Page 1
SAFETY DATA SHEET
ZEP SPIRIT II DETERGENT DISINFECTANT
Version 2.3
Revision Date 04/23/2020
Print Date 08/31/2020
Material name
:
ZEP SPIRIT II DETERGENT DISINFECTANT
EPA ID Number:
1839-83-1270
Material number
:
000000000000067923
Company
:
Zep, Inc.
Address
:
350 Joe Frank Harris Parkway, SE
Emerson, GA 30137
Telephone
:
404-352-1680
Emergency telephone numbers
For SDS Information
:
Compliance Services 1-877-428-9937
For a Medical Emergency
:
877-541-2016 Toll Free - All Calls Recorded
For a Transportation
Emergency
:
CHEMTREC: 800-424-9300 - All Calls Recorded.
In the District of Columbia 202-483-7616
Appearance
liquid
Colour
colourless
Odour
characteristic
Eye irritation
:
Category 2A
Hazard pictograms
:
Exclamation
mark
Signal word
:
Warning
Hazard statements
:
H319 Causes serious eye irritation.
Precautionary statements
:
Prevention:
P264 Wash skin thoroughly after handling.
P280 Wear eye protection/ face protection.
Response:
P305 + P351 + P338 IF IN EYES: Rinse cautiously with water
for several minutes. Remove contact lenses, if present and
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Manufacturer or supplier's details
Recommended use of the chemical and restrictions on use
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
GHS Classification
GHS label elements
1 / 12
Page 2
SAFETY DATA SHEET
ZEP SPIRIT II DETERGENT DISINFECTANT
Version 2.3
Revision Date 04/23/2020
Print Date 08/31/2020
easy to do. Continue rinsing.
P337 + P313 If eye irritation persists: Get medical advice/
attention.
Substance / Mixture
:
Mixture
Chemical name
CAS-No.
Concentration [%]
2-(2-butoxyethoxy)ethanol
112-34-5
>= 5 - < 10
tetrasodium ethylenediaminetetraacetate
64-02-8
>= 1 - < 5
General advice
:
Move out of dangerous area.
Show this safety data sheet to the doctor in attendance.
Do not leave the victim unattended.
If inhaled
:
If unconscious, place in recovery position and seek medical
advice.
If symptoms persist, call a physician.
In case of skin contact
:
Wash off immediately with plenty of water for at least 15
minutes.
If on skin, rinse well with water.
If on clothes, remove clothes.
In case of eye contact
:
Small amounts splashed into eyes can cause irreversible
tissue damage and blindness.
If in eyes, rinse with water for 15 minutes.
Continue rinsing eyes during transport to hospital.
Remove contact lenses.
Protect unharmed eye.
Keep eye wide open while rinsing.
If eye irritation persists, consult a specialist.
If swallowed
:
Keep respiratory tract clear.
Do NOT induce vomiting.
Never give anything by mouth to an unconscious person.
If symptoms persist, call a physician.
Take victim immediately to hospital.
Most important symptoms
and effects, both acute and
delayed
:
Effects are immediate and delayed.
Symptoms may include irritation, redness, pain, and rash.
Causes serious eye irritation.
Review section 2 of SDS to see all potential hazards.
Notes to physician
:
Treat symptomatically. Symptoms may be delayed.
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components
The exact percentages of disclosed substances are withheld as trade secrets.
SECTION 4. FIRST AID MEASURES
2 / 12
Page 3
SAFETY DATA SHEET
ZEP SPIRIT II DETERGENT DISINFECTANT
Version 2.3
Revision Date 04/23/2020
Print Date 08/31/2020
Suitable extinguishing media
:
Use water spray, alcohol-resistant foam, dry chemical or
carbon dioxide.
Unsuitable extinguishing
media
:
High volume water jet
Hazardous combustion
products
:
Carbon dioxide (CO2)
Carbon monoxide
Smoke
Nitrogen oxides (NOx)
Specific extinguishing
methods
:
Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.
Further information
:
Collect contaminated fire extinguishing water separately. This
must not be discharged into drains.
Fire residues and contaminated fire extinguishing water must
be disposed of in accordance with local regulations.
Special protective equipment
for firefighters
:
Wear self-contained breathing apparatus for firefighting if
necessary.
Personal precautions,
protective equipment and
emergency procedures
:
Use personal protective equipment.
Environmental precautions
:
Prevent further leakage or spillage if safe to do so.
Prevent product from entering drains.
If the product contaminates rivers and lakes or drains, inform
respective authorities.
Methods and materials for
containment and cleaning up
:
Soak up with inert absorbent material (e.g. sand, silica gel,
acid binder, universal binder, sawdust).
Keep in suitable, closed containers for disposal.
Advice on safe handling
:
Do not breathe vapours or spray mist.
Avoid contact with eyes.
For personal protection see section 8.
Smoking, eating and drinking should be prohibited in the
application area.
Dispose of rinse water in accordance with local and national
regulations.
Conditions for safe storage
:
Keep container tightly closed in a dry and well-ventilated
place.
Electrical installations / working materials must comply with
SECTION 5. FIREFIGHTING MEASURES
SECTION 6. ACCIDENTAL RELEASE MEASURES
SECTION 7. HANDLING AND STORAGE
3 / 12
Page 4
SAFETY DATA SHEET
ZEP SPIRIT II DETERGENT DISINFECTANT
Version 2.3
Revision Date 04/23/2020
Print Date 08/31/2020
the technological safety standards.
Materials to avoid
:
Store and keep away from, oxidizing agents and acids.
Components
CAS-No.
Value type
(Form of
exposure)
Control
parameters /
Permissible
concentration
Basis
2-(2-butoxyethoxy)ethanol
112-34-5
TWA
(Inhalable
fraction and
vapor)
10 ppm
ACGIH
Engineering measures
:
effective ventilation in all processing areas
Respiratory protection
:
No personal respiratory protective equipment normally
required.
Follow personal protective equipment guidance noted on the
product label when using this product, especially if cleaning
areas soiled with blood or body fluids.
In the workplace- If a significant exposure or spill occurs, use
respiratory protection unless adequate local exhaust
ventilation is provided or exposure assessment demonstrates
that exposures are within recommended exposure guidelines.
Material
:
Latex gloves
Remarks
:
When using this product to disinfect surfaces or handling
items soiled with blood or body fluids use disposable latex
gloves. Follow personal protective equipment guidance noted
on the product label when using this product, especially if
cleaning areas soiled with blood or body fluids.
Protective gloves
In the workplace- If a significant exposure or spill occurs, use
chemical-resistant gloves if prolonged or frequent contact is
possible or likely.
Eye protection
:
Safety glasses with side-shields
Ensure that eyewash stations and safety showers are close to
the workstation location.
Skin and body protection
:
For general disinfecting, no special protection is required.
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
Personal protective equipment
Hand protection
4 / 12
Page 5
SAFETY DATA SHEET
ZEP SPIRIT II DETERGENT DISINFECTANT
Version 2.3
Revision Date 04/23/2020
Print Date 08/31/2020
Follow personal protective equipment guidance noted on the
product label when using this product, especially if cleaning
areas soiled with blood or body fluids.
Choose body protection in relation to its type, to the
concentration and amount of dangerous substances, and to
the specific work-place.
Hygiene measures
:
When using do not eat or drink.
When using do not smoke.
Wash hands before breaks and at the end of workday.
Appearance
:
liquid
Colour
:
colourless
Odour
:
characteristic
Odour Threshold
:
No data available
pH : 11.5 - 12.5
Melting point/freezing point
:
No data available
Boiling point
:
> 100 °C
Flash point
:
> 93.3 °C
Method: closed cup
Upper explosion limit
:
not determined
Lower explosion limit
:
not determined
Vapour pressure
:
No data available
Density
:
1 g/cm3
Water solubility
:
soluble
Solubility in other solvents
:
not determined
Partition coefficient: noctanol/water
:
No data available
Auto-ignition temperature
:
not determined
Thermal decomposition
:
No data available
Viscosity, kinematic
:
3.8 mm2/s (20 °C)
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Solubility(ies)
Viscosity
5 / 12
Page 6
SAFETY DATA SHEET
ZEP SPIRIT II DETERGENT DISINFECTANT
Version 2.3
Revision Date 04/23/2020
Print Date 08/31/2020
Reactivity
:
Stable
Chemical stability
:
Stable under normal conditions.
Possibility of hazardous
reactions
:
No decomposition if stored and applied as directed.
Conditions to avoid
:
No data available
Incompatible materials
:
Oxidizing agents
Acids
Alkali metals
Hazardous decomposition
products
:
Carbon oxides
Nitrogen oxides (NOx)
Ammonia
Aggravated Medical
Condition
:
None known.
Symptoms of Overexposure
:
Effects are immediate and delayed.
Symptoms may include irritation, redness, pain, and rash.
Causes serious eye irritation.
Review section 2 of SDS to see all potential hazards.
Treat symptomatically. Symptoms may be delayed.
IARC
No component of this product present at levels greater than or
equal to 0.1% is identified as probable, possible or confirmed
human carcinogen by IARC.
ACGIH
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by ACGIH.
OSHA
No component of this product present at levels greater than or
equal to 0.1% is on OSHA’s list of regulated carcinogens.
NTP
No component of this product present at levels greater than or
equal to 0.1% is identified as a known or anticipated carcinogen
by NTP.
Acute oral toxicity
:
Acute toxicity estimate : > 5,000 mg/kg
Method: Calculation method
SECTION 10. STABILITY AND REACTIVITY
SECTION 11. TOXICOLOGICAL INFORMATION
Potential Health Effects
Carcinogenicity:
Acute toxicity
Product:
6 / 12
Page 7
SAFETY DATA SHEET
ZEP SPIRIT II DETERGENT DISINFECTANT
Version 2.3
Revision Date 04/23/2020
Print Date 08/31/2020
Result: Mild skin irritation
Method: Third Party Data - Actual or Inferred
Result: Eye irritation
Method: Third Party Data - Actual or Inferred
Exposure routes: Inhalation
Assessment: May cause damage to organs through prolonged or repeated exposure.
Remarks: No data available
Toxicity to fish
:
Skin corrosion/irritation
Product:
Serious eye damage/eye irritation
Product:
Respiratory or skin sensitisation
No data available
Germ cell mutagenicity
No data available
Carcinogenicity
No data available
Reproductive toxicity
No data available
STOT - single exposure
No data available
STOT - repeated exposure
Components:
tetrasodium ethylenediaminetetraacetate:
Aspiration toxicity
No data available
Further information
Product:
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity
Product:
7 / 12
Page 8
SAFETY DATA SHEET
ZEP SPIRIT II DETERGENT DISINFECTANT
Version 2.3
Revision Date 04/23/2020
Print Date 08/31/2020
Remarks: Toxic to aquatic organisms.
Harmful to aquatic organisms, may cause long-term
adverse effects in the aquatic environment.
Toxicity to daphnia and
other aquatic invertebrates
:
Remarks: Harmful to aquatic organisms, may cause
long-term adverse effects in the aquatic environment.
Toxic to aquatic organisms.
Partition coefficient: n-
octanol/water
:
Remarks: No data available
Partition coefficient: n-
octanol/water
:
Pow: 1
Regulation
40 CFR Protection of Environment; Part 82 Protection of
Stratospheric Ozone - CAA Section 602 Class I
Substances
Remarks
This product neither contains, nor was manufactured
with a Class I or Class II ODS as defined by the U.S.
Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A
+ B).
Additional ecological
information
:
No data available
Waste from residues
:
Do not dispose of waste into sewer.
Do not contaminate ponds, waterways or ditches with
chemical or used container.
Dispose of in accordance with local regulations.
Pesticide wastes are acutely hazardous. Improper disposal of
excess pesticide, spray mixture or rinsate is a violation of
Federal law. If these wastes cannot be disposed of by use
according to label instructions, contact your State Pesticide or
Provincial Environmental control agency, or the Hazardous
Persistence and degradability
No data available
Bioaccumulative potential
Product:
Components:
2-(2-butoxyethoxy)ethanol :
Mobility in soil
No data available
Other adverse effects
No data available
Product:
SECTION 13. DISPOSAL CONSIDERATIONS
Disposal methods
8 / 12
Page 9
SAFETY DATA SHEET
ZEP SPIRIT II DETERGENT DISINFECTANT
Version 2.3
Revision Date 04/23/2020
Print Date 08/31/2020
Waste Representative at the nearest EPA Regional Office for
guidance.
Contaminated packaging
:
Empty remaining contents.
Dispose of as unused product.
Do not re-use empty containers.
Transportation Regulation: 49 CFR (USA):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IMDG (Vessel):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IATA (Cargo Air):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IATA (Passenger Air):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: TDG (Canada):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
TSCA list
:
No substances are subject to a Significant New Use Rule.
SECTION 14. TRANSPORT INFORMATION
The product as delivered to the customer conforms to packaging requirements for shipment by road
under US Department of Transportation (DOT) regulations. Additional transportation classifications
noted above are for reference only, and not a certification or warranty of the suitability of the packaging
for shipment under these alternative transport regulations.
SECTION 15. REGULATORY INFORMATION
This product is regulated under the United States Federal Insecticide, Fungicide and Rodenticide Act
(FIFRA).
Pesticide Labeling Information Required Under U.S. FIFRA Regulations
This chemical is a pesticide product registered by the Environmental Protection Agency and is subject
to certain labeling requirements under federal pesticide law. These requirements differ from the
classification criteria and hazard information required for safety data sheets, and for workplace labels
of non-pesticide chemicals. Following is the hazard information as required on the pesticide label:
CAUTION
Causes moderate eye irritation.
This pesticide is toxic to fish.
9 / 12
Page 10
SAFETY DATA SHEET
ZEP SPIRIT II DETERGENT DISINFECTANT
Version 2.3
Revision Date 04/23/2020
Print Date 08/31/2020
No substances are subject to TSCA 12(b) export notification
requirements.
Components
CAS-No.
Component RQ
(lbs)
Calculated product RQ
(lbs)
sodium hydroxide
1310-73-2
1000
*
SARA 311/312 Hazards
:
Serious eye damage or eye irritation
SARA 302
:
No chemicals in this material are subject to the reporting
requirements of SARA Title III, Section 302.
SARA 313
:
This material does not contain any chemical components with
known CAS numbers that exceed the threshold (De Minimis)
reporting levels established by SARA Title III, Section 313.
The following components are subject to reporting levels
established by SARA Title III, Section 313:
2-(2-butoxyethoxy)ethanol
112-34-5
7.9572 %
2-butoxyethanol
111-76-2
0.04 %
This product does not contain any chemicals known to State of
California to cause cancer, birth defects, or any other
reproductive harm.
DSL
All components of this product are on the Canadian DSL
TSCA
On TSCA Inventory
EPCRA - Emergency Planning and Community Right-to-Know Act
CERCLA Reportable Quantity
*: Calculated RQ exceeds reasonably attainable upper limit.
SARA 304 Extremely Hazardous Substances Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
California Prop. 65
The components of this product are reported in the following inventories:
For information on the country notification status for other regions please contact the
manufacturer’s regulatory group.
Inventory Acronym and Validity Area Legend:
TSCA (USA), DSL (Canada), NDSL (Canada)
SECTION 16. OTHER INFORMATION
10 / 12
Page 11
SAFETY DATA SHEET
ZEP SPIRIT II DETERGENT DISINFECTANT
Version 2.3
Revision Date 04/23/2020
Print Date 08/31/2020
NFPA:
HMIS III:
Hazard pictograms
:
Exclamation
mark
Signal word
:
Warning:
Hazard statements
:
Causes serious eye irritation.
Precautionary statements
:
Prevention: Wash skin thoroughly after handling. Wear eye protection/ face protection.
Response: IF IN EYES: Rinse cautiously with water for several minutes. Remove
contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get
medical advice/ attention.
Version:
2.3
Revision Date:
04/23/2020
Print Date:
08/31/2020
FLAMMABILITY
PHYSICAL HAZARD
HEALTH
1
0
2
0 = not significant, 1 =Slight,
2 = Moderate, 3 = High
4 = Extreme, * = Chronic
FLAMMABILITY
INSTABILITY
HEALTH
1
0
2
0 = not significant, 1 =Slight,
2 = Moderate, 3 = High
4 = Extreme
SPECIAL HAZARD.
Further information
OSHA - GHS Label Information:
11 / 12
Page 12
SAFETY DATA SHEET
ZEP SPIRIT II DETERGENT DISINFECTANT
Version 2.3
Revision Date 04/23/2020
Print Date 08/31/2020
We believe the statements, technical information and recommendations contained herein are
reliable, but they are given without warranty or guarantee of any kind. The information in this
document applies to this specific material as supplied. It may not be valid for this material if it
is used in combination with any other materials. Users should make their own investigations
to determine the suitability and applicability of the information for their particular purposes.
This SDS has been prepared by the Compliance Services organization supporting this
manufacturer, supplier or distributor.
12 / 12
Loading...