SAFETY DATA SHEET
ZEP FORMULA 50 R.T.U. 1 CS 12 QTS
Version 2.2
Revision Date 09/11/2017
Print Date 11/07/2018
Material name
:
ZEP FORMULA 50 R.T.U. 1 CS 12 QTS
Material number
:
F50001
Company
:
Zep Inc.
Address
:
350 Joe Frank Harris Parkway, SE
Emerson, GA 30137
Telephone
:
404-352-1680
Emergency telephone numbers
For SDS Information
:
Compliance Services 1-877-428-9937
For a Medical Emergency
:
877-541-2016 Toll Free - All Calls Recorded
For a Transportation
Emergency
:
CHEMTREC: 800-424-9300 - All Calls Recorded.
In the District of Columbia 202-483-7616
Recommended use
:
Cleaner
Appearance
liquid
Colour
clear, green
Odour
like fruit
Skin irritation
:
Category 2
Eye irritation
:
Category 2A
Hazard pictograms
:
Signal word
:
Warning
Hazard statements
:
H315 Causes skin irritation.
H319 Causes serious eye irritation.
Precautionary statements
:
Prevention:
P264 Wash skin thoroughly after handling.
P280 Wear eye protection/ face protection.
P280 Wear protective gloves.
Response:
P302 + P352 IF ON SKIN: Wash with plenty of soap and water.
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Manufacturer or supplier's details
Recommended use of the chemical and restrictions on use
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
GHS Classification
GHS label elements
1 / 11
SAFETY DATA SHEET
ZEP FORMULA 50 R.T.U. 1 CS 12 QTS
Version 2.2
Revision Date 09/11/2017
Print Date 11/07/2018
P305 + P351 + P338 IF IN EYES: Rinse cautiously with water
for several minutes. Remove contact lenses, if present and
easy to do. Continue rinsing.
P332 + P313 If skin irritation occurs: Get medical advice/
attention.
P337 + P313 If eye irritation persists: Get medical advice/
attention.
P362 Take off contaminated clothing and wash before reuse.
Substance / Mixture
:
Mixture
General advice
:
Move out of dangerous area.
Consult a physician.
Show this safety data sheet to the doctor in attendance.
Do not leave the victim unattended.
If inhaled
:
If unconscious, place in recovery position and seek medical
advice.
If symptoms persist, call a physician.
In case of skin contact
:
Wash off immediately with plenty of water for at least 15
minutes.
If on skin, rinse well with water.
If on clothes, remove clothes.
In case of eye contact
:
Small amounts splashed into eyes can cause irreversible
tissue damage and blindness.
If in eyes, rinse with water for 15 minutes.
Continue rinsing eyes during transport to hospital.
Remove contact lenses.
Protect unharmed eye.
Keep eye wide open while rinsing.
If eye irritation persists, consult a specialist.
If swallowed
:
Keep respiratory tract clear.
Do NOT induce vomiting.
Never give anything by mouth to an unconscious person.
If symptoms persist, call a physician.
Take victim immediately to hospital.
Most important symptoms
and effects, both acute and
delayed
:
Effects may be delayed, symptoms may include minor eye or
skin irritation.
Overexposure may cause mild eye or skin irritation.
Notes to physician
:
Treat symptomatically. Symptoms may be delayed.
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components
No hazardous ingredients
The exact percentages of disclosed substances are withheld as trade secrets.
SECTION 4. FIRST AID MEASURES
2 / 11
SAFETY DATA SHEET
ZEP FORMULA 50 R.T.U. 1 CS 12 QTS
Version 2.2
Revision Date 09/11/2017
Print Date 11/07/2018
Suitable extinguishing media
:
Dry chemical
Water
Carbon dioxide (CO2)
Foam
Unsuitable extinguishing
media
:
High volume water jet
Specific hazards during
firefighting
:
Do not allow run-off from fire fighting to enter drains or water
courses.
Hazardous combustion
products
:
No hazardous combustion products are known
Specific extinguishing
methods
:
Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.
Further information
:
Collect contaminated fire extinguishing water separately. This
must not be discharged into drains.
Fire residues and contaminated fire extinguishing water must
be disposed of in accordance with local regulations.
Special protective equipment
for firefighters
:
Wear self-contained breathing apparatus for firefighting if
necessary.
Personal precautions,
protective equipment and
emergency procedures
:
Use personal protective equipment.
Environmental precautions
:
Prevent product from entering drains.
Prevent further leakage or spillage if safe to do so.
If the product contaminates rivers and lakes or drains inform
respective authorities.
Methods and materials for
containment and cleaning up
:
Soak up with inert absorbent material (e.g. sand, silica gel,
acid binder, universal binder, sawdust).
Keep in suitable, closed containers for disposal.
Advice on safe handling
:
Do not breathe vapours/dust.
Avoid contact with skin and eyes.
For personal protection see section 8.
Smoking, eating and drinking should be prohibited in the
application area.
To avoid spills during handling keep bottle on a metal tray.
Dispose of rinse water in accordance with local and national
regulations.
SECTION 5. FIREFIGHTING MEASURES
SECTION 6. ACCIDENTAL RELEASE MEASURES
SECTION 7. HANDLING AND STORAGE
3 / 11
SAFETY DATA SHEET
ZEP FORMULA 50 R.T.U. 1 CS 12 QTS
Version 2.2
Revision Date 09/11/2017
Print Date 11/07/2018
Conditions for safe storage
:
Keep container tightly closed in a dry and well-ventilated
place.
Observe label precautions.
Electrical installations / working materials must comply with
the technological safety standards.
Materials to avoid
:
Do not freeze.
Do not store near acids.
Oxidizing agents
Components
CAS-No.
Value type
(Form of
exposure)
Control
parameters /
Permissible
concentration
Basis
2-butoxyethanol
111-76-2
TWA
20 ppm
ACGIH
TWA
5 ppm
24 mg/m3
NIOSH REL
TWA
50 ppm
240 mg/m3
OSHA Z-1
TWA
25 ppm
120 mg/m3
OSHA P0
PEL
20 ppm
97 mg/m3
CAL PEL
Engineering measures
:
Handle only in a place equipped with local exhaust (or other
appropriate exhaust).
Respiratory protection
:
In case of insufficient ventilation, wear suitable respiratory
equipment.
Material
:
Protective gloves
Remarks
:
The suitability for a specific workplace should be discussed
with the producers of the protective gloves.
Eye protection
:
Ensure that eyewash stations and safety showers are close to
the workstation location.
Tightly fitting safety goggles
Wear face-shield and protective suit for abnormal processing
problems.
Skin and body protection
:
Impervious clothing
Choose body protection according to the amount and
concentration of the dangerous substance at the work place.
Hygiene measures
:
When using do not eat or drink.
When using do not smoke.
Wash hands before breaks and at the end of workday.
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
Personal protective equipment
Hand protection
4 / 11
SAFETY DATA SHEET
ZEP FORMULA 50 R.T.U. 1 CS 12 QTS
Version 2.2
Revision Date 09/11/2017
Print Date 11/07/2018
Appearance
:
liquid
Colour
:
clear, green
Odour
:
like fruit
Odour Threshold
:
No data available
pH : 11.5 - 12.5
Melting point/freezing point
:
No data available
Boiling point
:
100 °C
Flash point
:
does not flash
Evaporation rate
:
1
Upper explosion limit
:
No data available
Lower explosion limit
:
No data available
Vapour pressure
:
not determined
Relative vapour density
:
No data available
Density
:
1.01 g/cm3
Water solubility
:
soluble in cold water, soluble in hot water
Solubility in other solvents
:
not determined
Partition coefficient: noctanol/water
:
No data available
Auto-ignition temperature
:
not determined
Thermal decomposition
:
No data available
Viscosity, kinematic
:
3.4 mm2/s (20 °C)
Reactivity
:
Stable
Chemical stability
:
Stable under normal conditions.
Possibility of hazardous
reactions
:
No decomposition if stored and applied as directed.
Conditions to avoid
:
No data available
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Solubility(ies)
Viscosity
SECTION 10. STABILITY AND REACTIVITY
5 / 11
SAFETY DATA SHEET
ZEP FORMULA 50 R.T.U. 1 CS 12 QTS
Version 2.2
Revision Date 09/11/2017
Print Date 11/07/2018
Incompatible materials
:
Acids
Oxidizing agents
Hazardous decomposition
products
:
Carbon oxides
Aggravated Medical
Condition
:
None known.
Symptoms of Overexposure
:
Effects may be delayed, symptoms may include minor eye or
skin irritation.
IARC
No component of this product present at levels greater than or
equal to 0.1% is identified as probable, possible or confirmed
human carcinogen by IARC.
ACGIH
Confirmed animal carcinogen with unknown relevance to
humans
2-butoxyethanol
111-76-2
OSHA
No component of this product present at levels greater than or
equal to 0.1% is on OSHA’s list of regulated carcinogens.
NTP
No component of this product present at levels greater than or
equal to 0.1% is identified as a known or anticipated carcinogen
by NTP.
Acute oral toxicity
:
Acute toxicity estimate : > 5,000 mg/kg
Method: Calculation method
Result: Skin irritation
Classification: Irritating to skin.
Remarks: Irritating to skin.
Result: Eye irritation
Classification: Irritating to eyes.
Remarks: Irritating to eyes.
SECTION 11. TOXICOLOGICAL INFORMATION
Potential Health Effects
Carcinogenicity:
Acute toxicity
Product:
Skin corrosion/irritation
Product:
Serious eye damage/eye irritation
Product:
Respiratory or skin sensitisation
6 / 11
SAFETY DATA SHEET
ZEP FORMULA 50 R.T.U. 1 CS 12 QTS
Version 2.2
Revision Date 09/11/2017
Print Date 11/07/2018
Remarks: No data available
Partition coefficient: noctanol/water
:
Remarks: No data available
Regulation
40 CFR Protection of Environment; Part 82 Protection of
Stratospheric Ozone - CAA Section 602 Class I
Substances
Remarks
This product neither contains, nor was manufactured
with a Class I or Class II ODS as defined by the U.S.
No data available
Germ cell mutagenicity
No data available
Carcinogenicity
No data available
Reproductive toxicity
No data available
STOT - single exposure
No data available
STOT - repeated exposure
No data available
Aspiration toxicity
No data available
Further information
Product:
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity
No data available
Persistence and degradability
No data available
Bioaccumulative potential
Product:
Mobility in soil
No data available
Other adverse effects
No data available
Product:
7 / 11
SAFETY DATA SHEET
ZEP FORMULA 50 R.T.U. 1 CS 12 QTS
Version 2.2
Revision Date 09/11/2017
Print Date 11/07/2018
Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A
+ B).
Additional ecological
information
:
No data available
Waste from residues
:
Do not dispose of waste into sewer.
Do not contaminate ponds, waterways or ditches with
chemical or used container.
Dispose of in accordance with local regulations.
Contaminated packaging
:
Empty remaining contents.
Dispose of as unused product.
Do not re-use empty containers.
Transportation Regulation: 49 CFR (USA):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IMDG (Vessel):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IATA (Cargo Air):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IATA (Passenger Air):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: TDG (Canada):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
SECTION 13. DISPOSAL CONSIDERATIONS
Disposal methods
SECTION 14. TRANSPORT INFORMATION
The product as delivered to the customer conforms to packaging requirements for shipment by road
under US Department of Transportation (DOT) regulations. Additional transportation classifications
noted above are for reference only, and not a certification or warranty of the suitability of the packaging
for shipment under these alternative transport regulations.
SECTION 15. REGULATORY INFORMATION
8 / 11
SAFETY DATA SHEET
ZEP FORMULA 50 R.T.U. 1 CS 12 QTS
Version 2.2
Revision Date 09/11/2017
Print Date 11/07/2018
TSCA list
:
No substances are subject to a Significant New Use Rule.
No substances are subject to TSCA 12(b) export notification
requirements.
Components
CAS-No.
Component RQ
(lbs)
Calculated product RQ
(lbs)
sodium hydroxide
1310-73-2
1000
*
SARA 311/312 Hazards
:
Skin corrosion or irritation
Serious eye damage or eye irritation
SARA 302
:
No chemicals in this material are subject to the reporting
requirements of SARA Title III, Section 302.
SARA 313
:
This material does not contain any chemical components with
known CAS numbers that exceed the threshold (De Minimis)
reporting levels established by SARA Title III, Section 313.
This product does not contain any chemicals known to State of
California to cause cancer, birth defects, or any other
reproductive harm.
DSL
All components of this product are on the Canadian DSL
TSCA
On TSCA Inventory
EPCRA - Emergency Planning and Community Right-to-Know Act
CERCLA Reportable Quantity
*: Calculated RQ exceeds reasonably attainable upper limit.
SARA 304 Extremely Hazardous Substances Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
California Prop. 65
The components of this product are reported in the following inventories:
For information on the country notification status for other regions please contact the
manufacturer’s regulatory group.
Inventory Acronym and Validity Area Legend:
TSCA (USA), DSL (Canada), NDSL (Canada)
SECTION 16. OTHER INFORMATION
9 / 11
SAFETY DATA SHEET
ZEP FORMULA 50 R.T.U. 1 CS 12 QTS
Version 2.2
Revision Date 09/11/2017
Print Date 11/07/2018
NFPA:
HMIS III:
Hazard pictograms
:
Signal word
:
Warning:
Hazard statements
:
Causes skin irritation. Causes serious eye irritation.
Precautionary statements
:
Prevention: Wash skin thoroughly after handling. Wear eye protection/ face protection.
Wear protective gloves.
Response: IF ON SKIN: Wash with plenty of soap and water. IF IN EYES: Rinse
cautiously with water for several minutes. Remove contact lenses, if present and easy
to do. Continue rinsing. If skin irritation occurs: Get medical advice/ attention. If eye
irritation persists: Get medical advice/ attention. Take off contaminated clothing and
wash before reuse.
Version:
2.2
Revision Date:
09/11/2017
Print Date:
11/07/2018
Flammability
Health
Instability
2
0
0
Special hazard.
FLAMMABILITY
PHYSICAL HAZARD
HEALTH
0
0
2
0 = not significant, 1 =Slight,
2 = Moderate, 3 = High
4 = Extreme, * = Chronic
Further information
OSHA - GHS Label Information:
We believe the statements, technical information and recommendations contained herein are
reliable, but they are given without warranty or guarantee of any kind. The information in this
document applies to this specific material as supplied. It may not be valid for this material if it
is used in combination with any other materials. Users should make their own investigations
to determine the suitability and applicability of the information for their particular purposes.
This SDS has been prepared by the Compliance Services organization supporting this
manufacturer, supplier or distributor.
Zep Inc. markets products under well recognized and established brand names such as Zep®,
Zep Commercial®,Zep Professional®, Enforcer®, National Chemical™, Selig™, Misty®, Next
Dimension™, Petro®, i-Chem®, TimeMist®, TimeWick™, MicrobeMax®, Country Vet®,
Konk®, Original Bike Spirits®, Blue Coral®, Black Magic®, Rain-X®, Niagara National™, FC
Forward Chemicals®,Rexodan®, Mykal™, and a number of private labeled brands.
10 / 11
SAFETY DATA SHEET
ZEP FORMULA 50 R.T.U. 1 CS 12 QTS
Version 2.2
Revision Date 09/11/2017
Print Date 11/07/2018
11 / 11
Loading...