Page 1
SAFETY DATA SHEET
ZEP FAST 505 DEGREASER & CLEANER
Version 4.0
Revision Date 07/24/2018
Print Date 04/22/2019
Material name
:
ZEP FAST 505 DEGREASER & CLEANER
Material number
:
ZU50532
Company
:
Zep Inc.
Address
:
350 Joe Frank Harris Parkway, SE
Emerson, GA 30137
Telephone
:
404-352-1680
Emergency telephone numbers
For SDS Information
:
Compliance Services 1-877-428-9937
For a Medical Emergency
:
877-541-2016 Toll Free - All Calls Recorded
For a Transportation
Emergency
:
CHEMTREC: 800-424-9300 - All Calls Recorded.
In the District of Columbia 202-483-7616
Recommended use
:
Cleaner
Appearance
liquid
Colour
colourless, clear
Odour
characteristic
Skin irritation
:
Category 2
Eye irritation
:
Category 2A
Hazard pictograms
:
Signal word
:
Warning
Hazard statements
:
H315 Causes skin irritation.
H319 Causes serious eye irritation.
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Manufacturer or supplier's details
Recommended use of the chemical and restrictions on use
Note: This product is labeled as a consumer product in accordance with the United States
Consumer Product Safety Commission regulations. The warnings presented below in this Safety
Data Sheet (SDS) comply with the 2012 OSHA Hazard Communication Standard (GHS - Globally
Harmonized System of Classification and Labeling). The requirements for the labeling and
warnings of consumer products may differ from those required for GHS based hazard
communication.
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
GHS Classification
GHS label elements
1 / 11
Page 2
SAFETY DATA SHEET
ZEP FAST 505 DEGREASER & CLEANER
Version 4.0
Revision Date 07/24/2018
Print Date 04/22/2019
Precautionary statements
:
Prevention:
P264 Wash skin thoroughly after handling.
P280 Wear protective gloves/ eye protection/ face protection.
Response:
P302 + P352 IF ON SKIN: Wash with plenty of soap and water.
P305 + P351 + P338 IF IN EYES: Rinse cautiously with water
for several minutes. Remove contact lenses, if present and
easy to do. Continue rinsing.
P332 + P313 If skin irritation occurs: Get medical advice/
attention.
P337 + P313 If eye irritation persists: Get medical advice/
attention.
P362 Take off contaminated clothing and wash before reuse.
Substance / Mixture
:
Mixture
Chemical name
CAS-No.
Concentration [%]
tetrasodium ethylenediaminetetraacetate
64-02-8
>= 0.1 - <= 1
General advice
:
Move out of dangerous area.
Show this safety data sheet to the doctor in attendance.
Do not leave the victim unattended.
Get medical attention.
If inhaled
:
If unconscious, place in recovery position and seek medical
advice.
If symptoms persist, call a physician.
In case of skin contact
:
Wash off immediately with plenty of water for at least 15
minutes.
Remove contaminated clothing and shoes.
Wash contaminated clothing before reuse.
If skin irritation persists, call a physician.
In case of eye contact
:
Continue rinsing eyes during transport to hospital.
Remove contact lenses.
Protect unharmed eye.
Keep eye wide open while rinsing.
If eye irritation persists, consult a specialist.
Rinse immediately with plenty of water, also under the eyelids,
for at least 15 minutes.
If swallowed
:
Keep respiratory tract clear.
DO NOT induce vomiting unless directed to do so by a
physician or poison control center.
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components
The exact percentages of disclosed substances are withheld as trade secrets.
SECTION 4. FIRST AID MEASURES
2 / 11
Page 3
SAFETY DATA SHEET
ZEP FAST 505 DEGREASER & CLEANER
Version 4.0
Revision Date 07/24/2018
Print Date 04/22/2019
Never give anything by mouth to an unconscious person.
If symptoms persist, call a physician.
Take victim immediately to hospital.
Most important symptoms
and effects, both acute and
delayed
:
Effects are dependent on exposure (dose, concentration,
contact time).
Effects are immediate and delayed.
Symptoms may include irritation, redness, pain, and rash.
Causes skin irritation.
Causes serious eye irritation.
Review section 2 of SDS to see all potential hazards.
Notes to physician
:
Treat symptomatically. Symptoms may be delayed.
Suitable extinguishing media
:
Water spray jet
Carbon dioxide (CO2)
Alcohol-resistant foam
Dry chemical
Unsuitable extinguishing
media
:
High volume water jet
Specific hazards during
firefighting
:
Do not allow run-off from fire fighting to enter drains or water
courses.
Hazardous combustion
products
:
Carbon dioxide (CO2)
Carbon monoxide
Smoke
Sulphur oxides
Specific extinguishing
methods
:
Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.
Further information
:
Collect contaminated fire extinguishing water separately. This
must not be discharged into drains.
Fire residues and contaminated fire extinguishing water must
be disposed of in accordance with local regulations.
Standard procedure for chemical fires.
Special protective equipment
for firefighters
:
Wear self-contained breathing apparatus for firefighting if
necessary.
Personal precautions,
protective equipment and
emergency procedures
:
Use personal protective equipment.
Environmental precautions
:
Prevent further leakage or spillage if safe to do so.
Methods and materials for
containment and cleaning up
:
Neutralise with acid.
Soak up with inert absorbent material (e.g. sand, silica gel,
acid binder, universal binder, sawdust).
SECTION 5. FIREFIGHTING MEASURES
SECTION 6. ACCIDENTAL RELEASE MEASURES
3 / 11
Page 4
SAFETY DATA SHEET
ZEP FAST 505 DEGREASER & CLEANER
Version 4.0
Revision Date 07/24/2018
Print Date 04/22/2019
Keep in suitable, closed containers for disposal.
Advice on safe handling
:
Do not breathe vapours or spray mist.
Avoid contact with skin and eyes.
For personal protection see section 8.
Smoking, eating and drinking should be prohibited in the
application area.
Dispose of rinse water in accordance with local and national
regulations.
Conditions for safe storage
:
Keep container tightly closed in a dry and well-ventilated
place.
Electrical installations / working materials must comply with
the technological safety standards.
Materials to avoid
:
Oxidizing agents
Strong acids
Engineering measures
:
effective ventilation in all processing areas
Respiratory protection
:
In case of insufficient ventilation, wear suitable respiratory
equipment.
Material
:
Protective gloves
Remarks
:
The suitability for a specific workplace should be discussed
with the producers of the protective gloves.
Eye protection
:
Safety glasses
Access to clean water to rinse eyes must be available, options
include: eye wash stations or showers, or eye wash bottles
with pure water.
Skin and body protection
:
Impervious clothing
Choose body protection according to the amount and
concentration of the dangerous substance at the work place.
Hygiene measures
:
When using do not eat or drink.
When using do not smoke.
Wash hands before breaks and at the end of workday.
SECTION 7. HANDLING AND STORAGE
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
Contains no substances with occupational exposure limit values.
Personal protective equipment
Hand protection
4 / 11
Page 5
SAFETY DATA SHEET
ZEP FAST 505 DEGREASER & CLEANER
Version 4.0
Revision Date 07/24/2018
Print Date 04/22/2019
Appearance
:
liquid
Colour
:
colourless, clear
Odour
:
characteristic
Odour Threshold
:
No data available
pH : 11.5
Melting point/freezing point
:
No data available
Boiling point
:
100 °C
Flash point
:
93.3 °C
Evaporation rate
:
No data available
Upper explosion limit
:
No data available
Lower explosion limit
:
No data available
Vapour pressure
:
No data available
Relative vapour density
:
No data available
Density
:
1.001 g/cm3
Water solubility
:
completely soluble
Solubility in other solvents
:
not determined
Partition coefficient: noctanol/water
:
No data available
Auto-ignition temperature
:
not determined
Thermal decomposition
:
No data available
Viscosity, kinematic
:
No data available
Reactivity
:
Stable
Chemical stability
:
Stable under normal conditions.
Possibility of hazardous
reactions
:
No decomposition if stored and applied as directed.
Conditions to avoid
:
No data available
Incompatible materials
:
Oxidizing agents
Strong acids
Hazardous decomposition
:
Carbon dioxide (CO2)
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Solubility(ies)
Viscosity
SECTION 10. STABILITY AND REACTIVITY
5 / 11
Page 6
SAFETY DATA SHEET
ZEP FAST 505 DEGREASER & CLEANER
Version 4.0
Revision Date 07/24/2018
Print Date 04/22/2019
products
Carbon monoxide
Sulphur oxides
Aggravated Medical
Condition
:
None known.
Symptoms of Overexposure
:
Effects are dependent on exposure (dose, concentration,
contact time).
Effects are immediate and delayed.
Symptoms may include irritation, redness, pain, and rash.
IARC
No component of this product present at levels greater than or
equal to 0.1% is identified as probable, possible or confirmed
human carcinogen by IARC.
ACGIH
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by ACGIH.
OSHA
No component of this product present at levels greater than or
equal to 0.1% is on OSHA’s list of regulated carcinogens.
NTP
No component of this product present at levels greater than or
equal to 0.1% is identified as a known or anticipated carcinogen
by NTP.
Classification: Irritating to skin.
Method: Alkaline Reserve Titration
Classification: Irritating to eyes.
Method: Alkaline Reserve Titration
SECTION 11. TOXICOLOGICAL INFORMATION
Potential Health Effects
Carcinogenicity:
Acute toxicity
No data available
Skin corrosion/irritation
Product:
Serious eye damage/eye irritation
Product:
Respiratory or skin sensitisation
No data available
Germ cell mutagenicity
No data available
Carcinogenicity
No data available
6 / 11
Page 7
SAFETY DATA SHEET
ZEP FAST 505 DEGREASER & CLEANER
Version 4.0
Revision Date 07/24/2018
Print Date 04/22/2019
Exposure routes: Inhalation
Assessment: May cause damage to organs through prolonged or repeated exposure.
Remarks: No data available
Partition coefficient: noctanol/water
:
Remarks: No data available
Regulation
40 CFR Protection of Environment; Part 82 Protection of
Stratospheric Ozone - CAA Section 602 Class I
Substances
Remarks
This product neither contains, nor was manufactured
with a Class I or Class II ODS as defined by the U.S.
Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A
+ B).
Reproductive toxicity
No data available
STOT - single exposure
No data available
STOT - repeated exposure
Components:
tetrasodium ethylenediaminetetraacetate:
Aspiration toxicity
No data available
Further information
Product:
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity
No data available
Persistence and degradability
No data available
Bioaccumulative potential
Product:
Mobility in soil
No data available
Other adverse effects
No data available
Product:
7 / 11
Page 8
SAFETY DATA SHEET
ZEP FAST 505 DEGREASER & CLEANER
Version 4.0
Revision Date 07/24/2018
Print Date 04/22/2019
Additional ecological
information
:
No data available
Waste from residues
:
Do not dispose of waste into sewer.
Do not contaminate ponds, waterways or ditches with
chemical or used container.
Dispose of in accordance with local regulations.
Contaminated packaging
:
Empty remaining contents.
Dispose of as unused product.
Do not re-use empty containers.
Transportation Regulation: 49 CFR (USA):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IMDG (Vessel):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IATA (Cargo Air):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IATA (Passenger Air):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: TDG (Canada):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
TSCA list
:
No substances are subject to a Significant New Use Rule.
SECTION 13. DISPOSAL CONSIDERATIONS
Disposal methods
SECTION 14. TRANSPORT INFORMATION
The product as delivered to the customer conforms to packaging requirements for shipment by road
under US Department of Transportation (DOT) regulations. Additional transportation classifications
noted above are for reference only, and not a certification or warranty of the suitability of the packaging
for shipment under these alternative transport regulations.
SECTION 15. REGULATORY INFORMATION
8 / 11
Page 9
SAFETY DATA SHEET
ZEP FAST 505 DEGREASER & CLEANER
Version 4.0
Revision Date 07/24/2018
Print Date 04/22/2019
No substances are subject to TSCA 12(b) export notification
requirements.
SARA 311/312 Hazards
:
Skin corrosion or irritation
Serious eye damage or eye irritation
SARA 302
:
No chemicals in this material are subject to the reporting
requirements of SARA Title III, Section 302.
SARA 313
:
This material does not contain any chemical components with
known CAS numbers that exceed the threshold (De Minimis)
reporting levels established by SARA Title III, Section 313.
This product does not contain any chemicals known to State of
California to cause cancer, birth defects, or any other
reproductive harm.
DSL
This product contains one or more components that are listed on the
Canadian NDSL. All other components are on the Canadian DSL.
TSCA
On TSCA Inventory
EPCRA - Emergency Planning and Community Right-to-Know Act
CERCLA Reportable Quantity
This material does not contain any components with a CERCLA RQ.
SARA 304 Extremely Hazardous Substances Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
California Prop. 65
The components of this product are reported in the following inventories:
For information on the country notification status for other regions please contact the
manufacturer’s regulatory group.
Inventory Acronym and Validity Area Legend:
TSCA (USA), DSL (Canada), NDSL (Canada)
SECTION 16. OTHER INFORMATION
9 / 11
Page 10
SAFETY DATA SHEET
ZEP FAST 505 DEGREASER & CLEANER
Version 4.0
Revision Date 07/24/2018
Print Date 04/22/2019
NFPA:
HMIS III:
Hazard pictograms
:
Signal word
:
Warning:
Hazard statements
:
Causes skin irritation. Causes serious eye irritation.
Precautionary statements
:
Prevention: Wash skin thoroughly after handling. Wear protective gloves/ eye
protection/ face protection.
Response: IF ON SKIN: Wash with plenty of soap and water. IF IN EYES: Rinse
cautiously with water for several minutes. Remove contact lenses, if present and easy
to do. Continue rinsing. If skin irritation occurs: Get medical advice/ attention. If eye
irritation persists: Get medical advice/ attention. Take off contaminated clothing and
wash before reuse.
Version:
4.0
Revision Date:
07/24/2018
Print Date:
04/22/2019
Flammability
Health
Instability
2
0
0
Special hazard.
FLAMMABILITY
PHYSICAL HAZARD
HEALTH
1
0
2
0 = not significant, 1 =Slight,
2 = Moderate, 3 = High
4 = Extreme, * = Chronic
Further information
OSHA - GHS Label Information:
We believe the statements, technical information and recommendations contained herein are
reliable, but they are given without warranty or guarantee of any kind. The information in this
document applies to this specific material as supplied. It may not be valid for this material if it
is used in combination with any other materials. Users should make their own investigations
to determine the suitability and applicability of the information for their particular purposes.
This SDS has been prepared by the Compliance Services organization supporting this
manufacturer, supplier or distributor.
Zep Inc. markets products under well recognized and established brand names such as Zep®,
Zep Commercial®,Zep Professional®, Enforcer®, National Chemical™, Selig™, Misty®, Next
Dimension™, Petro®, i-Chem®, TimeMist®, TimeWick™, MicrobeMax®, Country Vet®,
Konk®, Original Bike Spirits®, Blue Coral®, Black Magic®, Rain-X®, Niagara National™, FC
Forward Chemicals®,Rexodan®, Mykal™, and a number of private labeled brands.
10 / 11
Page 11
SAFETY DATA SHEET
ZEP FAST 505 DEGREASER & CLEANER
Version 4.0
Revision Date 07/24/2018
Print Date 04/22/2019
11 / 11
Loading...