SAFETY DATA SHEET
ZEP AVIATION RTU CLEANER DISINFECTANT
Version 1.5
Revision Date 04/27/2020
Print Date 10/27/2020
Material name
:
ZEP AVIATION RTU CLEANER DISINFECTANT
EPA ID Number:
6836-152-1270
Material number
:
H02501
Company
:
Zep, Inc.
Address
:
350 Joe Frank Harris Parkway, SE
Emerson, GA 30137
Telephone
:
404-352-1680
Emergency telephone numbers
For SDS Information
:
Compliance Services 1-877-428-9937
For a Medical Emergency
:
877-541-2016 Toll Free - All Calls Recorded
For a Transportation
Emergency
:
CHEMTREC: 800-424-9300 - All Calls Recorded.
In the District of Columbia 202-483-7616
Appearance
liquid
Colour
green
Odour
pleasant
Substance / Mixture
:
Mixture
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Manufacturer or supplier's details
Recommended use of the chemical and restrictions on use
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
GHS Classification
Not a hazardous substance or mixture.
GHS label elements
Not a hazardous substance or mixture.
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components
No hazardous ingredients
1 / 10
SAFETY DATA SHEET
ZEP AVIATION RTU CLEANER DISINFECTANT
Version 1.5
Revision Date 04/27/2020
Print Date 10/27/2020
General advice
:
Do not leave the victim unattended.
Show this safety data sheet to the doctor in attendance.
Move out of dangerous area.
Get medical attention if symptoms occur.
If inhaled
:
If unconscious, place in recovery position and seek medical
advice.
If symptoms persist, call a physician.
In case of skin contact
:
Wash off immediately with soap and plenty of water.
If skin irritation persists, call a physician.
In case of eye contact
:
Remove contact lenses.
Protect unharmed eye.
If eye irritation persists, consult a specialist.
Rinse thoroughly with plenty of water for at least 15 minutes
and consult a physician.
If swallowed
:
Keep respiratory tract clear.
If swallowed, call a poison control centre or doctor
immediately.
Clean mouth with water and drink afterwards plenty of water.
Do not induce vomiting without medical advice.
Never give anything by mouth to an unconscious person.
Most important symptoms
and effects, both acute and
delayed
:
Effects may be delayed, symptoms may include minor eye or
skin irritation.
Overexposure may cause mild eye or skin irritation.
Notes to physician
:
Treat symptomatically. Symptoms may be delayed.
Suitable extinguishing media
:
Water spray
Dry powder
Foam
Unsuitable extinguishing
media
:
High volume water jet
Specific hazards during
firefighting
:
Do not allow run-off from fire fighting to enter drains or water
courses.
Hazardous combustion
products
:
No hazardous combustion products are known
Specific extinguishing
methods
:
Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.
Further information
:
Standard procedure for chemical fires.
Special protective equipment
for firefighters
:
Wear self-contained breathing apparatus for firefighting if
necessary.
SECTION 4. FIRST AID MEASURES
SECTION 5. FIREFIGHTING MEASURES
2 / 10
SAFETY DATA SHEET
ZEP AVIATION RTU CLEANER DISINFECTANT
Version 1.5
Revision Date 04/27/2020
Print Date 10/27/2020
Personal precautions,
protective equipment and
emergency procedures
:
Ensure adequate ventilation.
Wear respiratory protection.
Environmental precautions
:
Prevent product from entering drains.
Prevent further leakage or spillage if safe to do so.
If the product contaminates rivers and lakes or drains, inform
respective authorities.
Methods and materials for
containment and cleaning up
:
Sweep up or vacuum up spillage and collect in suitable
container for disposal.
Advice on safe handling
:
For personal protection see section 8.
Smoking, eating and drinking should be prohibited in the
application area.
Provide sufficient air exchange and/or exhaust in work rooms.
Conditions for safe storage
:
Keep container tightly closed in a dry and well-ventilated
place.
Containers which are opened must be carefully resealed and
kept upright to prevent leakage.
Materials to avoid
:
No materials to be especially mentioned.
Engineering measures
:
effective ventilation in all processing areas
Respiratory protection
:
In the case of vapour formation use a respirator with an
approved filter.
Material
:
Protective gloves
Remarks
:
The suitability for a specific workplace should be discussed
with the producers of the protective gloves.
Eye protection
:
Safety glasses
Skin and body protection
:
Choose body protection according to the amount and
concentration of the dangerous substance at the work place.
No special protection is required.
SECTION 6. ACCIDENTAL RELEASE MEASURES
SECTION 7. HANDLING AND STORAGE
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
Contains no substances with occupational exposure limit values.
Personal protective equipment
Hand protection
3 / 10
SAFETY DATA SHEET
ZEP AVIATION RTU CLEANER DISINFECTANT
Version 1.5
Revision Date 04/27/2020
Print Date 10/27/2020
Hygiene measures
:
Wash hands before breaks and at the end of workday.
When using do not smoke.
When using do not eat or drink.
Avoid contact with skin, eyes and clothing.
Appearance
:
liquid
Colour
:
green
Odour
:
pleasant
Odour Threshold
:
No data available
pH : 10 - 11
Melting point/freezing point
:
No data available
Boiling point
:
not determined
Flash point
:
Not applicable
Evaporation rate
:
No data available
Upper explosion limit
:
No data available
Lower explosion limit
:
No data available
Vapour pressure
:
31.69 hPa (25 °C)
Relative vapour density
:
No data available
Density
:
1.000 g/cm3
Water solubility
:
soluble
Solubility in other solvents
:
not determined
Partition coefficient: noctanol/water
:
No data available
Auto-ignition temperature
:
not determined
Thermal decomposition
:
No data available
Viscosity, kinematic
:
3.0 mm2/s (20 °C)
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Solubility(ies)
Viscosity
SECTION 10. STABILITY AND REACTIVITY
4 / 10
SAFETY DATA SHEET
ZEP AVIATION RTU CLEANER DISINFECTANT
Version 1.5
Revision Date 04/27/2020
Print Date 10/27/2020
Reactivity
:
Stable
Chemical stability
:
Stable under normal conditions.
Possibility of hazardous
reactions
:
Stable under recommended storage conditions.
No hazards to be specially mentioned.
Conditions to avoid
:
No data available
Incompatible materials
:
No data available
Hazardous decomposition
products
:
Carbon dioxide (CO2)
Nitrogen oxides (NOx)
Aggravated Medical
Condition
:
None known.
Symptoms of Overexposure
:
Effects may be delayed, symptoms may include minor eye or
skin irritation.
Overexposure may cause mild eye or skin irritation.
Treat symptomatically. Symptoms may be delayed.
IARC
No component of this product present at levels greater than or
equal to 0.1% is identified as probable, possible or confirmed
human carcinogen by IARC.
ACGIH
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by ACGIH.
OSHA
No component of this product present at levels greater than or
equal to 0.1% is on OSHA’s list of regulated carcinogens.
NTP
No component of this product present at levels greater than or
equal to 0.1% is identified as a known or anticipated carcinogen
by NTP.
SECTION 11. TOXICOLOGICAL INFORMATION
Potential Health Effects
Carcinogenicity:
Acute toxicity
No data available
Skin corrosion/irritation
No data available
Serious eye damage/eye irritation
No data available
Respiratory or skin sensitisation
No data available
Germ cell mutagenicity
5 / 10
SAFETY DATA SHEET
ZEP AVIATION RTU CLEANER DISINFECTANT
Version 1.5
Revision Date 04/27/2020
Print Date 10/27/2020
Remarks: No data available
Partition coefficient: noctanol/water
:
Remarks: No data available
Regulation
40 CFR Protection of Environment; Part 82 Protection of
Stratospheric Ozone - CAA Section 602 Class I
Substances
Remarks
This product neither contains, nor was manufactured
with a Class I or Class II ODS as defined by the U.S.
Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A
+ B).
No data available
Carcinogenicity
No data available
Reproductive toxicity
No data available
STOT - single exposure
No data available
STOT - repeated exposure
No data available
Aspiration toxicity
No data available
Further information
Product:
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity
No data available
Persistence and degradability
No data available
Bioaccumulative potential
Product:
Mobility in soil
No data available
Other adverse effects
No data available
Product:
6 / 10
SAFETY DATA SHEET
ZEP AVIATION RTU CLEANER DISINFECTANT
Version 1.5
Revision Date 04/27/2020
Print Date 10/27/2020
Additional ecological
information
:
No data available
Waste from residues
:
Dispose of in accordance with local regulations.
Do not contaminate ponds, waterways or ditches with
chemical or used container.
The product should not be allowed to enter drains, water
courses or the soil.
Pesticide wastes are acutely hazardous. Improper disposal of
excess pesticide, spray mixture or rinsate is a violation of
Federal law. If these wastes cannot be disposed of by use
according to label instructions, contact your State Pesticide or
Provincial Environmental control agency, or the Hazardous
Waste Representative at the nearest EPA Regional Office for
guidance.
Contaminated packaging
:
Empty containers should be taken to an approved waste
handling site for recycling or disposal.
Dispose of as unused product.
Do not re-use empty containers.
Transportation Regulation: 49 CFR (USA):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IMDG (Vessel):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IATA (Cargo Air):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IATA (Passenger Air):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: TDG (Canada):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
SECTION 13. DISPOSAL CONSIDERATIONS
Disposal methods
SECTION 14. TRANSPORT INFORMATION
The product as delivered to the customer conforms to packaging requirements for shipment by road
under US Department of Transportation (DOT) regulations. Additional transportation classifications
7 / 10
SAFETY DATA SHEET
ZEP AVIATION RTU CLEANER DISINFECTANT
Version 1.5
Revision Date 04/27/2020
Print Date 10/27/2020
TSCA list
:
No substances are subject to a Significant New Use Rule.
No substances are subject to TSCA 12(b) export notification
requirements.
Components
CAS-No.
Component RQ
(lbs)
Calculated product RQ
(lbs)
sodium hydroxide
1310-73-2
1000
*
SARA 311/312 Hazards
:
No SARA Hazards
SARA 302
:
No chemicals in this material are subject to the reporting
requirements of SARA Title III, Section 302.
SARA 313
:
This material does not contain any chemical components with
known CAS numbers that exceed the threshold (De Minimis)
reporting levels established by SARA Title III, Section 313.
This product does not contain any chemicals known to State of
California to cause cancer, birth defects, or any other
reproductive harm.
noted above are for reference only, and not a certification or warranty of the suitability of the packaging
for shipment under these alternative transport regulations.
SECTION 15. REGULATORY INFORMATION
This product is regulated under the United States Federal Insecticide, Fungicide and Rodenticide Act
(FIFRA).
Pesticide Labeling Information Required Under U.S. FIFRA Regulations
This chemical is a pesticide product registered by the Environmental Protection Agency and is subject
to certain labeling requirements under federal pesticide law. These requirements differ from the
classification criteria and hazard information required for safety data sheets, and for workplace labels
of non-pesticide chemicals. Following is the hazard information as required on the pesticide label:
CAUTION
Causes moderate eye irritation.
Observe label precautions.
EPCRA - Emergency Planning and Community Right-to-Know Act
CERCLA Reportable Quantity
*: Calculated RQ exceeds reasonably attainable upper limit.
SARA 304 Extremely Hazardous Substances Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
California Prop. 65
8 / 10
SAFETY DATA SHEET
ZEP AVIATION RTU CLEANER DISINFECTANT
Version 1.5
Revision Date 04/27/2020
Print Date 10/27/2020
DSL
This product contains one or more components that are listed on the
Canadian NDSL. All other components are on the Canadian DSL.
TSCA
On TSCA Inventory
NFPA:
HMIS III:
FLAMMABILITY
PHYSICAL HAZARD
HEALTH
0
0
0
0 = not significant, 1 =Slight,
2 = Moderate, 3 = High
4 = Extreme, * = Chronic
FLAMMABILITY
INSTABILITY
HEALTH
0
0
0
0 = not significant, 1 =Slight,
2 = Moderate, 3 = High
4 = Extreme
SPECIAL HAZARD.
The components of this product are reported in the following inventories:
For information on the country notification status for other regions please contact the
manufacturer’s regulatory group.
Inventory Acronym and Validity Area Legend:
TSCA (USA), DSL (Canada), NDSL (Canada)
SECTION 16. OTHER INFORMATION
Further information
OSHA - GHS Label Information:
Not a hazardous substance or mixture.
9 / 10
SAFETY DATA SHEET
ZEP AVIATION RTU CLEANER DISINFECTANT
Version 1.5
Revision Date 04/27/2020
Print Date 10/27/2020
Version:
1.5
Revision Date:
04/27/2020
Print Date:
10/27/2020
We believe the statements, technical information and recommendations contained herein are
reliable, but they are given without warranty or guarantee of any kind. The information in this
document applies to this specific material as supplied. It may not be valid for this material if it
is used in combination with any other materials. Users should make their own investigations
to determine the suitability and applicability of the information for their particular purposes.
This SDS has been prepared by the Compliance Services organization supporting this
manufacturer, supplier or distributor.
10 / 10
Loading...