Zenoah PE2300 User Manual

848AB193A0 (705)

OWNER’S MANUAL

WATER PUMP

PE2300

G

G
B

B

PE2300

GB-1

PE2300

SAFETY PRECAUTIONS

Warning labels bearing the mark on the product and in this
Manual refer to important safety matters. Please familiarize your­self with them and observe them well.
If a warning label on the product becomes soiled or detached,
please order a replacement label from your dealer and attach it
in the requisite place.

PRECAUTIONS

In this Operator's Manual, precautions that are considered to be
particularly important are indicated as follows.

WARNINGS IN THE MANUAL

WARNING

Failure to observe the precaution may result in the risk of death
or serious injury.

IMPORTANT

Failure to observe the precaution may result in damage or mal­function of the product.

NOTE

Other additional explanations that may be of use when operat­ing the product.

1. Parts location

Contents

1. Parts location .................................................. 2

2. Specification ................................................... 3

3. Symbols in the manual ................................... 3

4. Symbols on the machine ................................ 3

5. For safe operation........................................... 4

6. Set up ............................................................. 6

7. Fuel ................................................................. 6

8. Operation ........................................................ 7

9. Maintenance ................................................... 9

10. Storage ......................................................... 11

11. Disposal ........................................................ 11

12. Troubleshooting guide .................................. 12

5

6

20

19

15

14

4

1

17

18

7

8

9

13

2

3

12

11

16

10

(1) Air cleaner
(2) Throttle lever
(3) Spark plug
(4) Handle
(5) Self-suction plug
(6) Discharge port
(7) Suction port
(8) Hose coupling

(9) Clump
(10) Suction hose∗
(11) Strainer
(12) Clump
(13) Drain plug
(14) Base
(15) Fuel tank
(16) Engine stop switch
(17) Fuel tank cap
(18) Starter knob
(19) Exhaust vent
(20) Engine cover

∗This hose is not attached.

GB-2

2. Specification

Model name PE2300

Application Fresh water or agricultural water
Dry weight ∗ (kg) 4.7
External dimensions of main unit
(length x width x height) ∗ (mm)
Pump Type Self suction type volute pump

Suction/Discharge port diameter (mm)
To tal water head Discharge

Suction (m) 8
Discharge(Max) (L/min) 92
Max temperature for usage (°C) 75

Engine Type Single-cylinder air-cooled 2-cycle gasoline engine

Model number Zenoah G23LH
Exhaust capacity (cc) 22.5
Fuel used Lubricating oil/gasoline mix
Fuel tank capacity (L) 0.5
Lubricating oil used 2-cycle engine oil
Admixture ratio Gasoline 50 : Oil 1 (when using ZENOAH genuine oil)
Carburetor Diaphragm, rotary valve type
Ignition system Electronic controlled flywheel magnet type
Spark plugs CHAMPION CJ-6Y
Starter system Recoil starter type
Stopping system Primary cable short circuit
Air cleaner Dry type

Standard accessories 1 plug wrench, 1 Strainer, 2 hose coupling, 3 clump

∗ When accessories is not attached.

Due to product improvements, these specifications are subject to change without notice.

(m) 35

PUMP PERFORMANCE CURVE

288x221x321

25

PE2300

G
B

Total water head (m)

Diacharge (L/min.)

3. Symbols in the manual

(1)

(1)

Read owner’s manual before operating this machine.

(2) Warning / Attention

Never modify your machine.
We won’t warrant the machine, if you use the
remodeled pump or if you don’t observe
proper usage written in the manual.

(2)

the

4. Symbols on the machine

For safe operation and maintenance, symbols are carved
in relief on the machine. According to these indications,
please be careful not to make a mistake.

The port to refuel the “MIX GASOLINE”
Position: FUEL TANK CAP

The direction to close the choke
Position: AIR CLEANER COVER

The direction to open the choke
Position: AIR CLEANER COVER

GB-3

PE2300

5. For safe operation

Before using this product, please read this Operator's
Manual thoroughly to ensure correct operation. The fol­lowing are precautions that should be observed in order
to use the product smoothly. Elsewhere in the Manual,
the warning mark is used to bring your attention to
these precautions.

BEFORE USING THE PRODUCT

• Do not apply this pump for other than fresh water or
agricultural water.

• Those cannot be applied are Drinking Water, Muddy
Water, Sea Water, Flammable Fluids(Such as Kero­sene, Diesel Oil, Gasoline, or Heavy Oil), Chemical
Agents, Acid or Alkaline Fluids, etc.
Do not use this product when tired or otherwise in
poor physical condition, or when you may be unable
to judge correctly or operate accurately, such as after
taking cold relief medicines or drinking alcohol. Also,
children or persons who are unable to understand the
contents of this Manual should under no circum­stances be permitted to use the product.

• The engine exhaust gas contains toxic carbon mon­oxide. Please do not use the product indoors, in vinyl
houses or tunnels, or in other poorly ventilated places.

• When using for the first time, before commencing
actual operating please receive guidance in operating
the product from a person with adequate experience.

• Please take good care of this Operator's Manual and
refer to it for additional information from time to time.

• When selling or lending this product, it should be
accompanied by this Operator's Manual.

WARNING

•To avoid noise complaints, in general, operate prod­uct between 8 a.m. and 5 p.m. on weekdays and 9
a.m. to 5 p.m. on weekends.

IMPORTANT

Check and follow the local regulations as to sound
level and hours of operations for the product.

PRECAUTIONS BEFORE OPERATING

• Apply isolation measures to keep children or infants
away from the pump so that you can operate it in safe
area.

•Temperature of the pumping up water shall be in be­tween 5°C to 75°C. Otherwise, the pump may be dam­aged.

•Avoid idle pump operation(operation with no water in
the pump). This may cause pump damage.

• Be sure to use only suction hose or an equivalent
“water suction hose” as an water inlet hose.

• Make sure to couplings and clumps(attached to this
kit) when connecting the suction and discharge hoses
to the pump.

•Do not place any flammable object such as straw,
withered leaves, rubbish, oily wiping cloth, etc. around
the pump in operation.

• Do not use this product in the following cases.

1. When the product could fall over or in other situations
when it is difficult to hold or operate.

2. After sunset or at other times when eyesight is poor
and the safety of the operation area is difficult to as­certain.

3. In worsening weather (rain, fog, strong wind, lightning,
etc.)

GB-4

PRECAUTIONS WHEN TRANSPORTING THE
PUMP

• The engine shall be stopped to transfer pump.

• Do not transport the pump while it has fuel in the tank,
as these could leak out as a result of impact during
transportation.

• When transporting in a vehicle, please use a rope or
similar to fix the pump firmly to the cargo trailer in an
upright position. Please do not transport by bicycle
or motorbike, as this is dangerous.