Page 1
SAFETY DATA SHEET
BZ7368 WALNUT IHC n/PUMP R05360 4/1G
Version 3.0
Revision Date 07/07/2016
Print Date 05/09/2017
Material name
:
BZ7368 WALNUT IHC n/PUMP R05360 4/1G
Material number
:
000000000001046476
Company
:
Zep Inc.
Address
:
1310 Seaboard Industrial Blvd., NW
Atlanta, GA 30318
Telephone
:
404-352-1680
Emergency telephone numbers
For SDS Information
:
Compliance Services 1-877-428-9937
For a Medical Emergency
:
877-541-2016 Toll Free - All Calls Recorded
For a Transportation
Emergency
:
CHEMTREC: 800-424-9300 - All Calls Recorded.
In the District of Columbia 202-483-7616
Appearance
gel
Colour
tan, opaque
Odour
cinnamon-like, like fruit
Eye irritation
:
Category 2A
Hazard pictograms
:
Signal word
:
Warning
Hazard statements
:
H319 Causes serious eye irritation.
Precautionary statements
:
Prevention:
P264 Wash skin thoroughly after handling.
P280 Wear eye protection/ face protection.
Response:
P305 + P351 + P338 IF IN EYES: Rinse cautiously with water
for several minutes. Remove contact lenses, if present and
easy to do. Continue rinsing.
P337 + P313 If eye irritation persists: Get medical advice/
attention.
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Manufacturer or supplier's details
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
GHS Classification
GHS label elements
1 / 10
Page 2
SAFETY DATA SHEET
BZ7368 WALNUT IHC n/PUMP R05360 4/1G
Version 3.0
Revision Date 07/07/2016
Print Date 05/09/2017
Substance / Mixture
:
Mixture
Chemical name
CAS-No.
Concentration [%]
Alcohols, C12-16, ethoxylated
68551-12-2
>= 1 - < 5
2-methylpentane-2,4-diol
107-41-5
>= 1 - < 5
titanium dioxide
13463-67-7
>= 1 - < 5
1,1'-iminodipropan-2-ol
110-97-4
>= 1 - < 5
General advice
:
Do not leave the victim unattended.
Show this safety data sheet to the doctor in attendance.
Move out of dangerous area.
If inhaled
:
If unconscious place in recovery position and seek medical
advice.
If symptoms persist, call a physician.
In case of skin contact
:
This product is formulated for use on skin but should always
be immediately washed off with plenty of water. Discontinue
use if irritation and redness develop. If conditions persist for
more than 72 hours, consult a physician.
In case of eye contact
:
Remove contact lenses.
Protect unharmed eye.
Keep eye wide open while rinsing.
If eye irritation persists, consult a specialist.
Rinse immediately with plenty of water for at least 15 minutes.
If swallowed
:
DO NOT induce vomiting unless directed to do so by a
physician or poison control center.
Keep respiratory tract clear.
Never give anything by mouth to an unconscious person.
If symptoms persist, call a physician.
Suitable extinguishing media
:
Dry chemical
Water spray jet
Carbon dioxide (CO2)
Alcohol-resistant foam
Unsuitable extinguishing
media
:
High volume water jet
Specific hazards during
firefighting
:
Do not allow run-off from fire fighting to enter drains or water
courses.
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components
The exact percentages of disclosed substances are withheld as trade secrets.
SECTION 4. FIRST AID MEASURES
SECTION 5. FIREFIGHTING MEASURES
2 / 10
Page 3
SAFETY DATA SHEET
BZ7368 WALNUT IHC n/PUMP R05360 4/1G
Version 3.0
Revision Date 07/07/2016
Print Date 05/09/2017
Hazardous combustion
products
:
Carbon dioxide (CO2)
Carbon monoxide
Smoke
Nitrogen oxides (NOx)
Specific extinguishing
methods
:
Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.
Further information
:
Standard procedure for chemical fires.
Special protective equipment
for firefighters
:
Wear self-contained breathing apparatus for firefighting if
necessary.
Personal precautions,
protective equipment and
emergency procedures
:
Material can create slippery conditions.
Use non-slip safety shoes in areas where spills or leaks can
occur.
Refer to protective measures listed in sections 7 and 8.
Environmental precautions
:
Prevent product from entering drains.
Prevent further leakage or spillage if safe to do so.
If the product contaminates rivers and lakes or drains inform
respective authorities.
Methods and materials for
containment and cleaning up
:
Soak up with inert absorbent material (e.g. sand, silica gel,
acid binder, universal binder, sawdust).
Keep in suitable, closed containers for disposal.
Advice on safe handling
:
For personal protection see section 8.
Smoking, eating and drinking should be prohibited in the
application area.
Dispose of rinse water in accordance with local and national
regulations.
Avoid contact with eyes.
Conditions for safe storage
:
Containers which are opened must be carefully resealed and
kept upright to prevent leakage.
Keep containers tightly closed in a cool, well-ventilated place.
Materials to avoid
:
Oxidizing agents
Store and keep away from bases and alkalies.
Components
CAS-No.
Value type
(Form of
exposure)
Control
parameters /
Permissible
concentration
Basis
SECTION 6. ACCIDENTAL RELEASE MEASURES
SECTION 7. HANDLING AND STORAGE
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
3 / 10
Page 4
SAFETY DATA SHEET
BZ7368 WALNUT IHC n/PUMP R05360 4/1G
Version 3.0
Revision Date 07/07/2016
Print Date 05/09/2017
2-methylpentane-2,4-diol
107-41-5
C
25 ppm
ACGIH
C
25 ppm
125 mg/m3
NIOSH REL
C
25 ppm
125 mg/m3
OSHA P0
titanium dioxide
13463-67-7
TWA
10 mg/m3
ACGIH
TWA (total
dust)
15 mg/m3
OSHA Z-1
Engineering measures
:
Not applicable
Respiratory protection
:
In case of insufficient ventilation, wear suitable respiratory
equipment.
Remarks
:
No special protection is required.
Eye protection
:
Eye protection is not required while washing with this product.
In the workplace, the use of safety glasses is recommended to
avoid eye exposure during the handling of containers or
during spill clean-up.
Skin and body protection
:
No special protection is required.
Hygiene measures
:
Wash hands before breaks and at the end of workday.
When using do not smoke.
When using do not eat or drink.
Appearance
:
gel
Colour
:
tan, opaque
Odour
:
cinnamon-like, like fruit
Odour Threshold
:
No data available
pH : 7 - 8
Melting point/freezing point
:
No data available
Boiling point
:
100 °C
Flash point
:
Not applicable
Evaporation rate
:
> 1
Upper explosion limit
:
No data available
Lower explosion limit
:
No data available
Vapour pressure
:
No data available
Relative vapour density
:
No data available
Hazardous components without workplace control parameters
Personal protective equipment
Hand protection
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
4 / 10
Page 5
SAFETY DATA SHEET
BZ7368 WALNUT IHC n/PUMP R05360 4/1G
Version 3.0
Revision Date 07/07/2016
Print Date 05/09/2017
Density
:
1.024 g/cm3
Water solubility
:
partly soluble
Partition coefficient: noctanol/water
:
No data available
Auto-ignition temperature
:
not determined
Thermal decomposition
:
No data available
Viscosity, kinematic
:
No data available
Reactivity
:
Stable
Chemical stability
:
Stable under normal conditions.
Possibility of hazardous
reactions
:
No decomposition if stored and applied as directed.
Conditions to avoid
:
No data available
Incompatible materials
:
Bases
Oxidizing agents
Hazardous decomposition
products
:
Carbon oxides
Nitrogen oxides (NOx)
IARC
Group 2B: Possibly carcinogenic to humans
titanium dioxide
13463-67-7
OSHA
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by OSHA.
NTP
No component of this product present at levels greater than or
equal to 0.1% is identified as a known or anticipated carcinogen
by NTP.
No component of this product present at levels greater than or
equal to 0.1% is identified as a known or anticipated carcinogen
by NTP.
Solubility(ies)
Viscosity
SECTION 10. STABILITY AND REACTIVITY
SECTION 11. TOXICOLOGICAL INFORMATION
Potential Health Effects
Carcinogenicity:
Acute toxicity
Product:
5 / 10
Page 6
SAFETY DATA SHEET
BZ7368 WALNUT IHC n/PUMP R05360 4/1G
Version 3.0
Revision Date 07/07/2016
Print Date 05/09/2017
Acute oral toxicity
:
Acute toxicity estimate : > 5,000 mg/kg
Method: Calculation method
Acute oral toxicity
:
LD50 Oral Rat: 3,700 mg/kg
Acute oral toxicity
:
LD50 Rat: 4,765 mg/kg
Result: No skin irritation
Remarks: Eye irritation
Carcinogenicity Assessment
:
Not classifiable as a human carcinogen.
Remarks: No data available
Components:
2-methylpentane-2,4-diol:
1,1'-iminodipropan-2-ol:
Skin corrosion/irritation
Product:
Serious eye damage/eye irritation
Product:
Respiratory or skin sensitisation
No data available
Germ cell mutagenicity
No data available
Carcinogenicity
Product:
Reproductive toxicity
No data available
Alcohols, C12-16, ethoxylated:
2-methylpentane-2,4-diol:
titanium dioxide:
1,1'-iminodipropan-2-ol:
STOT - single exposure
No data available
STOT - repeated exposure
No data available
Aspiration toxicity
No data available
Further information
Product:
6 / 10
Page 7
SAFETY DATA SHEET
BZ7368 WALNUT IHC n/PUMP R05360 4/1G
Version 3.0
Revision Date 07/07/2016
Print Date 05/09/2017
Partition coefficient: noctanol/water
:
Remarks: No data available
Partition coefficient: noctanol/water
:
Pow: 0.58
Regulation
40 CFR Protection of Environment; Part 82 Protection of
Stratospheric Ozone - CAA Section 602 Class I
Substances
Remarks
This product neither contains, nor was manufactured
with a Class I or Class II ODS as defined by the U.S.
Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A
+ B).
Additional ecological
information
:
No data available
Waste from residues
:
Do not dispose of waste into sewer.
Do not contaminate ponds, waterways or ditches with
chemical or used container.
Dispose of in accordance with local regulations.
Contaminated packaging
:
Dispose of as unused product.
Empty remaining contents.
Do not re-use empty containers.
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity
No data available
Persistence and degradability
No data available
Bioaccumulative potential
Product:
Components:
2-methylpentane-2,4-diol :
Mobility in soil
No data available
Other adverse effects
No data available
Product:
SECTION 13. DISPOSAL CONSIDERATIONS
Disposal methods
7 / 10
Page 8
SAFETY DATA SHEET
BZ7368 WALNUT IHC n/PUMP R05360 4/1G
Version 3.0
Revision Date 07/07/2016
Print Date 05/09/2017
Transportation Regulation: 49 CFR (USA):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IMDG (Vessel):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IATA (Cargo Air):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IATA (Passenger Air):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: TDG (Canada):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
TSCA list
:
No substances are subject to a Significant New Use Rule.
No substances are subject to TSCA 12(b) export notification
requirements.
SARA 311/312 Hazards
:
Acute Health Hazard
SARA 302
:
No chemicals in this material are subject to the reporting
requirements of SARA Title III, Section 302.
SECTION 14. TRANSPORT INFORMATION
The product as delivered to the customer conforms to packaging requirements for shipment by road
under US Department of Transportation (DOT) regulations. Additional transportation classifications
noted above are for reference only, and not a certification or warranty of the suitability of the packaging
for shipment under these alternative transport regulations.
SECTION 15. REGULATORY INFORMATION
EPCRA - Emergency Planning and Community Right-to-Know Act
CERCLA Reportable Quantity
This material does not contain any components with a CERCLA RQ.
SARA 304 Extremely Hazardous Substances Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
8 / 10
Page 9
SAFETY DATA SHEET
BZ7368 WALNUT IHC n/PUMP R05360 4/1G
Version 3.0
Revision Date 07/07/2016
Print Date 05/09/2017
SARA 313
:
This material does not contain any chemical components with
known CAS numbers that exceed the threshold (De Minimis)
reporting levels established by SARA Title III, Section 313.
California Prop 65
This product does not contain any chemicals known to State of
California to cause cancer, birth defects, or any other
reproductive harm.
TSCA
On TSCA Inventory
NFPA:
HMIS III:
Hazard pictograms
:
Signal word
:
Warning:
Hazard statements
:
Causes serious eye irritation.
Precautionary statements
:
Prevention: Wash skin thoroughly after handling. Wear eye protection/ face protection.
Response: IF IN EYES: Rinse cautiously with water for several minutes. Remove
contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get
medical advice/ attention.
Version:
3.0
Flammability
Health
Instability
2
0
0
Special hazard.
FLAMMABILITY
PHYSICAL HAZARD
HEALTH
0
0
2
0 = not significant, 1 =Slight,
2 = Moderate, 3 = High
4 = Extreme, * = Chronic
The components of this product are reported in the following inventories:
For information on the country notification status for other regions please contact the
manufacturer’s regulatory group.
Inventory Acronym and Validity Area Legend:
TSCA (USA), DSL (Canada)
SECTION 16. OTHER INFORMATION
Further information
OSHA - GHS Label Information:
9 / 10
Page 10
SAFETY DATA SHEET
BZ7368 WALNUT IHC n/PUMP R05360 4/1G
Version 3.0
Revision Date 07/07/2016
Print Date 05/09/2017
Revision Date:
07/07/2016
Print Date:
05/09/2017
We believe the statements, technical information and recommendations contained herein are
reliable, but they are given without warranty or guarantee of any kind. The information in this
document applies to this specific material as supplied. It may not be valid for this material if it
is used in combination with any other materials. Users should make their own investigations
to determine the suitability and applicability of the information for their particular purposes.
This SDS has been prepared by the Compliance Services organization supporting this
manufacturer, supplier or distributor.
Zep Inc. markets products under well recognized and established brand names such as Zep®,
Zep Commercial®,Zep Professional®, Enforcer®, National Chemical™, Selig™, Mis ty®, Next
Dimension™, Petro®, i-Chem®, TimeMist®, TimeWick™, MicrobeMax®, Country Vet®,
Konk®, Original Bike Spirits®, Blue Coral®, Black Magic®, Rain-X®, Niagara National™, FC
Forward Chemicals®,Rexodan®, Mykal™, and a number of private labeled brands.
10 / 10
Loading...