SAFETY DATA SHEET
A06813 ZEP 30 DISINF CLNR 000301 20n20
Version 2.0
Revision Date 02/09/2018
Print Date 04/25/2019
Material name
:
Zep 30 Disinfectant Cleaner
EPA ID Number:
33176-6-1270
Material number
:
000000000000000301
Company
:
Zep, Inc.
Address
:
350 Joe Frank Harris Parkway, SE
Emerson, GA 30137
Telephone
:
404-352-1680
Emergency telephone numbers
For SDS Information
:
Compliance Services 1-877-428-9937
For a Medical Emergency
:
877-541-2016 Toll Free - All Calls Recorded
For a Transportation
Emergency
:
CHEMTREC: 800-424-9300 - All Calls Recorded.
In the District of Columbia 202-483-7616
Recommended use
:
Disinfectant
Appearance
Aerosol containing a liquefied gas
Colour
white
Odour
pleasant
Gases under pressure
:
Liquefied gas
Skin corrosion
:
Category 1
Serious eye damage
:
Category 1
Carcinogenicity
:
Category 2
Hazard pictograms
:
Signal word
:
Danger
Hazard statements
:
H280 Contains gas under pressure; may explode if heated.
H314 Causes severe skin burns and eye damage.
H351 Suspected of causing cancer.
Precautionary statements
:
Prevention:
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Manufacturer or supplier's details
Recommended use of the chemical and restrictions on use
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
GHS Classification
GHS label elements
1 / 12
SAFETY DATA SHEET
A06813 ZEP 30 DISINF CLNR 000301 20n20
Version 2.0
Revision Date 02/09/2018
Print Date 04/25/2019
P201 Obtain special instructions before use.
P202 Do not handle until all safety precautions have been read
and understood.
P260 Do not breathe dust or mist.
P264 Wash skin thoroughly after handling.
P280 Wear protective gloves/ protective clothing/ eye
protection/ face protection.
Response:
P301 + P330 + P331 IF SWALLOWED: Rinse mouth. Do NOT
induce vomiting.
P303 + P361 + P353 IF ON SKIN (or hair): Take off
immediately all contaminated clothing. Rinse skin with
water/shower.
P304 + P340 + P310 IF INHALED: Remove person to fresh air
and keep comfortable for breathing. Immediately call a
POISON CENTER/doctor.
P305 + P351 + P338 + P310 IF IN EYES: Rinse cautiously with
water for several minutes. Remove contact lenses, if present
and easy to do. Continue rinsing. Immediately call a POISON
CENTER/doctor.
P308 + P313 IF exposed or concerned: Get medical advice/
attention.
P363 Wash contaminated clothing before reuse.
Storage:
P410 + P403 Protect from sunlight. Store in a well-ventilated
place.
Disposal:
P501 Dispose of contents/container in accordance with local
regulation.
Substance / Mixture
:
Mixture
Chemical name
CAS-No.
Concentration [%]
2-(2-butoxyethoxy)ethanol
112-34-5
>= 5 - < 10
butane
106-97-8
>= 1 - < 5
Amides, coco, N,N-bis(hydroxyethyl)
68603-42-9
>= 0.1 - < 1
General advice
:
Move out of dangerous area.
Consult a physician.
Show this safety data sheet to the doctor in attendance.
Do not leave the victim unattended.
If inhaled
:
If unconscious, place in recovery position and seek medical
advice.
If symptoms persist, call a physician.
In case of skin contact
:
Immediate medical treatment is necessary as untreated
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components
The exact percentages of disclosed substances are withheld as trade secrets.
SECTION 4. FIRST AID MEASURES
2 / 12
SAFETY DATA SHEET
A06813 ZEP 30 DISINF CLNR 000301 20n20
Version 2.0
Revision Date 02/09/2018
Print Date 04/25/2019
wounds from corrosion of the skin heal slowly and with
difficulty.
Wash off immediately with plenty of water for at least 15
minutes.
If on clothes, remove clothes.
In case of eye contact
:
Small amounts splashed into eyes can cause irreversible
tissue damage and blindness.
Continue rinsing eyes during transport to hospital.
Remove contact lenses.
Protect unharmed eye.
Keep eye wide open while rinsing.
If eye irritation persists, consult a specialist.
Immediately flush eyes for at least 15 minutes. Get medical
attention.
If swallowed
:
Keep respiratory tract clear.
Never give anything by mouth to an unconscious person.
If symptoms persist, call a physician.
DO NOT induce vomiting unless directed to do so by a
physician or poison control center.
Take victim immediately to hospital.
Most important symptoms
and effects, both acute and
delayed
:
Effects are dependent on exposure (dose, concentration,
contact time).
Effects are immediate and delayed.
Symptoms may include blistering, irritation, burns, and pain.
Causes severe skin burns and eye damage.
Suspected of causing cancer.
Review section 2 of SDS to see all potential hazards.
Notes to physician
:
Treat symptomatically. Symptoms may be delayed.
Suitable extinguishing media
:
Water spray jet
Carbon dioxide (CO2)
Alcohol-resistant foam
Dry chemical
Unsuitable extinguishing
media
:
High volume water jet
Specific hazards during
firefighting
:
Do not allow run-off from fire fighting to enter drains or water
courses.
Hazardous combustion
products
:
Carbon dioxide (CO2)
Carbon monoxide
Smoke
Specific extinguishing
methods
:
Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.
Further information
:
Collect contaminated fire extinguishing water separately. This
must not be discharged into drains.
SECTION 5. FIREFIGHTING MEASURES
3 / 12
SAFETY DATA SHEET
A06813 ZEP 30 DISINF CLNR 000301 20n20
Version 2.0
Revision Date 02/09/2018
Print Date 04/25/2019
Fire residues and contaminated fire extinguishing water must
be disposed of in accordance with local regulations.
Special protective equipment
for firefighters
:
Wear self-contained breathing apparatus for firefighting if
necessary.
Personal precautions,
protective equipment and
emergency procedures
:
Use personal protective equipment.
Environmental precautions
:
Prevent product from entering drains.
Prevent further leakage or spillage if safe to do so.
If the product contaminates rivers and lakes or drains inform
respective authorities.
Methods and materials for
containment and cleaning up
:
Soak up with inert absorbent material (e.g. sand, silica gel,
acid binder, universal binder, sawdust).
Sweep up or vacuum up spillage and collect in suitable
container for disposal.
Advice on safe handling
:
Avoid exposure - obtain special instructions before use.
Avoid contact with skin and eyes.
For personal protection see section 8.
Do not breathe vapours or spray mist.
Take precautionary measures against static discharges.
Provide sufficient air exchange and/or exhaust in work rooms.
Dispose of rinse water in accordance with local and national
regulations.
Always replace cap after use.
Conditions for safe storage
:
BEWARE: Aerosol is pressurized. Keep away from direct sun
exposure and temperatures over 50 °C. Do not open by force
or throw into fire even after use. Do not spray on flames or
red-hot objects.
No smoking.
Keep in a dry, cool and well-ventilated place.
Observe label precautions.
Electrical installations / working materials must comply with
the technological safety standards.
Materials to avoid
:
Oxidizing agents
Components
CAS-No.
Value type
(Form of
exposure)
Control
parameters /
Permissible
Basis
SECTION 6. ACCIDENTAL RELEASE MEASURES
SECTION 7. HANDLING AND STORAGE
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
4 / 12
SAFETY DATA SHEET
A06813 ZEP 30 DISINF CLNR 000301 20n20
Version 2.0
Revision Date 02/09/2018
Print Date 04/25/2019
concentration
2-(2-butoxyethoxy)ethanol
112-34-5
TWA
(Inhalable
fraction and
vapor)
10 ppm
ACGIH
butane
106-97-8
TWA
800 ppm
1,900 mg/m3
NIOSH REL
TWA
800 ppm
1,900 mg/m3
OSHA P0
PEL
800 ppm
1,900 mg/m3
CAL PEL
Engineering measures
:
effective ventilation in all processing areas
Respiratory protection
:
Use respiratory protection unless adequate local exhaust
ventilation is provided or exposure assessment demonstrates
that exposures are within recommended exposure guidelines.
Remarks
:
The suitability for a specific workplace should be discussed
with the producers of the protective gloves.
Eye protection
:
Tightly fitting safety goggles
Wear face-shield and protective suit for abnormal processing
problems.
Access to clean water to rinse eyes must be available, options
include: eye wash stations or showers, or eye wash bottles
with pure water.
Skin and body protection
:
Impervious clothing
Choose body protection according to the amount and
concentration of the dangerous substance at the work place.
Hygiene measures
:
When using do not eat or drink.
When using do not smoke.
Wash hands before breaks and at the end of workday.
Appearance
:
Aerosol containing a liquefied gas
Colour
:
white
Odour
:
pleasant
Odour Threshold
:
No data available
pH : 12.5 - 13.0
Melting point/freezing point
:
No data available
Boiling point
:
not determined
Personal protective equipment
Hand protection
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
5 / 12
SAFETY DATA SHEET
A06813 ZEP 30 DISINF CLNR 000301 20n20
Version 2.0
Revision Date 02/09/2018
Print Date 04/25/2019
Flash point
:
No data available
Evaporation rate
:
not determined
Flammability (solid, gas)
:
Not classified as a flammability hazard
Upper explosion limit
:
No data available
Lower explosion limit
:
No data available
Vapour pressure
:
not determined
Relative vapour density
:
No data available
Density
:
1 g/cm3
Water solubility
:
soluble
Solubility in other solvents
:
not determined
Partition coefficient: noctanol/water
:
No data available
Auto-ignition temperature
:
not determined
Thermal decomposition
:
No data available
Viscosity, kinematic
:
No data available
Reactivity
:
Stable
Chemical stability
:
Stable under normal conditions.
Possibility of hazardous
reactions
:
No decomposition if stored and applied as directed.
Conditions to avoid
:
Extremes of temperature and direct sunlight.
Heat, flames and sparks.
Incompatible materials
:
Oxidizing agents
Hazardous decomposition
products
:
Carbon oxides
Aggravated Medical
Condition
:
None known.
Symptoms of Overexposure
:
Effects are dependent on exposure (dose, concentration,
Solubility(ies)
Viscosity
SECTION 10. STABILITY AND REACTIVITY
SECTION 11. TOXICOLOGICAL INFORMATION
Potential Health Effects
6 / 12
SAFETY DATA SHEET
A06813 ZEP 30 DISINF CLNR 000301 20n20
Version 2.0
Revision Date 02/09/2018
Print Date 04/25/2019
contact time).
Effects are immediate and delayed.
Symptoms may include blistering, irritation, burns, and pain.
IARC
Group 2B: Possibly carcinogenic to humans
Amides, coco, N,Nbis(hydroxyethyl)
68603-42-9
ACGIH
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by ACGIH.
OSHA
No component of this product present at levels greater than or
equal to 0.1% is on OSHA’s list of regulated carcinogens.
NTP
No component of this product present at levels greater than or
equal to 0.1% is identified as a known or anticipated carcinogen
by NTP.
Remarks: Extremely corrosive and destructive to tissue.
Remarks: May cause irreversible eye damage.
Carcinogenicity:
Acute toxicity
No data available
Skin corrosion/irritation
Product:
Serious eye damage/eye irritation
Product:
Respiratory or skin sensitisation
No data available
Germ cell mutagenicity
No data available
Carcinogenicity
No data available
Reproductive toxicity
No data available
STOT - single exposure
No data available
STOT - repeated exposure
No data available
Aspiration toxicity
No data available
7 / 12
SAFETY DATA SHEET
A06813 ZEP 30 DISINF CLNR 000301 20n20
Version 2.0
Revision Date 02/09/2018
Print Date 04/25/2019
Remarks: No data available
Remarks: No data available
Partition coefficient: noctanol/water
:
Remarks: No data available
Partition coefficient: noctanol/water
:
Pow: 1
Partition coefficient: noctanol/water
:
Pow: 2.89
Partition coefficient: noctanol/water
:
Remarks: No data available
Regulation
40 CFR Protection of Environment; Part 82 Protection of
Stratospheric Ozone - CAA Section 602 Class I
Substances
Remarks
This product neither contains, nor was manufactured
with a Class I or Class II ODS as defined by the U.S.
Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A
+ B).
Additional ecological
information
:
No data available
Further information
Product:
Components:
Amides, coco, N,N-bis(hydroxyethyl):
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity
No data available
Persistence and degradability
No data available
Bioaccumulative potential
Product:
Components:
2-(2-butoxyethoxy)ethanol :
butane :
Amides, coco, N,N-bis(hydroxyethyl) :
Mobility in soil
No data available
Other adverse effects
No data available
Product:
8 / 12
SAFETY DATA SHEET
A06813 ZEP 30 DISINF CLNR 000301 20n20
Version 2.0
Revision Date 02/09/2018
Print Date 04/25/2019
Additional ecological
information
:
No data available
Waste from residues
:
Dispose of in accordance with local regulations.
Do not contaminate ponds, waterways or ditches with
chemical or used container.
The product should not be allowed to enter drains, water
courses or the soil.
Contaminated packaging
:
Empty remaining contents.
Dispose of as unused product.
Do not re-use empty containers.
Do not burn, or use a cutting torch on, the empty drum.
Transportation Regulation: 49 CFR (USA):
ORM-D, CONSUMER COMMODITY
Transportation Regulation: IMDG (Vessel):
UN1950, AEROSOLS, NON-FLAMMABLE, 2.2, - Limited quantity
Transportation Regulation: IATA (Cargo Air):
UN1950, AEROSOLS, NON-FLAMMABLE, 2.2, - Limited quantity
Transportation Regulation: IATA (Passenger Air):
UN1950, AEROSOLS, NON-FLAMMABLE, 2.2, - Limited quantity
Transportation Regulation: TDG (Canada):
UN1950, AEROSOLS, NON-FLAMMABLE, 2.2, - Limited quantity
Components:
Amides, coco, N,N-bis(hydroxyethyl) :
SECTION 13. DISPOSAL CONSIDERATIONS
Disposal methods
SECTION 14. TRANSPORT INFORMATION
The product as delivered to the customer conforms to packaging requirements for shipment by road
under US Department of Transportation (DOT) regulations. Additional transportation classifications
noted above are for reference only, and not a certification or warranty of the suitability of the packaging
for shipment under these alternative transport regulations.
SECTION 15. REGULATORY INFORMATION
This product is regulated under the United States Federal Insecticide, Fungicide and Rodenticide Act
(FIFRA).
Pesticide Labeling Information Required Under U.S. FIFRA Regulations
9 / 12
SAFETY DATA SHEET
A06813 ZEP 30 DISINF CLNR 000301 20n20
Version 2.0
Revision Date 02/09/2018
Print Date 04/25/2019
TSCA list
:
No substances are subject to a Significant New Use Rule.
No substances are subject to TSCA 12(b) export notification
requirements.
Components
CAS-No.
Component RQ
(lbs)
Calculated product RQ
(lbs)
2,2'-iminodiethanol
111-42-2
100
*
SARA 311/312 Hazards
:
Gases under pressure
Skin corrosion or irritation
Serious eye damage or eye irritation
Carcinogenicity
SARA 302
:
No chemicals in this material are subject to the reporting
requirements of SARA Title III, Section 302.
SARA 313
:
The following components are subject to reporting levels
established by SARA Title III, Section 313:
2-(2-butoxyethoxy)ethanol
112-34-5
5.91 %
2-butoxyethanol
111-76-2
0.09 %
WARNING: This product can expose you to chemicals
including Amides, coco, N,N-bis(hydroxyethyl), biphenyl-2-ol,
2,2'-iminodiethanol, which is/are known to the State of
California to cause cancer. For more information go to
www.P65Warnings.ca.gov.
This chemical is a pesticide product registered by the Environmental Protection Agency and is subject
to certain labeling requirements under federal pesticide law. These requirements differ from the
classification criteria and hazard information required for safety data sheets, and for workplace labels
of non-pesticide chemicals. Following is the hazard information as required on the pesticide label:
CAUTION
Harmful if swallowed.
EPCRA - Emergency Planning and Community Right-to-Know Act
CERCLA Reportable Quantity
*: Calculated RQ exceeds reasonably attainable upper limit.
SARA 304 Extremely Hazardous Substances Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
California Prop. 65
The components of this product are reported in the following inventories:
Inventory Acronym and Validity Area Legend:
TSCA (USA), DSL (Canada), NDSL (Canada)
10 / 12
SAFETY DATA SHEET
A06813 ZEP 30 DISINF CLNR 000301 20n20
Version 2.0
Revision Date 02/09/2018
Print Date 04/25/2019
NFPA:
HMIS III:
Hazard pictograms
:
Signal word
:
Danger:
Hazard statements
:
Contains gas under pressure; may explode if heated. Causes severe skin burns and
eye damage. Suspected of causing cancer.
Precautionary statements
:
Prevention: Obtain special instructions before use. Do not handle until all safety
precautions have been read and understood. Do not breathe dust or mist. Wash skin
thoroughly after handling. Wear protective gloves/ protective clothing/ eye protection/
face protection.
Response: IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. IF ON SKIN (or
hair): Take off immediately all contaminated clothing. Rinse skin with water/shower. IF
INHALED: Remove person to fresh air and keep comfortable for breathing. Immediately
call a POISON CENTER/doctor. IF IN EYES: Rinse cautiously with water for several
minutes. Remove contact lenses, if present and easy to do. Continue rinsing.
Immediately call a POISON CENTER/doctor. IF exposed or concerned: Get medical
advice/ attention. Wash contaminated clothing before reuse.
Storage: Protect from sunlight. Store in a well-ventilated place.
Disposal: Dispose of contents/container in accordance with local regulation.
Version:
2.0
Revision Date:
02/09/2018
Print Date:
04/25/2019
Flammability
Health
Instability
3
1
0
Special hazard.
FLAMMABILITY
PHYSICAL HAZARD
HEALTH
1
2
3*
0 = not significant, 1 =Slight,
2 = Moderate, 3 = High
4 = Extreme, * = Chronic
SECTION 16. OTHER INFORMATION
Further information
OSHA - GHS Label Information:
We believe the statements, technical information and recommendations contained herein are
reliable, but they are given without warranty or guarantee of any kind. The information in this
document applies to this specific material as supplied. It may not be valid for this material if it
is used in combination with any other materials. Users should make their own investigations
to determine the suitability and applicability of the information for their particular purposes.
11 / 12
SAFETY DATA SHEET
A06813 ZEP 30 DISINF CLNR 000301 20n20
Version 2.0
Revision Date 02/09/2018
Print Date 04/25/2019
This SDS has been prepared by the Compliance Services organization supporting this
manufacturer, supplier or distributor.
Zep Inc. markets products under well recognized and established brand names such as Zep®,
Zep Commercial®,Zep Professional®, Enforcer®, National Chemical™, Selig™, Misty®, Next
Dimension™, Petro®, i-Chem®, TimeMist®, TimeWick™, MicrobeMax®, Country Vet®,
Konk®, Original Bike Spirits®, Blue Coral®, Black Magic®, Rain-X®, Niagara National™, FC
Forward Chemicals®,Rexodan®, Mykal™, and a number of private labeled brands.
12 / 12
Loading...