Zep ZU1046324 User Manual

SAFETY DATA SHEET

ZEP GROUT CLEANER & BRIGHTENER 4PK

Version 3.0

Revision Date 07/10/2018

Print Date 04/26/2019

Material name

:

ZEP GROUT CLEANER & BRIGHTENER 4PK
Material number

:

ZU1046324

Company

:

Zep Inc.

Address

:

350 Joe Frank Harris Parkway, SE
Emerson, GA 30137
Telephone

:

404-352-1680

Emergency telephone numbers

For SDS Information

:

Compliance Services 1-877-428-9937

For a Medical Emergency

:

877-541-2016 Toll Free - All Calls Recorded

For a Transportation
Emergency

:

CHEMTREC: 800-424-9300 - All Calls Recorded.
In the District of Columbia 202-483-7616

Recommended use

:

Bathroom Care Maintenance
Appearance

liquid

Colour

colourless, light yellow

Odour

characteristic

Skin corrosion

:

Category 1

Serious eye damage

:

Category 1

Hazard pictograms

:

Signal word

:

Danger

Hazard statements

:

H314 Causes severe skin burns and eye damage.
Precautionary statements

:

Prevention:

SECTION 1. PRODUCT AND COMPANY IDENTIFICATION

Manufacturer or supplier's details

Recommended use of the chemical and restrictions on use

Note: This product is labeled as a consumer product in accordance with the United States
Consumer Product Safety Commission regulations. The warnings presented below in this Safety
Data Sheet (SDS) comply with the 2012 OSHA Hazard Communication Standard (GHS - Globally
Harmonized System of Classification and Labeling). The requirements for the labeling and
warnings of consumer products may differ from those required for GHS based hazard
communication.

SECTION 2. HAZARDS IDENTIFICATION

Emergency Overview

GHS Classification

GHS label elements

1 / 12

SAFETY DATA SHEET

ZEP GROUT CLEANER & BRIGHTENER 4PK

Version 3.0

Revision Date 07/10/2018

Print Date 04/26/2019

P264 Wash skin thoroughly after handling.
P280 Wear protective gloves/ protective clothing/ eye
protection/ face protection.

Response:

P301 + P330 + P331 IF SWALLOWED: Rinse mouth. Do NOT
induce vomiting.
P303 + P361 + P353 IF ON SKIN (or hair): Take off
immediately all contaminated clothing. Rinse skin with
water/shower.
P304 + P340 + P310 IF INHALED: Remove person to fresh air
and keep comfortable for breathing. Immediately call a
POISON CENTER/doctor.
P305 + P351 + P338 + P310 IF IN EYES: Rinse cautiously with
water for several minutes. Remove contact lenses, if present
and easy to do. Continue rinsing. Immediately call a POISON
CENTER/doctor.
P363 Wash contaminated clothing before reuse.
Disposal:
P501 Dispose of contents/container in accordance with local
regulation.
Substance / Mixture

:

Mixture

Chemical name

CAS-No.

Concentration [%]

urea hydrochloride

506-89-8

>= 10 - < 30

Monoethanolamine Chloride

Not Assigned

>= 1 - < 3

hydrochloric acid

7647-01-0

>= 1 - < 3

Alcohols, C9-11, ethoxylated

68439-46-3

>= 1 - < 3

General advice

:

Move out of dangerous area.
Get medical attention immediately.
Show this safety data sheet to the doctor in attendance.
Do not leave the victim unattended.

If inhaled

:

If unconscious, place in recovery position and seek medical
advice.
If symptoms persist, call a physician.

In case of skin contact

:

Immediate medical treatment is necessary as untreated
wounds from corrosion of the skin heal slowly and with
difficulty.
Wash off immediately with plenty of water for at least 15
minutes.
Remove contaminated clothing and shoes.
Wash contaminated clothing before reuse.

SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS

Hazardous components

The exact percentages of disclosed substances are withheld as trade secrets.

SECTION 4. FIRST AID MEASURES

2 / 12

SAFETY DATA SHEET

ZEP GROUT CLEANER & BRIGHTENER 4PK

Version 3.0

Revision Date 07/10/2018

Print Date 04/26/2019

If skin irritation persists, call a physician.

In case of eye contact

:

Small amounts splashed into eyes can cause irreversible
tissue damage and blindness.
Rinse immediately with plenty of water, also under the eyelids,
for at least 15 minutes.
Remove contact lenses.
Protect unharmed eye.
Keep eye wide open while rinsing.
If eye irritation persists, consult a specialist.

If swallowed

:

Keep respiratory tract clear.
DO NOT induce vomiting unless directed to do so by a
physician or poison control center.
Do not give milk or alcoholic beverages.
Never give anything by mouth to an unconscious person.
If symptoms persist, call a physician.
Take victim immediately to hospital.

Most important symptoms
and effects, both acute and
delayed

:

Effects are dependent on exposure (dose, concentration,
contact time).
Effects are immediate and delayed.
Symptoms may include blistering, irritation, burns, and pain.
Causes severe skin burns and eye damage.
Review section 2 of SDS to see all potential hazards.

Notes to physician

:

Treat symptomatically. Symptoms may be delayed.

Suitable extinguishing media

:

Alcohol-resistant foam
Carbon dioxide (CO2)
Dry chemical
Water spray jet

Unsuitable extinguishing
media

:

High volume water jet

Specific hazards during
firefighting

:

Do not allow run-off from fire fighting to enter drains or water
courses.

Hazardous combustion
products

:

Carbon dioxide (CO2)
Carbon monoxide
Smoke
Chlorine compounds

Specific extinguishing
methods

:

Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.

Further information

:

Collect contaminated fire extinguishing water separately. This
must not be discharged into drains.
Fire residues and contaminated fire extinguishing water must
be disposed of in accordance with local regulations.
Standard procedure for chemical fires.

SECTION 5. FIREFIGHTING MEASURES

3 / 12

SAFETY DATA SHEET

ZEP GROUT CLEANER & BRIGHTENER 4PK

Version 3.0

Revision Date 07/10/2018

Print Date 04/26/2019

Special protective equipment
for firefighters

:

Wear self-contained breathing apparatus for firefighting if
necessary.

Personal precautions,
protective equipment and
emergency procedures

:

Use personal protective equipment.
Ensure adequate ventilation.
Remove all sources of ignition.
Evacuate personnel to safe areas.
Avoid dust formation.

Environmental precautions

:

Prevent product from entering drains.
Prevent further leakage or spillage if safe to do so.
If the product contaminates rivers and lakes or drains inform
respective authorities.

Methods and materials for
containment and cleaning up

:

Soak up with inert absorbent material (e.g. sand, silica gel,
acid binder, universal binder, sawdust).
Keep in suitable, closed containers for disposal.

Advice on safe handling

:

Do not breathe vapours/dust.
Avoid contact with skin and eyes.
For personal protection see section 8.
Smoking, eating and drinking should be prohibited in the
application area.
To avoid spills during handling keep bottle on a metal tray.
Dispose of rinse water in accordance with local and national
regulations.

Conditions for safe storage

:

Keep container tightly closed in a dry and well-ventilated
place.
Observe label precautions.
Electrical installations / working materials must comply with
the technological safety standards.

Materials to avoid

:

Store and keep away from bleach.
Oxidizing agents
Store and keep away from bases and alkalies.

Components

CAS-No.

Value type
(Form of
exposure)

Control
parameters /
Permissible
concentration

Basis

hydrochloric acid

7647-01-0

C

2 ppm

ACGIH

C

5 ppm
7 mg/m3

NIOSH REL

SECTION 6. ACCIDENTAL RELEASE MEASURES

SECTION 7. HANDLING AND STORAGE

SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION

Components with workplace control parameters

4 / 12