Page 1
SAFETY DATA SHEET
A07319 ZEP VENTURE II 000601 20N18
Version 3.1
Revision Date 03/24/2020
Print Date 08/26/2020
Material name
:
ZEP VENTURE II CLEANER DISINFECTANT
DEODORIZER VIRUCIDE
EPA ID Number:
1839-84-1270
Material number
:
000000000000000601
Company
:
Zep, Inc.
Address
:
350 Joe Frank Harris Parkway, SE
Emerson, GA 30137
Telephone
:
404-352-1680
Emergency telephone numbers
For SDS Information
:
Compliance Services 1-877-428-9937
For a Medical Emergency
:
877-541-2016 Toll Free - All Calls Recorded
For a Transportation
Emergency
:
CHEMTREC: 800-424-9300 - All Calls Recorded.
In the District of Columbia 202-483-7616
Recommended use
:
Cleaner
Appearance
Aerosol containing a liquefied gas
Colour
clear, colourless
Odour
pleasant
Gases under pressure
:
Liquefied gas
Eye irritation
:
Category 2A
Specific target organ toxicity repeated exposure
(Inhalation)
:
Category 2
Hazard pictograms
:
Signal word
:
Warning
Hazard statements
:
H280 Contains gas under pressure; may explode if heated.
H319 Causes serious eye irritation.
H373 May cause damage to organs through prolonged or
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Manufacturer or supplier's details
Recommended use of the chemical and restrictions on use
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
GHS Classification
GHS label elements
1 / 11
Page 2
SAFETY DATA SHEET
A07319 ZEP VENTURE II 000601 20N18
Version 3.1
Revision Date 03/24/2020
Print Date 08/26/2020
repeated exposure if inhaled.
Precautionary statements
:
Prevention:
P260 Do not breathe dust/ fume/ gas/ mist/ vapours/ spray.
P264 Wash skin thoroughly after handling.
P280 Wear eye protection/ face protection.
Response:
P305 + P351 + P338 IF IN EYES: Rinse cautiously with water
for several minutes. Remove contact lenses, if present and
easy to do. Continue rinsing.
P314 Get medical advice/ attention if you feel unwell.
P337 + P313 If eye irritation persists: Get medical advice/
attention.
Storage:
P410 + P403 Protect from sunlight. Store in a well-ventilated
place.
Disposal:
P501 Dispose of contents/container in accordance with local
regulation.
Substance / Mixture
:
Mixture
Chemical name
CAS-No.
Concentration [%]
2-(2-butoxyethoxy)ethanol
112-34-5
>= 3 - < 5
butane
106-97-8
>= 3 - < 5
tetrasodium ethylenediaminetetraacetate
64-02-8
>= 1 - < 3
propane
74-98-6
>= 1 - < 3
General advice
:
Move out of dangerous area.
Show this safety data sheet to the doctor in attendance.
Do not leave the victim unattended.
If inhaled
:
If unconscious, place in recovery position and seek medical
advice.
Consult a physician after significant exposure.
In case of skin contact
:
If skin irritation persists, call a physician.
If on clothes, remove clothes.
Wash off immediately with plenty of water for at least 15
minutes.
In case of eye contact
:
Remove contact lenses.
Protect unharmed eye.
Keep eye wide open while rinsing.
If eye irritation persists, consult a specialist.
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components
The exact percentages of disclosed substances are withheld as trade secrets.
SECTION 4. FIRST AID MEASURES
2 / 11
Page 3
SAFETY DATA SHEET
A07319 ZEP VENTURE II 000601 20N18
Version 3.1
Revision Date 03/24/2020
Print Date 08/26/2020
Rinse immediately with plenty of water for at least 15 minutes.
If swallowed
:
Keep respiratory tract clear.
Never give anything by mouth to an unconscious person.
If symptoms persist, call a physician.
DO NOT induce vomiting unless directed to do so by a
physician or poison control center.
Take victim immediately to hospital.
Most important symptoms
and effects, both acute and
delayed
:
Causes serious eye irritation.
May cause damage to organs through prolonged or repeated
exposure if inhaled.
Review section 2 of SDS to see all potential hazards.
Notes to physician
:
Treat symptomatically. Symptoms may be delayed.
Suitable extinguishing media
:
Water spray jet
Alcohol-resistant foam
Carbon dioxide (CO2)
Dry chemical
Unsuitable extinguishing
media
:
High volume water jet
Specific hazards during
firefighting
:
Do not allow run-off from fire fighting to enter drains or water
courses.
Hazardous combustion
products
:
Carbon dioxide (CO2)
Carbon monoxide
Smoke
Nitrogen oxides (NOx)
Specific extinguishing
methods
:
Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.
Further information
:
Collect contaminated fire extinguishing water separately. This
must not be discharged into drains.
Fire residues and contaminated fire extinguishing water must
be disposed of in accordance with local regulations.
Special protective equipment
for firefighters
:
Wear self-contained breathing apparatus for firefighting if
necessary.
Personal precautions,
protective equipment and
emergency procedures
:
Use personal protective equipment.
Ensure adequate ventilation.
Remove all sources of ignition.
Evacuate personnel to safe areas.
Beware of vapours accumulating to form explosive
concentrations. Vapours can accumulate in low areas.
SECTION 5. FIREFIGHTING MEASURES
SECTION 6. ACCIDENTAL RELEASE MEASURES
3 / 11
Page 4
SAFETY DATA SHEET
A07319 ZEP VENTURE II 000601 20N18
Version 3.1
Revision Date 03/24/2020
Print Date 08/26/2020
Environmental precautions
:
Prevent product from entering drains.
Prevent further leakage or spillage if safe to do so.
If the product contaminates rivers and lakes or drains, inform
respective authorities.
Methods and materials for
containment and cleaning up
:
Soak up with inert absorbent material (e.g. sand, silica gel,
acid binder, universal binder, sawdust).
Sweep up or vacuum up spillage and collect in suitable
container for disposal.
Advice on safe handling
:
Avoid exposure - obtain special instructions before use.
Avoid contact with skin and eyes.
For personal protection see section 8.
Smoking, eating and drinking should be prohibited in the
application area.
Do not breathe vapours or spray mist.
Take precautionary measures against static discharges.
Provide sufficient air exchange and/or exhaust in work rooms.
Dispose of rinse water in accordance with local and national
regulations.
Always replace cap after use.
Conditions for safe storage
:
BEWARE: Aerosol is pressurized. Keep away from direct sun
exposure and temperatures over 50 °C. Do not open by force
or throw into fire even after use. Do not spray on flames or
red-hot objects.
Keep in a dry, cool and well-ventilated place.
Observe label precautions.
No smoking.
Electrical installations / working materials must comply with
the technological safety standards.
Materials to avoid
:
Oxidizing agents
Components
CAS-No.
Value type
(Form of
exposure)
Control
parameters /
Permissible
concentration
Basis
2-(2-butoxyethoxy)ethanol
112-34-5
TWA
(Inhalable
fraction and
vapor)
10 ppm
ACGIH
butane
106-97-8
TWA
800 ppm
1,900 mg/m3
NIOSH REL
TWA
800 ppm
1,900 mg/m3
OSHA P0
PEL
800 ppm
CAL PEL
SECTION 7. HANDLING AND STORAGE
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
4 / 11
Page 5
SAFETY DATA SHEET
A07319 ZEP VENTURE II 000601 20N18
Version 3.1
Revision Date 03/24/2020
Print Date 08/26/2020
1,900 mg/m3
STEL
1,000 ppm
ACGIH
propane
74-98-6
TWA
1,000 ppm
1,800 mg/m3
NIOSH REL
TWA
1,000 ppm
1,800 mg/m3
OSHA Z-1
TWA
1,000 ppm
1,800 mg/m3
OSHA P0
PEL
1,000 ppm
1,800 mg/m3
CAL PEL
Engineering measures
:
effective ventilation in all processing areas
Respiratory protection
:
Use respiratory protection unless adequate local exhaust
ventilation is provided or exposure assessment demonstrates
that exposures are within recommended exposure guidelines.
Material
:
Protective gloves
Remarks
:
The suitability for a specific workplace should be discussed
with the producers of the protective gloves.
Eye protection
:
Access to clean water to rinse eyes must be available, options
include: eye wash stations or showers, or eye wash bottles
with pure water.
Safety glasses
Skin and body protection
:
Impervious clothing
Choose body protection according to the amount and
concentration of the dangerous substance at the work place.
Hygiene measures
:
When using do not eat or drink.
When using do not smoke.
Wash hands before breaks and at the end of workday.
Appearance
:
Aerosol containing a liquefied gas
Colour
:
clear, colourless
Odour
:
pleasant
Odour Threshold
:
No data available
pH : 11.0 - 12.0
Melting point/freezing point
:
No data available
Boiling point
:
100 °C
Flash point
:
Personal protective equipment
Hand protection
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
5 / 11
Page 6
SAFETY DATA SHEET
A07319 ZEP VENTURE II 000601 20N18
Version 3.1
Revision Date 03/24/2020
Print Date 08/26/2020
Not applicable
Evaporation rate
:
< 1 Flammability (solid, gas)
:
The product is not flammable.
Upper explosion limit
:
No data available
Lower explosion limit
:
No data available
Vapour pressure
:
0.021 hPa
Relative vapour density
:
No data available
Density
:
1.013 g/cm3
Water solubility
:
soluble
Partition coefficient: noctanol/water
:
No data available
Auto-ignition temperature
:
not determined
Thermal decomposition
:
No data available
Viscosity, kinematic
:
No data available
Heat of combustion
:
4.48 kJ/g
Reactivity
:
Stable
Chemical stability
:
Stable under normal conditions.
Possibility of hazardous
reactions
:
No decomposition if stored and applied as directed.
Conditions to avoid
:
Heat, flames and sparks.
Extremes of temperature and direct sunlight.
Incompatible materials
:
Oxidizing agents
Hazardous decomposition
products
:
Carbon oxides
IARC
No component of this product present at levels greater than or
equal to 0.1% is identified as probable, possible or confirmed
Solubility(ies)
Viscosity
SECTION 10. STABILITY AND REACTIVITY
SECTION 11. TOXICOLOGICAL INFORMATION
Potential Health Effects
Carcinogenicity:
6 / 11
Page 7
SAFETY DATA SHEET
A07319 ZEP VENTURE II 000601 20N18
Version 3.1
Revision Date 03/24/2020
Print Date 08/26/2020
human carcinogen by IARC.
ACGIH
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by ACGIH.
OSHA
No component of this product present at levels greater than or
equal to 0.1% is on OSHA’s list of regulated carcinogens.
NTP
No component of this product present at levels greater than or
equal to 0.1% is identified as a known or anticipated carcinogen
by NTP.
Acute oral toxicity
:
Acute toxicity estimate : > 5,000 mg/kg
Method: Calculation method
Remarks: May irritate skin.
Remarks: May irritate eyes.
Exposure routes: Inhalation
Assessment: May cause damage to organs through prolonged or repeated exposure.
Acute toxicity
Product:
Skin corrosion/irritation
Product:
Serious eye damage/eye irritation
Product:
Respiratory or skin sensitisation
No data available
Germ cell mutagenicity
No data available
Carcinogenicity
No data available
Reproductive toxicity
No data available
STOT - single exposure
No data available
STOT - repeated exposure
Components:
tetrasodium ethylenediaminetetraacetate:
Aspiration toxicity
No data available
Further information
7 / 11
Page 8
SAFETY DATA SHEET
A07319 ZEP VENTURE II 000601 20N18
Version 3.1
Revision Date 03/24/2020
Print Date 08/26/2020
Remarks: No data available
Partition coefficient: noctanol/water
:
Remarks: No data available
Partition coefficient: noctanol/water
:
Pow: 1
Partition coefficient: noctanol/water
:
Pow: 2.89
Regulation
40 CFR Protection of Environment; Part 82 Protection of
Stratospheric Ozone - CAA Section 602 Class I
Substances
Remarks
This product neither contains, nor was manufactured
with a Class I or Class II ODS as defined by the U.S.
Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A
+ B).
Additional ecological
information
:
An environmental hazard cannot be excluded in the
event of unprofessional handling or disposal., Harmful to
aquatic life.
Waste from residues
:
The product should not be allowed to enter drains, water
Product:
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity
No data available
Persistence and degradability
No data available
Bioaccumulative potential
Product:
Components:
2-(2-butoxyethoxy)ethanol :
butane :
Mobility in soil
No data available
Other adverse effects
No data available
Product:
SECTION 13. DISPOSAL CONSIDERATIONS
Disposal methods
8 / 11
Page 9
SAFETY DATA SHEET
A07319 ZEP VENTURE II 000601 20N18
Version 3.1
Revision Date 03/24/2020
Print Date 08/26/2020
courses or the soil.
Do not contaminate ponds, waterways or ditches with
chemical or used container.
Dispose of in accordance with local regulations.
Contaminated packaging
:
Empty remaining contents.
Dispose of as unused product.
Do not re-use empty containers.
Do not burn, or use a cutting torch on, the empty drum.
Transportation Regulation: 49 CFR (USA):
UN1950, AEROSOLS, NON-FLAMMABLE, 2.2, - Limited quantity
Transportation Regulation: IMDG (Vessel):
UN1950, AEROSOLS, NON-FLAMMABLE, 2.2, - Limited quantity
Transportation Regulation: IATA (Cargo Air):
UN1950, AEROSOLS, NON-FLAMMABLE, 2.2, - Limited quantity
Transportation Regulation: IATA (Passenger Air):
UN1950, AEROSOLS, NON-FLAMMABLE, 2.2, - Limited quantity
Transportation Regulation: TDG (Canada):
UN1950, AEROSOLS, NON-FLAMMABLE, 2.2, - Limited quantity
TSCA list
:
No substances are subject to a Significant New Use Rule.
No substances are subject to TSCA 12(b) export notification
requirements.
SECTION 14. TRANSPORT INFORMATION
The product as delivered to the customer conforms to packaging requirements for shipment by road
under US Department of Transportation (DOT) regulations. Additional transportation classifications
noted above are for reference only, and not a certification or warranty of the suitability of the packaging
for shipment under these alternative transport regulations.
SECTION 15. REGULATORY INFORMATION
This product is regulated under the United States Federal Insecticide, Fungicide and Rodenticide Act
(FIFRA).
Pesticide Labeling Information Required Under U.S. FIFRA Regulations
This chemical is a pesticide product registered by the Environmental Protection Agency and is subject
to certain labeling requirements under federal pesticide law. These requirements differ from the
classification criteria and hazard information required for safety data sheets, and for workplace labels
of non-pesticide chemicals. Following is the hazard information as required on the pesticide label:
WARNING
Causes skin and eye irritation.
Harmful if swallowed.
9 / 11
Page 10
SAFETY DATA SHEET
A07319 ZEP VENTURE II 000601 20N18
Version 3.1
Revision Date 03/24/2020
Print Date 08/26/2020
Components
CAS-No.
Component RQ
(lbs)
Calculated product RQ
(lbs)
sodium hydroxide
1310-73-2
1000
*
SARA 311/312 Hazards
:
Gases under pressure
Serious eye damage or eye irritation
Specific target organ toxicity (single or repeated exposure)
SARA 302
:
No chemicals in this material are subject to the reporting
requirements of SARA Title III, Section 302.
SARA 313
:
The following components are subject to reporting levels
established by SARA Title III, Section 313:
2-(2-butoxyethoxy)ethanol
112-34-5
4 %
This product does not contain any chemicals known to State of
California to cause cancer, birth defects, or any other
reproductive harm.
DSL
This product contains one or several components that are not on the
Canadian DSL nor NDSL.
TSCA
On TSCA Inventory
EPCRA - Emergency Planning and Community Right-to-Know Act
CERCLA Reportable Quantity
*: Calculated RQ exceeds reasonably attainable upper limit.
CERCLA Reportable Quantity
This material does not contain any components with a CERCLA RQ.
SARA 304 Extremely Hazardous Substances Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
California Prop. 65
The components of this product are reported in the following inventories:
For information on the country notification status for other regions please contact the
manufacturer’s regulatory group.
Inventory Acronym and Validity Area Legend:
TSCA (USA), DSL (Canada), NDSL (Canada)
SECTION 16. OTHER INFORMATION
10 / 11
Page 11
SAFETY DATA SHEET
A07319 ZEP VENTURE II 000601 20N18
Version 3.1
Revision Date 03/24/2020
Print Date 08/26/2020
NFPA:
HMIS III:
Hazard pictograms
:
Signal word
:
Warning:
Hazard statements
:
Contains gas under pressure; may explode if heated. Causes serious eye irritation. May
cause damage to organs through prolonged or repeated exposure if inhaled.
Precautionary statements
:
Prevention: Do not breathe dust/ fume/ gas/ mist/ vapours/ spray. Wash skin
thoroughly after handling. Wear eye protection/ face protection.
Response: IF IN EYES: Rinse cautiously with water for several minutes. Remove
contact lenses, if present and easy to do. Continue rinsing. Get medical advice/
attention if you feel unwell. If eye irritation persists: Get medical advice/ attention.
Storage: Protect from sunlight. Store in a well-ventilated place.
Disposal: Dispose of contents/container in accordance with local regulation.
Version:
3.1
Revision Date:
03/24/2020
Print Date:
08/26/2020
Flammability
Health
Instability
3
0
0
Special hazard.
FLAMMABILITY
PHYSICAL HAZARD
HEALTH
0
2
3*
0 = not significant, 1 =Slight,
2 = Moderate, 3 = High
4 = Extreme, * = Chronic
Further information
OSHA - GHS Label Information:
We believe the statements, technical information and recommendations contained herein are
reliable, but they are given without warranty or guarantee of any kind. The information in this
document applies to this specific material as supplied. It may not be valid for this material if it
is used in combination with any other materials. Users should make their own investigations
to determine the suitability and applicability of the information for their particular purposes.
This SDS has been prepared by the Compliance Services organization supporting this
manufacturer, supplier or distributor.
Zep Inc. markets products under well recognized and established brand names such as Zep®,
Zep Commercial®,Zep Professional®, Enforcer®, National Chemical™, Selig™, Misty®, Next
Dimension™, Petro®, i-Chem®, TimeMist®, TimeWick™, MicrobeMax®, Country Vet®,
Konk®, Original Bike Spirits®, Blue Coral®, Black Magic®, Rain-X®, Niagara National™, FC
Forward Chemicals®,Rexodan®, Mykal™, and a number of private labeled brands.
11 / 11
Loading...