattended.
Move out of dangerous area.
Show this safety data sheet to the doctor in attendance.
If inhaled
:
If unconscious place in recovery position and seek medical
advice.
If symptoms persist, call a physician.
In case of skin contact
:
If on clothes, remove clothes.
If on skin, rinse well with water.
Wash off immediately with plenty of water for at least 15
minutes.
In case of eye contact
:
Remove contact lenses.
Protect unharmed eye.
If eye irritation persists, consult a specialist.
Rinse immediately with plenty of water for at least 15 minutes.
Potential Health Effects
Carcinogenicity:
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components
SECTION 4. FIRST AID MEASURES
2 / 10
Page 3
SAFETY DATA SHEET
BZ7423 ZEP ODOR ELMNTR ZUAIR32 12Q/CS
Version 2.0
Revision Date 08/27/2015
Print Date 10/14/2015
If swallowed
:
Keep respiratory tract clear.
Never give anything by mouth to an unconscious person.
If symptoms persist, call a physician.
DO NOT induce vomiting unless directed to do so by a
physician or poison control center.
Suitable extinguishing media
:
Water spray jet
Alcohol-resistant foam
Carbon dioxide (CO2)
Dry chemical
Unsuitable extinguishing
media
:
High volume water jet
Specific hazards during
firefighting
:
Do not allow run-off from fire fighting to enter drains or water
courses.
Hazardous combustion
products
:
Carbon dioxide (CO2)
Carbon monoxide
Smoke
Specific extinguishing
methods
:
Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.
Further information
:
Standard procedure for chemical fires.
Collect contaminated fire extinguishing water separately. This
must not be discharged into drains.
Fire residues and contaminated fire extinguishing water must
be disposed of in accordance with local regulations.
Special protective equipment
for firefighters
:
Wear self-contained breathing apparatus for firefighting if
necessary.
Personal precautions,
protective equipment and
emergency procedures
:
Ensure adequate ventilation.
Evacuate personnel to safe areas.
Use personal protective equipment.
Environmental precautions
:
Prevent product from entering drains.
Prevent further leakage or spillage.
If the product contaminates rivers and lakes or drains inform
respective authorities.
Methods and materials for
containment and cleaning up
:
Soak up with inert absorbent material (e.g. sand, silica gel,
acid binder, universal binder, sawdust).
Keep in suitable, closed containers for disposal.
SECTION 5. FIREFIGHTING MEASURES
SECTION 6. ACCIDENTAL RELEASE MEASURES
3 / 10
Page 4
SAFETY DATA SHEET
BZ7423 ZEP ODOR ELMNTR ZUAIR32 12Q/CS
Version 2.0
Revision Date 08/27/2015
Print Date 10/14/2015
Advice on safe handling
:
Do not breathe vapours/dust.
Avoid contact with skin and eyes.
For personal protection see section 8.
Smoking, eating and drinking should be prohibited in the
application area.
Dispose of rinse water in accordance with local and national
regulations.
Conditions for safe storage
:
Keep container tightly closed in a dry and well-ventilated
place.
Containers which are opened must be carefully resealed and
kept upright to prevent leakage.
Electrical installations / working materials must comply with
the technological safety standards.
Materials to avoid
:
Components
CAS-No.
Value type
(Form of
exposure)
Control
parameters /
Permissible
concentration
Basis
ethanol
64-17-5
TWA
1,000 ppm
ACGIH
TWA
1,000 ppm
1,900 mg/m3
NIOSH REL
TWA
1,000 ppm
1,900 mg/m3
OSHA Z-1
TWA
1,000 ppm
1,900 mg/m3
OSHA P0
Respiratory protection
:
In case of insufficient ventilation, wear suitable respiratory
equipment.
Remarks
:
The suitability for a specific workplace should be discussed
with the producers of the protective gloves.
Eye protection
:
Ensure that eyewash stations and safety showers are close to
the workstation location.
Safety glasses
Skin and body protection
:
Impervious clothing
Choose body protection according to the amount and
concentration of the dangerous substance at the work place.
Hygiene measures
:
Wash hands before breaks and at the end of workday.
When using do not eat or drink.
When using do not smoke.
SECTION 7. HANDLING AND STORAGE
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
Personal protective equipment
Hand protection
4 / 10
Page 5
SAFETY DATA SHEET
BZ7423 ZEP ODOR ELMNTR ZUAIR32 12Q/CS
Version 2.0
Revision Date 08/27/2015
Print Date 10/14/2015
Appearance
:
liquid
Colour
:
colourless
Odour
:
pleasant
Odour Threshold
:
No data available
pH : 6 - 7.5
Melting point/freezing point
:
No data available
Boiling point
:
100 °C
Flash point
:
> 93.3 °C
Method: TCC
Evaporation rate
:
No data available
Upper explosion limit
:
No data available
Lower explosion limit
:
No data available
Vapour pressure
:
No data available
Relative vapour density
:
No data available
Density
:
0.99 g/cm3
Water solubility
:
soluble
Solubility in other solvents
:
not determined
Partition coefficient: noctanol/water
:
No data available
Auto-ignition temperature
:
not determined
Thermal decomposition
:
No data available
Viscosity, kinematic
:
No data available
Reactivity
:
Stable
Chemical stability
:
Stable under normal conditions.
Possibility of hazardous
reactions
:
No decomposition if stored and applied as directed.
Conditions to avoid
:
No data available
Incompatible materials
:
No data available
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Solubility(ies)
Viscosity
SECTION 10. STABILITY AND REACTIVITY
5 / 10
Page 6
SAFETY DATA SHEET
BZ7423 ZEP ODOR ELMNTR ZUAIR32 12Q/CS
Version 2.0
Revision Date 08/27/2015
Print Date 10/14/2015
Hazardous decomposition
products
:
No decomposition if stored and applied as directed.
Acute oral toxicity
:
LD50 Oral Rat: 7,060 mg/kg
Acute inhalation toxicity
:
LC50 Rat: 124.7 mg/l
Exposure time: 4 h
Remarks: May cause skin irritation and/or dermatitis.
Remarks: May irritate eyes.
SECTION 11. TOXICOLOGICAL INFORMATION
Acute toxicity
Components:
ethanol:
Skin corrosion/irritation
Product:
Serious eye damage/eye irritation
Product:
Respiratory or skin sensitisation
No data available
Germ cell mutagenicity
No data available
Carcinogenicity
No data available
Reproductive toxicity
No data available
ethanol:
Alcohols, C12-16, ethoxylated:
D-Glucopyranose, oligomers, decyl octyl glycosides:
STOT - single exposure
No data available
STOT - repeated exposure
No data available
Aspiration toxicity
No data available
Further information
Product:
6 / 10
Page 7
SAFETY DATA SHEET
BZ7423 ZEP ODOR ELMNTR ZUAIR32 12Q/CS
Version 2.0
Revision Date 08/27/2015
Print Date 10/14/2015
Remarks: No data available
Partition coefficient: noctanol/water
:
Remarks: No data available
Regulation
40 CFR Protection of Environment; Part 82 Protection of
Stratospheric Ozone - CAA Section 602 Class I
Substances
Remarks
This product neither contains, nor was manufactured
with a Class I or Class II ODS as defined by the U.S.
Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A
+ B).
Additional ecological
information
:
An environmental hazard cannot be excluded in the
event of unprofessional handling or disposal., Harmful to
aquatic life.
Waste from residues
:
Do not contaminate ponds, waterways or ditches with
chemical or used container.
The product should not be allowed to enter drains, water
courses or the soil.
Dispose of in accordance with local regulations.
Contaminated packaging
:
Empty remaining contents.
Dispose of as unused product.
Do not re-use empty containers.
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity
No data available
Persistence and degradability
No data available
Bioaccumulative potential
Product:
Mobility in soil
No data available
Other adverse effects
No data available
Product:
SECTION 13. DISPOSAL CONSIDERATIONS
Disposal methods
7 / 10
Page 8
SAFETY DATA SHEET
BZ7423 ZEP ODOR ELMNTR ZUAIR32 12Q/CS
Version 2.0
Revision Date 08/27/2015
Print Date 10/14/2015
Transportation Regulation: 49 CFR (USA):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IMDG (Vessel):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IATA (Cargo Air):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IATA (Passenger Air):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: TDG (Canada):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
SARA 311/312 Hazards
:
Acute Health Hazard
SARA 302
:
No chemicals in this material are subject to the reporting
requirements of SARA Title III, Section 302.
SARA 313
:
This material does not contain any chemical components with
known CAS numbers that exceed the threshold (De Minimis)
reporting levels established by SARA Title III, Section 313.
California Prop 65
This product does not contain any chemicals known to State of
California to cause cancer, birth defects, or any other
reproductive harm.
TSCA
On TSCA Inventory
DSL
This product contains one or several components that are not on the
Canadian DSL nor NDSL.
AICS
Not in compliance with the inventory
NZIoC
Not in compliance with the inventory
PICCS
Not in compliance with the inventory
SECTION 14. TRANSPORT INFORMATION
SECTION 15. REGULATORY INFORMATION
EPCRA - Emergency Planning and Community Right-to-Know Act
CERCLA Reportable Quantity
This material does not contain any components with a CERCLA RQ.
SARA 304 Extremely Hazardous Substances Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
The components of this product are reported in the following inventories:
8 / 10
Page 9
SAFETY DATA SHEET
BZ7423 ZEP ODOR ELMNTR ZUAIR32 12Q/CS
Version 2.0
Revision Date 08/27/2015
Print Date 10/14/2015
IECSC
On the inventory, or in compliance with the inventory
NFPA:
HMIS III:
Hazard pictograms
:
Signal word
:
Warning:
Hazard statements
:
Causes serious eye irritation.
Precautionary statements
:
Prevention: Wash skin thoroughly after handling. Wear eye protection/ face protection.
Response: IF IN EYES: Rinse cautiously with water for several minutes. Remove
contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get
medical advice/ attention.
Version:
2.0
Revision Date:
08/27/2015
Print Date:
10/14/2015
Flammability
Health
Instability
2
1
0
Special hazard.
FLAMMABILITY
PHYSICAL HAZARD
HEALTH
1
0
2
0 = not significant, 1 =Slight,
2 = Moderate, 3 = High
4 = Extreme, * = Chronic
Inventory Acronym and Validity Area Legend:
AICS (Australia), DSL (Canada), IECSC (China), REACH (European Union), ENCS (Japan), ISHL
(Japan), KECI (Korea), NZIoC (New Zealand), PICCS (Philippines), TCSI (Taiwan), TSCA (USA)
SECTION 16. OTHER INFORMATION
Further information
OSHA GHS Label Information:
We believe the statements, technical information and recommendations contained herein are
reliable, but they are given without warranty or guarantee of any kind. The information in this
document applies to this specific material as supplied. It may not be valid for this material if it
is used in combination with any other materials. Users should make their own investigations
to determine the suitability and applicability of the information for their particular purposes.
This SDS has been prepared by the Compliance Services organization supporting this
manufacturer, supplier or distributor.
9 / 10
Page 10
SAFETY DATA SHEET
BZ7423 ZEP ODOR ELMNTR ZUAIR32 12Q/CS
Version 2.0
Revision Date 08/27/2015
Print Date 10/14/2015
Zep Inc. markets products under well recognized and established brand names such as Zep®,
Zep Commercial®,Zep Professional®, Enforcer®, National Chemical™, Selig™, Misty®, Next
Dimension™, Petro®, i-Chem®, TimeMist®, TimeWick™, MicrobeMax®, Country Vet®,
Konk®, Original Bike Spirits®, Blue Coral®, Black Magic®, Rain-X®, Niagara National™, FC
Forward Chemicals®,Rexodan®, Mykal™, and a number of private labeled brands.
10 / 10
Loading...